Portable Bar Company COMPACT BAR User manual

Table of contents:
- Part List
- Set Up Guide
- Compact Bar Covers
COMPACT BAR SET UP GUIDE

• Read all the instructions before installing.
• Remove all packing materials before you start.
• This installation requires basic mechanical skills.
• Proper installation is the responsibility of the installer.
• Product failure due to improper installation is not covered under
the warranty.
• Keep this instruction manual.
BEFORE YOU BEGIN THE INSTALLATION
PAGE 2 OF 8

COMPACT BAR ASSEMBLY PART LIST PAGE 3 OF 9
Main Frame
QTY: 1
Counter Top
QTY: 1
Speed Rail
QTY: 1
Ice Bin
QTY: 1
Lock Pin
QTY: 5
Note: Parts are not to scale.
Acrylic Panel
QTY: 4
Cutting Board
QTY: 1
Cover
QTY: 1
See page 7

COMPACT BAR ASSEMBLY SET UP STEPS
STEP 1: Remove the pins and . Unlock the spring
latches at the bottom ( ).
-
P1 P2
L1 L2
P1
P2
L1
L2
STEP 2: Open the doors as shown below.
Figure 1
Figure 2
CAUTION: The doors slide down when fully open.
See Figure 3.
Figure 3
PAGE 4 OF 9
STEP 3: Place the side pins as shown below ( ).
-
Remove pins and .
P1 P2
P3 P4
P3
P1
P2
P4
Figure 4
Note: Adjust levelers to desired
lenght for added stability.
Note 2: Pins may look
and
like the pin below:
P1 P2

COMPACT BAR ASSEMBLY SET UP STEPS
STEP 4: Lift the shelf and place the pins and
as shown below.
P3
P4
STEP 5: Set down the shelf and remove the pin
as shown below.
P5
PAGE 5 OF 9
STEP 6: Insert the pin .
P5
P3
P4
P5
P5
Figure 5
Figure 6
Figure 7
STEP 7: Place the counter top as shown below. Lock the counter
top in place using the two spring latches and
L3 L4
L3
L4
Figure 8

STEP 8: Place the speed rail and the ice bin
as shown below.
Figure 9
Figure 10
COMPACT BAR ASSEMBLY SET UP STEPS
PAGE 6 OF 9
How to remove the acrylic panels if needed
Back Panel
STEP 1: Remove screws and . Then remove
the tab as shown below.
S1 S2
S1
S2
STEP 2: Pull up the acrylic panel.
STEP 1: Remove screws and . Then remove
the side frame as shown below.
S3 S4
STEP 2: Slide out the side panel.
STEP 1: Remove screws and .
Slide out the panel.
S5
S6
S3
S4
S5
S6
Side Panel
Top Panel

COMPACT BAR ASSEMBLY SET UP STEPS PAGE 7 OF 9
Figure 11. Full Assembly.

COMPACT BAR COVERS
PAGE 8 OF 9
Speed rail cover
Main frame cover
Counter cover

Contact us
Tel # [phone]
866-659-3353Fax #
[e-mail]-mail:
Visit us at
www.theportablebarcompany.com
COMPACT BAR SET UP GUIDE - 12/23/2016