Quantum 56511 Assembly instructions

56511
Visit our website at: http://www.harborfreight.com
Email our technical support at: [email protected]
Owner’s Manual & Safety Instructions
Save This Manual Keep this manual for the safety warnings and precautions, assembly,
operating, inspection, maintenance and cleaning procedures. Write the product’s serial number in the
back of the manual near the assembly diagram (or month and year of purchase if product has no number).
Keep this manual and the receipt in a safe and dry place for future reference. 19f
When unpacking, make sure that the product is intact
and undamaged. If any parts are missing or broken,
please call 1-888-866-5797 as soon as possible.
Copyright© 2019 by Harbor Freight Tools®. All rights reserved.
No portion of this manual or any artwork contained herein may be reproduced in
any shape or form without the express written consent of Harbor Freight Tools.
Diagrams within this manual may not be drawn proportionally. Due to continuing
improvements, actual product may differ slightly from the product described herein.
Tools required for assembly an d se rv ic e may n ot b e in cl uded.
Read this material before using this product.
Failure to do so can result in serious injury.
SAVE THIS MANUAL.

Page 2 For technical questions, please call 1-888-866-5797. Item 56511 For technical questions, please call 1-888-866-5797. Item 56511
Specifications
Input Rating 5VDC, 0.3A
Battery Li-Ion 3.7V, 320mAh 10440 type
Charge Time* 1 hr 30 min
Run Time 5 hr 30 min (low mode)
*Note: Charge time will vary depending on the amp rating of the USB port the cord is attached to.
IMPORTANT SAFETY INFORMATION
To prevent serious injury, FIRE, and EXPLOSION:
1. Keep dry.
2. Only use included charging adaptors. Other
adaptors may damage tool or cause fire.
3. Do not submerge Light.
4. Do not operate in explosive atmospheres, such as in
the presence of flammable liquids, gases, or dust.
5. People with pacemakers should consult their
physician(s) before use. Electromagnetic fields in
close proximity to heart pacemaker could cause
pacemaker interference or pacemaker failure.
6. Not a toy. Keep out of reach of children.
7. Contains Li-Ion battery. Battery must be
recycled or disposed of properly. Do not open,
crush, heat above 140° F or incinerate.

Page 3For technical questions, please call 1-888-866-5797.Item 56511 For technical questions, please call 1-888-866-5797.Item 56511
Operation
Read the ENTIRE IMPORTANT SAFETY INFORMATION section at the beginning of this document
including all text under subheadings therein before set up or use of this product.
NOTE: Before using the Light for the
first time, fully charge the Battery.
1. Press the Switch to turn on the Light. The
Light first illuminates in high mode. Press
the Switch again to turn the Light off.
2. After switching off from high mode, press the
Switch to turn the Light on in low mode. Press
the Switch again to turn the Light off.
3. To toggle between high and low modes, press the
Switch to turn the Light on. Gently press the Switch
to toggle between high and low modes. To turn the
Light off, firmly press the Switch until you hear a click.
4. When finished with the Light, turn it off and
store indoors away from children.
Switch
Base
Clip
Charging Instructions
1. Pull Cover back following the direction of the
arrow. Insert one end of the USB Charging
Cable (included) into the Charging Jack.
2. Plug the other end of the USB Charging
Cable into a powered USB port.
3. The Charging Jack will turn Red during
charging. When charging is done, it will turn
Green. Unplug the USB Charging Cable
and push Cover over the Charging Jack.
NOTICE: Do not leave the Battery in a
discharged state. Charge the Battery every
3 months if the Light is not in use. This will keep
the Battery from wearing down and add to its life.
USB
Charging
Cable Charging
Jack Cover
Battery Removal
1. Unscrew the Base of the Light and
remove it along with the Clip.
2. Using pliers (sold separately) or similar
tool, peel off the protective black cap from
the end of the threaded connector.
3. Using tweezers (sold separately) or similar
tool, pull out the switch housing.
4. Pull out the spring/battery assembly
and cut wires from battery.
5. Contains Li-Ion battery. Battery must be
recycled or disposed of properly. Do not open,
crush, heat above 140° F or incinerate.

Limited 90 Day Warranty
Harbor Freight Tools Co. makes every effort to assure that its products meet high quality and durability standards,
and warrants to the original purchaser that this product is free from defects in materials and workmanship for the
period of 90 days from the date of purchase. This warranty does not apply to damage due directly or indirectly,
to misuse, abuse, negligence or accidents, repairs or alterations outside our facilities, criminal activity, improper
installation, normal wear and tear, or to lack of maintenance. We shall in no event be liable for death, injuries
to persons or property, or for incidental, contingent, special or consequential damages arising from the use of
our product. Some states do not allow the exclusion or limitation of incidental or consequential damages, so the
above limitation of exclusion may not apply to you. THIS WARRANTY IS EXPRESSLY IN LIEU OF ALL OTHER
WARRANTIES, EXPRESS OR IMPLIED, INCLUDING THE WARRANTIES OF MERCHANTABILITY AND FITNESS.
To take advantage of this warranty, the product or part must be returned to us with transportation charges
prepaid. Proof of purchase date and an explanation of the complaint must accompany the merchandise.
If our inspection verifies the defect, we will either repair or replace the product at our election or we may
elect to refund the purchase price if we cannot readily and quickly provide you with a replacement. We will
return repaired products at our expense, but if we determine there is no defect, or that the defect resulted
from causes not within the scope of our warranty, then you must bear the cost of returning the product.
This warranty gives you specific legal rights and you may also have other rights which vary from state to state.
26541 Agoura Road • Calabasas, CA 91302 • 1-888-866-5797