Rocam Losi EROS MIX 4/1 Quick start guide

INSTRUCTION MANUAL
ASSEMBLY, INSTALLATION, USE AND MAINTENANCE.
Rev. 07/2013
Rocam Losi s.r.l. declines every responsibility on any print and/or transcription mistake contained in this booklet
Rocam Losi s.r.l. can change features and datas of this booklet with the proposal of keeping on increase the quality of its products.
Anytime and without notice, this booklet can’t be considered as contract with third parties.
1
Item:
EROS MIX 4/1
EROS MIX 5/1A
EROS MIX 5/1B
EROS MIX 6/1
Indice
1. Instruction Warnings........................................................................................................2
2. Safety and Right Use Warnings.......................................................................................2
3. Warranty..........................................................................................................................2
4. Settings............................................................................................................................2
4.1 Appliance Start-up......................................................................................................3
4.1.1 Warm side............................................................................................................3
4.1.1 Refrigerated side .................................................................................................3
4.2 Technical Features.....................................................................................................4
4.3 Use Suggestions........................................................................................................5
4.3.1 Warm side............................................................................................................5
4.3.2 Refrigerated side .................................................................................................6
4.4 Spare Parts................................................................................................................7
4.4.1 Warm side............................................................................................................7
4.4.2 Refrigerated side ...............................................................................................10
4.5 Optionals..................................................................................................................12
4.5.1 Optional 9 ..........................................................................................................13
5. Cleaning and Maintenance............................................................................................13
5.1 Breakdowns..............................................................................................................14
5.2 Wiring diagram.........................................................................................................15
6. Disposal.........................................................................................................................16
EN

INSTRUCTION MANUAL
ASSEMBLY, INSTALLATION, USE AND MAINTENANCE.
Rev. 07/2013
Rocam Losi s.r.l. declines every responsibility on any print and/or transcription mistake contained in this booklet
Rocam Losi s.r.l. can change features and datas of this booklet with the proposal of keeping on increase the quality of its products.
Anytime and without notice, this booklet can’t be considered as contract with third parties.
2
1. Instruction Warnings
User has to hold the whole instructions. User must store up this document in case
of use. Producer do not assume any responsibility for damages incurred due to the failure
of improper use of this manual. All measures in this manual are in mm.
2. Safety and Right Use Warnings
The products meet the latest technological evolutions and current safety
guidelines.
Trolley line EROS, object of this booklet, is projected to be in compliance
with directives and field laws, in order to guarantee a safe and reliable
product. Any other use will be considered inapposite to the original
destination. Producer do not assume any responsibility for damages caused
by an improper use. Responsibility lies only on user. A proper use also includes
compliance with the instructions for use and installation and any additional documentation
as well as the conditions of inspection and maintenance.
3. Warranty
Due to commercial and construction requirements, the manufacturer reserves the
right to make changes in order to enhance the quality and use of product. The
manufacturer, in compliance with European Community legislation, grants its products for
24 months. This guarantee does not include electrical parts, labour and all replacements
related to an improper use of the good. Any manipulation carried out automatically
excludes the liability of the manufacturer. The products or parts to be replaced or repaired
for unequivocal defects in workmanship and materials used must be in a “free port” at the
offices of the producer, who after a careful inspection, will repair or replace them. The
repairs are carried out exclusively at the headquarters of the manufacturer, and none cost
incurred by the customer for repairs will be refunded by the manufacturer unless expressly
agreed.
4. Settings This item is packed and shipped assembled. The manufacturer declines
every responsibility of damage of someone or something caused by the failure
to comply with the instructions of this manual. Do not make any structural
change to the trolley. The elements composing the trolley (plastic,
polyurethane foam, bubble wrap, Styrofoam, cardboard and so on) must be
kept away from children as potential sources of danger and must be collected and
disposed off separately in accordance with local regulations. The manufacturer declines
every responsibility of damage of someone or something caused by the failure to comply
with the instructions of this manual. After the unpacking of the item from its packing,
proceed by removing the adhesive plastic tape before sarting up the product. Any residual
glue has to be removed carefully (do not use abrasive cleaners). The device is designed to
run on AC to the voltage specified on the technical data plate (located on the bottom of the
tank). The grounding line is marked by the colours yellow/green and must not be
interrupted. The device is provided with a cable in accordance with the CE regulations and

INSTRUCTION MANUAL
ASSEMBLY, INSTALLATION, USE AND MAINTENANCE.
Rev. 07/2013
Rocam Losi s.r.l. declines every responsibility on any print and/or transcription mistake contained in this booklet
Rocam Losi s.r.l. can change features and datas of this booklet with the proposal of keeping on increase the quality of its products.
Anytime and without notice, this booklet can’t be considered as contract with third parties.
3
with a schuko plug (that can be replaced, when necessary, with a different plug, suitable
for the specified wattage and in accordance to the current regulations and guidelines;
when necessary, replace the provided cable with a new one with the same features).
Before switching the appliance
•Check if the electrical system can withstand the appliance’s load (WATT as indicated
on the technical plate).
•Make sure that the electrical system is provided with ground connection according to
the current norms and guidelines.
•Connect the appliance with the ground network through a cable connected to the
specific screw placed on the external casing of the appliance (See Component n°15
page. 6).
4.1 Appliance Start-up
4.1.1 Warm side
Once ready to switch on the appliance, plug the device in the electrical system and
turn the thermostat knob to the desired temperature. If the switch light is turned on, the
device is working correctly and is reaching the selected temperature.
Once started up, the appliance reaches the selected temperature in about one hour
(it depends much on the starting temperature, the room temperature and the exposure of
the buffet trolley).the switch will turn off once the device has reached the selected
temperature.
The appliance will keep the temperature during the service time.
This buffet trolley has been designed and created to work exclusively
through the “bain-marie” system, therefore It shall never be turned on
when without water in the tank.
4.1.1 Refrigerated side
Once ready to switch on the appliance, plug the device in the electrical system and
press the power switch placed on the compressor front grid. You will hear a soft buzzing
coming from the compressor and the thermostat display will show the starting temperature
of the device. Once started up, the appliance reaches the selected temperature in about
one hour (it depends much on the starting temperature, the room temperature and the
exposure of the buffet trolley). The thermostat is set from the manufacturer on +2°C for a
optimal use of the device. Use the attached instructions to change the settings of the
digital thermostat.
CAUTION! Any change in the thermostat settings must be done on the
temperature only. Any other parameter changes can affect and damage
the operation of the compressor
PLEASE REFER TO THE ATTACHED INSTRUCTIONS

INSTRUCTION MANUAL
ASSEMBLY, INSTALLATION, USE AND MAINTENANCE.
Rev. 07/2013
Rocam Losi s.r.l. declines every responsibility on any print and/or transcription mistake contained in this booklet
Rocam Losi s.r.l. can change features and datas of this booklet with the proposal of keeping on increase the quality of its products.
Anytime and without notice, this booklet can’t be considered as contract with third parties.
4
4.2 Technical Features
Eros MIX
4/1
Eros MIX
5/1A
Eros MIX
5/1B
Eros MIX
6/1
Power supply
230 V
230 V
230 V
230 V
Lamp
Neon 36W
Neon 36W
Neon 36W
Neon 58W
WARM SIDE
Temperature Range
+30°/+90°C
+30°/+90°C
+30°/+90°C
+30°/+90°C
Range operating
temperature
+30°/+90°C
+30°/+90°C
+30°/+90°C
+30°/+90°C
Rating
1400W
1400W
2100W
2100W
Well capacity
2 x GN 1/1
2 x GN 1/1
3 x GN 1/1
3 x GN 1/1
Pans height (mm)
180
180
180
180
REFRIGERATED
SIDE
Cooling power
310 W
405 W
310 W
405 W
Compressor power
Classe T 1/4
Hp
Classe T 1/4
Hp
Classe T 1/4
Hp
Classe T 1/4
Hp
Compressor
sound
pressure
level (dBA)
A 1 mt.
47
51
47
51
A 10
mt.
27
31
27
31
Cooling gas
R 404
R 404
R 404
R 404
Gas quantity (Kg)
0,33
0,35
0,33
0,35
Min-Max
Temperature Set
-10°/+50°C
-10°/+50°C
-10°/+50°C
-10°/+50°C
Range operating
temperature
+2°/+8°C
+2°/+8°C
+2°/+8°C
+2°/+8°C
Tank capacity
500x510
830x510
500x510
830x510
Tank height (mm)
180
180
180
180
Weight (Kg)
180
210
210
250

INSTRUCTION MANUAL
ASSEMBLY, INSTALLATION, USE AND MAINTENANCE.
Rev. 07/2013
Rocam Losi s.r.l. declines every responsibility on any print and/or transcription mistake contained in this booklet
Rocam Losi s.r.l. can change features and datas of this booklet with the proposal of keeping on increase the quality of its products.
Anytime and without notice, this booklet can’t be considered as contract with third parties.
5
4.3 Use Suggestions
4.3.1 Warm side
Gastronorm pans (with food) can be placed inside the general well in all the
possible splits combinations.
If the trolley has a laminated wood
structure, pay close attention to
the contact between the water in
large quantity and the wooden
parts to avoid blisterings and
scrapings of the same.
The final customer must regularly check the food
temperature and, if necessary, has to change the
keeping temperature according to the
requirements.
Before switching on, fill the tank
with a moderate amount of water
and, in any case, do NEVER
exceed with water in the tank (see
max water level marked on the
“MAX” water level mark

INSTRUCTION MANUAL
ASSEMBLY, INSTALLATION, USE AND MAINTENANCE.
Rev. 07/2013
Rocam Losi s.r.l. declines every responsibility on any print and/or transcription mistake contained in this booklet
Rocam Losi s.r.l. can change features and datas of this booklet with the proposal of keeping on increase the quality of its products.
Anytime and without notice, this booklet can’t be considered as contract with third parties.
6
4.3.2 Refrigerated side
Here below a list of suggestions for a optimal use of the buffet trolley:
Gastronorm tanks (with food) in all the possible splits combinations can be placed
inside the general tank. Otherwise, a grid in the GN 1/1 ( see optional 5 on page 9) can be
used to place and display ready meals.
. We suggest to place fresh seafood on a coat of ice chips on the grid.
Since this trolley is not a fridge, but a trolley for food display and service (2/3
hours service), it should not operate continuously.
Please use the following table for the storage temperatures. The
provided temperatures (recommended by the food code in accordance to the
HACCP Regulation) are approximate and subject to change and subject to
changes according to the environment, the sun exposure and the quantity of food.
The final customer must regularly check the food temperature and, if necessary,
has to change the keeping temperature according to the requirements.
* We suggest to place fresh seafood on a coat of ice chips on the grid.
Food
Min.Temp
(°C)
Max.Temp
(°C)
Pastry
+2°
+8°
Pasta
+2°
+7°
Butchery
+2°
+6°
Seafood*
+0°
+4°
Gastronomy
Cooked food
+2°
+10°
Cooked food with eggs, milk or
coated with jelly
+0°
+4°
Dairy
+2°
+4°
Cheese
+2°
+10°
Cold Cuts
+2°
+10°
Vegetables
Whole
+8°
+10°
4 range (chopped)
+2°
+6°

INSTRUCTION MANUAL
ASSEMBLY, INSTALLATION, USE AND MAINTENANCE.
Rev. 07/2013
Rocam Losi s.r.l. declines every responsibility on any print and/or transcription mistake contained in this booklet
Rocam Losi s.r.l. can change features and datas of this booklet with the proposal of keeping on increase the quality of its products.
Anytime and without notice, this booklet can’t be considered as contract with third parties.
7
4.4 Spare Parts
4.4.1 Warm side

INSTRUCTION MANUAL
ASSEMBLY, INSTALLATION, USE AND MAINTENANCE.
Rev. 07/2013
Rocam Losi s.r.l. declines every responsibility on any print and/or transcription mistake contained in this booklet
Rocam Losi s.r.l. can change features and datas of this booklet with the proposal of keeping on increase the quality of its products.
Anytime and without notice, this booklet can’t be considered as contract with third parties.
8
Rif.
Code
Quantity
Description
Eros MIX
4/1
Eros MIX
5/1A
Eros MIX
5/1B
Eros MIX
6/1
1
RF
2
2
2
2
Castor Ø125 with brake
2
RS
3
3
3
3
Standard Castor Ø125
3
16
16
16
16
Screws 6x20 black
burnished
5
1
1
1
1
Drain Cock 1/2”
6
1
1
1
1
Control Panel
7
1
1
1
1
Switch Light Lid
8
1
1
1
1
Switch light
9
1
1
1
1
Thermostat 30°/90°C
10
1
1
1
1
Thermostat knob
11
4
4
4
4
Control panel screws
12
1
1
1
1
Schuko cable (1 for both
sides)
13
1
1
1
1
Cablegland
14
2
2
2
2
Screws 3,5x12
15
1
1
1
1
Cablegland plate
16
1
1
1
1
Grounding coupler
17
6
6
6
8
Dish holder bracket
18
12
12
12
16
Washer M6
19
24
24
24
32
Screws 3,5x20
20
18
18
18
24
Screws 3,5x16
21
1
1
1
1
Door handle
22
2
2
2
2
Screws 3,5x12
23
1
1
1
1
Door
24
2
2
2
2
Door hinges
25
2
2
2
2
Screws
26
2
2
2
2
Screws 3,5x16
27
2*
2*
2*
2*
Long side dish holder
28
2
2
2
2
Chromed oval top support
tube
29
1*
1*
1*
1*
Top
30
2
2
2
2
Screws 6x40
31
2
2
2
2
Washer M6
32
1*
1*
1*
1*
Undermounted top in
st.steel

INSTRUCTION MANUAL
ASSEMBLY, INSTALLATION, USE AND MAINTENANCE.
Rev. 07/2013
Rocam Losi s.r.l. declines every responsibility on any print and/or transcription mistake contained in this booklet
Rocam Losi s.r.l. can change features and datas of this booklet with the proposal of keeping on increase the quality of its products.
Anytime and without notice, this booklet can’t be considered as contract with third parties.
9
33
2*
2*
2*
2*
Dome
34
14
14
14
18
Nut M4
35
14
14
14
18
Washer indented M4
36
1*
1*
1*
1*
Neon lamp
37
2
2
2
2
Neon screws
38
2
2
3
3
Heating element 700W
39
2
2
3
3
Ceramic fiber felt
40
2
2
3
3
Heating element cover
41
12
12
18
18
Washer M6
42
12
12
18
18
Nut M6
43
2
2
3
3
Galvanized bottom heating
element lid
44
12
12
18
18
Screws 6x10
*Always mention the reference model.

INSTRUCTION MANUAL
ASSEMBLY, INSTALLATION, USE AND MAINTENANCE.
Rev. 07/2013
Rocam Losi s.r.l. declines every responsibility on any print and/or transcription mistake contained in this booklet
Rocam Losi s.r.l. can change features and datas of this booklet with the proposal of keeping on increase the quality of its products.
Anytime and without notice, this booklet can’t be considered as contract with third parties.
10
4.4.2 Refrigerated side