Scotsman NME954 Guide

This parts list contains the service parts and wiring
diagrams for this model. Check the model number
in question to be sure that it is applicable to this
parts list.
Note that these machines have been
manufactured in both 50 and 60 cycle.
60 Hz model numbers end in -3 or -32.
50 Hz model numbers end in -6.
Another change was to the water cooled
condensers. Model numbers ending in A have a
different water cooled condenser than the current
model.
TABLE OF CONTENTS
Cabinet . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2
Air Cooled Refrigeration . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3
Water Cooled Refrigeration . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
Water System . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
Gearmotor . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
NME Evaporator . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
FME Evaporator . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
Control Box . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Wiring Diagrams . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10
NME954 & FME1204 SERVICE PARTS
June 2002
Page 1

NME954 & FME1204 SERVICE PARTS
July 2006
Page 2
Cabinet Assembly
2
1
313 17 8
14
5, 6
9, 10
4
7
3
11
15
12
16
ITEM PART
NUMBER NUMBER DESCRIPTION
1 03-1531-01 Screw
2 A33256-002 Top Panel, S.S.
3 A34038-002 Service Panel, non-louvered
A33946-032 Service panel, louvered
3a A32975-001 Air filter media, for louvered
service panel. Same on other side
4 A33292-002 Right Side Panel, S.S.
5 03-0271-00 Speed Clip
6 15-0808-01 Emblem, grey
7 03-1404-12 Screw
8 A33255-002 Front Panel, louvered
A39048-001 Front panel, non-louvered
ITEM PART
NUMBER NUMBER DESCRIPTION
9 02-2976-01 Filter Assembly for louvered
front panel
10 03-1660-01 Filter clip
11 A34348-001 Ft. brace
12 A34039-001 Control Box Support
13 A32435-002 Left Side Panel, S.S.
14 03-1419-22 Screw
15 Water Cooled only:
A35924-002 Rear panel, stainless
16. A35890-001 Base
17 02-0836-00 Catch
15-0411-00 Strike (on front panel)
18 A36078-001 Reservoir bracket
3a
18

NME954 & FME1204 SERVICE PARTS
April 2007
Page 3
ITEM PART
NUMBER NUMBER DESCRIPTION
16 A36496-001 Suction Line
17 11-0501-22 Hi Pressure Cut Out
18 A32961-020 Insulation Kit (3 piece)
19 11-0488-21 Thermo Expansion Valve
20 18-8768-22 Compressor 208-230/60/1
Overload for above is internal
18-8768-24 Compressor 200-230/60/3
Overload for above is internal
18-8772-26 Compressor 220-240/50/1
18-8772-21 Overload for above
21 11-0502-21 Low pressure cut out switch
22 16-1138-01 Core
23 16-1137-01 Access valve body
24 16-1140-01 Cap
ITEM PART
NUMBER NUMBER DESCRIPTION
1 18-3815-01 Fan Blade
2 12-1576-02 Fan Motor
3 02-2378-01 Fan Bracket
4 03-1404-12 Screw
5 02-3319-02 Dryer
6 A33231-015 Fan Shroud
7 A35582-002 Fan shroud cover, stainless
8 18-8717-01 Condenser
9 16-0832-20 Access valve
9a 16-0832-02 Stem cap
9b 16-0832-03 Core cap
10 A34045-001 Drain casting
11 03-1645-01 Screw
12 18-2200-28 Grommet
13 18-2300-27 Sleeve
14 03-1407-07 Washer
15 03-1405-20 Cap Screw
Air Cooled Refrigeration
7
8
6
1
4
2
5
10
18, 19
16
17
20
9
11
15
14
13
12
21
Alt Access Valve
22
23 24

NME954 & FME1204 SERVICE PARTS
April 2007
Page 4
12 16-0832-20 Access Valve Complete
12a 16-0832-02 Stem cap
12b 16-0832-03 Core cap
13 11-0501-22 Hi Pressure Cut Out
14 A36496-001 Suction Line
15 A32961-020 Insulation Kit (3 piece)
16 11-0488-21 Thermo Expansion Valve
17 18-8768-22 Compressor 208-230/60/1
Overload for above is internal
18-8768-24 Compressor 200-230/60/3
Overload for above is internal
18-8772-26 Compressor 220-240/50/1
18-8772-21 Overload for above
18 11-0502-21 Low pressure cut out switch
19 16-1138-01 Core
20 16-1137-01 Access valve body
21 16-1140-01 Cap
ITEM PART
NUMBER NUMBER DESCRIPTION
1 18-8718-25 Condenser for A series
18-8873-21 Condenser for B series
2 03-1645-01 Screw
3 11-0478-.01 Water Reg. Valve
4 16-0401-02 Elbow (not shown)
5 A34044-001 Drain Assembly
6 03-1403-14 Screw
7 02-3319-02 Dryer
8 03-1407-07 Washer
9 18-2200-27 Sleeve
10 18-2200-28 Grommet
11 03-1405-20 Screw
Water Cooled Refrigeration
7
1
2
3, 4
6
5
2
15, 16
14
13
17
12
2
11
8
9
10
18
19
20 21

ITEM PART
NUMBER NUMBER DESCRIPTION
15 03-1394-01 Pal nut
16 A36154-001 Evap. water inlet tube
17 02-1338-00 Hose clamp
18 02-3692-02 Drain fitting
19 02-3826-01 Res. overflow hose
20 A36078-002 Reservoir bracket
21 13-0840-01 Rubber cap
ITEM PART
NUMBER NUMBER DESCRIPTION
1 03-1420-03 Cap Screw
2 A32890-020 Evaporator
3 02-0929-23 Water Seal
4 02-3266-20 Reservoir & valve
5 02-3266-21 Float valve
6 02-3266-03 Plunger/seat
7 12-2760-21 Water Level Sensor
8 A32777-001 Retaining Ring for Seal
9 02-3837-01 Drip Pan
10 13-0704-00 Gasket
11 13-0868-01 Water Shed
12 16-1039-01 Male connector
13 16-0835-01 Water fitting
14 13-0895-01 Inlet tubing, 4 ft req.
5
6
Water System
4
15
7
16
21
17
20
18
14
12, 13
19
1
2
3
8
9
10
11
NME954 & FME1204 SERVICE PARTS
April 2005
Page 5

NME954 & FME1204 SERVICE PARTS
July 2006
Page 6
Gearmotor
13
10
11
12
8
9
7
6
5
4
3
2
1
*NOTE: GEARCASE
COVER INCLUDES
COVER, OUTPUT
SHAFT, KEY, OUTPUT
GEAR, BEARINGS AND
SEAL
ITEM PART
NUMBER NUMBER DESCRIPTION
1 13-0868-01 Water Shed
2 A32379-029 Seal
3 no number End bell
4 A32379-026 Bolt (6)
5 A32379-022 Gearcase Cover*
6 A32379-024 1st Gear and Bearings
7 A32379-023 2nd Gear and Bearings
8 A32379-021 Gasket
9 A32379-020 Gearcase
10 12-2430-24 Start switch, Emerson
12-2430-44 Start switch, GE split phase
11 12-2430-22 Drive Motor
12 12-2430-29 Rotor Bearing, Emerson
12-2430-49 Rotor bearing, GE split phase
13 A32379-027 Oil, 1 Container
14 A33220-022 Complete Assy
Complete assembly includes water shed and drip pan
gasket.
15 A33220-030 Gear and case kit, no motor

NME Evaporator
17. 13-0868-01 Water Shed
18. A34559-020 Bearing
19. 02-2977-01 Lip Seal
20. 13-0704-00 Drip Pan Gasket
21. 13-0617-54 O-Ring
22. 02-3837-01 Drip Pan
23. 13-0617-45 O-Ring
24. 03-1544-08 Soc. Head Screw
25. A32900-020 Breaker
(includes 18 & 19)
26. A38071-022 Auger
27. A32890-020 Evaporator
28. 03-1420-03 Cap Screw
29. A32962-001 Insulation Bot. (half)
30. 13-0929-02 Insulation donut*
* Insulation changed Oct. 2000. Item 4, 6 and 6a
no longer used. Item 5 changed. Item 30 added.
1
2
4
22
29
28
27
26
29
23
25
21
24
19
18
16
15
14
13
12 11
10
8
9
8
7
6
5
4
3
17
6a
20
ITEM PART
NUMBER NUMBER DESCRIPTION
1. A34969-001 Bail clip
2. 02-3268-01 Drain tube holder
3. 02-2930-04 Ice Chute Cover
4. A32963-001* Insulation Top (half)
5. 02-3841-01* Ice Chute Body, includes
insulation, repl item 4
6. A33102-001* Insulation Collar Inside
6a A35419-020* Strap kit
7. 02-2929-04 Ice Chute Lower
8. A37708-021 Bin Controls Kit.
(set of 2)
9. A32930-001 Chute Gasket
10. 03-1405-52 Hex Cap Screw
11. 02-3001-01 Ice Sweep
12. 13-0871-01 Water Shed
13. 02-2978-01 Lip Seal
14. 02-3128-20 Breaker Cover
15. 13-0617-52 O-Ring
16. 08-0660-01 Auger Stud & washer
30
NME954 & FME1204 SERVICE PARTS
April 2005
Page 7

NME954 & FME1204 SERVICE PARTS
July 2006
Page 8
21. 13-0617-52 O-Ring
22. 02-2916-01 Slotted Collar
23. 13-0617-45 O-Ring
24. 03-1544-08 Soc. Head Screw
25. A34505-020 Breaker (Divider)
(includes 18 & 19)
26. A38071-022 Auger
27. A32890-020 Evaporator
28. 03-1420-03 Cap Screw
29. A32962-001 Insulation Bot. (half)
30. 02-3837-01 Drip Pan
31. 13-0704-00 Drip Pan Gasket
32. 13-0868-01 Water Shed
33. 13-0617-49 O-Ring
34 03-1408-36 Washer
35 13-0929-01 Insulation donut*
* Insulation changed Oct 2000. Items 4, 6 and 17
no longer used. Item 5 changed. Item 35 added.
4
32
31
30
29
28
27
26
29
23
25
21
24
22
20
33
19
18
16
15
14
13
12
11
10
8
9
8
7
6
5
4
3
34
17
35
ITEM PART
NUMBER NUMBER DESCRIPTION
1. A34969-001 Bail clip
2. 02-3268-01 Drain tube holder
3. 02-2930-04 Ice Chute Cover
4. A32963-001 Insulation Top (half)*
5. 02-3841-01 Ice Chute Body, with
foam, replaces item 4*
6. A33102-001 Insulation Collar Inside*
7. 02-2929-04 Ice Chute Lower
8. A37708-021 Bin Controls Assy.
(set of 2)
9. A32930-001 Chute Gasket
10. 03-1405-52 Hex Cap Screw
11. 02-3001-01 Ice Sweep
12. 13-0871-01 Water Shed
13. 02-2978-01 Lip Seal
14. 02-3128-20 Breaker Cover
15. 13-0617-54 O-Ring
16. 08-0660-21 Auger Stud, thrust Washer
17. A35419-020 Strap kit*
18. A34559-020 Bearing
19. 02-2977-01 Lip Seal
20. 03-1405-27 Screw
1
2
FME Evaporator

3
9
7
10
6
5
1
2
2
4
8
ITEM PART
NUMBER NUMBER DESCRIPTION
1 18-1901-54 Start Capacitor, 60 Hz
18-1901-53 Start Capacitor, 50 Hz
2. 03-1638-03 Screw
3. A35971-002 Run Cap Bracket
4. A35971-001 Start cap bracket
5. 18-1902-45 Run capacitor, 60 Hz
18-1902-53 Run capacitor, 50 Hz
6. 12-2469-02 Single Phase Contactor
12-2533-02 Three phase contactor
Note: Hz means Cycles, 50 Hz is 50 cycle, the
model number ends in a -6 for 50 Hz models.
ITEM PART
NUMBER NUMBER DESCRIPTION
7 12-2835-21 Circuit Board
8. 12-0426-02 Mode Switch
NME-6 or FME-6 only: (50 Hz)
12-2637-01 Mode Switch
9. 12-2350-01 Standoff
10 18-1903-33 Potential Relay, 60 Hz
18-1903-54 Potential relay, 50 Hz
NOT ILLUSTRATED
11. A37861-001 Control Box Cover
Control Box
NME954 & FME1204 SERVICE PARTS
May 2002
Page 9

C0IL
MTR
MTR
C0IL
MTR 1
2
T2
P
P
O
O
T
T
52
RUN
CAP
START
CAP
21
COMPRESSOR
C
R
S
FAN
(AIRCOOLEDONLY)
T1
CONTACTOR
HPCLPC
PHOTOTRANS I STOR
CONDUCT IV ITY PROB E
1R
LED
AUGER DRIVE RELAY
COM
N. O.
PR I NTED
CIRCUIT
ASSEMBLY
COMP R
R
E
E
L
L
A
A
Y
Y
COM
N. O.
L2 L1
POWER SUPPLY
MODE
SWITCH
AUGER DR IV E
RELAY
ALL CONTROLS SHOWN IN
ICE MA K ING M O D E
AIR AND WATER COOLED, 208-230/60/1
NME954 & FME1204 SERVICE PARTS
January 2000
Page 10