Sealey HVD16C User manual

2-IN-1 CORDLESS/CORDED HIGH VELOCITY
DRUM FAN 16” 230V/20V
MODEL NO: HVD16C
Thank you for purchasing a Sealey product. Manufactured to a high standard, this product will, if used according to these
instructions, and properly maintained, give you years of trouble free performance.
IMPORTANT: PLEASE READ THESE INSTRUCTIONS CAREFULLY. NOTE THE SAFE OPERATIONAL REQUIREMENTS, WARNINGS & CAUTIONS. USE
THE PRODUCT CORRECTLY AND WITH CARE FOR THE PURPOSE FOR WHICH IT IS INTENDED. FAILURE TO DO SO MAY CAUSE DAMAGE AND/OR
PERSONAL INJURY AND WILL INVALIDATE THE WARRANTY. KEEP THESE INSTRUCTIONS SAFE FOR FUTURE USE.
1. SAFETY
1.1. ELECTRICAL SAFETY
WARNING! It is the user’s responsibility to check the following:
Check all electrical equipment and appliances to ensure that they are safe before using. Inspect power supply leads, plugs and all
electrical connections for wear and damage. Sealey recommend that an RCD (Residual Current Device) is used with all electrical
products. You may obtain an RCD by contacting your local Sealey stockist.
If the product is used in the course of business duties, it must be maintained in a safe condition and routinely PAT (Portable
Appliance Test) tested.
ELECTRICAL SAFETY INFORMATION: it is important that the following information is read and understood.
1.1.1. Ensure that the insulation on all cables and on the appliance is safe before connecting it to the power supply.
1.1.2. Regularly inspect power supply cables and plugs for wear or damage and check all connections to ensure that they are secure.
1.2. GENERAL SAFETY
9Disconnect the fan from the mains power when not in use and before servicing or performing any maintenance.
9Use the fan in dry areas only. DO NOT use in wet or areas with high condensation such as showers, pools etc.
WARNING! If the fan falls into water or any other liquid, immediately switch off and disconnect from the power supply.
DO NOT touch the fan until the power supply has been disconnected.
9Always disconnect the fan from power supply if moving from one location to another and ensure fan is stood on a level surface.
9The fan air flow is powerful. Before use ensure that there is nothing nearby that will be damaged or displaced by the stream of air.
9Keep the fan clean and maintained in good condition.
9Ensure battery is inserted with polarity correct.
9Only use designated battery packs.
8DO NOT operate the fan where there are explosive or flammable gases, fumes or other hazardous substances.
8DO NOT stand the fan on the power cable.
8DO NOT operate fan without grill in place.
8DO NOT handle power adaptor with wet hands.
8DO NOT insert any objects through the fan guard.
8DO NOT pull the power adaptor plug from the mains socket by the lead.
8DO NOT get the power adaptor wet, or use in wet, damp conditions (for indoor use only).
8DO NOT cover the fan when in use.
8DO NOT immerse the fan in water or any other liquid.
8DO NOT allow children to operate the fan.
8DO NOT stand the fan where it may be knocked over or off a surface, or where the lead may cause a person to trip.
8DO NOT use the fan outdoors.
8DO NOT modify speed control or attempt to fit any additional external speed control device to the fan.
8DO NOT try to take the power adaptor plug apart.
8DO NOT allow supply terminals to be short-circuited.
8DO NOT use power adaptor for any other product.
8DO NOT place fan or batteries near fire or heat,
9When not in use place the fan in original box, or otherwise cover to protect from dust and store in a safe, dry, childproof location.
9If fan is to be stored or unused for a long period remove the battery.
WARNING! DO NOT use any other type of power adaptor with this product than the supplied power adaptor. Failure to observe this
 warningcouldresultininjuryandorreandwillinvalidatethewarranty.
WARNING! Remove battery pack from appliance while being charged.
This appliance can be used by children aged from 8 years and above and persons with reduced physical, sensory or mental capabilities or lack of
experience and knowledge if they have been given supervision or instruction concerning use of the appliance in a safe way and understand the
hazards involved. Children shall not play with the appliance. Cleaning and user maintenance shall not be made by children without supervision.
HVD16C Issue 1 19/04/22
Original Language Version
© Jack Sealey Limited
Refer to
instructions Indoor Use Only Do not
cover

2. INTRODUCTION
PartoftheSV20Serieso󰀨eringaone-battery-ts-allsolution,keepingcostsdownwithoutcompromisingonperformance.Highvelocity
continuous variable speed drum fan which is mains or cordless power meaning increased versatility in positioning cooling where it is most
required.Lightweight,portableandrobustunitttedwithrubberfeetforstability.Featuresahandleplus360°tiltingstandallowingcontrolof
airowtoexactlywhereitisneeded.Carefullybalancedandfullyguardedaluminiumbladesprovidequietandsafeoperationandissuitable
for use in industrial, commercial, agricultural, automotive workshop, showroom and home applications. To run cordless requires compatible
20V battery and mains charger, sold separately. CP20VBP4 (4Ah), CP20VBP6 (6Ah), CP20VMC (Mains Charger).
3. SPECIFICATION
Model No:................................................................HVD16C
Current:...........................................................................1.2A
Fan diameter:....................................................................16”
MaximumAirow:..................................................... 1650cfm
Power:.............................................................................24W
Speed Range:...................................................580-1470rpm
Speeds:.......................................Continuous Variable Speed
Supply:................................................................... 20V 220V
4. ASSEMBLY
4.1.  Assemblefanasshowning.1.Totightenfanatanangleusethumbwheels(g.1.1,g.1.3).
4.2.  Connectbatterytounit(g.2.A).Seesafetysectionforguidance.Notesupplyterminals(g.2.B).Polarityismarkedonthebody.
4.3.  Whenusingthemainssupply,seesafetysectionforguidance.Insertpowersupplycabletoportonappliance(g.2.D).
5. OPERATION
WARNING! Ensure that you read, understand and apply safety instructions in Section 1 before using fan.
5.1. Check that the speed control is set to OFF and then plug into power supply or fit battery (fig.2) and switch the power on.
5.2.  ToadjustthefanspeedusethecontrolknobonthePowerAdaptor(fig.3)
5.3. Adjust the direction of the air flow by moving from side to side and tilting the fan up or down as required (fig.1).
5.4.  TurnthespeedcontrolswitchtoOFFanddisconnectthefanfrommainspowerorremovebatterypackafteruse(fig.2,fig.3).
6. MAINTENANCE
WARNING! Ensure that the fan is disconnected from the mains power supply before attempting any of the following:
6.1. Use a soft, damp cloth to clean the fan.
8DO NOT immerse the fan in water and never allow water to drip onto the motor housing. DO NOT use solvents, petroleum, paint
thinner or other chemicals to clean the fan.
6.2. To clean the fan blade, undo the cross headed screws around the circumference, remove the grille and clean the blade with a
slightly damp cloth.Replace the grille as required and refit the cross headed screws.
6.3. Should the motor, switch or the power lead require service or maintenance contact your local Sealey stockist.
Original Language Version
© Jack Sealey Limited
Fig.3
Maximum Fan Flow Rate (F): 48.5m³/min
Fan Power Input (P): 22.8W
Service Value (SV): 2.1(m3/min)/W
Standby Power Consumption (Psb): 0.3W
Seasonal Electricity Consumption (Q): 7.6kWh/a
Fan Sound Power Level (Lwa): 68dB(A)
Maximum Air Velocity (c): 3.4m/s
HVD16C Issue 1 19/04/22
Fig.2
Fig.1

HVD16C Issue 1 19/04/22
Original Language Version
© Jack Sealey Limited
Sealey Group, Kempson Way, Suffolk Business Park, Bury St Edmunds, Suffolk. IP32 7AR
01284 757500 01284 703534 [e-mail] www.sealey.co.uk
ENVIRONMENT PROTECTION
Recycle unwanted materials instead of disposing of them as waste. All tools, accessories and packaging should be sorted, taken to
a recycling centre and disposed of in a manner which is compatible with the environment. When the product becomes completely
unserviceable and requires disposal, drain any fluids (if applicable) into approved containers and dispose of the product and fluids
according to local regulations.
WEEE REGULATIONS
Dispose of this product at the end of its working life in compliance with the EU Directive on Waste Electrical and Electronic Equipment
(WEEE). When the product is no longer required, it must be disposed of in an environmentally protective way. Contact your local solid
waste authority for recycling information.
Note: It is our policy to continually improve products and as such we reserve the right to alter data, specifications and component parts without prior
notice.
Important: No Liability is accepted for incorrect use of this product.
Warranty: Guarantee is 12 months from purchase date, proof of which is required for any claim.