Sealey Siegen Tools S01169 User manual

VACUUM OIL & FLUID EXTRACTOR MANUAL 6.5LT
MODEL NO: S01169
Thank you for purchasing a Sealey product. Manufactured to a high standard, this product will, if used according to these
instructions, and properly maintained, give you years of trouble free performance.
IMPORTANT: PLEASE READ THESE INSTRUCTIONS CAREFULLY. NOTE THE SAFE OPERATIONAL REQUIREMENTS, WARNINGS & CAUTIONS. USE
THE PRODUCT CORRECTLY AND WITH CARE FOR THE PURPOSE FOR WHICH IT IS INTENDED. FAILURE TO DO SO MAY CAUSE DAMAGE AND/OR
PERSONAL INJURY AND WILL INVALIDATE THE WARRANTY. KEEP THESE INSTRUCTIONS SAFE FOR FUTURE USE.
1. SAFETY
WARNING! Ensure health & safety, local authority, and general workshop practice regulations are strictly adhered to when using
this equipment.
9 Familiariseyourselfwiththeextractorsapplicationandlimitations,aswellasthespecicpotentialhazardspeculiartothisproduct.
9Maintain the extractor in good condition.
9Replace or repair damaged parts. Use genuine parts only. Non authorised parts will invalidate the warranty.
9 Useonlytoextractengineortransmissionoils,orsimilarNON-Corrosiveuids.Unitmayalsobeusedforthetransferofwater.
9Ensure safety eye protection and protective clothing are worn when using this product.
9Keep the work area clean, uncluttered and ensure there is adequate lighting.
9 Maintaincorrectbalanceandfooting.Ensuretheoorisnotslipperyandwearnonslipshoes.
9Keep children and unauthorised persons away from the working area.
9Dispose of waste liquids in accordance with local authority regulations.
8DO NOTstoreuidsinthecontainer.Onceusedtoextractuid,itmustbeemptiedintoanapprovedreceptacleassoonaspossible.
8DO NOTusetoextracthazardousorharmfulchemicals,solvents,petrol,diesel,kerosene,alkalineoracids.Ifbychancesuchuids
 areusedintheunit,itmustbeimmediatelydrainedandthoroughlycleaned.Usewithprohibiteduidswillinvalidateyourwarranty.
8DO NOT dismantle, tamper or adapt the extractor for any purpose other than for which it is designed.
8DO NOTusetheunitifithasbeendroppedormishandled,checktheunittoensurethereisnodamage.Keep the extractor clean
and store in a safe dry location.
8DO NOT store in areas of high temperature, direct sunlight, rain or snow.
2. INTRODUCTION
6.5ltrCapacitydeviceconstructedfromcompositematerialsandsuitablefortheextractionofalltypesofengine,transmissionandlubricatingoils
fromcars,motorcycles,marineengines,stationaryenginesandindustrialmachinery.Alsosuitableforlowviscosityfluidssuchaswater.Supplied
withØ4,Ø6andØ8mmsuctionprobesandØ10mmx1mtrextensiontube.Toremoveoilfromacarengine,simplypushtheprobedownthe
dipstickholeandpumpthehandleonthetopoftheunit.Probescanbestoredintheholderwhennotinuse.Canalsobeusedfordrainingfish
tanks,basinsandsinks.
3. SPECIFICATION
Model No: ....................................S01169
Capacity:.......................................6.5ltr
SuctionProbes: .. Ø4x1000mm,Ø6x1000mm,Ø8x1000mm
ExtensionTube: ........................Ø10x1000mm
Nett Weight: ..................................2.20kg
4. OPERATION
4.1 OIL EXTRACTION (fig.1)
4.1.1.  Ensurethevehicleisonlevelgroundandruntheengineforapproximately5minutestowarmtheoilandallowanycontaminants 
within the oil to thoroughly mix and turn the engine off.
4.1.2.  Removethevehicle’soildipstick.
4.1.3.  Selectandinserttheappropriatediameterprobeintothedipstickholeuntilitreachesthebottomofthesump.
4.1.4.  Connecttheextensiontubetoboththepumpinletandprobe.
4.1.5.  Raisethehandletoitshighestlimitandpumpitfullyseveraltimestocreateavacuumwhichwillautomaticallybegintoextractthe
  oil/fluid.Observetheoil/fluidasitrisesupthechamberandstoppumpingwhenthefluidis6”(150mm)fromthetop.Theunitwill 
continue to fill and will automatically shut off when the internal float valve operates. DO NOT continue to pump after the unit has shut
  offasthismayresultinliquidenteringtheinnerpumpchamber.Ifthisshouldoccurrefertosection4.1.8onhowtoexpelfluidfrom
the pump.
4.1.6.  Oncecompleted,removethemainsuctiontubefromthepump,pourtheoil/fluidintoasuitablecontainer(theunitcanbetipped,
  butnofurtherthan90°,tofacilitateemptying)anddisposeofitinaccordancewithlocalauthorityregulations.
4.1.7.  Beforeusingthepumpagainpressthevacuumreleasevalvefor5secondstoreleasethevacuumwithinthepump.Thisvalveis 
situated on the top of the unit underneath the handle.
4.1.8.  Intheeventoffluidenteringtheinnerpumpchamberitcanbeexpelledfromtheunitasfollows.Firstlypressthevacuumrelease 
  valvefor5secondstoreleasethevacuumwithinthepump.Sealoffthefluidentry/pouringholebyplacingyourhandoverit,then
  pumpthehandleupanddownseveraltimes.Anyfluidthathasenteredthepumpwillbeexpelledfromtheairvalveontheunderside
of the unit.
S01169|Issue2(H,F)22/10/18
Original Language Version
©JackSealeyLimited
Refer to
instructions
Wear eye
protection
Wear protective
gloves
Wear safety
footwear
Wear protective
clothing Donottipunitbeyond90°

4.2. OTHER FLUIDS
4.2.1.  Selectandinserttheappropriatediameterprobeintothefluidtobedrained.
4.2.2.  Connecttheextensiontubetoboththepumpinletandtheprobe.
4.2.3.  Theoperationoftheextractoristhesameasdescribedinsections4.1.5to4.1.7.
S01169|Issue2(H,F)22/10/18
Original Language Version
©JackSealeyLimited
Sealey Group, Kempson Way, Suffolk Business Park, Bury St Edmunds, Suffolk. IP32 7AR
01284 757500 01284 703534 [e-mail] www.sealey.co.uk
ENVIRONMENT PROTECTION
Recycleunwantedmaterialsinsteadofdisposingofthemaswaste.Alltools,accessoriesandpackagingshouldbesorted,takento
arecyclingcentreanddisposedofinamannerwhichiscompatiblewiththeenvironment.Whentheproductbecomescompletely
unserviceableandrequiresdisposal,drainanyfluids(ifapplicable)intoapprovedcontainersanddisposeoftheproductandfluids
according to local regulations.
Note:Itisourpolicytocontinuallyimproveproductsandassuchwereservetherighttoalterdata,specificationsandcomponentpartswithoutpriornotice.
Important:NoLiabilityisacceptedforincorrectuseofthisproduct.
Warranty:Guaranteeis12monthsfrompurchasedate,proofofwhichisrequiredforanyclaim.
Partssupportisavailableforthisproduct.Pleaselogontowww.sealey.co.uk,email[e-mail]ortelephone01284757500
g.1