Sony CQ-RG133W1 User manual

General
Power Supply DC 12V (11V - 16V),
Test Voltage 14.4V
Negative Ground
Tone Controls Bass ; ±12dB at 100Hz
Treble ; ±12dB at 10kHz
Current Consumption Less than 2.5A (Tape play mode,
0.5W×4ch)
Maximum Power Output 40W×4ch (at 400Hz, Vol. Max.)
Suitable Speaker Impedance 4-8Ω
Pre-Amp Output Voltage 2V (CD play mode; 1kHz, 0dB)
Output Impedance 200Ω
FM Stereo Radio
Frequency Range 87.5 - 108.0MHz
Usable Sensitivity 12.0dBf (1.1µV, 75Ω)
Frequency Response 30Hz to 15,000Hz (±3dB)
Alternate Channel Sensitivity 75dB
Stereo Separation 35dB(1kHz)
Signal to Noise Ratio 70dB(Mono)
© 2005 Matsushita Electric Industrial Co., Ltd. All
rights reserved. Unauthorized copying and
distribution is a violation of law.
CQ-RG133W1
Removable Face High-Power Cassette /
Receiver with Changer Control
AM Radio
Frequency Range 531 - 1,602kHz
Usable Sensitivity 28dB/µV (25µV, S/N 20dB)
Tape Player
Reproduction System 4-track,2-program stereo
Tape Speed 1-7/8” /sec (4.76cm/sec)
FF/REW Time Less than 200 sec (C-60)
Wavelength 780nm
Frequency Response 35Hz to 14,000Hz (±3dB)
Signal to Noise Ratio 52dB
Dimensions** 178×50×150mm
Weight** 1.6kg
* Specifications and the design are subject to possible modification
without notice due to improvements.
** Dimensions and Weight shown are approximate.
AUTOMOTIVE AFTERMARKET
Specification*
Order No. ACED050522C3

1 ABOUT LEAD FREE SOLDER (PbF) 2
2 FEATURES 2
3 REPLACING THE FUSE 2
4 MAINTENANCE 2
5 RADIO ALIGNMENT 2
6 DIMENSIONS 2
7 WIRING CONNECTION 3
8 BLOCK DIAGRAM 4
9 TERMINALS DESCRIPTION 5
1 ABOUT LEAD FREE
SOLDER (PbF)
Distinction of PbF PCB:
PCBs (manufactured) using lead free solder will have a PbF
stamp on the PCB.
Caution :
· Pb free solder has a higher melting point than standard
solder; Typically the melting point is 50 - 70°F (30 -
40°C) higher. Please use a soldering iron with
temperature control and adjust it to 700 ± 20°F (370 ±
10°C). In case of using high temperature soldering iron,
please be careful not to heat too long.
· Pb free solder will tend to splash when heated too high
(about 1100°F/600°C)
· This lead free solder will be used for the products after
serial No. 1,000,001.
2 FEATURES
· PLL (Phase Locked Loop) Synthesized Tuning
· 1DIN Size Body with Cassette Player,AM/FM Tuner, Power
AMP (30Wx4)
· 18-FM , 6-AM stations preset
· Auto preset and scan function
· CD Changer Control function
3 REPLACING THE FUSE
Be sure to use a fuse of the specified rating (10A) when
replacing a blown fuse. Fuses with higher capacity ratings,use
of any substitute, or connection without a fuse may result in a
fire hazard or damage to the unit.
4 MAINTENANCE
Your product is designed and manufactured to ensure a
minimum of maintenance. Use a soft cloth for routine exterior
cleaning. Never use benzine, or other solvent.
5 RADIO ALIGNMENT
Do not align the AM/FM package blocks. When the package
block is necessary, it will be supplied already aligned at the
10 PACKAGE AND IC BLOCK DIAGRAM 6
11 REPLACEMENT PARTS LIST (Unit) 8
12 EXPLODED VIEW (Unit) 12
13 REPLACEMENT PARTS LIST (Tape Player Parts) 13
14 EXPLODED VIEW (Tape Deck) 15
15 WIRING DIAGRAM 16
16 SCHEMATIC DIAGRAM 19
17 SCHEMATIC DIAGRAM for printing with A4 size 21
factory.
6 DIMENSIONS
CONTENTS
Page Page
2
CQ-RG133W1

7 WIRING CONNECTION
3
CQ-RG133W1

8 BLOCK DIAGRAM
4
CQ-RG133W1

IC601 : YEMLC72358N
Pin
No. Port Descriptions I/O (V) FM (V) AM (V) TAPE (V)
66 MODE B MODE B I 0 0 0
1XIN Crystal Oscilator I 2 2 2
2TEST2 TEST2 I 0 0 0
3SI0/PG3 CD Changer Data I 0 0 0
4SO0/PG2 - O - - -
5SCK0/PG1 CD Changer Clock I 0 0 0
6PGO Remoto Data Output O 0 0 0
7SI1/PF3 LCD Data Output I4.2 4.4 4.2
8SO1/PF2 LCD Data input O 0 5 0
9SCK1/PF1 LCD Clock O 5 5 5
10 PF0 LCD Chip Enble O 0 0 0
11 SI2/PE3 - O - - -
12 SO2/PE2 ALPS Rotary Encoder
Input I4.8 4.7 5
13 SCK2/PE1 In / Out Detection I 1 1 1
14 PE0 - O - - -
15 PD3 - O - - -
16 PD2 - O - - -
17 PD1 - O - - -
18 PD0 - O - - -
19 PC3 - O - - -
20 PC2 - O - - -
21 PC1 - O - - -
22 PC0 - O - - -
23 PB3 - O - - -
24 PB2 - O - - -
25 PB1 - O - - -
26 PB0 - O - - -
27 PA3 (Connect to Ground) I - - -
28 PA2 (Connect to Ground) I - - -
29 PA1 (Connect to Ground) I - - -
30 PA0 (Connect to Ground) I - - -
31 VDD Power supply +5V - 5 5 5
32 PQ0 - O - - -
33 PP3 System Power Control O 5 5 5
34 PP2 AMP ST-BY Control O 5 5 5
35 PP1 Mute Control O 5 5 0
36 PP0 Alarm LED Output O 0 0 0
37 PO3 Search Stop Control O 0 0 0
38 PO2 - O - - -
39 PO1 I2C Data O 5 5 5
40 PO0 I2C Clock O 5 5 5
41 PN3 - O - - -
42 PN2 - O - - -
43 PN1 - O - - -
44 PN0/BEEP - O - - -
45 PM3 - O - - -
46 PM2 - O - - -
47 PM1 - O - - -
48 PM0 - O - - -
49 PL3 - O - - -
50 PL2 Forward/Reverse Select I 0 0 5
51 PL1 - I 0 0 4.4
52 PL0 Tape In / Out Detection I 0 0 4.5
53 PK3 Battery Detection I5.7 5.6 5.7
54 PK2 - O - - -
55 PK1/INT1 ALPS Rotary Encoder
Input I4.8 04.8
56 PK0/INT0 CD Changer Strobe I 0 0 0
57 PJ3 Power LED Output
Control O 0 0 0
58 PJ2 FM MONO SW O 0 0 0
59 PJ1 Tuner On / Off Control O 0 0 7.1
60 PJ0 FM/AM Select Switch O 0 0 0
61 PI1/ADI5 (Connect to Ground) I - - -
62 PI0/ADI4 Mode Select B I 5 5 5
63 PH3/ADI3 Mode Select A I 0 0 5
Pin
No. Port Descriptions I/O (V) FM (V) AM (V) TAPE (V)
64 PH2/ADI2 Stereo Signal Input I4.8 0 0
65 PH1/ADI1 FM SD Input I0.77 2.5 0
66 PH0/ADI0 AM SD Input I0.56 2.2 0
67 HOLD ACC Detection I5.2 5.2 5.2
68 SNS Hot / Cold Detection I4.6 4.5 4.6
69 LCTR (Connect to Ground) I
70 HCTR FM/AM IF Input I2.3 2.3 0
71 EO3 - O - - -
72 SUBPD - O - - -
73 VDD Power supply +5V - 5 5 5
74 AMIN (Connect to Ground) I - - -
75 FMIN FM OSC Input I2.2 2.3 0
76 VSS Ground - 0 0 0
77 EO2 - O - - -
78 EO1 FM / AM VT Output O1.3 1.3 1.4
79 TEST1 TEST1 I 0 0 0
80 XOUT Crystal Oscilator O2.5 2.5 2.5
9.2. Display Block
IC901 : YEAMLC75853NW
Pin No. Port Descriptions I/O
(V) (V)
1-8 SEG1-8 LCD segment O2.5
9-35 SEG9-35 LCD segment O2.5
36-39 NC No connection - -
40-43 COM1-4 LCD common O2.5
44-49 KS1-6 Key data output O0.9
50-54 KI1-5 Key data input I 0
55 TEST (Connecting to ground) - 0
56 VDD +5V power supply -5.1
57 VDD1 Ground through capacitor -3.3
58 VDD2 Ground through capacitor -1.7
59 Vss Ground - 0
60 OSC CR oscillator -3.9
61 DO Key data output O4.4
62 CE Chip enable I 0
63 CLK LCD clock I 0
64 DI LCD data input I 0
9 TERMINALS DESCRIPTION
9.1. Main Block
5
CQ-RG133W1

P50 CT-T02B
IC602 YEAMTC4584FN
IC 200 YEAMLA3161
10 PACKAGE AND IC BLOCK DIAGRAM
IC270 C1EA00000041
6
CQ-RG133W1

IC205 YEAMPT2313L
7
CQ-RG133W1

Ref.
No. Part No. Part Name & Description Remarks
1. IC’s and Transistors
MAIN BLOCK [E-4C242]
IC200 YEAMLA3161 IC T
IC205 YEAMPT2313L IC T
IC270 C1EA00000041 IC T
IC601 LC72358N9B51 IC T
IC602 YEAMTC4584FN IC T
P50 CT-T02B Tuner T
Q51 YEANDTC144ST Transistor T
Q62 YEANA144EKT Transistor T
Q241 YEANC143TKT Transistor T
Q242 YEANC143TKT Transistor T
Q341 YEANC143TKT Transistor T
Q342 YEANC143TKT Transistor T
Q401 YEAN2SK583T Transistor T
Q610 YEANKRC107M Transistor T
Q630 YEANDTA144ST Transistor T
Q703 YEANKRC107M Transistor T
Q705 YEANA123YSAT Transistor T
Q707 YEANKRA226M Transistor T
Q708 YEAND1762EF Transistor T
Q710 YEANB1243QRT Transistor T
Q711 YEANKRC107M Transistor T
Q715 YEANKTC3203 Transistor T
Q718 YEANA144EKT Transistor T
Q719 YEANC114EKTX Transistor T
Q800 YEAND1762EF Transistor T
DISPLAY BLOCK [E-4C243]
IC901 YEAMLC75853NW IC T
Q901 YEANA114EKTX Transistor T
2. Diodes
MAIN BLOCK [E-4C242]
D251 YEAD1N4005ST Silicon Diode T
D252 YEAD1N4005ST Silicon Diode T
D261 YEAD1N4005ST Silicon Diode T
D262 YEAD1N4005ST Silicon Diode T
D351 YEAD1N4005ST Silicon Diode T
D352 YEAD1N4005ST Silicon Diode T
D361 YEAD1N4005ST Silicon Diode T
D362 YEAD1N4005ST Silicon Diode T
D401 YEADMTZJ10CT Zener Diode T
D50 YEAD1N4148C Diode T
D602 YEADMTZJ82BT Zener Diode T
D603 YEAD1N4148C Diode T
D606 YEAD1N4148C Diode T
Ref.
No. Part No. Part Name & Description Remarks
D607 YEAD1N4148C Diode T
D627 YEAD1N4148C Diode T
D701 YEAD1N5404FT Diode T
D703 YEAD1N4005ST Silicon Diode T
D704 YEADMTZJ91BT Zener Diode T
D705 YEADMTZJ51CT Zener Diode T
D707 YEAD1N4005ST Silicon Diode T
D708 YEAD1N4148C Diode T
D709 YEADRD62JS3T Zener Diode T
D710 YEAD1N4148C Diode T
D711 YEAD1N4148C Diode T
D712 YEADRD51JS3T Zener Diode T
D713 YEADMTZJ75BT Zener Diode T
D714 MA700TA Diode T
D752 YEADMTZJ51CT Zener Diode T
D753 YEADMTZJ82BT Zener Diode T
D901 YEAD1N4148C Diode T
Z700 ERZG07DK470T ZNR T
DISPLAY BLOCK [E-4C243]
D901 YEADSML310MT LED (GREEN) T
D902 YEADSML310MT LED (GREEN) T
D903 YEADSML310MT LED (GREEN) T
D904 YEADSML310MT LED (GREEN) T
D905 YEADSML310MT LED (GREEN) T
D906 YEADSML310MT LED (GREEN) T
D907 YEADSML310MT LED (GREEN) T
D908 YEADSML310MT LED (GREEN) T
D909 YEADSML310MT LED (GREEN) T
D910 YEADSML310MT LED (GREEN) T
D911 YEADSML310MT LED (GREEN) T
D912 YEADSML310MT LED (GREEN) T
D913 YEADSML310MT LED (GREEN) T
D914 YEADSML310MT LED (GREEN) T
D920 YEADSML310LT LED(RED) T
D921 B3AFB0000162 LED GREEN(LTA673) T
D931 MA8056LMHTX Diode T
D932 MA8056LMHTX Diode T
D933 MA8056LMHTX Diode T
D934 MA8056LMHTX Diode T
D935 MA8056LMHTX Diode T
3. Capacitors
MAIN BLOCK [E-4C242]
C51 ECEA1CKA470IV Electrolytic 47MFD 16WV T
C52 ECUV1H103KBN Ceramic 0.01MFD 50WV T
C53 ECUV1H103KBN Ceramic 0.01MFD 50WV T
C54 ECUV1H103KBN Ceramic 0.01MFD 50WV T
C55 YEU05B101K Axial 100PF 6WV T
C57 ECUV1H333KBN Ceramic 0.033MFD 50WV T
C58 ECUV1H333KBN Ceramic 0.033MFD 50WV T
C59 ECUV1H103KBN Ceramic 0.01MFD 50WV T
C60 ECUV1H103KBN Ceramic 0.01MFD 50WV T
C61 ECUV1H104KBM Ceramic 0.1MFD 50WV T
C62 ECUV1H104KBM Ceramic 0.1MFD 50WV T
C201 ECUV1H122KBN Ceramic 0.0012MFD 50WV T
C202 ECEA1CKS101IV Electrolytic 100MFD 16WV T
C203 ECEA1HKS010IV Electrolytic 1MFD 50WV T
C204 ECUV1H273KBN Ceramic 0.027MFD 50WV T
C232 ECEA1CKS100IV Electrolytic 10MFD 16WV T
C233 ECEA1HKS2R2IV Electrolytic 2.2MFD 50WV T
C234 ECUV1H104KBN Ceramic 0.1MFD 50WV T
C237 ECUV1H104KBN Ceramic 0.1MFD 50WV T
C238 ECUV1H272KBN Ceramic 0.0027MFD 50WV T
C239 ECEA1HKS3R3IV Electrolytic 3.3MFD 50WV T
C240 ECEA1HKS3R3IV Electrolytic 3.3MFD 50WV T
C241 ECEA1HKS010IV Electrolytic 1MFD 50WV T
C242 ECEA1HKS010IV Electrolytic 1MFD 50WV T
C249 ECUV1H222KBN Ceramic 2200pF 50WV T
C250 ECUV1H222KBN Ceramic 2200pF 50WV T
11 REPLACEMENT PARTS LIST (Unit)
8
CQ-RG133W1

Ref.
No. Part No. Part Name & Description Remarks
C251 ECEA1HKS010IV Electrolytic 1MFD 50WV T
C252 ECEA1HKS010IV Electrolytic 1MFD 50WV T
C253 ECEA1CKS100IV Electrolytic 10MFD 16WV T
C259 ECUV1H103KBN Ceramic 0.01MFD 50WV T
C301 ECUV1H122KBN Ceramic 0.0012MFD 50WV T
C302 ECEA1CKS101IV Electrolytic 100MFD 16WV T
C303 ECEA1HKS010IV Electrolytic 1MFD 50WV T
C304 ECUV1H273KBN Ceramic 0.027MFD 50WV T
C308 ECEA1AKS221IV Electrolytic 220MFD 10WV T
C325 ECEA0JKS101IV Electrolytic 100MFD 6.3WV T
C332 ECEA1CKS100IV Electrolytic 10MFD 16WV T
C333 ECEA1HKS2R2IV Electrolytic 2.2MFD 50WV T
C334 ECUV1H104KBN Ceramic 0.1MFD 50WV T
C337 ECUV1H104KBN Ceramic 0.1MFD 50WV T
C338 ECUV1H272KBN Ceramic 0.0027MFD 50WV T
C339 ECEA1HKS3R3IV Electrolytic 3.3MFD 50WV T
C340 ECEA1HKS3R3IV Electrolytic 3.3MFD 50WV T
C341 ECEA1HKS010IV Electrolytic 1MFD 50WV T
C342 ECEA1HKS010IV Electrolytic 1MFD 50WV T
C349 ECUV1H222KBN Ceramic 2200pF 50WV T
C350 ECUV1H222KBN Ceramic 2200pF 50WV T
C351 ECEA1HKS010IV Electrolytic 1MFD 50WV T
C352 ECEA1HKS010IV Electrolytic 1MFD 50WV T
C353 ECEA1CKS100IV Electrolytic 10MFD 16WV T
C401 ECEA1VSN4R7IV Electrolytic 4.7MFD 35WV T
C402 ECEA1AKS101IV Electrolytic 100MFD 10WV T
C403 ECUV1H103KBN Ceramic 0.01MFD 50WV T
C408 ECUV1H102KBN Ceramic 0.001MFD 50WV T
C410 ECUV1H104KBN Ceramic 0.1MFD 50WV T
C601 ECUV1H220JCN Ceramic 22pF 50WV T
C602 ECUV1H220JCN Ceramic 22pF 50WV T
C608 ECUV1H103KBN Ceramic 0.01MFD 50WV T
C610 ECEA1CKS100IV Electrolytic 10MFD 16WV T
C612 ECEA0JKS331IV Electrolytic 330MFD 6.3WV T
C625 ECEA1HKS010IV Electrolytic 1MFD 50WV T
C630 ECEA1CKS470IV Electrolytic 47MFD 16WV T
C631 ECEA1HKS010IV Electrolytic 1MFD 50WV T
C691 YEECFYH0H223 Electrolytic 22000MFD 5.5WV T
C701 ECEA0JKS101IV Electrolytic 100MFD 6.3WV T
C705 ECEA1CKS100IV Electrolytic 10MFD 16WV T
C707 ECEA1AKS221IV Electrolytic 220MFD 10WV T
C708 ECEA1AKS221IV Electrolytic 220MFD 10WV T
C709 ECEA1CKS101IV Electrolytic 100MFD 16WV T
C710 ECEA1CKS101IV Electrolytic 100MFD 16WV T
C711 ECUV1H103KBN Ceramic 0.01MFD 50WV T
C715 ECEA0JKS101IV Electrolytic 100MFD 6.3WV T
C717 ECEA1CKS100IV Electrolytic 10MFD 16WV T
C718 ECEA1HKS010IV Electrolytic 1MFD 50WV T
C720 ECA1CDT332Y Electrolytic 3300MFD 16WV T
C721 ECEA1HKS2R2IV Electrolytic 2.2MFD 50WV T
C722 ECEA1HKS010IV Electrolytic 1MFD 50WV T
C723 ECUV1H103KBN Ceramic 0.01MFD 50WV T
C724 ECEA1AKS470IV Electrolytic 47MFD 10WV T
C725 ECEA1HKSR47IV Electrolytic 0.47MFD 50WV T
C726 ECEA1HKSR47IV Electrolytic 0.47MFD 50WV T
C727 ECEA1CKA470IV Electrolytic 47MFD 16WV T
C735 ECUV1H103KBN Ceramic 0.01MFD 50WV T
C751 ECEA1CKS100IV Electrolytic 10MFD 16WV T
C755 ECEA1CKA470IV Electrolytic 47MFD 16WV T
DISPLAY BLOCK [E-4C243]
C901 ECUV1H224KBN Ceramic 0.22MFD 50WV T
C902 ECUV1H104KBN Ceramic 0.1MFD 50WV T
C903 ECUV1H104KBN Ceramic 0.1MFD 50WV T
C904 ECUV1H102KBN Ceramic 0.001MFD 50WV T
4. Resistors
MAIN BLOCK [E-4C242]
J801 ERJ8GX0R00V Chip 0 ohms 1/8W T
J802 ERJ8GX0R00V Chip 0 ohms 1/8W T
J803 ERJ8GX0R00V Chip 0 ohms 1/8W T
J804 ERJ8GX0R00V Chip 0 ohms 1/8W T
J805 ERJ8GX0R00V Chip 0 ohms 1/8W T
Ref.
No. Part No. Part Name & Description Remarks
J806 ERJ8GX0R00V Chip 0 ohms 1/8W T
J807 ERJ8GX0R00V Chip 0 ohms 1/8W T
J808 ERJ8GX0R00V Chip 0 ohms 1/8W T
J809 ERJ8GX0R00V Chip 0 ohms 1/8W T
J810 ERJ8GX0R00V Chip 0 ohms 1/8W T
J811 ERJ8GX0R00V Chip 0 ohms 1/8W T
J812 ERJ8GX0R00V Chip 0 ohms 1/8W T
J813 ERJ8GX0R00V Chip 0 ohms 1/8W T
J814 ERJ8GX0R00V Chip 0 ohms 1/8W T
J815 ERJ8GX0R00V Chip 0 ohms 1/8W T
J816 ERJ8GX0R00V Chip 0 ohms 1/8W T
J817 ERJ8GX0R00V Chip 0 ohms 1/8W T
J818 ERJ8GX0R00V Chip 0 ohms 1/8W T
J819 ERJ8GX0R00V Chip 0 ohms 1/8W T
J820 ERJ8GX0R00V Chip 0 ohms 1/8W T
J821 ERJ8GX0R00V Chip 0 ohms 1/8W T
J822 ERJ8GX0R00V Chip 0 ohms 1/8W T
J901 ERJ8GX0R00V Chip 0 ohms 1/8W T
R50 ERJ6GEYJ5R6V Chip 5.6 ohms 1/10W T
R51 ERJ6GEYJ472V Chip 4.7k ohms 1/10W T
R52 ERJ6GEYJ123V Chip 12k ohms 1/10W T
R53 ERJ6GEYJ221V Chip 220 ohms 1/10W T
R54 ERJ8GEYJ103V Carbon 10k ohms 1/8W T
R56 ERJ8GEYJ103V Carbon 10k ohms 1/8W T
R58 ERJ6GEYJ473V Chip 47k ohms 1/10W T
R59 ERJ6GEYJ822V Chip 8.2k ohms 1/10W T
R201 ERJ6GEYJ333V Chip 33k ohms 1/10W T
R202 ERJ6GEYJ270V Chip 27 ohms 1/10W T
R203 ERJ6GEYJ472V Chip 4.7k ohms 1/10W T
R204 ERJ6GEYJ124V Chip 120k ohms 1/10W T
R225 ERD25TJ822T Carbon 8.2k ohms 1/4W T
R226 ERJ6GEYJ472V Chip 4.7k ohms 1/10W T
R241 ERJ6GEYJ103V Chip 10k ohms 1/10W T
R242 ERJ6GEYJ103V Chip 10k ohms 1/10W T
R243 ERJ8GEYJ471V Chip 470 ohms 1/8W T
R250 ERJ6GEYJ562V Chip 5.6k ohms 1/10W T
R253 ERD25TJ472T Carbon 4.7k ohms 1/4W T
R263 ERJ6GEYJ101V Chip 100 ohms 1/10W T
R264 ERJ6GEYJ101V Chip 100 ohms 1/10W T
R271 ERD25TJ101T Carbon 100 ohms 1/4W T
R272 ERD25TJ101T Carbon 100 ohms 1/4W T
R281 ERJ6GEYJ223V Chip 22k ohms 1/10W T
R282 ERJ6GEYJ223V Chip 22k ohms 1/10W T
R301 ERJ6GEYJ333V Chip 33k ohms 1/10W T
R302 ERJ6GEYJ270V Chip 27 ohms 1/10W T
R303 ERJ6GEYJ472V Chip 4.7k ohms 1/10W T
R304 ERJ6GEYJ124V Chip 120k ohms 1/10W T
R309 ERJ8GEYJ221V Chip 220 ohms 1/8W T
R325 ERD25TJ822T Carbon 8.2k ohms 1/4W T
R326 ERJ6GEYJ472V Chip 4.7k ohms 1/10W T
R338 ERD25TJ102T Carbon 1k ohms 1/4W T
R339 ERD25TJ102T Carbon 1k ohms 1/4W T
R341 ERJ6GEYJ103V Chip 10k ohms 1/10W T
R342 ERJ6GEYJ103V Chip 10k ohms 1/10W T
R343 ERJ8GEYJ471V Chip 470 ohms 1/8W T
R350 ERJ6GEYJ562V Chip 5.6k ohms 1/10W T
R353 ERD25TJ472T Carbon 4.7k ohms 1/4W T
R363 ERJ6GEYJ101V Chip 100 ohms 1/10W T
R364 ERJ6GEYJ101V Chip 100 ohms 1/10W T
R371 ERD25TJ101T Carbon 100 ohms 1/4W T
R372 ERD25TJ101T Carbon 100 ohms 1/4W T
R381 ERJ6GEYJ223V Chip 22k ohms 1/10W T
R382 ERJ6GEYJ223V Chip 22k ohms 1/10W T
R401 ERJ8GEYJ472V Chip 4.7k ohms 1/8W T
R404 ERDS2TJ152T Carbon 1.5k ohms 1/4W T
R405 ERJ6GEYJ152V Chip 1.5k ohms 1/10W T
R406 ERJ8GEYJ152V Carbon 1.5k ohms 1/8W T
R407 ERJ6GEYJ471V Chip 470 ohms 1/10W T
R408 ERD25TJ181T Carbon 180 ohms 1/4W T
R603 ERJ6GEYJ473V Chip 47k ohms 1/10W T
R604 ERJ6GEYJ473V Chip 47k ohms 1/10W T
R606 ERD25TJ102T Carbon 1k ohms 1/4W T
R611 W5NL Jump 5mm T
9
CQ-RG133W1

Ref.
No. Part No. Part Name & Description Remarks
R614 ERDS2TJ473T Carbon 47k ohms 1/4W T
R615 ERD25TJ473T Carbon 47k ohms 1/4W T
R616 ERDS2TJ473T Carbon 47k ohms 1/4W T
R617 ERJ6GEYJ473V Chip 47k ohms 1/10W T
R618 ERD25TJ102T Carbon 1k ohms 1/4W T
R619 ERJ6GEYJ473V Chip 47k ohms 1/10W T
R621 ERDS2TJ183T Carbon 18k ohms 1/4W T
R623 ERJ6GEYJ563V Chip 56k ohms 1/10W T
R624 ERJ6GEYJ473V Chip 47k ohms 1/10W T
R626 ERJ6GEYJ472V Chip 4.7k ohms 1/10W T
R628 ERJ6GEYJ333V Chip 33k ohms 1/10W T
R629 ERJ6GEYJ104V Chip 100k ohms 1/10W T
R630 ERD25TJ102T Carbon 1k ohms 1/4W T
R636 ERJ6GEYJ103V Chip 10k ohms 1/10W T
R637 ERJ6GEYJ103V Chip 10k ohms 1/10W T
R638 ERJ6GEYJ472V Chip 4.7k ohms 1/10W T
R642 ERJ6GEYJ103V Chip 10k ohms 1/10W T
R643 ERJ6GEYJ223V Chip 22k ohms 1/10W T
R648 ERJ6GEYJ473V Chip 47k ohms 1/10W T
R650 ERDS2TJ102T Carbon 1k ohms 1/4W T
R654 ERJ6GEYJ473V Chip 47k ohms 1/10W T
R655 ERJ6GEYJ473V Chip 47k ohms 1/10W T
R656 ERJ6GEYJ473V Chip 47k ohms 1/10W T
R691 ERJ6GEYJ102V Chip 1k ohms 1/10W T
R692 ERJ6GEYJ102V Chip 1k ohms 1/10W T
R693 ERJ6GEYJ102V Chip 1k ohms 1/10W T
R694 ERJ6GEYJ102V Chip 1k ohms 1/10W T
R695 ERD25TJ102T Carbon 1k ohms 1/4W T
R696 ERD25TJ102T Carbon 1k ohms 1/4W T
R697 ERD25TJ102T Carbon 1k ohms 1/4W T
R698 ERD25TJ102T Carbon 1k ohms 1/4W T
R699 ERJ6GEYJ102V Chip 1k ohms 1/10W T
R700 ERD25TJ102T Carbon 1k ohms 1/4W T
R701 ERD25TJ102T Carbon 1k ohms 1/4W T
R705 ERD25FJ331T Carbon 330 ohms 1/4W T
R721 ERD25FJ5R6T Carbon 5.6 ohms 1/4W T
R722 ERD25TJ331T Carbon 330 ohms 1/4W T
R723 ERD25FJ5R6T Carbon 5.6 ohms 1/4W T
R725 ERDS2TJ221T Carbon 220 ohms 1/4W T
R727 ERJ6GEYJ473V Chip 47k ohms 1/10W T
R728 ERDS1FJ681T Carbon 680 ohms 1/2W T
R729 ERDS1FJ681T Carbon 680 ohms 1/2W T
R736 ERJ6GEYJ105V Carbon 1M ohms 1/10W T
R737 ERJ8GEYJ472V Chip 4.7k ohms 1/8W T
R738 ERDS2TJ330T Carbon 33 ohms 1/4W T
R739 ERJ6GEYJ562V Chip 5.6k ohms 1/10W T
R740 ERD25TJ472T Carbon 4.7k ohms 1/4W T
R751 ERD25FJ2R7T Carbon 2.7 ohms 1/4W T
R752 ERJ6GEYJ103V Chip 10k ohms 1/10W T
DISPLAY BLOCK [E-4C243]
J901 ERJ8GX0R00V Chip 0 ohms 1/8W T
J902 ERJ8GX0R00V Chip 0 ohms 1/8W T
J903 ERJ8GX0R00V Chip 0 ohms 1/8W T
J904 ERJ8GX0R00V Chip 0 ohms 1/8W T
J905 ERJ8GX0R00V Chip 0 ohms 1/8W T
J906 ERJ8GX0R00V Chip 0 ohms 1/8W T
J907 ERJ8GX0R00V Chip 0 ohms 1/8W T
J908 ERJ8GX0R00V Chip 0 ohms 1/8W T
J909 ERJ6GEY0R00V Chip 0 ohms 1/10W T
J910 ERJ8GX0R00V Chip 0 ohms 1/8W T
J911 ERJ8GX0R00V Chip 0 ohms 1/8W T
J920 ERJ6GEY0R00V Chip 0 ohms 1/10W T
J940 ERJ6GEY0R00V Chip 0 ohms 1/10W T
J941 ERJ6GEY0R00V Chip 0 ohms 1/10W T
J943 ERJ8GX0R00V Chip 0 ohms 1/8W T
J948 ERJ8GX0R00V Chip 0 ohms 1/8W T
J949 ERJ8GX0R00V Chip 0 ohms 1/8W T
R901 ERJ6GEYJ221V Chip 220 ohms 1/10W T
R902 ERJ6GEYJ181V Chip 180 ohms 1/10W T
R903 ERJ6GEYJ181V Chip 180 ohms 1/10W T
R904 ERJ6GEYJ181V Chip 180 ohms 1/10W T
R905 ERJ6GEYJ331V Chip 330 ohms 1/10W T
Ref.
No. Part No. Part Name & Description Remarks
R906 ERJ6GEYJ331V Chip 330 ohms 1/10W T
R907 ERJ6GEYJ681V Chip 680 ohms 1/10W T
R909 ERJ6GEYJ681V Chip 680 ohms 1/10W T
R910 ERJ6GEYJ103V Chip 10k ohms 1/10W T
R911 ERJ6GEYJ473V Chip 47k ohms 1/10W T
R912 ERJ6GEYJ4R7V Chip 4.7 ohms 1/10W T
R928 ERJ6GEYJ103V Chip 10k ohms 1/10W T
5. Connectors
MAIN BLOCK [E-4C242]
CN210 YEAE2011P05 Connector T
CN350 YEAER120002 Connector ( RCA ) T
CN601 YEAE012475 Connector T
CN680 YEAE4CDIN023 Connector T
CN701 K1FA116B0028 Connector T
CN751 YEAE2011P06 Connector T
DISPLAY BLOCK [E-4C243]
CN901 YEAE012476 Connector T
6. Electric Parts
SWITCHES
SW902 K0H1BA000445 Tack Swich T
SW903 K0H1BA000445 Tack Swich T
SW905 K0H1BA000445 Tack Swich T
SW909 K0H1BA000445 Tack Swich T
SW911 K0H1BA000445 Tack Swich T
SW912 K0H1BA000445 Tack Swich T
SW913 K0H1BA000445 Tack Swich T
SW914 K0H1BA000445 Tack Swich T
SW916 K0H1BA000445 Tack Swich T
SW917 K0H1BA000445 Tack Swich T
SW918 K0H1BA000445 Tack Swich T
SW919 K0H1BA000445 Tack Swich T
SW920 K0H1BA000445 Tack Swich T
SW921 K0H1BA000445 Tack Swich T
LCD
LCD901 YEXDCM4C099A LCD T
CRYSTAL
XL601 YEXL4C45TT Crystal T
COILS
L101 YELT02C470KT Axial Coil T
L102 YELT02C101KT Axial Coil T
L700 YETQ024C055V Choke Coil T
SURGE PROTECTOR
Z51 YEADYP201M Surge Protector T
POSISTOR
PT701 YERT7AR4R7MT Posistor T
VR
VR901 K9AA024A0007 ENCODE VR T
7. Accessories
INSTALLATION PARTS
FX0214C316ZA Mounting Collar T
YAJ024C115ZA Power Connector T
YFC054C061ZA Unit Case T
YFG044C002ZA Rear Support Strap T
8. Mechanical Parts
MISCELLANEOUS
ANT1 YAA104C700ZA ANT Jack T(2-C)
AT1 YAT034C009ZA Terminal T(2-C)
AT2 YAT034C009ZA Terminal T(2-B)
AT3 YAT034C009ZA Terminal T(2-C)
CP210 YEAE11H4105A Connector T(3-C)
CP751 YEAE1661801C Connector ( Deck ) T(4-C)
2YFA054C036YA Under Cover T(1-C)
10
CQ-RG133W1

Ref.
No. Part No. Part Name & Description Remarks
3YFV014C068ZA Sheet T(1-C)
4YFA084C042ZA Rear Plate T(3-C)
5YFA074C046ZA Front Plate T(2-B)
6YFA094C091ZA Right Plate T(2-C)
7YFF014C047ZA Heat Sink T(3-B)
8YEJT034C001 Screw T(2-C)
9XTB3+6FFXS Screw T(3-B);
T(3-C);
T(2-C)
10 XSB3+6FXS Screw T(3-C)
11 YEJT034C019 Screw(Cup Tight 3x12) T(3-B)
12 FX0214C320ZA RCA Bkt T(3-C)
13 XTB26+8G Screw T(3-C)
14 FX0214C172WA IC Bracket T(2-B)
15 FX0214C322ZA Tr Bkt T(2-B)
16 YJS064C002ZA Screw (m3x8) T(2-B)
17 YEFD044C026A Deck Mechanism T(3-C)
18 FX0214C325ZA Deck Bracket T(3-C)
19 XSB26+4FX Screw T(3-C)
20 YFC024C596ZA Esc Holder T(2-B)
21 YEFS011113 Pad T(2-B)
22 YFX024C054ZB Cast Cover T(2-B)
23 FX0054C045ZA Spring(Cast) T(2-B)
24 YFE134C440ZA Push Button T(2-B)
25 FX0054C058ZA Spring (Push Button) T(2-B)
26 YEFX9991682A Release Hook T(2-B)
27 FX0054C049ZA Spring(Hook) T(2-B)
28 YJT034C015CA Step Screw T(2-B)
29 YFA034C044ZA Upper Cover T(4-C)
30 YFC054C059ZA Trim Plate(Print) T(1-A)
31 YFX054C051ZA Spring Plate(R) T(2-C)
32 YFX054C052ZA Spring Plate(L) T(3-B)
34 YFC034C010ZA Esc Front Cover T(1-A)
35 YFE134C425ZA Button (Eject) T(1-A)
36 YFE134C427ZA Button (REW) T(1-A)
37 YFE134C426ZA Button (FF) T(1-A)
38 FX0054C056ZA Spring T(1-A)
39 YFE134C433ZA Button(Band/Pwr) T(2-A)
40 YFE134C432ZA Button (Preset) T(1-A)
41 YFE134C431ZA Button(Tune/Track) T(1-B)
42 YFE134C430ZA Button(CD.C/Disp) T(1-B)
44 YFE074C057ZA Vol Knob T(2-A)
45 YFX054C053ZA Spring (Knob) T(2-A)
46 YFE134C419ZA Button(Release) T(1-B)
47 FX0054C055ZA Spring (Open) T(1-B)
48 YFC024C595ZA Rear Cover T(2-B)
49 XTN2+8GFZ Screw (Esc) T(2-B)
50 YFV024C080ZA Sheet(LCD) T(2-B)
51 YFX214C315YA LCD Bracket T(2-B)
52 YEFX0012300 Back light assy T(2-B)
53 FX0464C013YA Eject Lever T(4-B)
54 YFE134C148ZA Eject Lever Holder T(3-B)
55 YFE134C149ZA Lever Holder T(3-C)
56 YEJT034C007 Screw T(4-B)
57 AAPB242B0-J Main PCB Ass’y T(2-C)/
RTL
58 ESCRG133W1J ESC Unit Ass’y T(1-A);
T(2-B)/
RTL
59 APCB243B1-J Key PCB Ass’y T(2-B)/
RTL
11
CQ-RG133W1

12 EXPLODED VIEW (Unit)
12
CQ-RG133W1

Ref.
No. Part No. Part Name & Description Remarks
MISCELLANEOUS
1X-0363-1001 Main Chassis Ass”y (C-2)
2X-0363-1002 Head Plate Ass”y (B-3)
3X-0363-1004 FR Convert Arm(A) Ass”y (B-3)
4X-0363-6001 Reel Base Ass”y (D-1)
5X-0363-6002 Lever Bracket Ass’y (B-4)
6X-0363-6003 TU Gear Arm Ass’y (B-4)
7X-0363-6004 Pinch Arm( R )Ass’y (C-2)
8X-0363-6005 Pinch Arm( F )Ass’y (C-4)
9X-0363-6006 Detector Cam Ass’y (D-2)
10 X-0363-2005 Reel Spindle Ass”y (D-2)
11
12 X0036-1019 Eject Cam Lock Ass’y (B-1)
13
14
15 X-0363-6010 Flywheel Ass’y(F)CPL T(D-4)
16 X-0363-6011 Flywheel Ass’y(R)CPL T(D-4)
17
18
19 X0036-1051 FF Lever (AT) (A-4)
20 X0036-1053 Rew Leaver(AT) (A-4)
21 X0036-1007 Eject Leaver (C-2)
22 X0036-1029 Lock Arm( A ) (B-4)
23 X0036-1015 Spg Support Plate (A-3)
24 X0036-1018 Center Plate (A-1)
25 X0036-1023 Changer Lever (B) (B-4)
26 X0036-1026 FR Arm(B) (D-3)
27
28
29
30 1-0138-1002 Cassette Hanger(X) (A-1)
31 1-0138-1006 Adjuster Shim(X) (B-3)
32 1-0138-1010 (B-1)
33
34
35 1-0363-1003 Eject Cam (C-1)
36
37 1-0036-2001 Idle Gear (D-1)
38 1-0036-2003 Reduction Gear (B) (C-1)
39 1-0036-2004 Reduction Gear (A) (C-1)
40 1-0036-2007 Ratchet (C-1)
41 1-0036-2009 Sensor Arm (D-1)
42 1-0036-2010 Selector Gear (D-1)
43 1-0036-2014 Detector Gear (D-1)
44 1-0038-2014 Gear Lock Arm (C-1)
45 1-0038-2018 Tape Guide (B-3)
46 1-0363-2006 Adjuster Link(B) (B-3)
47 1-0138-2005-3 Adjuster Arm Blue (B-3)
48 1-0036-2005 Pulley Gear (D-3)
49 1-0032-2007 Tape Hooker (B-1)
50 1-0058-2021-5 Idle Pulley(A) (C-3)
51
Ref.
No. Part No. Part Name & Description Remarks
52
53 1-0036-3032 FF Roller(A) (A-3)
54 1-0036-3018 Collar(Selector Gear) (D-1)
55 1-0363-3042 Motor Pully(MBC) (B-2)
56
57 1-0363-3007 HP Roller(A) (B-3)
58 1-0363-3011 Program Roller (B-4)
59
60
61 1-0036-4001 FF/REW Lever SPG (A-4)
62 1-0036-4002 Lock Lever SPG (B-4)
63 1-0036-4003 Gear Lock Arm SPG (C-1)
64
65 1-0036-4006 Head Plate SPG (B-3)
66 1-0036-4007 Eject Cam Lock SPG (A-1)
67 1-0036-4008 Program Arm SPG (B-4)
68 1-0036-4010 Adjuster Arm SPG(A) (A-3)
69 1-0036-4011 Adjuster Arm SPG(B) (A-3)
70 1-0036-4015 Dash SPG (D-1)
71 1-0036-4017 SW Select Arm SPG (B-3)
72 1-0036-4023 Center Plate SPG(B) (A-1)
73 1-0038-4014 Ratchet SPG (C-1)
74 1-0138-4001 Back Tension SPG (D-2)
75
76 1-0363-4003 Pinch Arm SPG( F ) (C-4)
77 1-0363-4004 Pinch Arm SPG( R ) (C-2)
78 1-0363-4005 Eject Leaver SPG (C-1)
79 1-0363-4006 Eject Cam SPG (C-1)
80 1-0036-5004 Main Belt T(D-4)
81 1-0363-5007 Return Link (A-1)
82 1-0363-5001 SUB Belt T(D-2)
83 1-0363-5003 Selector Link (B) (B-4)
84
85 1-0036-7002 Wire(A)Black 60mm (D-4)
86 1-0036-7003 Wire(B)Red 60mm (D-3)
87 1-0036-7073 Wire(AL)Yellow 60mm (D-3)
88
89
90 1-0036-7057 Motor T(A-2)
91
92
93 1-0363-7001 Mute SW (C-3)
94 1-0363-7002 Slide SW (C-4)
95 1-0363-7003 Slide SW PWB (C-4)
96 1-0363-7004 Head T(A-3)
97 1-0363-7005 Power SW (C-2)
98
99
100
101
102
103
104
105 2-1816-0032-
E8 LMW-S (C-3)
106 2-1812-0030-
D2 PSW-S (B-3)
107 2-0036-5024 PSW(Reel)B (A-3)
108
109 2-1712-0050-
16 E-Ring (A-4)
110 2-1712-5060-
16 E-Ring (B-4)
111
112
113
114
115 2-1331-7040-
C2 Screw (M1.7x4) (C-3)
116 2-1331-7060-
C2 Screw (M1.7x6) (C-2)
13 REPLACEMENT PARTS LIST (Tape Player Parts)
13
CQ-RG133W1

Ref.
No. Part No. Part Name & Description Remarks
117 2-1382-0030-
C2 Screw (M2x3) (D-1)
118 2-1332-0040-
C1 Screw (M2x4) (B-4)
119 2-1032-0070-
C2 Screw (M2x7) (B-3)
120 2-1032-0025-
C2 Screw (M2x2.5) (A-1)
121 2-1012-0040-
C2 Screw (M2x4) (A-3)
122 2-1012-0030-
F2 Screw (M2x3) (C-3)
123 1-0138-5002 Screw (M2x5) (A-3)
14
CQ-RG133W1

14 EXPLODED VIEW (Tape Deck)
15
CQ-RG133W1

15.1. Main Block-1
15 WIRING DIAGRAM
[E-4C242] [TOP VIEW]
CQ-RG153U/RG133W/RG133W1 Main PCB
16
CQ-RG133W1

15.2. Main Block-2
CQ-RG153U/RG133W/RG133W1 MAIN PCB
[E-4C242] [BOTTOM VIEW]
17
CQ-RG133W1

15.3. Display Block
[E-4C243] [TOP VIEW] [E-4C243] [BOTTOM VIEW]
CQ-RG153U/RG133W/RG133W1
Display PCB
18
CQ-RG133W1

16 SCHEMATIC DIAGRAM
16.1. Main Block
CQ-RG153U/RG133W/RG133W1 Main Block
E-4C242
CQ-RG133W1
19

16.2. Display Block
E-4C243
CQ-RG153U/RG133W/RG133W1 Display Block
CQ-RG133W1
20