Sony Walkman WM-FX551 User manual

WM-FX551/FX553
AEP Model
E Model
WM-FX551/FX553
US Model
Canadian Model
Tourist Model
WM-FX553
SERVICE MANUAL
RADIO CASSETTE PLAYER
Sony Corporation
Personal Audio Company
Published by Sony Engineering Corporation
9-923-156-12
2002A1600-1
© 2002.1
WPhoto : WM-FX551
Ver 1.1 2002. 01
SPECIFICATIONS
Radio section
Frequency range
FM : 87.5 - 108 MHz
AM : 531 - 1,602 kHz
Tape section
Frequency response
(Dolby NR off)
Playback : 20 -18,000 Hz
Output
Headphones (2REMOTE jack)
Load impedance 8 - 300 ohms
Power output
5 mW + 5 mW (16 ohms)
General
Power requirements
1.5 V
Dimensions (w/h/d)
Apporx. 109 ×79.2 ×25.9 mm, incl.
projecting parts and controls
Mass
Approx. 150 g
FX553 : Approx. 175 g incl.
headphones with remote control
and cassette
FX551 : Approx. 160 g incl.
headphones and cassette
Supplied accessories
Stereo headphones with remote
control (1) (FX553)
Stereo headphones (1) (FX551)
Clip (1) (FX553)
Carring pouch (1)
Design and specifications are subject to
charge without notice.
Manufactured under license from Dolby Laboratories
Licensing Corporation.
“DOLBY” and the double-D symbol aare trademarks
of Dolby Laboratories Licensing Corporation.
Model Name Using Similar Mechanism NEW
Tape Transport Mechanism Type MT-WMEX550-125

— 2 —
TABLE OF CONTENTS
Flexible Circuit Board Repairing
• Keep the temperature of the soldering iron aroud 270˚ C during
repairing.
• Do not touch the soldering iron on the same conductor of the
circuit board (within 3 times).
• Be careful not to apply force on the conductor when soldering
or unsoldering.
Notes on chip component replacement
• Never reuse a disconnected chip component.
• Notice that the minus side of a tantalum capacitor may be
damaged by heat.
Specification ················································································· 1
1. GENERAL ·········································································· 3
2. SERVICE NOTE ······························································· 3
3. DISASSEMBLY
3-1. Case Assy Removal ······················································· 4
3-2. Tuner Board Removal···················································· 4
3-3. Audio Board Removal ··················································· 5
3-4. Cassette Lid Assy Removal ··········································· 5
3-5. Mechanism Deck Removal············································ 6
4. MECHANICAL ADJUSTMENT ·································· 7
5. ELECTRICAL ADJUSTMENT ···································· 7
6. EXPLANATION OF IC TERMINALS························· 9
7. DIAGRAMS
7-1. Printed Wiring Boards (Tuner Section) ······················· 11
7-2. Schematic Diagram (Tuner Section) ··························· 15
7-3. Schematic Diagram (Audio Section)··························· 18
7-4. Printed Wiring Board (Audio Section) ························ 21
8. EXPLODED VIEWS
8-1. Cabinet Section ··························································· 27
8-2. Audio, Tuner Board Section ········································ 28
8-3. Mechanism Section (MT-WMEX550-125) ················· 29
9. ELECTRICAL PARTS LIST ······································· 30
The components identified by mark !or
dotted line with mark !are critical for safety.
Replace only with part number specified.
Les composants identifiés par une marque
!sont critiques pour la sécurité.
Ne les remplacer que par une pièce portant
le numéro spécifié.

— 3 —
SECTION 1
GENERAL
• LOCATION OF CONTROL
SECTION 2
SERVICE NOTE
• Regarding the method of adjustment and voltage check, perform sections 3-1 and 3-2 of the DISASSEMBLY, and attach the JIG to the
AUDIO board as shown below.
1
!¢
2
4
5
6
3
9
!
08
!£
!⁄
!⁄ Battery case
!“
!`
7
1OPEN knob
4TUNING + button
6ENTER button
7ˇ/REPEAT button
8p/RADIO OFF button
9MENU button
0SET button
!BAND button
!` VOLUME knob
!“ HOLD knob
!¢ Display window
!£ 2REMOTE jack
5TUNING –button
2PRESET + /AMS FF button
3PRESET –/AMS REW button
Screw
(M1.4 ×5.0) Screw (M1.4 ×5.0)
TUNER board
Screw (M1.7 ×4.0)
Screw
(M1.4 ×5.0)
JIG
AUDIO board

—4 —
SECTION 3
DISASSEMBLY
Note : Follow the disassembly procedure in the numerical order given.
3-1. CASE ASSY REMOVAL
3-2. TUNER BOARD REMOVAL
5Case assy
3Screw
(M1.4 ×2.2)
1Screw
(M1.4 ×2.2)
2Screw
(M1.4 ×2.2
)
4
1Scew (M1.7 ×6)
4TUNER board
3Scew
(M1.4 ×4.5)
6GUIDE (TU )
5
2Scew (M1.7 ×3)

—5 —
3-3. AUDIO BOARD REMOVAL
3-4. CASSETTE LID ASSY REMOVAL
5AUDIO board 1Remove solder
2Remove solder
3Flexible board
4
2Screw (M1.4 ×2)
5Cassette lid assy
3Screw (M1.4 ×2)
1OPEN button
4

—6 —
3-5. MECHANISM DECK REMOVAL
2
1
3
4Reel ornament
5Mechanism deck

SECTION 4
MECHANICAL ADJUSTMENT
PRECAUTION
1. Clean the following parts with a denatured-alcahol-moistened
sweb :
Playback head Pinch roller
Rubber belt Capstan
2. Demagnetize the playback head using a demagnetizer.
3. Do not use a magnetized screwdriver for adjustments.
4. After adjusting, apply screw-locking compound onto the
adjusted parts.
5. Unless specified otherwise, use a specified voltage (1.3V) to
perform the adjustments.
Torqu Measurement
Mode
FWD
FWD
Back Tension
REV
REV
Back Tension
FF
REW
Torqu meter
CQ-102C
CQ-102RC
CQ-201B
Meter reading
20 - 30 g · cm
0.4 - 2.0 g · cm
20 - 30 g · cm
0.4 - 2.0 g · cm
More than 40 g · cm
SECTION 5
ELECTRICAL ADJUSTMENT
PRECAUTION
1. Specified voltage : 1.3V
2. Switch position
DOLBY NR switch : OFF
AVLS switch : OFF
CASSETTE SECTION
Test Tape
Tape Speed Adjustmnet
Procedure :
1. Playback WS-48A (Tape center part) in the FWD state and
adjust RV601 so that the frequency counter reading becomes
3,000Hz ±30Hz.
2. Playback WS-48A (Tape center) in the REV state.
Check that frequency counter reading is within 2.0% of the
reading of step1.
Adjustment Point :
[MAIN BOARD] — SIDE A —
TUNER SECTION
[AM]
BAND switch : AM
[FM]
BAND switch : FM
• Repeat the procedures in each adjustment several times, and the
frequency coverage and tracking adjustments should be finally
done by the trimmer capacitors.
AM TRACKING ADJUSTMENT
Adjust for a maximum reading on level meter.
L4 621kHz
CT1 1,395kHz
FM IF ADJUSTMENT
Adjust for a maximum reading on level meter.
L3 10.7MHz
( ) : Saudi Arabia model
FM VOLTAGE ADJUSTMENT
1.1 V ±0.05 V (3.6V±0.05V)
L2 76MHz (87.5MHz)
FM VCO Adjustment
Procedure :
1. Connect the frequency counter to the positions shown below.
2. Turn the set to 98MHz.
3. Adjust RV1 for 19kHz ±100Hz reading on the frequency
counter.
Adjustment Parts Location :
[TUNER BOARD] — SIDEA —
Type
WS-48A
Signal
3kHz, 0dB
Purpose
Tape Speed Adjustment
SECTION 6
EXPLANATION OF IC TERMINALS
— 7 — — 8 — — 9 — — 10 —
Test tape
WS-48A
(3kHz, 0dB)
Set
16Ω
PHONES jack
+
–
Frequency counte
r
RV601 :Tape speed
AM RF signal
generator
30% amplitude modulation
by 400Hz signal.
Output level : as low as possible
Put the lead-wire antenna
close to the set.
Set
32Ω
PHONES
+
–
FM RF signal
generator
22.5kHz frequency
deviation by 400Hz signal.
Output level : as low as possible.
0.01µF
to ANT (TP1
)
Level meter
FM RF signal
generator
Carrier frequency : 98MHz
Modulation : No moduration
Output level : 0.1V (100dB)
0.01µF
to ANT (TP1
)
Pin No.
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
I/O
O
O
O
O
O
O
O
I
I
I
I
I
O
I
O
I
I
I
I
O
O
I/O
O
O
Description
Common terminal.
Common terminal.
Common terminal.
Segment output terminal.
Segment output terminal.
Segment output terminal.
Segment output terminal.
Segment output terminal.
Segment output terminal.
Segment output terminal.
Segment output terminal.
Segment output terminal.
Segment output terminal.
Segment output terminal.
Segment output terminal.
Segment output terminal.
Segment output terminal.
Segment output terminal.
Segment output terminal.
Segment output terminal.
Segment output terminal.
Segment output terminal.
Segment output terminal.
Segment output terminal.
Segment output terminal.
Remote control data output.
DDC control terminal (when DDC ON = L).
BAND control output (when AM = Hi-imp, when FM = L).
MUTE control terminal (when MUTE ON = L).
HEAD select terminal (when FWD = Hi-imp, when REV = L).
Tone control terminal (when BOOST ON = Hi-imp, when OFF = L).
IF REQ control terminal (when REQ = Hi-imp).
HOLDER detect input (when HOLDER CLOSE = H).
Communication request from the remote controller. (H = VCC).
HOLDER detect and TAPE error erase detect terminal.
TAPE rotating direction detect terminal.
Input when the key is pressed during HOLD (H = ADVref).
Terminal for controlling the rotation detect circuit.
Rotation detect input.
AMS sensitivity select (when AMS = H, when BL.SKIP = L).
Tape sound existing or not-exiting detect (Music
exists: L, music does not exist: H.
Voltage detect input.
KEY input terminal.
Reference voltage of AD IN 1, 2.
LED output terminal.
E2PROM CS control terminal.
E2PROM DATA I/O.
E2PROM CLOCK terminal.
BEEP (when TC : 1.6 kHz, when CF : 3.0 kHz).
Function
COM 1
COM 2
COM 3
S1
S2
S3
S4
S5
S6
S7
S8
S9
S10
S11
S12
S13
S14
S15
S16
S17
S18
S19
S20
S21
S22
R DATA OUT
DDC1 CTL
BAND AM/FM
MUTE CTL
F/R CTL
BST CTL
IF REQ
HOLD SW
R DATA IN
HOLDER, TUME
F/R SW
HOLD SENS
PHOTO CTL
PHOTO IN
AMS CTL
AMS IN
BATT DET
KEY IN
AD Vref
LED CTL
CS
M DATA I/O
M CLOCK
BEEP
Circuit
Output
Output (Nch)
Output (Nch)
Output (Nch)
Output (Nch)
Output (Nch)
Output (Nch)
Input
Input
Input
Input
Input
Input/Output
Input/Output
Input/Output
Input/Output
Input/Output
Input/Output
Input/Output
Input/Output
Input/Output
Input/Output
Input/Output
Input/Output
Remarks
VLD at High level.
Pull-up at outside
(TUNER side).
Pull-up at outside (Vref).
Pull-up at outside (Vcc).
Pull-up at outside (Vcc).
Pull-up at outside (Vcc).
Pull-up at outside (Vref).
Pull-up at outside (V LCD ).
A/D input.
A/D input.
A/D input.
A/D input.
Pull-down at outside.
Pull-up at outside.
Pin Name
COM 1
COM 2
COM 3
S1
S2
S3
S4
S5
S6
S7
S8
S9
S10
S11
S12
S13
S14
S15
S16
S17
S18
S19
S20
S21
S22
P13-1
P13-2
P13-3
P14-0
P14-1
P14-2
P14-3
IN2
K0
K1
K2
K3
P1-1
P1-2
P1-3
P2-0/AD IN1
P2-1/AD IN2
P2-2
P2-3
P3-0
P3-1
P3-2
P3-3/BUZR
P4-0
INT
—
—
—
—
—
—
—
—
—
—
—
—
—
—
—
—
—
—
—
—
—
—
—
—
—
H
Hi-imp
Hi-imp
Hi-imp
Hi-imp
L
Hi-imp
—
L
—
—
L
L
—
L
—
—
H
—
L
L
L
L
—
ACT
—
—
—
—
—
—
—
—
—
—
—
—
—
—
—
—
—
—
—
—
—
—
—
—
—
—
L
—
L
—
Hi-imp
L
—
VCC
—
—
AD Vrcl
H
—
H
—
—
—
—
H
—
—
—
—
Pin No.
50
51
52
53
54
55
56
57
58
59
60
61
62
63
64
65
66
67
68
69
70
71
72
73
74
75
76
77
78
79
80
I/O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
I
Description
MOTOR control terminal.
MOTOR control terminal.
MOTOR control terminal.
REC circuit control output.
RADIO system control terminal (when RADIO ON = L).
Terminal for controllingAVLS (when ON = L).
AMP control output (when AMP ON = H).
Tone control terminal (when GRV = L, when MB = H).
PL control terminal.
TC/CF select output (when PRE OFF = H, when PRE ON = Hi-imp).
Terminal for controlling DOLBY circuit
(when OFF = H, when ON = Hi-imp).
DDC control terminal (ON at Hi-imp, OFF at L).
TUNER MONO/STEREO select terminal (MONO at H).
TEST terminal (Normal operation at L or NC).
IF input.
TUNER sensitivity select terminal (LOCAL at H, DX at L).
Phase comparator output.
External interrupt terminal.
Pre-scaler output (FM at H).
Power supply GND terminal.
Pre-scaler input.
AM local oscillator output.
Power supply voltage.
RESET terminal (H during operation).
Terminal to which external oscillator is connected.
Terminal to which external oscillator is connected.
Terminal to which external capacitor is connected
to stabilize crystal oscillator power supply.
Terminal to step-up power supply voltage for LCD drive.
Terminal to step-up power supply voltage for LCD drive.
Terminal to step-up power supply voltage for LCD drive.
Terminal for 1.5V constant voltage power supply of LCD drive.
Function
MOTOR CTL
MOTOR DIR
MOTOR BRK
REC CTL
RADIO CTL
AVLS CTL
AMP CTL
GRV/MB CTL
PM CTL
PRE AMP CTL
DOLBY CTL
DDC2 CTL
MONO/ST
TEST
IF IN
LOCAL/DX
DO
HOLD
PSC
GND
FM IN
AM IN
VDD
RESET
XOUT
XIN
VXT
VLCD
C1
C2
VEE
Circuit
Input/Output
Input/Output
Input/Output
Input/Output
Input/Output
Input/Output
Input/Output
Input/Output
Ternary output
Ternary output
Ternary output
Ternary output
Output
Output
External interrupt
Remarks
Open
Pin Name
P4-1
P4-1
P4-2
P4-3
P5-0
P5-1
P5-2
P5-3
P6-0
P6-1
P6-2
P6-3
MUTE
TEST
IF IN
DO1/OT
DO2
HOLD
PSC
GND
FM IN
AM IN
VDD
RESET
XOUT
XIN
VXT
VLCD
C1
C2
VEE
INT
L
L
L
L
H
L
L
L
L
Hi-imp
Hi-imp
Hi-imp
L
—
—
L
—
H
—
—
—
—
—
L
—
—
—
—
—
—
—
ACT
H
H
H
H
L
L
H
H
H
Hi-imp
Hi-imp
Hi-imp
—
—
—
—
—
—
H
—
—
—
—
H
—
—
—
—
—
—
—
100Ω
+
–
Frequency counte
r
1µF
TP23
(IC7 pin !“)
IC7 pin 9
• IC1 TC9326F
L3 : FM IF Adjustment
TP1
TP13
L2 : FM VT
Voltage Adjustment
RV1 : FM VCO Adjustment
L4 : AM Tracking
Adjustment
CT1 : AM Tracking
Adjustment

• IC BLOCK DIAGRAMS
IC3 TA7371AF-EL (TUNER SECTION)
IC7 TA-2022AFN-EL (TUNER SECTION)
IC301 TA2072AF (AUDIO SECTION)
IC601 MM1279XVBE (AUDIO SECTION)
— 25 — — 26 —
MEMO

— 27 —
SECTION 8
EXPLODED VIEWS
8-1. CABINET SECTION
Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks
1 3-010-838-25 SCREW (M1.4X2.2)
2 X-3373-584-1 CASE (FB) ASSY (FX551)
2 X-3373-588-1 CASE (FH) ASSY (FX553)
3 X-3373-573-1 LID (FX-H) ASSY, CASSETTE (FX553)
3 X-3373-574-1 LID (FX-B) ASSY, CASSETTE (FX551)
4 3-009-676-01 ORNAMENT, REEL (FX551)
4 3-009-676-11 ORNAMENT, REEL (FX553)
5 3-930-794-11 KNOB (HOLD) (FX551)
5 3-930-794-21 KNOB (HOLD) (FX553)
6 3-928-465-01 DETENT, CASSETTE
7 3-009-677-01 KNOB (OPEN)
10 3-012-466-01 LID (D), BATTERY CASE (FX551)
10 3-012-466-11 LID (D), BATTERY CASE (FX553)
12 3-010-838-19 SCREW (M1.4X2)
Note:
• -XX, -X mean standardized parts, so they may
have some differences from the original one.
• Items marked “*” are not stocked since they
are seldom required for routine service. Some
delay should be anticipated when ordering these
items.
• The mechanical parts with no reference number
in the exploded views are not supplied.
• Abbreviation
EA : Saudi Arabia model
CND : Canadian model
IT : Italian model
3
12
12
7
4
2
1
1
not supplied
5
6
10

—28 —
8-2. AUDIO, TUNER BOARD SECTION
51 3-375-114-41 SCREW (M1.7X3)
52 A-3016-925-A TUNER BOARD, COMPLETE
53 A-3061-472-A AUDIO BOARD, COMPLETE
54 3-009-670-01 TERMINAL (-), BATTERY
55 3-009-662-01 COVER (A), MD
(FX551:E,EA/FX553:US,CND,E,EA,TOURIST)
55 3-009-662-11 COVER (A),MD (FX551:AEP,IT/FX553:AEP,IT)
56 3-355-424-61 SCREW, TAPPING (M1.7x6)
57 3-010-838-59 SCREW (M1.4X4.5)
58 X-3373-589-1 BRACKET ASSY
59 3-009-667-01 SPRING, TENSION
60 3-009-675-01 HOLDER, BATTERY
61 3-009-669-01 TERMINAL (+), BATTERY
63 3-010-520-01 COVER, SW
64 3-012-434-01 GUIDE (TU)
65 3-009-668-01 PLATE, C LOCK
66 3-010-173-01 BRACKET (B)
67 X-3373-173-11 HOLDER ASSY CASSETTE
S901 1-762-793-11 SWITCH, LEAF
J801 1-779-080-11 JACK,DC (POLARITY UNIFIED TYPE)
Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks
67
56
66
65
55
51
51
52
57
56
63
53
S901
MT-WMEX550-125
58
56
59
60
61
54
51
64
56
J801

— 29 —
8-3. MECHANISM SECTION (MT-WMEX550-125)
Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks
101 3-011-277-01 COVER (B) (Y), MD
102 3-704-413-31 SCREW (M1.4X7.2)
103 X-3372-850-1 PINCH LEVER (N) ASSY
104 3-007-434-01 PULLEY (REVERSE)
105 3-007-428-01 WASHER (R)
106 X-3372-851-1 FLYWHEEL (R) ASSY
107 3-007-439-01 SLIDER (LOCK)
108 3-386-694-01 WASHER
109 X-3372-852-1 FLYWHEEL (N) ASSY
110 3-007-430-01 BELT
111 3-007-960-01 SPRING (EJECT) (Y), TORSION
114 3-007-436-01 SPRING (TRIGGER), TORSION
115 X-3372-848-1 CLUTCH ASSY (M)
116 3-007-435-01 GEAR (FR)
117 X-3372-853-1 LEVER (FRG) ASSY
119 3-007-432-01 SHEET (R), REFLECTION
120 3-007-427-01 SCREW (IB LOCK)
121 X-3373-245-1 CHASSIS (S) ASSY (Y)
122 3-007-455-01 SPRING (R), TORSION
123 3-007-458-01 SPRING (H/B), TENSION
124 3-007-456-01 SPRING (N), TORSION
125 3-007-454-01 SPRING (FR), TORSION
126 3-007-457-01 SPRING (TEN), TENSION
127 X-3372-849-1 PINCH LEVER (R) ASSY
128 3-010-954-01 SPRING (BT), COMPRESSION
129 3-918-943-01 WASHER, STOPPER
130 3-366-017-01 BUSHING (CAPSTAN
131 3-007-429-01 WASHER (R), STOPPER
132 3-932-724-21 WASHER
*133 3-010-272-01 BELT, RETAINER
134 3-010-274-01 TABLE, REEL
HP301 1-500-420-11 HEAD, MAGNETIC (PLAYBACK)
PM901 1-454-674-31 SOLENOID, PLUNGER
M901 1-698-885-11 MOTOR (REEL/CAPSTAN)
110
109
108
107
106
105
104
123
111 124
114
115
132
116
117
119
125 134
133
120
126
121
127
128
129
130
102
128
122
131
130
103
HP301
not supplied
M901
PM901
101
134

Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks
—30 —
SECTION 9
ELECTRICAL PARTS LIST
NOTE:
• Due to standardization, replacements in the
parts list may be different from the parts
specified in the diagrams or the components
used on the set.
• -XX, -X mean standardized parts, so they may
have some difference from the original one.
• Items marked “*” are not stocked since they
are seldom required for routine service. Some
delay should be anticipated when ordering these
items.
• CAPACITORS:
uF: µF
• RESISTORS
All resistors are in ohms.
METAL: metal-film resistor
METAL OXIDE: Metal Oxide-film resistor
F: nonflammable
• COILS
uH: µH
• SEMICONDUCTORS
In each case, u: µ, for example:
uA...: µA... , uPA... , µPA... ,
uPB... , µPB... , uPC... , µPC... ,
uPD..., µPD...
When indicating parts by reference number,
please include the board naame.
The components identified by mark !or
dotted line with mark !are critical for safety.
Replace only with part number specified.
Les composants identifiés par une marque
!sont critiques pour la sécurité.
Ne les remplacer que par une pièce portant
le numéro spécifié.
A-3061-472-A AUDIO BOARD, COMPLETE
**********************
< CAPACITOR >
C101 1-162-963-11 CERAMIC CHIP 680PF 10% 50V
C102 1-162-963-11 CERAMIC CHIP 680PF 10% 50V
C103 1-135-151-21 TANTALUM CHIP 4.7uF 20% 4V
C104 1-164-227-11 CERAMIC CHIP 0.022uF 10% 25V
C105 1-164-677-11 CERAMIC CHIP 0.033uF 10% 16V
C106 1-115-156-11 CERAMIC CHIP 1uF 10V
C107 1-162-965-11 CERAMIC CHIP 0.0015uF 10% 50V
C108 1-135-180-21 TANTALUM CHIP 3.3uF 20% 6.3V
C109 1-164-174-11 CERAMIC CHIP 0.0082uF 10% 25V
C110 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V
C111 1-107-823-11 CERAMIC CHIP 0.47uF 10% 16V
C112 1-115-156-11 CERAMIC CHIP 1uF 10V
C113 1-115-156-11 CERAMIC CHIP 1uF 10V
C114 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V
C115 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V
C116 1-109-982-11 CERAMIC CHIP 1uF 10% 10V
C117 1-115-156-11 CERAMIC CHIP 1uF 10V
C119 1-115-156-11 CERAMIC CHIP 1uF 10V
C201 1-162-963-11 CERAMIC CHIP 680PF 10% 50V
C202 1-162-963-11 CERAMIC CHIP 680PF 10% 50V
C203 1-135-151-21 TANTALUM CHIP 4.7uF 20% 4V
C204 1-164-227-11 CERAMIC CHIP 0.022uF 10% 25V
C205 1-164-677-11 CERAMIC CHIP 0.033uF 10% 16V
C206 1-115-156-11 CERAMIC CHIP 1uF 10V
C207 1-162-965-11 CERAMIC CHIP 0.0015uF 10% 50V
C208 1-135-180-21 TANTALUM CHIP 3.3uF 20% 6.3V
C209 1-164-174-11 CERAMIC CHIP 0.0082uF 10% 25V
C210 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V
C211 1-107-823-11 CERAMIC CHIP 0.47uF 10% 16V
C212 1-115-156-11 CERAMIC CHIP 1uF 10V
C213 1-115-156-11 CERAMIC CHIP 1uF 10V
C214 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V
C215 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V
C216 1-115-156-11 CERAMIC CHIP 1uF 10V
C217 1-115-156-11 CERAMIC CHIP 1uF 10V
C219 1-115-156-11 CERAMIC CHIP 1uF 10V
C301 1-135-316-11 TANTAL. CHIP 22uF 20% 2.5V
C302 1-115-467-11 CERAMIC CHIP 0.22uF 10% 10V
C303 1-109-982-11 CERAMIC CHIP 1uF 10% 10V
C304 1-135-151-21 TANTALUM CHIP 4.7uF 20% 4V
C305 1-135-316-11 TANTAL. CHIP 22uF 20% 2.5V
C306 1-135-149-21 TANTALUM CHIP 2.2uF 20% 10V
C307 1-164-227-11 CERAMIC CHIP 0.022uF 10% 25V
C308 1-135-180-21 TANTALUM CHIP 3.3uF 20% 6.3V
C309 1-115-156-11 CERAMIC CHIP 1uF 10V
C310 1-135-151-21 TANTALUM CHIP 4.7uF 20% 4V
C311 1-165-128-11 CERAMIC CHIP 0.22uF 16V
C312 1-135-151-21 TANTALUM CHIP 4.7uF 20% 4V
C313 1-135-201-11 TANTALUM CHIP 10uF 20% 4V
C314 1-107-823-11 CERAMIC CHIP 0.47uF 10% 16V
C315 1-115-156-11 CERAMIC CHIP 1uF 10V
C316 1-115-156-11 CERAMIC CHIP 1uF 10V
C317 1-115-467-11 CERAMIC CHIP 0.22uF 10% 10V
C318 1-135-149-21 TANTALUM CHIP 2.2uF 20% 10V
C319 1-107-688-11 TANTAL. CHIP 1.5uF 20% 10V
C320 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V
C321 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V
C322 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V
C601 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V
C602 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V
C603 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V
C604 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V
C605 1-164-156-11 CERAMIC CHIP 0.1uF 25V
C606 1-115-467-11 CERAMIC CHIP 0.22uF 10% 10V
C607 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V
C608 1-109-982-11 CERAMIC CHIP 1uF 10% 10V
C701 1-135-151-21 TANTALUM CHIP 4.7uF 20% 4V
C702 1-115-156-11 CERAMIC CHIP 1uF 10V
C703 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V
< CONNECTOR >
CN301 1-766-336-21 CONNECTOR, FFC/FPC 6P
CN701 1-779-079-11 CONNECTOR, BOARD TO BOARD
< DIODE >
D701 8-719-404-49 DIODE MA111
D702 8-719-049-09 DIODE 1SS367-T3SONY
D703 8-719-423-36 DIODE MA8120-H-TX
D704 8-719-423-36 DIODE MA8120-H-TX
D705 8-719-423-36 DIODE MA8120-H-TX
< FERRITE BEAD >
FB703 1-414-385-11 INDUCTOR, FERRITE BEAD
FB704 1-414-385-11 INDUCTOR, FERRITE BEAD
FB705 1-414-235-11 INDUCTOR, FERRITE BEAD
FB706 1-414-235-11 INDUCTOR, FERRITE BEAD
FB707 1-414-235-11 INDUCTOR, FERRITE BEAD
< IC >
IC301 8-759-359-76 IC TA2072AF
IC601 8-759-356-46 IC MM1279XVBE
IC701 8-759-460-25 IC S-8321AJMP-DNJ-T2
< JACK >
J701 1-778-930-21 JACK 7P (PHONE)
J801 1-779-080-11 JACK,DC (POLARITY UNIFIED TYPE)
AUDIO

Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks
— 31 —
< COIL >
L101 1-412-011-31 INDUCTOR CHIP 27uH
L201 1-412-011-31 INDUCTOR CHIP 27uH
L301 1-412-011-31 INDUCTOR CHIP 27uH
L701 1-412-034-11 INDUCTOR CHIP 330uH
< PHOTO INTERUPTER >
PH701 8-719-988-15 PHTO REFLECTOR PR-11-C
< TRANSISTOR >
Q301 8-729-426-51 TRANSISTOR XP1210-TXE
Q302 8-729-422-39 TRANSISTOR XN4404
Q303 8-729-426-36 TRANSISTOR XP1215-TXE
Q304 8-729-230-72 TRANSISTOR 2SA1362YG
Q306 8-729-426-36 TRANSISTOR XP1215-TXE
Q601 8-729-403-42 TRANSISTOR XN1401
Q602 8-729-402-84 TRANSISTOR XN4601
Q701 8-729-421-26 TRANSISTOR UN5216
Q702 8-729-230-72 TRANSISTOR 2SA1362YG
Q704 8-729-425-46 TRANSISTOR XP4315-TXE
< RESISTOR >
JC101 1-216-864-91 CONDUCTOR, CHIP (1608)
JC201 1-216-864-91 CONDUCTOR, CHIP (1608)
JC801 1-216-296-91 CONDUCTOR, CHIP (3216)
R101 1-216-812-11 METAL CHIP 180 5% 1/16W
R102 1-216-847-11 METAL CHIP 150K 5% 1/16W
R103 1-216-831-11 METAL CHIP 6.8K 5% 1/16W
R104 1-216-824-11 METAL CHIP 1.8K 5% 1/16W
R105 1-216-825-11 METAL CHIP 2.2K 5% 1/16W
R106 1-216-839-11 METAL CHIP 33K 5% 1/16W
R107 1-216-795-11 METAL GLAZE 6.8 5% 1/16W
R108 1-218-270-11 METAL GLAZE 1.1K 5% 1/16W
R109 1-216-834-11 METAL CHIP 12K 5% 1/16W
R110 1-216-852-11 METAL CHIP 390K 5% 1/16W
R111 1-216-822-11 METAL CHIP 1.2K 5% 1/16W
R112 1-216-824-11 METAL CHIP 1.8K 5% 1/16W
R113 1-216-809-11 METAL CHIP 100 5% 1/16W
R114 1-216-840-11 METAL CHIP 39K 5% 1/16W
(EXCEPT US)
R114 1-216-845-11 METAL CHIP 100K 5% 1/16W
(US)
R115 1-216-842-11 METAL CHIP 56K 5% 1/16W
R201 1-216-812-11 METAL CHIP 180 5% 1/16W
R202 1-216-847-11 METAL CHIP 150K 5% 1/16W
R203 1-216-831-11 METAL CHIP 6.8K 5% 1/16W
R204 1-216-824-11 METAL CHIP 1.8K 5% 1/16W
R205 1-216-825-11 METAL CHIP 2.2K 5% 1/16W
R206 1-216-839-11 METAL CHIP 33K 5% 1/16W
R207 1-216-795-11 METAL GLAZE 6.8 5% 1/16W
R208 1-218-270-11 METAL GLAZE 1.1K 5% 1/16W
R209 1-216-834-11 METAL CHIP 12K 5% 1/16W
R210 1-216-852-11 METAL CHIP 390K 5% 1/16W
R211 1-216-822-11 METAL CHIP 1.2K 5% 1/16W
R212 1-216-824-11 METAL CHIP 1.8K 5% 1/16W
R213 1-216-809-11 METAL CHIP 100 5% 1/16W
R214 1-216-840-11 METAL CHIP 39K 5% 1/16W
(EXCEPT US)
R214 1-216-845-11 METAL CHIP 100K 5% 1/16W
(US)
R215 1-216-842-11 METAL CHIP 56K 5% 1/16W
R301 1-218-891-11 METAL GLAZE 68K 0.50% 1/16W
R302 1-216-839-11 METAL CHIP 33K 5% 1/16W
R303 1-216-825-11 METAL CHIP 2.2K 5% 1/16W
R304 1-218-295-11 METAL GLAZE 43K 5% 1/16W
R305 1-216-821-11 METAL CHIP 1K 5% 1/16W
R307 1-216-847-11 METAL CHIP 150K 5% 1/16W
R309 1-216-826-11 METAL CHIP 2.7K 5% 1/16W
R310 1-216-793-11 METAL GLAZE 4.7 5% 1/16W
R604 1-216-817-11 METAL CHIP 470K 5% 1/16W
R605 1-216-830-11 METAL CHIP 5.6K 5% 1/16W
R606 1-216-809-11 METAL CHIP 100 5% 1/16W
R607 1-216-837-11 METAL CHIP 22K 5% 1/16W
R611 1-216-821-11 METAL CHIP 1K 5% 1/16W
R612 1-216-833-11 METAL CHIP 10K 5% 1/16W
R613 1-216-821-11 METAL CHIP 1K 5% 1/16W
R701 1-216-849-11 METAL CHIP 220K 5% 1/16W
R702 1-216-849-11 METAL CHIP 220K 5% 1/16W
R703 1-216-845-11 METAL CHIP 100K 5% 1/16W
R704 1-216-821-11 METAL CHIP 1K 5% 1/16W
R705 1-216-821-11 METAL CHIP 1K 5% 1/16W
R706 1-216-843-11 METAL CHIP 68K 5% 1/16W
R707 1-216-843-11 METAL CHIP 68K 5% 1/16W
R708 1-216-849-11 METAL CHIP 220K 5% 1/16W
R709 1-216-857-11 METAL CHIP 1M 5% 1/16W
R710 1-216-823-11 METAL CHIP 1.5K 5% 1/16W
R711 1-216-829-11 METAL CHIP 4.7K 5% 1/16W
R712 1-216-849-11 METAL CHIP 220K 5% 1/16W
R713 1-216-821-11 METAL CHIP 1K 5% 1/16W
R714 1-216-821-11 METAL CHIP 1K 5% 1/16W
R715 1-216-821-11 METAL CHIP 1K 5% 1/16W
< CONPOSITION CIRCUIT BLOCK >
RB301 1-233-872-21 RES, NETWORK (CHIP TYPE)
RB601 1-233-873-21 RES, NETWORK (CHIP TYPE)
RB602 1-233-576-11 RES, CHIP NETWORK 100
< VARIABLE RESISTOR >
RV301 1-225-342-11 RES, VAR, CARBON 10K/10K (VOLUME)
RV601 1-223-576-11 RES, ADJ, METAL GLAZE 2.2K
< SWITCH >
S701 1-572-922-11 SWITCH, SLIDE (HOLD)
S702 1-572-581-11 SWITCH, SLIDE
S703 1-762-970-21 SWITCH, PUSH (1 KEY)
< THERMISTOR(POSITIVE) >
THP601 1-810-794-11 THERMISTOR, POSITIVE
************************************************************
AUDIO

Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks
— 32 —
A-3016-925-A TUNER BOARD, COMPLETE
**********************
*3-012-429-01 HOLDER (LCD)
< CAPACITOR >
C1 1-164-360-11 CERAMIC CHIP 0.1uF 16V
C2 1-164-360-11 CERAMIC CHIP 0.1uF 16V
C3 1-164-360-11 CERAMIC CHIP 0.1uF 16V
C4 1-115-156-11 CERAMIC CHIP 1uF 10V
C5 1-162-927-11 CERAMIC CHIP 100PF 5% 50V
C6 1-162-917-11 CERAMIC CHIP 15PF 5% 50V
C7 1-162-917-11 CERAMIC CHIP 15PF 5% 50V
C8 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V
C9 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V
C10 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50V
C11 1-164-676-11 CERAMIC CHIP 2200PF 5% 16V
C12 1-162-928-11 CERAMIC CHIP 120PF 5% 50V
C13 1-162-923-11 CERAMIC CHIP 47PF 5% 50V
C14 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V
C15 1-162-910-11 CERAMIC CHIP 5PF 0.25PF 50V
C16 1-162-905-11 CERAMIC CHIP 1PF 0.25PF 50V
C17 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V
C18 1-104-847-11 TANTAL. CHIP 22uF 20% 4V
C19 1-162-905-11 CERAMIC CHIP 1PF 0.25PF 50V
C20 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50V
C21 1-164-676-11 CERAMIC CHIP 2200PF 5% 16V
C22 1-162-926-11 CERAMIC CHIP 82PF 5% 50V
C23 1-162-928-11 CERAMIC CHIP 120PF 5% 50V
C24 1-165-176-11 CERAMIC CHIP 0.047uF 10% 16V
C25 1-165-176-11 CERAMIC CHIP 0.047uF 10% 16V
C26 1-162-923-11 CERAMIC CHIP 47PF 5% 50V
C27 1-162-935-11 CERAMIC CHIP 4PF 0.25PF 50V
C28 1-164-227-11 CERAMIC CHIP 0.022uF 10% 25V
C29 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V
C30 1-164-227-11 CERAMIC CHIP 0.022uF 10% 25V
C31 1-164-315-11 CERAMIC CHIP 470PF 5% 50V
C32 1-162-918-11 CERAMIC CHIP 18PF 5% 50V
C33 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V
C34 1-104-847-11 TANTAL. CHIP 22uF 20% 4V
C35 1-164-227-11 CERAMIC CHIP 0.022uF 10% 25V
C36 1-162-923-11 CERAMIC CHIP 47PF 5% 50V
C37 1-115-156-11 CERAMIC CHIP 1uF 10V
C38 1-164-227-11 CERAMIC CHIP 0.022uF 10% 25V
C39 1-135-151-21 TANTALUM CHIP 4.7uF 20% 4V
C40 1-115-156-11 CERAMIC CHIP 1uF 10V
C41 1-165-176-11 CERAMIC CHIP 0.047uF 10% 16V
C42 1-164-362-11 CERAMIC CHIP 470PF 5% 50V
C43 1-104-908-11 TANTAL. CHIP 47uF 20% 2.5V
C44 1-164-227-11 CERAMIC CHIP 0.022uF 10% 25V
C45 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V
C46 1-162-965-11 CERAMIC CHIP 1500PF 10% 50V
C47 1-164-227-11 CERAMIC CHIP 0.022uF 10% 25V
C48 1-115-156-11 CERAMIC CHIP 1uF 10V
C49 1-115-156-11 CERAMIC CHIP 1uF 10V
C50 1-164-227-11 CERAMIC CHIP 0.022uF 10% 25V
C52 1-163-139-00 CERAMIC CHIP 820PF 5% 50V
C53 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V
C54 1-104-912-11 TANTAL. CHIP 3.3uF 20% 6.3V
C55 1-104-912-11 TANTAL. CHIP 3.3uF 20% 6.3V
C56 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V
C57 1-164-345-11 CERAMIC CHIP 0.082uF 10% 25V
C58 1-115-156-11 CERAMIC CHIP 1uF 10V
C59 1-165-176-11 CERAMIC CHIP 0.047uF 10% 16V
C60 1-164-227-11 CERAMIC CHIP 0.022uF 10% 25V
C61 1-104-847-11 TANTAL. CHIP 22uF 20% 4V
C62 1-164-227-11 CERAMIC CHIP 0.022uF 10% 25V
C63 1-162-968-11 CERAMIC CHIP 0.0047uF 10% 50V
C64 1-165-128-11 CERAMIC CHIP 0.22uF 16V
C65 1-162-968-11 CERAMIC CHIP 0.0047uF 10% 50V
C66 1-164-227-11 CERAMIC CHIP 0.022uF 10% 25V
C67 1-135-091-00 TANTALUM CHIP 1uF 20% 16V
C68 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V
C69 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V
C70 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V
C71 1-162-962-11 CERAMIC CHIP 470PF 10% 50V
C72 1-110-501-11 CERAMIC CHIP 0.33uF 10% 16V
C73 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V
C74 1-164-360-11 CERAMIC CHIP 0.1uF 16V
C75 1-164-360-11 CERAMIC CHIP 0.1uF 16V
C76 1-162-927-11 CERAMIC CHIP 100PF 5% 50V
C77 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V
C78 1-162-923-11 CERAMIC CHIP 47PF 5% 50V
C80 1-162-909-11 CERAMIC CHIP 4PF 0.25PF 50V
C81 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V
C83 1-115-156-11 CERAMIC CHIP 1uF 10V
< FILTER >
CF1 1-767-313-11 FILTER, CERAMIC 10.7MHz
CF2 1-767-313-11 FILTER, CERAMIC 10.7MHz
CF3 1-767-480-11 FILTER, AM CERAMIC 450KHz
CF4 1-767-357-11 FILTER, CERAMIC 10.7MHz
< CONNECTOR >
CN1 1-694-248-11 CONDUCTIVE BOARD, CONNECTION
< TRIMMER >
CT1 1-141-327-11 CAP, CHIP TYPE TRIMMER 10PF
< DIODE >
D1 8-719-053-30 DIODE MA2S357-(TX). SO
D2 8-719-053-30 DIODE MA2S357-(TX). SO
D3 8-719-055-61 DIODE HVR100-9TRU
D4 8-719-055-61 DIODE HVR100-9TRU
D5 8-719-051-01 DIODE CL-170HR-CD-T (BATT)
D6 8-719-420-51 DIODE MA729
D7 8-719-404-49 DIODE MA111
D8 8-719-420-87 DIODE MA8130
< IC >
IC1 8-759-457-71 IC TC9326F
IC2 8-759-234-31 IC TD6134AF
IC3 8-759-362-23 IC TA7371AF-EL
IC4 8-759-527-64 IC AK93C45-SFU
IC4 8-759-527-65 IC AK93C45-SFE
IC4 8-759-527-66 IC AK93C45-SFEH
IC5 8-759-457-70 IC XC62RP1602MR
IC6 8-759-387-31 IC TC75S55F(TE85R)
IC7 8-759-362-25 IC TA-2022AFN-EL
IC8 8-759-445-08 IC XC61ASØTXXMR
TUNER
Ver 1.1 2002.01

Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks
— 33 —
< COIL >
L1 1-216-864-11 METAL CHIP 0 5% 1/16W
L2 1-416-180-11 COIL (WITH CORE) (FM-OSC)
L3 1-416-181-11 COIL (WITH CORE) (FM-MIX)
L4 1-501-812-11 ANTENNA, FERRITE-ROD (MW)
L5 1-412-010-41 INDUCTOR CHIP 22uH
L6 1-412-010-41 INDUCTOR CHIP 22uH
L7 1-412-010-41 INDUCTOR CHIP 22uH
L8 1-412-010-41 INDUCTOR CHIP 22uH
L9 1-412-010-41 INDUCTOR CHIP 22uH
L10 1-412-010-41 INDUCTOR CHIP 22uH
< LIQUID CRYSTAL DISPLAY >
ND1 1-801-656-11 DISPLAY PANEL, LIQUID CRYSTAL
< TRANSISTOR >
Q1 8-729-037-89 TRANSISTOR 2SC4627-C(TXE)
Q2 8-729-028-69 TRANSISTOR 2SC4655-BC(TX)
Q3 8-729-037-89 TRANSISTOR 2SC4627-C(TXE)
Q4 8-729-037-89 TRANSISTOR 2SC4627-C(TXE)
Q5 8-729-823-86 TRANSISTOR 2SA1745
Q6 8-729-028-69 TRANSISTOR 2SC4655-BC(TX)
Q7 8-729-428-95 TRANSISTOR UN9116-QRS-(TXE)
Q8 8-729-037-63 TRANSISTOR UN9115J-(TX).SO
Q9 8-729-800-71 TRANSISTOR 2SB815B7-TB
Q10 8-729-800-71 TRANSISTOR 2SB815B7-TB
Q11 8-729-420-68 TRANSISTOR 2SD1328-R-TX
Q12 8-729-800-37 TRANSISTOR 2SD1048-X7
Q13 8-729-028-69 TRANSISTOR 2SC4655-BC(TX)
Q14 8-729-037-71 TRANSISTOR UN9210J-(TX).SO
Q15 8-729-037-63 TRANSISTOR UN9115J-(TX).SO
Q16 8-729-028-69 TRANSISTOR 2SC4655-BC(TX)
Q17 8-729-028-69 TRANSISTOR 2SC4655-BC(TX)
Q18 8-729-807-87 TRANSISTOR 2SB1295-UL6
Q19 8-729-037-71 TRANSISTOR UN9210J-(TX).SO
Q21 8-729-037-63 TRANSISTOR UN9115J-(TX).SO
< RESISTOR >
R1 1-216-825-11 METAL CHIP 2.2K 5% 1/16W
R2 1-216-853-11 METAL CHIP 470K 5% 1/16W
R3 1-216-853-11 METAL CHIP 470K 5% 1/16W
R4 1-216-821-11 METAL CHIP 1K 5% 1/16W
R5 1-216-829-11 METAL CHIP 220 5% 1/16W
R6 1-216-829-11 METAL CHIP 4.7K 5% 1/16W
R7 1-218-870-11 METAL GLAZE 9.1K 0.50% 1/16W
R8 1-218-836-11 METAL GLAZE 360 0.50% 1/16W
R9 1-216-833-11 METAL CHIP 10K 5% 1/16W
R10 1-216-813-11 METAL CHIP 220 5% 1/16W
R11 1-216-853-11 METAL CHIP 470K 5% 1/16W
R12 1-216-853-11 METAL CHIP 470K 5% 1/16W
R13 1-216-809-11 METAL CHIP 100 5% 1/16W
R14 1-216-825-11 METAL CHIP 2.2K 5% 1/16W
R15 1-216-845-11 METAL CHIP 100K 5% 1/16W
R16 1-216-851-11 METAL CHIP 330K 5% 1/16W
R17 1-216-833-11 METAL CHIP 10K 5% 1/16W
R18 1-216-821-11 METAL CHIP 1K 5% 1/16W
R19 1-216-821-11 METAL CHIP 1K 5% 1/16W
R20 1-216-833-11 METAL CHIP 10K 5% 1/16W
R21 1-216-833-11 METAL CHIP 10K 5% 1/16W
R22 1-216-815-11 METAL CHIP 330 5% 1/16W
R23 1-216-845-11 METAL CHIP 100K 5% 1/16W
R24 1-216-853-11 METAL CHIP 470K 5% 1/16W
R25 1-216-827-11 METAL CHIP 3.3K 5% 1/16W
R26 1-216-849-11 METAL CHIP 220K 5% 1/16W
R27 1-216-825-11 METAL CHIP 2.2K 5% 1/16W
R28 1-216-815-11 METAL CHIP 330 5% 1/16W
R29 1-218-845-11 METAL GLAZE 820 0.50% 1/16W
R30 1-218-847-11 METAL GLAZE 1K 0.50% 1/16W
R31 1-218-849-11 METAL GLAZE 1.2K 0.50% 1/16W
R32 1-218-851-11 METAL GLAZE 1.5K 0.50% 1/16W
R33 1-218-863-11 METAL GLAZE 4.7K 0.50% 1/16W
R34 1-218-859-11 METAL GLAZE 3.3K 0.50% 1/16W
R35 1-218-864-11 METAL GLAZE 5.1K 0.50% 1/16W
R36 1-218-868-11 METAL GLAZE 7.5K 0.50% 1/16W
R37 1-218-871-11 METAL GLAZE 10K 0.50% 1/16W
R38 1-218-879-11 METAL GLAZE 22K 0.50% 1/16W
R39 1-216-823-11 METAL CHIP 1.5K 5% 1/16W
R40 1-216-829-11 METAL CHIP 4.7K 5% 1/16W
R41 1-216-845-11 METAL CHIP 100K 5% 1/16W
R42 1-216-820-11 METAL CHIP 820 5% 1/16W
R43 1-216-833-11 METAL CHIP 10K 5% 1/16W
R44 1-216-819-11 METAL CHIP 680 5% 1/16W
R45 1-216-825-11 METAL CHIP 2.2K 5% 1/16W
R46 1-216-799-11 METAL CHIP 15 5% 1/16W
R47 1-216-817-11 METAL CHIP 470 5% 1/16W
R48 1-216-829-11 METAL CHIP 4.7K 5% 1/16W
R49 1-216-845-11 METAL CHIP 100K 5% 1/16W
R50 1-216-833-11 METAL CHIP 10K 5% 1/16W
R51 1-216-829-11 METAL CHIP 4.7K 5% 1/16W
R52 1-216-841-11 METAL CHIP 47K 5% 1/16W
R53 1-216-817-11 METAL CHIP 470 5% 1/16W
R54 1-216-829-11 METAL CHIP 4.7K 5% 1/16W
R55 1-216-831-11 METAL CHIP 6.8K 5% 1/16W
R56 1-216-831-11 METAL CHIP 6.8K 5% 1/16W
R57 1-216-826-11 METAL CHIP 2.7K 5% 1/16W
R58 1-216-845-11 METAL CHIP 100K 5% 1/16W
R59 1-216-831-11 METAL CHIP 6.8K 5% 1/16W
R60 1-216-831-11 METAL CHIP 6.8K 5% 1/16W
R61 1-216-833-11 METAL CHIP 10K 5% 1/16W
R62 1-216-841-11 METAL CHIP 47K 5% 1/16W
R63 1-216-833-11 METAL CHIP 10K 5% 1/16W
R64 1-216-829-11 METAL CHIP 4.7K 5% 1/16W
R65 1-216-849-11 METAL CHIP 220K 5% 1/16W
R66 1-216-849-11 METAL CHIP 220K 5% 1/16W
R67 1-216-853-11 METAL CHIP 470K 5% 1/16W
R68 1-216-857-11 METAL CHIP 1M 5% 1/16W
R69 1-216-853-11 METAL CHIP 470K 5% 1/16W
R70 1-216-849-11 METAL CHIP 220K 5% 1/16W
R71 1-216-821-11 METAL CHIP 1K 5% 1/16W
R72 1-216-845-11 METAL CHIP 100K 5% 1/16W
R73 1-216-849-11 METAL CHIP 220K 5% 1/16W
R75 1-216-845-11 METAL CHIP 100K 5% 1/16W
R76 1-216-835-11 METAL CHIP 15K 5% 1/16W
R79 1-216-821-11 METAL CHIP 1K 5% 1/16W
R81 1-216-801-11 METAL CHIP 2.2K 5% 1/16W
TUNER

Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks
— 34 —
< VARIABLE RESISTOR >
RV1 1-223-578-11 RES, ADJ, METAL GLAZE 22K
< SWITCH >
S1 1-692-453-11 SWITCH, KEY BOARD (RADIO OFF)
S2 1-692-453-11 SWITCH, KEY BOARD (REPEAT)
S3 1-692-453-11 SWITCH, KEY BOARD (FF)
S4 1-692-453-11 SWITCH, KEY BOARD (REW)
S5 1-692-453-11 SWITCH, KEY BOARD (BAND)
S7 1-771-053-11 SWITCH, KEY BOARD (MENU)
S8 1-771-053-11 SWITCH, KEY BOARD (SET)
S9 1-692-453-11 SWITCH, KEY BOARD (TUNING +)
S10 1-692-453-11 SWITCH, KEY BOARD (TUNING -)
S11 1-692-453-11 SWITCH, KEY BOARD (ENTER)
< TRANSFORMER >
T1 1-416-182-11 COIL (AM-OSC)
T2 1-416-183-11 COIL (AM-MIX)
T3 1-423-745-11 TRANSFORMER, DC-DC CONVERTER
< VIBRATOR >
X1 1-577-262-11 VIBRATOR, CRYSTAL 75KHz
************************************************************
MISCELLANEOUS
**************
HP301 1-500-420-11 HEAD, MAGNETIC (PLAYBACK)
M901 1-698-885-11 MOTOR
PM901 1-454-674-31 SOLENOID, PLUNGER
S901 1-762-793-11 SWITCH, LEAF
************************************************************
WM-FX551/FX553
ACCESSORIES & PACKING MATERIALS
*******************************
1-505-536-11 HEADPHONE (WITH REMOCON)
(FX553:EXCEPT US)
1-505-700-11 HEADPHONE, REMOCON(MDR-WME553)
(FX553:US)
!1-528-465-11 BATTERY CHARGER (BC-820T)
(FX553:TOURIST)
1-569-007-11 ADAPTOR, CONVERSION 2P(FX553:TOURIST)
3-858-910-11 MANUAL, INSTRUCTION (ENGLISH/ITALIAN)
(FX551:AEP,IT,EA/FX553:AEP,IT,EA)
3-858-910-21 MANUAL, INSTRUCTION (FRENCH/GERMAN)
(FX551:AEP/FX553:AEP)
3-858-910-31 MANUAL, INSTRUCTION (SPANISH/DUTCH)
(FX551:AEP/FX553:AEP)
3-858-910-41 MANUAL, INSTRUCTION
(SWEDISH/PORTUGUESE)(FX551:AEP/FX553:AEP)
3-858-910-51 MANUAL, INSTRUCTION (ENGLISH/SPANISH)
(FX551:E/FX553:US,E,TOURIST)
3-858-910-61 MANUAL, INSTRUCTION (CHINESE/KOREAN)
(FX551:E/FX553:E,TOURIST)
3-858-910-71 MANUAL, INSTRUCTION (ENGLISH/FRENCH)
(FX553:CND)
3-918-892-01 CASE, CARRYING
3-918-937-01 CASE, CARRYING
3-920-201-01 CLIP (FX553)
8-953-187-90 HEADPHONE MDR-ED136//K SET (FX551)
TUNER
• Abbreviation
EA : Saudi Arabia model
CND : Canadian model
IT : Italian model
The components identified by
mark !or dotted line with mark
!are critical for safety.
Replace only with part number
specified.
Les composants identifiés par
une marque !sont critiques
pour la sécurité.
Ne les remplacer que par une
pièce portant le numéro spécifie.