Sony Xperia C C2304 User manual

1287-4316 Rev 2
Sony Mobile Communications AB –Company Internal
Component Replacement
- electrical -
Xperia CTM
C2304,C2305,S39h

1287-4316 Rev 2
Sony Mobile Communications AB –Company Internal
2(8)
CONTENTS
1Replaceable Components .............................................................3
2Component Placing........................................................................5
3Additional Repair info....................................................................6
4Revision History.............................................................................8
For general information about electrical repair related issues, refer to
1220-1336: Generic Repair Manual - electrical
Test after electrical replacement: refer to 1273-1772 Mechanical Test Instruction
Do not remove shield can lids (Heat pasta are added and RF performance will be damaged)

1287-4316 Rev 2
Sony Mobile Communications AB –Company Internal
3(8)
1 Replaceable Components
EXPLANATION OF ABBREVIATIONS USED IN THE COLUMN ‘COMMENTS’ BELOW
COMPONENT LOCATION
P= Primary side
S= Secondary side
REPAIR METHOD
HA = Hot Air (removal & mounting)
ST = Soldering Tool (removal & mounting)
HA/ST = Hot Air for removal - Soldering Tool for mounting
BGA = BGA Station
BH = Bottom Heater
ADDITIONAL INFORMATION
1 (2,3,4, etc.) = Proceed to ‘Additional Repair Info’ for further instructions in the indicated section(s).

1287-4316 Rev 2
Sony Mobile Communications AB –Company Internal
4(8)
Position
Component
Part no.
Comments
ANT1601
Connector Leaf Spring Plug 1p Antenna
A/314-0000-00659
S HA+BH 1
ANT1602
Connector Leaf Spring Plug 1p Antenna
A/314-0000-00659
S HA+BH 2
ANT1603
Connector Leaf Spring Plug 1p Antenna
A/314-0000-00659
S HA+BH 2
ANT1604
Connector Leaf Spring Plug 1p Antenna
A/314-0000-00659
S HA+BH 1
J1002
RF Coax Connector
A/314-0000-00831
P HA+BH 3
J1100
Audio Jack Connector
A/314-0000-00815
P HA+BH or BGA 4
JBAT1100
Battery Connector
A/314-0000-00818
S HA+BH 5
JRF1000
Connector Coax Receptacle 1p test switch
A/314-0000-00282
S HA+BH 6
JRF1601
Connector Coax Receptacle 1p test switch
A/314-0000-00282
S HA+BH 7
SW1301
Input Switch (Reset button)
A/315-0000-00071
S HA+BH 8

1287-4316 Rev 2
Sony Mobile Communications AB –Company Internal
5(8)
2 Component Placing
To access the Component Placing document, double-click the icon below.
Applicable for on-screen viewing only –icon not shown on hard-copies.
Primary side
Secondary side

1287-4316 Rev 2
Sony Mobile Communications AB –Company Internal
6(8)
3 Additional Repair info
1
ANT1601, ANT1604
Replace if mechanical damaged. (No or bad GPS)
Protect the Audio Jack connector with capton tape!
2
ANT1602, ANT1603
Replace if mechanical damaged. ( No or bad WLAN/ BT)
Protect the BtB connector with capton tape!
3
J1002
Replace if mechanical damaged. (No or bad network,
main antenna)
4
J1100
Replace if mechanical damaged. (No or bad audio in
headset)

1287-4316 Rev 2
Sony Mobile Communications AB –Company Internal
7(8)
Repair Actions: Additional Repair Info
5
JBAT1100
Replace if mechanical damaged. (Phone dead or power
off)
6
JRF1000
Replace if open circuit 1-2 (No or bad network, main
antenna)
Protect the input switch with capton tape!
7
JRF1601
Replace if open circuit 1-2 ( No or bad WLAN/ BT)
8
SW1301
Replace if short circuit (Restart) or if open circuit when
pushed (reset not possible).
Protect the RF connector with capton tape!

1287-4316 Rev 2
Sony Mobile Communications AB –Company Internal
8(8)
4 Revision History
Rev.
Date
Changes / Comments
1
2014-05-13
Initial release
2
2014-08-14
J1101 USB connector removed from parts list. (Side glued)