Sony Hcd-sr1 User manual

SERVICE MANUAL

Sony Corporation

Audio Group

Published by Sony Engineering Corporation

AEP Model

UK Model

HCD-SR1/SR2/SR3

E Model

Australian Model

HCD-SR2

SACD/DVD RECEIVER

9-879-009-04

2004I16-1

Ver 1.3 2004. 09

SPECIFICATIONS

HCD-SR1/SR2/SR3

HCD-SR1/SR2/SR3 are the amplifier, DVD/

SACD and tuner section in DAV-SR1/SR2/SR3.

PHOTO: HCD-SR2

Model Name Using Similar Mechanism NEW

Mechanism Type CDM80A-DVBU24

Optical Pick-up Name DBU-1

Amplifier section

Stereo mode (rated) 65 W + 65 W (4 ohms at

1 kHz, DIN)

Surround mode Front:

100

W +

100

W

(reference) (with SS-TS21)

music power output Center*:

100

W

(with SS-CT33)

Surround*:

100

W +

100

W

(with SS-TS20)

Subwoofer*:

100

W ×2

(with SS-WS12)

*Depending on the sound field settings and the source,

there may be no sound output.

Inputs VIDEO/TV/SAT:

Sensitivity: 250 mV/

450 mV/450 mV

Impedance: 50 kilohms

Output SURROUND BACK

Voltage: 2V

Impedance: 1 kilohms

Phones Accepts low-and high-

impedance headphones.

Super Audio CD/DVD system

Laser Semiconductor laser

(Super Audio CD/DVD: λ

= 650 nm)

(CD: λ= 780 nm)

Emission duration:

continuous

Signal format system PAL/NTSC

Frequency response (at 2 CH STEREO mode)

DVD (PCM): 2 Hz to 22

kHz (±1.0 dB)

CD: 2Hzto20 kHz(±1.0

dB)

Harmonic distortion Less than 0.03 %

Tuner section

System PLL quartz-locked digital

synthesizer system

FM tuner section

Tuning range 87.5 – 108.0 MHz (50 kHz

step)

Antenna (aerial) FM wire antenna (aerial)

Antenna (aerial) terminals 75 ohms, unbalanced

Intermediate frequency 10.7 MHz

AM tuner section

Tuning range

European, Russian models:

531 – 1,602 kHz (with the

interval set at 9 kHz)

531 – 1,602 kHz (with the

interval set at 9 kHz)

531 – 1,602 kHz (with the

interval set at 9 kHz)

530 – 1,710 kHz (with the

interval set at 10 kHz)

Antenna (aerial) AM loop antenna (aerial)

Intermediate frequency 450 kHz

Middle Easten models:

Other models:

European, Russian models:

Video section

Outputs

Video: 1 Vp-p 75 ohms

V

S video:

Y: 1 Vp-p 75 ohms

C:0.286 Vp-p 75 ohms

COMPONENT:

Y: 1 Vp-p 75 ohms

P

B

/C

B

, P

R

/C

R

: 0.7 Vp-p

75 ohms

ideo: Vp-p 75 ohmsOther models:

General

Power requirements

European models: 230 V AC, 50/60 Hz

Other models: 220 – 240 V AC,

50/60 Hz

Power consumption 120 W

0.3W(atthePower

Saving mode)

Dimensions (approx.) 430×60×385mm

incl. projecting

parts

Mass (approx.) 4.7 kg

Design and specifications are subject to change

without notice.

/h/d)(w

w

.

x

i

a

o

y

u

1

6

3

.

c

o

m

Q

3

7

6

3

1

5

1

5

0

9

2

8

9

4

2

9

8

T

E

L

1

3

9

4

2

9

6

5

1

3

9

2

8

9

4

2

9

8

0

5

1

5

1

3

6

7

3

Q

TEL 13942296513 QQ 376315150 892498299

http://www.xiaoyu163.com

2

HCD-SR1/SR2/SR3

UNLEADED SOLDER

Boards requiring use of unleaded solder are printed with the lead-

free mark (LF) indicating the solder contains no lead.

(Caution: Some printed circuit boards may not come printed with

the lead free mark due to their particular size)

: LEAD FREE MARK

Unleaded solder has the following characteristics.

•Unleaded solder melts at a temperature about 40 °C higher

than ordinary solder.

Ordinary soldering irons can be used but the iron tip has to be

applied to the solder joint for a slightly longer time.

Soldering irons using a temperature regulator should be set to

about 350 °C.

Caution: The printed pattern (copper foil) may peel away if

the heated tip is applied for too long, so be careful!

•Strong viscosity

Unleaded solder is more viscou-s (sticky, less prone to flow)

than ordinary solder so use caution not to let solder bridges

occur such as on IC pins, etc.

•Usable with ordinary solder

It is best to use only unleaded solder but unleaded solder may

also be added to ordinary solder.

SAFETY-RELATED COMPONENT WARNING!!

COMPONENTS IDENTIFIED BY MARK 0OR DOTTED LINE

WITH MARK 0ON THE SCHEMATIC DIAGRAMS AND IN

THE PARTS LIST ARE CRITICAL TO SAFE OPERATION.

REPLACE THESE COMPONENTS WITH SONY PARTS WHOSE

PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR

IN SUPPLEMENTS PUBLISHED BY SONY.

Notes on chip component replacement

•Never reuse a disconnected chip component.

•Notice that the minus side of a tantalum capacitor may be

damaged by heat.

Flexible Circuit Board Repairing

•Keep the temperature of the soldering iron around 270 °C

during repairing.

•Do not touch the soldering iron on the same conductor of the

circuit board (within 3 times).

•Be careful not to apply force on the conductor when soldering

or unsoldering.

CAUTION

Use of controls or adjustments or performance of procedures

otherthan those specifiedhereinmay result inhazardousradiation

exposure.

Laser component in this product is capable of emitting radiation

exceeding the limit for Class 1.

This appliance is classified as

a CLASS 1 LASER product.

The CLASS 1 LASER

PRODUCT MARKING is

located on the rear exterior.

w

.

x

i

a

o

y

u

1

6

3

.

c

o

m

Q

3

7

6

3

1

5

1

5

0

9

2

8

9

4

2

9

8

T

E

L

1

3

9

4

2

9

6

5

1

3

9

2

8

9

4

2

9

8

0

5

1

5

1

3

6

7

3

Q

TEL 13942296513 QQ 376315150 892498299

http://www.xiaoyu163.com

3

HCD-SR1/SR2/SR3

TABLE OF CONTENTS

1. SERVICING NOTE ................................................... 4

2. GENERAL ................................................................... 5

3. DIAGRAMS

3-1. Printed Wiring Board – RF Board – ................................ 10

3-2. Schematic Diagram – RF Board –................................... 11

3-3. Printed Wiring Board – DRIVER Board – ...................... 12

3-4. Schematic Diagram – DRIVER Board –......................... 12

3-5. Printed Wiring Board – DMB08 Board (Side A) – ......... 13

3-6. Printed Wiring Board – DMB08 Board (Side B) – ......... 14

3-7. Schematic Diagram – DMB08 Board (1/10) –................ 15

3-8. Schematic Diagram – DMB08 Board (2/10) –................ 16

3-9. Schematic Diagram – DMB08 Board (3/10) –................ 17

3-10. Schematic Diagram – DMB08 Board (4/10) –................ 18

3-11. Schematic Diagram – DMB08 Board (5/10) –................ 19

3-12. Schematic Diagram – DMB08 Board (6/10) –................ 20

3-13. Schematic Diagram – DMB08 Board (7/10) –................ 21

3-14. Schematic Diagram – DMB08 Board (8/10) –................ 22

3-15. Schematic Diagram – DMB08 Board (9/10) –................ 23

3-16. Schematic Diagram – DMB08 Board (10/10) –.............. 24

3-17. Printed Wiring Board – AMP Board (Side A) – .............. 25

3-18. Printed Wiring Board – AMP Board (Side B) – .............. 26

3-19. Schematic Diagram – AMP Board (1/4) – ...................... 27

3-20. Schematic Diagram – AMP Board (2/4) – ...................... 28

3-21. Schematic Diagram – AMP Board (3/4) – ...................... 29

3-22. Schematic Diagram – AMP Board (4/4) – ...................... 30

3-23. Printed Wiring Board – IO Section – .............................. 31

3-24. Schematic Diagram – IO Section (1/2) – ........................ 32

3-25. Schematic Diagram – IO Section (2/2) – ........................ 33

3-26. Printed Wiring Board – DDCON Board –....................... 34

3-27. Schematic Diagram – DDCON Board – ......................... 35

3-28. Printed Wiring Board – FL Board – ................................ 36

3-29. Schematic Diagram – FL Board – ................................... 37

3-30. Printed Wiring Board – SPK Board – ............................. 38

3-31. Schematic Diagram – SPK Board – ................................ 38

3-32. Printed Wiring Board

– POWER/FRONT PANEL Section –............................. 39

3-33. Schematic Diagram

– POWER/FRONT PANEL Section –............................. 40

4. EXPLODEDVIEWS

4-1. Case Section .................................................................... 41

4-2. Front Panel Section ......................................................... 42

4-3. Chassis Section................................................................ 43

4-4. Mechanism Deck Section-1 (CDM80-DVBU24) ........... 44

4-5. Mechanism Deck Section-2 (CDM80-DVBU24) ........... 45

4-6. Mechanism Deck Section-3 (CDM80-DVBU24) ........... 46

4-7. Base Unit Section ............................................................ 47

5. ELECTRICAL PARTS LIST .................................. 48

w

.

x

i

a

o

y

u

1

6

3

.

c

o

m

Q

3

7

6

3

1

5

1

5

0

9

2

8

9

4

2

9

8

T

E

L

1

3

9

4

2

9

6

5

1

3

9

2

8

9

4

2

9

8

0

5

1

5

1

3

6

7

3

Q

TEL 13942296513 QQ 376315150 892498299

http://www.xiaoyu163.com

4

HCD-SR1/SR2/SR3 SECTION 1

SERVICING NOTE

NOTES ON HANDLING THE OPTICAL PICK-UP

BLOCK OR BASE UNIT

The laser diode in the optical pick-up block may suffer electrostatic

break-down because of the potential difference generated by the

charged electrostatic load, etc. on clothing and the human body.

During repair, pay attention to electrostatic break-down and also

use the procedure in the printed matter which is included in the

repair parts.

The flexible board is easily damaged and should be handled with

care.

NOTES ON LASER DIODE EMISSION CHECK

The laser beam on this model is concentrated so as to be focused on

the disc reflective surface by the objective lens in the optical pick-

up block. Therefore, when checking the laser diode emission,

observe from more than 30 cm away from the objective lens.

MODEL IDENTIFICATION

— BACK PANEL —

Part No.

• Abbreviation

AUS :Australian model

EA : Saudi Arabia model

HK : Hong Kong model

KR : Korean model

RU : Russian model

SP : Singapore model

Model Name Part No.

SR1: AEP, UK 2-109-513-4[]

SR2: AEP, UK 4-253-896-0[]

SR2: RU 4-253-896-1[]

SR2: AUS 4-253-896-2[]

SR2: SP, HK, KR 4-253-896-3[]

SR2: EA 4-253-896-4[]

SR3: AEP, UK 4-253-896-5[]

SR3: RU 4-253-896-6[]

w

.

x

i

a

o

y

u

1

6

3

.

c

o

m

Q

3

7

6

3

1

5

1

5

0

9

2

8

9

4

2

9

8

T

E

L

1

3

9

4

2

9

6

5

1

3

9

2

8

9

4

2

9

8

0

5

1

5

1

3

6

7

3

Q

TEL 13942296513 QQ 376315150 892498299

http://www.xiaoyu163.com

5

HCD-SR1/SR2/SR3

SECTION 2

GENERAL

Front Panel

A[/1(power) switch/STANDBY indicator

(25)

BDisc slot (25)

C(remote sensor) (11)

DFront panel display (90)

EPHONES (on the side of the system)

jack (25)

FVOLUME +/– (25, 77)

G./>(26, 28)

Hx(stop) (26)

I(play/pause) (25)

JFUNCTION (25, 64, 66)

KZ(eject) (25)

This section is extracted

from instruction manual.

w

.

x

i

a

o

y

u

1

6

3

.

c

o

m

Q

3

7

6

3

1

5

1

5

0

9

2

8

9

4

2

9

8

T

E

L

1

3

9

4

2

9

6

5

1

3

9

2

8

9

4

2

9

8

0

5

1

5

1

3

6

7

3

Q

TEL 13942296513 QQ 376315150 892498299

http://www.xiaoyu163.com

6

HCD-SR1/SR2/SR3

Rear Panel

(European, Russian models)

ASPEAKER jacks (13)

BSURROUND BACK jack (15)

CVIDEO AUDIO IN (L/R) jacks (19)

DSAT OPTICAL DIGITAL IN jack (20)

EAM terminals (17)

FFM 75ΩCOAXIAL jack (17)

GEURO AV OUTPUT (TO TV) jacks (19)

HSAT AUDIO IN (L/R) jacks (19)

AUDIO IN

VIDEO

SURROUND

BACK SAT

SAT

SPEAKER

AUDIO IN OPTICAL

DIGITAL IN

RL

CENTER FRONT LFRONT R

SURR L

WOOFER

WOOFERSURR R

EURO AV OUTPUT(TO TV)

COAXIAL

AM FM 75

Rear Panel

ASPEAKER jacks (13)

BSURROUND BACK jack (15)

CVIDEO AUDIO IN (L/R) jacks (19)

DCOMPONENT VIDEO OUT jacks (19)

ESAT OPTICAL DIGITAL IN jack (20)

FAM terminals (17)

GFM 75ΩCOAXIAL jack (17)

HMONITOR OUT (VIDEO/S VIDEO) jacks

(19)

ISAT AUDIO IN (L/R) jacks (19)

AUDIO IN

VIDEO

SURROUND

BACK SAT

SAT

SPEAKER

AUDIO IN OPTICAL

DIGITAL IN

RL

CENTER FRONT LFRONT R

SURR L

WOOFER

WOOFERSURR R

COAXIAL

AM FM 75

COMPOMEMT VIDEO OUT

MONITOR OUT

S VIDEO

(DVD ONLY)

VIDEO

YP

B

/C

B

P

R

/C

R

(Other models)

w

.

x

i

a

o

y

u

1

6

3

.

c

o

m

Q

3

7

6

3

1

5

1

5

0

9

2

8

9

4

2

9

8

T

E

L

1

3

9

4

2

9

6

5

1

3

9

2

8

9

4

2

9

8

0

5

1

5

1

3

6

7

3

Q

TEL 13942296513 QQ 376315150 892498299

http://www.xiaoyu163.com

7

HCD-SR1/SR2/SR3

Remote

Note

This remote control glows in the dark. However,

beforeglowing, the remote must be exposed to light for

awhile.

A

Z

(eject) (25, 26)

BDISPLAY (40, 42, 66)

CSLEEP (69)

D./>, PRESET –/+ (26, 28, 66, 67)

EH(play) (26, 27, 32, 33, 36, 37)

FDVD TOP MENU/ALBUM– (28, 30, 31)

GC/X/x/c/ENTER (22, 28, 28, 30, 31, 33,

33, 35, 36, 38, 44, 50, 53, 54, 55, 57, 65,

67, 69, 71, 78)

HDVD DISPLAY (30, 31, 35, 36, 38, 42, 43,

44, 53, 54, 55)

IAUTO FORMAT DIRECT (46, 47)

JDSGX (52)

KDVD SETUP (22, 57, 71)

LSUBTITLE (54)

MAUDIO (44)

NANGLE (53)

ONumber buttons (28, 28, 33, 38, 53, 55,

57, 60, 62)

PENTER

QTUNER MENU (65, 67)

RTV [/1(on/standby) (60)

S"/1(standby) (22, 25, 65)

TSONY TV DIRECT (62)

UTUNER/BAND (65, 66, 67)

VFUNCTION (25, 64, 66, 67)

Wm/M// SLOW, TUNING –/+ (32,

37, 65, 66)

Xx(stop) (26, 27, 28, 55, 66)

YX(pause) (26)

ZMUTING (26)

wj DVD MENU/ALBUM+ (28, 30, 31)

wk VOL +/– (26, 66)

wl ORETURN (28, 30, 31, 33, 38, 55, 57,

71)

e; MODE (47, 48)

ea NIGHT MODE (52)

es PLAY MODE (33, 35)

ed REPEAT (33, 36)

ef TV (60, 62)

eg TV/VIDEO (60, 62)

eh TV CH +/– (60, 62)

ej TV VOL +/– (60)

ek AMP MENU (50, 69, 78)

el CLEAR (22, 33, 38)

r; FM MODE (66)

Open the cover.

w

.

x

i

a

o

y

u

1

6

3

.

c

o

m

Q

3

7

6

3

1

5

1

5

0

9

2

8

9

4

2

9

8

T

E

L

1

3

9

4

2

9

6

5

1

3

9

2

8

9

4

2

9

8

0

5

1

5

1

3

6

7

3

Q

TEL 13942296513 QQ 376315150 892498299

http://www.xiaoyu163.com

8

HCD-SR1/SR2/SR3 SECTION 3

DIAGRAMS

•Circuit Boards Location

AMP board

SPK board

IO board

TUNER UNIT

DMB08 board

LF board

HP board

FL board

SONY LAMP board

PW KEY board

CONTROL KEY board

DRIVER board

RF board

DDCON board

SWITCHING REGLATOR

SCART board

(only for AEP, UK and Russian models)

w

.

x

i

a

o

y

u

1

6

3

.

c

o

m

Q

3

7

6

3

1

5

1

5

0

9

2

8

9

4

2

9

8

T

E

L

1

3

9

4

2

9

6

5

1

3

9

2

8

9

4

2

9

8

0

5

1

5

1

3

6

7

3

Q

TEL 13942296513 QQ 376315150 892498299

http://www.xiaoyu163.com

99

HCD-SR1/SR2/SR3

For Schematic Diagrams.

Note:

• All capacitors are in µF unless otherwise noted. (p: pF)

50 WV or less are not indicated except for electrolytics and

tantalums.

• All resistors are in Ωand 1/4W or less unless otherwise

specified.

• f: internal component.

•C: panel designation.

•A: B+ Line.

•B: B– Line.

• Voltages and waveforms are dc with respect to ground un-

der no-signal (detuned) conditions.

• Voltages and waveforms are dc with respect to ground in

service mode.

• Waveforms are taken with a oscilloscope.

Voltage variations may be noted due to normal production

tolerances.

no mark : DVD STOP

• Circled numbers refer to waveforms.

• Signal path.

F: AUDIO

J: CD PLAY

c: DVD PLAY

d: TUNER

L: VIDEO

i: OPTICAL DIGITAL IN

h: VIDEO IN

a: CHROMA

E: Y

r: COMPONENT VIDEO

e: AUX IN

I: SACD PLAY

q: R, G, B

• Abbreviation

AUS : Australian model

HK : Hong Kong model

KR : Korean model

MX : Mexican model

RU : Russian model

SP : Singapore model

For Printed Wiring Boards.

Note:

•X: parts extracted from the component side.

• a: Through hole.

•: Pattern from the side which enables seeing.

(The other layers' patterns are not indicated.)

• Indication of transistor

THIS NOTE IS COMMON FOR PRINTED WIRING BOARDS AND SCHEMATIC DIAGRAMS.

(In addition to this, the necessary note is printed in each block.)

Caution:

Pattern face side: Parts on the pattern face side seen from

(Side A) the pattern face are indicated.

Parts face side: Parts on the parts face side seen from

(Side B) the parts face are indicated.

Note: The components identified by mark 0or dotted line

with mark 0are critical for safety.

Replace only with part number specified.

CEB

These are omitte

d

Q

C

EB

These are omitte

d

MEMO

w

.

x

i

a

o

y

u

1

6

3

.

c

o

m

Q

3

7

6

3

1

5

1

5

0

9

2

8

9

4

2

9

8

T

E

L

1

3

9

4

2

9

6

5

1

3

9

2

8

9

4

2

9

8

0

5

1

5

1

3

6

7

3

Q

TEL 13942296513 QQ 376315150 892498299

http://www.xiaoyu163.com

1010

HCD-SR1/SR2/SR3

3-1. PRINTED WIRING BOARD — RF BOARD — •See page 8 for Circuit Boards Location. :Uses unleaded solder.

(SIDE A)

RF BOARD (SIDE B)

RF BOARD

IC001

DMB08 BOARD

CN401

(Page 13)

A

E

OPTICAL PICK-UP

BLOCK

(TDP022W)

FLEXIBLE BOARD

1-684-822-

11

(11) 1-684-822-

11

(11)

1

16

17 32

48

33

64 49

1 2 3 4 5 6 7 8 9 10 11 12 13

A

B

C

D

E

F

• Semiconductor

Location

Ref. No.

Location

D001 B-3

D002 B-3

IC001 D-11

Q001 C-11

Q002 B-11

w

.

x

i

a

o

y

u

1

6

3

.

c

o

m

Q

3

7

6

3

1

5

1

5

0

9

2

8

9

4

2

9

8

T

E

L

1

3

9

4

2

9

6

5

1

3

9

2

8

9

4

2

9

8

0

5

1

5

1

3

6

7

3

Q

TEL 13942296513 QQ 376315150 892498299

http://www.xiaoyu163.com

1111

HCD-SR1/SR2/SR3

3-2. SCHEMATIC DIAGRAM — RF BOARD —

JL005

C011

R033

C036

R034

C039

C038

C037

C040

R021

JL007

C003 R010R008R007

IOP1

L002

C004D002

R006

C001

C010

R004R003

IOP2

L001

C002D001

R022

R025

R023

C016

C015

C014

R014

R013

R012

R011

R018

R017

R016

R015

C042

C020

C021

C022

C023

R024

R026C027C028

C029

C018

C017

C019

C024

C031

C033 C012 C005

R032

JL003

JL006

R029

R028

R027

JL002

JL001

C032

C034

C049

C009

C035

IC001

CN003

CN001

CN002

C025

C006 C013

R005 R009

R035

R019 R020

C041

R001

Q001 Q002

C008

R041

JL004

C030

C026

1000p

0

0.47

10M

0.033

330p

0.1

0

100

6.3V 4703333

10

16V

1SS355TE

-17

470

100

6.3V

1000p

3333

10

16V

1SS355TE

-17

220

100

820

2200p

0

180p

22p

0

12k0.10.1

0.01

5600p

2200p

5600p

0.01

1000p

0.1 0.1 22

10V

100

0

0.047

0.1

CXD1881AR

9P

24P

29P

0.1

22

10V 0.1

47k 47k

0

00

0.1

100

2SB1132-T100-QR 2SB1132-T100-QR

0.1

1k

0.01

0.1

MIRR

RFP

CD_LD

DVD_LD

SDEN

DATA_RF

CLK_RF

SDEN

DATA_RF

CLK_RF

LDON

A

B

C

D

E

F

TE

FE

TE

FE

PD

RFMON

B

A

F

D

C

RFP

E

CD_LD

DVD_LD

PD FD-

FD+

TD-

TD+

FD+

FD-

TD+

TD-

SLB-

SLB+

SLA-

SLA+

PI/CE

LDON

MIRR

SLA+

SLB+

SLB-

SLA-

B

A

F

RF

GND

VC

VCC

C

D

E

PD

VR

SW

LD GND

DVD LD

CD LD

N.C

FCS+

FCS-

TRK+

TRK-

AGND

RFAC

AGND

AVC

MIRR

TE

FE

A5V

SDEN

DATA_RF

CLK_RF

LDON

A3V

RFMON

INLIM

LDSEL

VCC

SPDL+

SPDL-

SLEDA+

SLEDA-

SLEDB+

SLEDB-

TD+

TD-

FD+

FD-

SLEDA+

SLEDB+

SLEDA-

SLEDB-

LED

GND

INLIM

SPDL-

SPDL+

INLIM

INLIM_3V

{LIMIT-SW(A)}

{LIMIT-SW(B)}

PI

FOCUS/TRACKING ERROR AMP

CD/DVD/SACD RF AMP,

AUTOMATIC POWER

CONTROL

(FOR DVD)

AUTOMATIC POWER

CONTROL

(FOR CD)

FLEXIBLE

BOARD

47µH47µH

DBU-1

DMB08 BOARD

(1/10)

CN401

(Page 15)

4

1

3

2

IC B/D

No mark : DVD STOP

Ver 1.2

w

.

x

i

a

o

y

u

1

6

3

.

c

o

m

Q

3

7

6

3

1

5

1

5

0

9

2

8

9

4

2

9

8

T

E

L

1

3

9

4

2

9

6

5

1

3

9

2

8

9

4

2

9

8

0

5

1

5

1

3

6

7

3

Q

TEL 13942296513 QQ 376315150 892498299

http://www.xiaoyu163.com

1212

HCD-SR1/SR2/SR3

3-3. PRINTED WIRING BOARD — DRIVER BOARD — •See page 8 for Circuit Boards Location.

:Uses unleaded solder.

3-4. SCHEMATIC DIAGRAM — DRIVER BOARD —

IC701

G

DMB08 BOARD

CN007

(Page 13)

M701

(LOADING)

(TRIGGER) (DISC IN/OUT)

(CHUKING)

1

9

M

12

A

B

C

34

No mark : DVD STOP

+7V

G

DMB08 BOARD (10/10)

CN007

(Page 24)

IC B/D

IC701

CN701

R702

R701

C711

C705

D701

S703 S701 S702

M701

BA6956AN

7P

CT-L

100

680

10

50V

0.01

MTZJ-T-77-4.7C

(TRIGGER) (DISC IN/OUT) (CHUKING)

(LOADING)

Ver 1.2

w

.

x

i

a

o

y

u

1

6

3

.

c

o

m

Q

3

7

6

3

1

5

1

5

0

9

2

8

9

4

2

9

8

T

E

L

1

3

9

4

2

9

6

5

1

3

9

2

8

9

4

2

9

8

0

5

1

5

1

3

6

7

3

Q

TEL 13942296513 QQ 376315150 892498299

http://www.xiaoyu163.com

1313

HCD-SR1/SR2/SR3

3-5. PRINTED WIRING BOARD — DMB08 BOARD (SIDE A) — •See page 8 for Circuit Boards Location. :Uses unleaded solder.

IC401

IC301

IC901

IC813

IC612

IC605

IC606

IC801

IC607

IC701 IC206

IC402

D

DDCON

BOARD

CN800

(Page 34)

FOR

CHECK

FOR

CHECK

A

RF

BOARD

CN002

(Page 11)

F

IO

BOARD

CN201

(Page 31)

E

IO

BOARD

CN601

(Page 31)

SWITCHING

REGULATOR

CN8

C

AMP

BOARD

CN301

(Page 26)

B

AMP

BOARD

CN302

(Page 26)

G

DRIVER

BOARD

CN701

(Page 12)

12

A

B

C

D

E

F

3456789

• Semiconductor

Location

Ref. No.

Location

D900 C-2

D901 C-4

IC206 D-5

IC301 C-2

IC401 D-2

IC402 D-2

IC605 C-8

IC606 C-7

IC607 B-7

IC612 B-6

IC701 D-4

IC801 B-5

IC813 C-4

IC901 B-2

w

.

x

i

a

o

y

u

1

6

3

.

c

o

m

Q

3

7

6

3

1

5

1

5

0

9

2

8

9

4

2

9

8

T

E

L

1

3

9

4

2

9

6

5

1

3

9

2

8

9

4

2

9

8

0

5

1

5

1

3

6

7

3

Q

TEL 13942296513 QQ 376315150 892498299

http://www.xiaoyu163.com

1414

HCD-SR1/SR2/SR3

3-6. PRINTED WIRING BOARD — DMB08 BOARD (SIDE B) — •See page 8 for Circuit Boards Location. :Uses unleaded solder.

IC604

IC005

IC004

IC608

IC904

IC601

IC002

IC006

IC703

IC205

IC203

IC215

IC202

IC814

IC501

IC803

IC802

IC903

IC907

IC302

IC812

IC303

IC704

IC808

IC706

IC001

IC603

IC609

IC900

SR1/SR3

SR1/SR2

EXCEPT

AEP,UK

EXCEPT

HK,SP,KR

AEP,UK,RU

12

A

B

C

D

E

345678

• Semiconductor

Location

Ref. No.

Location

D902 B-7

D903 B-6

D904 C-7

D907 B-7

IC001 E-3

IC002 D-2

IC004 C-2

IC005 C-2

IC006 E-4

IC202 D-4

IC203 D-3

IC205 D-4

IC215 C-3

IC302 C-7

IC303 C-4

IC501 E-7

IC601 D-2

IC603 E-2

IC604 C-2

IC608 D-2

IC609 D-2

IC703 E-5

IC704 C-4

IC706 D-5

IC802 C-7

IC803 C-6

IC808 B-4

IC812 C-5

IC814 C-5

IC900 B-3

IC903 C-6

IC904 D-1

IC907 B-7

Q301 D-6

Q302 D-3

Q900 B-7

Q901 B-7

Q902 B-7

Q903 B-6

Q906 B-6

Q907 C-7

Q908 B-3

Q909 B-3

Q910 B-3

Q913 B-7

w

.

x

i

a

o

y

u

1

6

3

.

c

o

m

Q

3

7

6

3

1

5

1

5

0

9

2

8

9

4

2

9

8

T

E

L

1

3

9

4

2

9

6

5

1

3

9

2

8

9

4

2

9

8

0

5

1

5

1

3

6

7

3

Q

TEL 13942296513 QQ 376315150 892498299

http://www.xiaoyu163.com

1515

HCD-SR1/SR2/SR3

3-7. SCHEMATIC DIAGRAM — DMB08 BOARD (1/10) —

11

16

0.7

0.8

1.6

5

0

1.6

3.3

0.8

0

1.6

0

1.6

0

3.2

0

3.3

5

0

0.2

1.3

1.6

0

1.6

0

3.3

3

1.6

1.2

0.9

3.3

1.6

1.7

0

3.3

0.4

0

NO MARK : DVD STOP

IC B/D

R445

R450

R455

R452

R446

R448

R444

R453

R449

C401

C417

C408

R439

C416

R401

C402

C407

JL536

JL535

JL531

JL530

JL529

JL526

JL525

JL524

JL523

JL537

JL512

JL511

JL510

JL509

JL508

JL507

JL506

JL505

R420

JL522

JL527

R421

R423

R425

R426

R429

R430

C409

C405

JL544

JL504

JL503

JL502

JL501

R437

R440

R434

C415

R433

C414

JL500

R442

R428

R414

AMP,REFERENCE VOLTAGE

GENERATOR

R418

R419

R451

C425

C420

C418

C428

C424

C421

C433

C436C435

C406

IC402

C432

C404

FL401

FL402

IC401

CN401

C411 C410

R441

R443

C419

R412

R413

R411

C423

C422

R457

C427

R447

C426

C412

C413

C434

1k

100k

1M

10k

1k

470k

1M

33k

0.1

330

10

10V

0

10

10V

0

1k

0.0022

10

16V

47k

0.01

47k

0.01

10k

1k

0

10k

68k

10k

0.0022

0.1

0.0033B

0.022

B

0.1

0.0015

0.10.1

0.0022

NJM3404AV(TE2)

100p

0.1

0UH

(2012)

0UH

(2012)

CXD3068Q

29P

0.1 10

16V

1k

47k

0.047

B

10k

0

0.1

100p

3.3k

0.47

B

10k

0.01

B

0.0022

10

10V

DIGITAL SIGNAL PROCESSOR,

DIGITAL SERVO PROCESSOR

Ver 1.2

w

.

x

i

a

o

y

u

1

6

3

.

c

o

m

Q

3

7

6

3

1

5

1

5

0

9

2

8

9

4

2

9

8

T

E

L

1

3

9

4

2

9

6

5

1

3

9

2

8

9

4

2

9

8

0

5

1

5

1

3

6

7

3

Q

TEL 13942296513 QQ 376315150 892498299

http://www.xiaoyu163.com

1616

HCD-SR1/SR2/SR3

3-8. SCHEMATIC DIAGRAM — DMB08 BOARD (2/10) —

15

1

0.9

12

0

3.2

1.6

NO MARK : DVD STOP

0.8

5.1

3.2

1.6

5.1

1.6

1.4

1.1

1.6

1.3

1.6

1.1

C504

C506

C509

C512

C514

C526 FOCUS/TRACKING

COIL DRIVER, SPINDLE,

SLED MOTOR DRIVER

C529

R512

R513

R514

R516 R517

R519

R520

R521

R522

R523

R524

R525

R527

R529

R530 R531

R532

R533

R534 R535

R536

R580

R582

R583

C525

C527

C508

C510

R416

R592

C524

R579

R581

C519

IC501

R510

R511

C503

R515

C528

33000p

330p

0.01

22

16V

0.1

56k

10k

4.7k 2.2k

100k

10k

100k

4.7k

10k

2.2k

33k

56k 0

0

33k

56k 0

200k

33k

10k

0.1

0.001

0

0.1

8.2k

12k

0.01

FAN8035L

150k

33000p

10k

47

6.3V

Ver 1.2

w

.

x

i

a

o

y

u

1

6

3

.

c

o

m

Q

3

7

6

3

1

5

1

5

0

9

2

8

9

4

2

9

8

T

E

L

1

3

9

4

2

9

6

5

1

3

9

2

8

9

4

2

9

8

0

5

1

5

1

3

6

7

3

Q

TEL 13942296513 QQ 376315150 892498299

http://www.xiaoyu163.com

1717

HCD-SR1/SR2/SR3

3-9. SCHEMATIC DIAGRAM — DMB08 BOARD (3/10) —

IC B/D

1.6

3.3

0

1.6

3.3

1.6

0

5

2

0

1.6

5

0

5

3.2

3.3

1.5

0

1.6

3.2

1

3.3

2.5

2.6

0

1.6

0

3.3

0

5

0

3.2

0

3.2

3.3

0

5

0

5

0

3.3

5

0

1.9

1.6

1.5

3.3

1.6

1.5

1.6

0.5

0.9

0.3

3.3

1.6

3.2

1.7

0

5

0

3.2

0

3.2

0

0.2

0.8

0.4

3.3

0.4

3

0.4

2.1

3.2

0

5

0

5

3.3

5

3.2

5

3.3

0

2.3

5

0

3.2

0

0.8

0.4

3.3

0

3.3

0

3.2

2.1

0

0.2

0.4

2

0.4

3.3

1.6

5

4.6

NO MARK : DVD STOP

C764

C761

C762

C730

C740

C741

C724

C723C722

C714

C713

C718

C712

C711

C709

C772

C767

C773

C771

R721

C720

R724

R726R725

R720

C760

C763

C706

R767

R765

C774

C775

C702

C781 C776

C742

R760

C777

C721

C766

C725

TP701

TP702

C752

R780

R781

IC703(2/2)

R728

R727

C521

C729

R799

C703

R706

R702

R703

R716

R718

R717

R719

R715

R713

R764

R763

R750

IC703(1/2)

R778

C779

C780

R743

R744

R731

IC706

R776

R545

BUFFER

C523

R544

R538

R541

R540

R772

C727

R747

R729

R701

R771

FL704

FL705

FL706

FL701

FL703

FL702

IC701

DVD DECODER

R762

C770

C778

C768

C769

C765

R777

R746

R745

R742

R741

C744

R705

R737

R704

R735

C743

R732

R730

C745

C726

C716

C717

C715

COMPARATOR

R748

R709

C708

R708

R707

R714

R710

R711

R712

C728

0.01

B

0.01

B

0.01

B

0.01

B

0.01

B

0.01

B

0.1 F

0.01

B

0.01

B

0.1 F

0.01

B

100p

CH

0.01

0.1

F

0.1

0.01

B

0.47

B

0.047

B

33k

0.1

B

1k

100k

1.8k

1k

0.01

B

0.01

B

0.1

F

47k

22k

0.0047

0.01 B

100

4V

10

10V

0.1

F

0.01

B

0

0.01

B

0.1 B

100p

0.1 F

0.1

0

NJM3404AV(TE2)

10k

3.3k

0.0015

10

10V

0

0.1

10k

100

10k

100k

1k

10k

1M

8.2k

10k

NJM3404AV(TE2)

100k

10

10V

10

10V

22

M51V18165M-60TS-KR1

16Mbit D-RAM

0

100k

0.0015

100k

10k

22

10

10V

33k

8.2k

680

2.2k

0UH

(2012)

0UH

(2012)

0UH

(2012)

0UH

(2012)

0UH

(2012) 0UH

(2012)

TMC57929PGF

-RDP

22k

0.01 B

0.01B

0.01 B

0.01

B

0

47k

22

0.01

B

10k

0.01

B

10k

22

0.01

B

0.1

F

0.47

B

0.01

B

0.0015

33k

150k

0.01

470k

100

10k

2.2k

10k

0.1

B

19

18

Ver 1.2

w

.

x

i

a

o

y

u

1

6

3

.

c

o

m

Q

3

7

6

3

1

5

1

5

0

9

2

8

9

4

2

9

8

T

E

L

1

3

9

4

2

9

6

5

1

3

9

2

8

9

4

2

9

8

0

5

1

5

1

3

6

7

3

Q

TEL 13942296513 QQ 376315150 892498299

http://www.xiaoyu163.com

1818

HCD-SR1/SR2/SR3

3-10. SCHEMATIC DIAGRAM — DMB08 BOARD (4/10) —

IC B/D

3.3

0

3.3

2.5

3.2

0

3.3

0

3.3

5.1

0

2.2

0.8

3.3

0

3.3

0

3.3

3.2

0

1.5

1.2

3.2

0

3.2

0

0.8

3.2

0

2.5

0

3.2

0

3.2

0

3.2

0

2.5

3.2

0

0.7

3.2

3.3

3.2

0.2

2.5

0.9

2.5

3.3

2.5

3.3

0

2.5

0

0.7

2.5

3.2

1.6

2.5

3.2

0

3.3

0

3.3

0.8

3.2

0

3.2

0

3.3

0

3.3

0

3.2

0

3.3

NO MARK : DVD STOP

R827

C808

SL811

SL812

C813

R808

C805

C843

C812

C811

C838

C839

C803

C848

C817 C818

C871

C867 C866

C857

C856

C855

C861

R828

R831

R847

R839

R842

C842

C854

R800

SL813

R804

R805

FL812

FL811

R806

LEVEL SHIFT

FL810

FL807

IC812

IC813

IC801

DSD DECODER

C796

C849

C837

C804

C819

R830

R829

C807

C810

R867

R823

R822

R821

R848

R849

R850

R826

C865

C870 R803

C815

C797

R889

R888

R887

R886

R885

R884

R883

R882

IC704

IC808

16Mbit SD-RAM

LEVEL SHIFT

SACD/DVD SELECT

+2.5V REG

C840

C802

C841

IC814

100

100p

0.01

10k

0.01

B

0.01

B

0.01

B

0.01

B

0.01

B

0.01

B

0.01

B

0.01

B

0.01

B

0.01

B0.01

B

0.01

B

0.01

B

0.01

B

0.01

B

4.7k

33k

22

4.7k

10k

0.01

B

0.01

B

4.7k

0

10k

POWER-EMIS

(3216)

POWER-EMIS

0

0UH

(2012)

0UH

(2012)

SN74LV245APWR

CXD2753R

0.1

F

0.01

B

0.01

B

0.01

B

4.7k

100

0.01B

0

22

0.01

B

33000p 100 0.01

B

100 4V

10k

TK11125CSCL-G MSM56V16160F-8TK

7R1

10

10V

10

10V

10

10V

TC7WH157FK

(TE85R)

17

19

Ver 1.2

w

.

x

i

a

o

y

u

1

6

3

.

c

o

m

Q

3

7

6

3

1

5

1

5

0

9

2

8

9

4

2

9

8

T

E

L

1

3

9

4

2

9

6

5

1

3

9

2

8

9

4

2

9

8

0

5

1

5

1

3

6

7

3

Q

TEL 13942296513 QQ 376315150 892498299

http://www.xiaoyu163.com

1919

HCD-SR1/SR2/SR3

3-11. SCHEMATIC DIAGRAM — DMB08 BOARD (5/10) —

3

17

(3/10)

18

10

5

9

8

7

6

IC B/D

3.2

0

3.2

0

3.2

2.5

2.6

0

3.2

0

3.2

0

3.2

3.1

3.2

1.5

3.2

1.6

0.6

0

3.2

0

3.2

3.1

3.2

3.2 3.2

0

3.2

0

3.2

1.6

1.1

1.6

3.3

1.6

1.1

1.6

3.2

0

3.2

0.5

0

3.2

0

3.2

0

3.2

4.1

0

5

3.2

0

3.1

3.2

1.2

1.4

3.2

0.1

3.2

0.6

3.2

0.6

NO MARK : DVD STOP

C302

C308

C309

C310

C311

IC802

L301

Q301

R303

R304

R305

R306

R307

R308

R311R312

R316

R317

R318

R321

R323

R326

R327

R328

R329

R330

R335

R344

R346

R350

R354

R355

R357

R358

R361

R364

R738

R356

FL303

FL304

FL301

X302 R362

IC302

C317

C320

IC803

R325

JL301

JL302

JL303

JL304

JL305

JL306

JL307

CL302

CL303

CL301

CL304

IC301

R333

R324

C307

C304

R331

R360

R332 R365

R366

R337

R359

R353

C316

C313

IC303

CLOCK GENERATOR

FILP-FLOP

SWITCHING

C318

C809

R363

CN301

C301

C303

C312

X301

0.01

B

33000p

100p

0.01

B

TC7S32FU(TE85R)

DTC114EKA-T146

LASER DIODE SELECT

22

10k

22

10k

100

22

1k

100

1M

22

68

10k

4.7k

22

68

0UH

(2012)

0UH

(2012)

0UH

(2012)

27MHz 150

BR24L16F-WE2

EEPROM

12p

0.01

B

SN74AHC2G74HDCUR

33k

CXP973064-245R

MECHANISM CONTROLLER

10k

0

0.01 B

220

10k

10k 100k

100k

100

10k

10 16V

0.1 F

SM8707GV -G-E2

12p

0.01

10k

10

10V

0.01

B

10

10V

20MHz

7P

Ver 1.2

w

.

x

i

a

o

y

u

1

6

3

.

c

o

m

Q

3

7

6

3

1

5

1

5

0

9

2

8

9

4

2

9

8

T

E

L

1

3

9

4

2

9

6

5

1

3

9

2

8

9

4

2

9

8

0

5

1

5

1

3

6

7

3

Q

TEL 13942296513 QQ 376315150 892498299

http://www.xiaoyu163.com

2020

HCD-SR1/SR2/SR3

3-12. SCHEMATIC DIAGRAM — DMB08 BOARD (6/10) —

22

21

16

18

IC B/D

3.3

0

4.9

4

0

1.7

1.6

3.3

3.2

1.6

0

3.3

4.8

3.3

2.9

3.2

3.3

0

3.3

0

3.3

0

3.3

0

3.3

0

2.5

1.6

4.7

2.5

4.7

3.2

3

3.2

0

1

0

1.7

3.3

1.6

2.6

0

1.6

1.7

1.6

3.3

1.6

1

2.6

3.3

2.6

1.6

2.6

1.6

0

1.6

1.7

3.3

1.7

0

2.5

1

1.7

1.6

3.3

0

4.7

0

4.6

0

2.6

3.3

0

3.3

0

2.6

0

3.3

0

2.6

2.7

0

2.5

3.3

0

4.7

0

3.3

0

2.5

0

NO MARK : DVD STOP

C603

C609 C612

C613

C616 C617

C636

C643

C648

C652

C667

C674

L602

R602

R608

R634

R639 R640

R642

R655

R658

R661

R662

R664

R666

R667

R679 R680

R687

R673

R674

R675

R676

R677

R672

R628

R631

R616

C634

R603

R604

R606

R629

R623

C664

C611

C626

C627

C635

C637

C640

C642

C644

C646

C647

C650

C653

C661

C665

C666

C668

C669

C670

C671

C675

C679

C673

IC612

R698

R699

R637

R688

R691

R697

R995

R996

IC604

R605

R607

R645

C629

IC607

R740

R768

C632

R898

FL603

C651

R663

C660

FL604

R671

R997

C672

R678R998

R659

X601

R648 R689

R994

FL607

FL606

R692

R625

R600

C604

C608

X600

R615

R611

R614

IC606

C641

22p

0.1

10

0.1 0.1

0.1

220

4V

0.1

220

4V

10

1M

3.3k

1k

100 100

100

100 100

1k

220

100

5.6k

0.1

100

10

0.01

CXD9742Q

DIGITAL AUDIO PROCESSOR

10k

2.2k

0

4.7k

IS61LV6416 -10TLT

S-RAM

1k

100

1M

15p 1k

0

15p

10k

0UH

0.01

100

0.01

0UH

100

4.7k

0.01

4.7k4.7k

33

13.9MHz

33 10k

4.7k

0UH

2.2k

3.3k

100

56p

0.1

12.288MHz

4.7k

100

33k

LC89056W-E

DIGITAL AUDIO

INTERFACE

0.01

CXD9718BQ

DIGITAL AUDIO

SIGNAL PROCESSOR

Ver 1.2

w

.

x

i

a

o

y

u

1

6

3

.

c

o

m

Q

3

7

6

3

1

5

1

5

0

9

2

8

9

4

2

9

8

T

E

L

1

3

9

4

2

9

6

5

1

3

9

2

8

9

4

2

9

8

0

5

1

5

1

3

6

7

3

Q

TEL 13942296513 QQ 376315150 892498299

http://www.xiaoyu163.com

Sony HCD-SR1 User manual

Popular Receiver manuals by other brands