SPORTSPOWER MSC-3992 User manual

DO NOT RETURN TO THE STORE.
For customer service, please call 1-866-370-2131 Monday-Friday 9:00am-5:00pm Eastern Time
or visit our website at www.sportspowerltd.net
SPORTSPOWER LTD, FLAT M, 3/FLOOR, KAISER ESTATE PHASE 3, 11 HOK YUEN STREET, HUNGHOM, KOWLOON, HK.
Corporate US toll-free number 1-800-497-6106
7 STATION JUMP N SWING SET
MODEL # MSC-3992
OWNER’S MANUAL
ASSEMBLY INSTRUCTION, CARE, MAINTENANCE AND USER’S GUIDE
FOR RESIDENTIAL USE ONLY
- This product is intended for use by children from ages 3 to 8
- This unit is designed for use by up to 7 children at one time.
Maximum weight of each user is 100 lbs.(45.4kg), with a
combined maximum weight of 700lbs(317kg)
- Assembly requires two adults
- Do not allow more than one child to play on the individual
swing/slide at the same time
- Do not allow children to slide down head first.
WARNING
PLEASE RETAIN THESE INSTRUCTIONS FOR FUTURE REFERENCE

Dear Valued Customer,
Congratulations on your Sportspower play set purchase! Please read and completely understand the contents
of this owner’s manual. This manual contains specific safety instructions that must be followed to enable safe
play and prevent injuries. This play set is for residential use only.
This play set is NOT intended for public or commercial use. The warranty will be voided if the play set is
used in a commercial application.
The product is designed for use by children between the ages of 3-8. Children must NOT play on this set until
it is properly assembled and inspected by an adult. Adult supervision is required at all times while children
are playing on the equipment. Do not allow children under six (6) years old to be near during the assembly
of this product due to choking hazards of small parts.
The equipment must be installed on level ground. Uneven ground must be leveled prior to installation.
Installation on sloping or uneven ground will put stress on the joints, causing the unit to become loose and
unstable which may result in serious injuries. You must ensure there are no obstructions or structures (e.g.
electrical wires, branches, house, fence, garage, etc) within six (6) feet from the equipment.
The Consumer Product Safety Commission’s Outdoor Home Playground Safety Handbook recommends to
install and maintain the playground equipment over at least 9 inches of wood chips, mulch or shredded rubber
(for equipment up to 8 feet high) or sand or pea gravel (for equipment no more than 5 feet high) as shock
absorbing material. Dirt and grass, which are the most prevalent surfaces under home playground equipment,
do not adequately protect children from serious head injuries. Install protective surfacing at least six feet in
all directions from play equipment. For swings, the surface should extend, in back and front, twice the height
of the suspending bar. Do not install your play set over hard surface, e.g. asphalt, concrete, packed earth, tile
or brick floor. Please refer to extracts from the CONSUMER PRODUCT SAFETY COMMISSION’S
OUTDOOR HOME PLAYGROUND SAFETY HANDBOOK contained in this manual for further details.
Do not allow children to use the product during windy or wet weather conditions. You should consult a local
contractor about ways to anchor the product in your location.
Please thoroughly read and follow the instructions in this Owner’s Manual to ensure safe and enjoyable play
for your children. The equipment must be checked before each use and maintained regularly. This includes,
but is not limited to inspecting the play set for cracks, excess wear, missing parts, loose connections, and for
overall integrity. When the set shows any signs of weakness or damage, you must stop using the play set
immediately, properly store the set or restrict access by users until the condition is resolved.
Your product is warranted against defects in material and workmanship. Extended warranty is also offered
to those customers registering their products at www.sportspowerltd.net within 14 days from the date of
purchase. Please refer to our warranty policy at the back of this manual for details.
INTRODUCTION
1
If you experience any problems with your product, do not return to the store.
For customer service, please call 1-866-370-2131 Monday-Friday 9:00am-5:00pm Eastern Time.
If you are unable to reach us at this number for any reason, call 1-800-497-6106 or visit
www.sportspowerltd.net

IMPORTANT SAFETY INSTRUCTIONS
BEFORE YOU BEGIN: Carefully read all instructions in this manual before assembling and using this
product. The unit must be assembled by adults. Heavy duty working gloves must be worn to avoid injuries
during assembly.
Children must not use the equipment until properly assembled and anchored. Adult supervision is required
during the use of this equipment at all times
READ ALL INSTRUCTIONS BEFORE ASSEMBLYING OR USING THIS EQUIPMENT
AGE LIMIT
• This product is designed to be used safely by up to six (7) children between the ages of 3 to 8. Maximum
user weight is 100 pounds (45.4kg) each with a combined maximum weight of 700 pounds (317kg.)
• The play set is designed for children over three (3) years of age. Use by smaller children can result in
entrapment.
• On-site adult supervision is required at all times for children of all ages.
•
Do not allow use by children with any physical condition that may affect his/her ability to use this equipment
safely.
BEFORE YOU BEGIN: Carefully read all instructions in this manual before assembling and using this
product. The unit must be assembled by adults. Children must not use the equipment until it is properly
assembled and anchored. Adult supervision is required during the use of this equipment at all times.
• Identify the location appropriate for the placement of your equipment. The play set must be placed on level
ground and not over hard surface. Ensure equipment is placed more than six (6) feet from any structures
or obstructions on all sides. Remove any tripping hazards from the vicinity of the play area, such as roots,
stumps, rocks, landscaping, sprinkler heads, exposed plumbing, electrical boxes, etc.
•
Unpack all parts. Take a complete inventory of all parts and hardware using the parts and hardware lists in
the following pages. If any parts are missing, please call customer service for assistance. Store the product
back in the original box and do not begin to install until all parts are obtained.
LOCATION OF PLAY SET
• The equipment must be placed more than six(6) feet(1.8 meter) from any structures or obstructions, including
but not limited to buildings, fence, garage, trees, laundry lines, electrical wires. The safe play area refers to
a zone extending 6 feet beyond the play set on all sides, including the space above the play set. Children
can be seriously injured running or swinging into obstacles. The play set must be installed on level ground.
Uneven ground must be leveled prior to installation. Installation on sloping or uneven ground will put stress
on the joints, causing the unit to become loose and unstable which may result in serious injuries.
•
Remove any tripping hazards from the safe play area, such as roots, tree stumps, rocks, landscaping, sprinkler
heads, railroad ties, plumbing and electrical connections.
• Do not install your play set over hard surface, e.g. asphalt, concrete, packed earth, tile or brick floor. A fall
onto a hard surface can result in serious injury or death to the user
WARNING
2

3
The following is a list of recommended ground covers from the Consumer Product Safety Commission:
The Consumer Product Safety Commission’s Outdoor Home Playground Safety Handbook recommends to
install and maintain the playground equipment over at least 9 inches of wood chips, mulch or shredded rubber
(for equipment up to 8 feet high) or sand or pea gravel (for equipment no more than 5 feet high) as shock
absorbing material. Dirt and grass, which are the most prevalent surfaces under home playground equipment,
do not adequately protect children from serious head injuries. Install protective surfacing at least six feet in
all directions from play equipment. For swings, the surface should extend, in back and front, twice the height
of the suspending bar. You should consult a local contractor about ways to secure the product in your location.
Do not install your play set over hard surface, e.g. asphalt, concrete, packed earth, tile or brick floor. Please
refer to the CONSUMER PRODUCT SAFETY COMMISSION’S OUTDOOR HOME PLAYGROUND
SAFETY HANDBOOK for detailed guidelines to prevent injuries from falls and other hazards on public and
home playgrounds.
WEATHER CONDITIONS
•
DO NOT use this equipment if the swing seat, slide or other parts are wet. Use the play set only when the
parts are clean and dry. If the equipment is wet, the user could slip and suffer injuries.
• Please be aware of weather conditions when using the equipment. If it is too windy, users could lose control
and suffer injuries. The playground equipment must be properly anchored, stored away or restricted from
use during inclement weather such as heavy winds or severe weather storms. You should consult a local
contractor about ways to anchor the product in your location.
PLAY SUPERVISION
• DO NOT allow more than one child to play on the swing, trapeze bar or slide at any one time.
• DO NOT allow children to stand on the swing seats or glide ride.
•
DO NOT allow children to walk too close to moving parts. ALWAYS keep a safe distance to avoid being
struck by other children while playing on swings, slides, trapeze, etc.
• DO NOT allow children to twist the swing chains or ropes, or loop them over the top support bar as this
may reduce the strength of the chain or rope.
• DO NOT swing empty seats as this may cause injuries.
• ALWAYS guide children to sit in the center of swinging parts, with their full weight placed in the seat
center and holding on to the swing chains.
• DO NOT allow children to jump off the equipment while it is in motion. ALWAYS come to a full stop
before dismounting.
•
ALWAYS dress children appropriately for safe play, e.g. wear well-fitted rubber sole shoes, and remove
loose or sharp items such as jewelry, hair accessories, scarf, ponchos which may become entangled in the
equipment or cause injuries.
•
ALWAYS make sure children remove their bike or other sports helmets before playing on the playground.
Helmets can become entrapped in playground, posing a strangulation hazard.
• DO NOT allow children to slide down head first.
• DO NOT allow children to climb onto swing or jump to and from different play areas of the equipment.
ALWAYS return safely to the ground before approaching another play area.
•
DO NOT allow children to climb on structural parts (e.g. legs, top bar). These are structural components
and are not designed for play.
•
ALWAYS check the slide or other parts exposed to the body for extreme heat from the sun before allowing
children to use the equipment.
• ALWAYS prevent access and secure from any unauthorized use when there is no adult supervision.
• DO NOT allow pets or other animals near the equipment to prevent damage or injuries.
SUGGESTED MATERIAL
Double Shredded Bark Mulch
Uniform Wood Chips
Fine Gravel
Fine Sand
SUGGESTED MATERIAL
9”
12”
12”
12”

REGULAR INSPECTION OF THE EQUIPMENT
•
DO NOT use the equipment if any bolts or nuts are missing or loose. ALWAYS check to ensure the
equipment and all parts are well secured and stable before each use.
•
ALWAYS clear the play area of any rocks, sharp objects, or any materials that could be potentially
hazardous to users.
•
DO NOT attach items to the equipment that are not specifically designed for use with the equipment,
including, but not limited to, jump ropes, clothesline, pet leashes, cables and chains as they may cause
choke hazards.
•
The steel and plastic parts used in your product are subject to normal wear. Gradual deterioration of the
material will occur, the speed of which will depend on the level of exposure to UV rays, airborne
pollution, outdoor weather conditions such as rain and wind and the amount of use. You must inspect
the equipment prior to every use. This includes, but is not limited to inspecting the set for cracks, excess
wear, missing parts, loose connections, and for overall integrity. When the set shows any signs of
weakness, you must stop using the play set immediately, properly store the set or restrict access by
users until the condition is resolved.
•
Verify that the suspended climbing ropes, chain or cable are secured at both ends and tightened, so that
there is no loose ropes, chain or cable hanging that can result in choking hazard.
4

CARE AND MAINTENANCE
ANNUAL MAINTENANCE CHECKLIST
AT THE BEGINNING OF EACH PLAY SEASON:
• Tighten all hardware.
• Lubricate all metallic moving parts per manufacturer’s instructions.
•
Check all protective coverings on bolts, pipes, edges and corners. Replace if they are loose, cracked or
missing.
•
Check all moving parts including swing seats, ropes, cables and chains for wear, rust or other deterioration.
Replace as needed.
•
Check metal parts for rust. If found, sand and repaint using a non-lead based paint meeting the requirements
of 16 CFR 1303.
•
Reinstall any plastic parts, such as swing seats or any other items that were removed for the cold season.
• Rake and check depth of loose fill protective surfacing material to prevent compaction and to maintain
appropriate depth. Replace as needed.
TWICE A MONTH DURING PLAY SEASON:
• Tighten all hardware.
•
Check all protective coverings on bolts, pipes, edges and corners. Replace if they are loose, cracked or
missing.
•
Rake and check depth of loose fill protective surfacing material to prevent compaction and to maintain
appropriate depth. Replace as needed.
ONCE A MONTH DURING PLAY SEASON:
• Lubricate all metallic moving parts per manufacturer’s instructions
•
Check all moving parts including swing seats, ropes, cables and chains for wear, rust or other deterioration.
Replace as needed.
AT THE END OF EACH PLAY SEASON OR WHEN THE TEMPERATURER DROPS BELOW 32 °F .
• Remove plastic swing seats and other items as specified by the manufacturer and take indoors or restrict use.
• Rake and check depth of loose fill protective surfacing material to prevent compaction and to maintain
appropriate depth. Replace as needed.
As a general rule, maintenance should be performed at any time it is deemed necessary.
DISPOSAL INSTRUCTIONS
•
Please use care when disassembling the equipment. Wear heavy duty working gloves to avoid injuries.
• Fully disassemble the entire swing and slide sets before disposal. Do not leave partially disassembled
equipment parts in areas accessible by children.
• Should you wish to recycle the steel tubing, please take the frame to your recycling center.
•
All plastic parts could be recycled. Take it to your local recycling center. Do not let children play with
any disassembled parts destined for disposal, such as chains, slide, tubing, bolts, nuts, screws, etc.
5

IMPORTANT
CONSUMER INFORMATION SHEET
6
The Consumer Product Safety Commission estimates there are about 200,000 playground related injuries
involving children each year. Injuries involving this hazard pattern tend to be among the most serious of
all playground injuries and have the potential to be fatal, particularly when the injury is to the head. The
surface under and around playground equipment can be a major factor in determining the injury-causing
potential of a fall. It is self evident that a fall onto a shock absorbing surface is less likely to cause a serious
injury than a fall onto a hard surface. Playground equipment should never be placed on hard surfaces such
as concrete or asphalt and while grass may appear to be acceptable it may quickly turn to hard packed earth
in areas of high traffic. Shredded bark, mulch,,wood chips, fine sand or fine gravel are considered to be
acceptable shock absorbing surface when installed and maintained at a sufficient depth under and around
playground equipment.
Table below lists the maximum height from which a child would not be expected to sustain a life-threatening
head injury in a fall onto four different loose-fill surfacing materials if they are installed and maintained at
depths of 6” (15.25CM), 9” (22.9CM), and 12” (30.5CM).
However,it should be recognized that all injuries due to falls cannot be prevented no matter what surfacing
material is used.
We recommend that a shock absorbing material should extend a minimum of 6ft in all directions from the
perimeter of stationary equipment such as climbers and slides. However, because children may deliberately
jump from a moving swing, the shock absorbing material should extend in the front and rear of a swing
a minimum distance of 2 times the height of the pivot point measured from a point directly beneath the
pivot on the supporting structure. This information is intended to assist in comparing the relative shock
-absorbing properties of various materials. No particular material is recommended over another. However,
each material is only effective when Properly maintained. Materials should be checked periodically and
replenished to maintain correct depth as determined necessary for your equipment. The choice of a material
depends on the type and height of the playground equipment, the availability of the material in your area
and its cost. Note: The maximum fall height for this product is 6 feet. The minimum ground Clearance
between the bottom of the suspended plays and the playing or ground service must be 8 inches.
This information has been extracted from the CPSC publication on" Playground Safety". You can obtain
more information by sending a postcard to the: Office of public Affairs，U.S. Consumer Product Safety
Commission，Washington，D.C.20207
FALL HEGHT IN FEET FROM WHICH
A LIFE THREAENING HEAD INJURY WOULD NOT BE EXPECTED
TYPE OF MATERIAL 6” (15.25CM) DEPTH 9” (22.9CM) DEPTH 12” (30.5CM) DEPTH
11” (27.94CM)
12” (30.5CM)
9” (22.86CM)
10” (25.4CM)
10” (25.4CM)
7” (17.8CM)
5” (12.7CM)
7” (17.8CM)
6” (15.25CM)
6” (15.25CM)
6” (15.25CM)
5” (12.7CM)
WOOD CHIPS
FINE SAND
FINE GRAVEL
DOUBLE SHREDDED BARK MULCH

7

mm
mm mm
mm
mm
mm
128

mm
mm mm
mm mm
9

mm
mm
mm
mm mm
mm
trapeze
S1
2
10

11
trapeze
!"#$%&#'%()**+%),-* (*)
12
12
S
S1
S2
trapeze

mm
mm
mm
mm
mm
12

mm
13

mm
mm
mm
mm
14


mm
mm
mm
mm
mm
mm
15

16

17

18

19