5
LUBRICATION OF ENGINE
Your engine comes with NO oil in the sump. You will need to
add engine oil, refer to pages 8 and 10 for complete details and
images. Failure to do this may result in damage to the engine,
generator and/or injury to the user.
GENERAL SAFETY INSTRUCTIONS
Before attempting to operate this generator the following
basic safety precautions should be taken to reduce the risk
of fire, electric shock and personal injury. It is important to
read the instruction manual and to understand applications,
limitations and potential hazards associated with this generator.
It is important that you read, understand and follow these
instructions very carefully. They are designed for the safety of
yourself and others ensuring a long and trouble free service
life from your generator. This generator is not intended for use
by persons (including children) with reduced physical, sensory
or mental capabilities, or lack of experience and knowledge,
unless they have been given supervision or instruction
concerning the use of the appliance by a person responsible for
their safety.
OPERATING ENVIRONMENT
NEVER use your generator indoors. Your generator produces
deadly carbon monoxide and this is harmful and can cause
death. Only use your generator in well ventilated areas like
the outdoors. Do not expose your generator to rain or use
in damp or wet locations. Do not expose your generator to
direct sunlight. Keep the work area well lit. Do not use your
generator in areas where there is a risk of explosion or fire
from combustible materials, flammable liquids, paint, varnish,
petrol, etc flammable gases and dust of an explosive nature.
As a precaution it is recommended that you consult an expert
on selecting and using a suitable fire extinguisher and have
it available for use in an emergency when operating the
generator.
GUARD AGAINST ELECTRIC SHOCK
Never touch the generator with wet or damp hands as electric
shock may occur. Always ensure your generator is connected to
ground, i.e. Earthed with the supplied earth stake, see page 11.
BEWARE OF CHILDREN & PETS
Children and pets should be kept out of the operating area.
Children should not be allowed to touch or operate generators
or touch extension cords. All generators should be kept out
of reach of children. When NOT in use keep the generator
preferably stored or locked in a secure well ventilated cabinet
or room with the fuel tank empty.
SELECT A GENERATOR WITH A SUFFICIENT
RATING
Select the right generator for the job. Do not use a generator to do
a job for which it was not designed. Do not force a small generator
to do the job of a heavy duty generator. Any damage caused by
overloading will void the warranty. Do not use generators for
purposes not intended.
PROTECT POWER LEADS FROM DAMAGE
Always disconnect power cords from a power supply socket by
pulling the plug. Never pull on the cord. Keep the power lead
away from heat, oil, solvents and sharp edges. If a power lead
becomes damaged have it replaced by an authorised service
facility.
FUEL - UNLEADED 91 PETROL - NO
ETHANOL
Fuel used in this generator is poisonous. Always wear approved
breathing protection when decanting fuel. If you get any fuel on
your skin or clothes wash the affected area immediately with
soap and water and change your clothes. If you get fuel in your
eyes wash immediately with clean water and seek medical
attention. If any fuel is swallowed DO NOT induce vomiting, seek
immediate medical attention.
HOT COMPONENTS
Beware many of the components will get hot during use. Never
touch any of the metal pipes, pump or motor as these may burn.
MAINTAIN YOUR GENERATOR WITH CARE
When not using your generator ensure the fuel cock is
‘OFF’. Never leave the fuel cock ‘ON’ as this can damage the
carburettor. Follow the instructions for lubricating and changing
accessories. Keep handles clean, dry and free from oil and
grease. Ensure that ventilation slots are kept clean and free
from dust at all times. Blocked ventilation slots can cause
overheating and damage to the motor. Ensure that the air and
fuel filters are kept clean at all times.
REMOVE ADJUSTING KEYS AND WRENCHES
Form the habit of always checking to see that any adjusting keys
or wrenches have been removed from the generator before
operating.
FIRE PRECAUTIONS
Always contact your fire authority before using the generator
on fire restricted days. It is not recommended to use your
generator when a total fire ban is in force. Never refuel your
generator while it is still running. Never connect your generator
to a commercial or domestic power outlet. As a precaution it
is recommended that an expert is consulted on obtaining and
using a suitable fire extinguisher.
CLEANING YOUR GENERATOR
Always stop your generator before you commence cleaning.
Always ensure that your generator has cooled, about one
(1) hour, before cleaning and storing. When cleaning your
generator use only a damp soft cloth. NEVER use liquid or
solvents of any type. All areas can be wiped down.
