State Water Heaters 100 SERIES User manual
1
Instruction Manual
PRINTED 1213 318269-002
PLACE THESE INSTRUCTIONS ADJACENT TO HEATER AND NOTIFY OWNER TO KEEP FOR FUTURE REFERENCE.
COMMERCIAL ELECTRIC WATER HEATERS
MODELS CSB-52/80/120 (SERIES 100)
Saudi Arabia and Kuwait Manual
INSTALLATION - SERVICE - MAINTENANCE
- OPERATION - LIMITED WARRANTY
2
GENERAL SAFETY INFORMATION
SAFE INSTALLATION, USE, AND SERVICE
The proper installation, use and servicing of this water heater is extremely important to your safety and the safety of others.
Many safety-related messages and instructions have been provided in this manual and on your own water heater to warn you and
others of a potential injury hazard. Read and obey all safety messages and instructions throughout this manual. It is very important
that the meaning of each safety message is understood by you and others who install, use, or service this water heater.
This is the safety alert symbol. It is used to alert you
to potential personal injury hazards. Obey all safety
messages that follow this symbol to avoid possible
injury or death.
IMPORTANT DEFINITIONS
involved. Installation skills such as plumbing, electrical supply are required in addition to electrical testing skills when performing service.
is responsible for (a) the installation, testing or replacement of gas piping or (b) the connection, installation, testing, repair or servicing
of appliances and equipment; that is experienced in such work; that is familiar with all precautions required; and that has complied with
DANGER
WARNING
CAUTION
DANGER indicates an imminently
hazardous situation which, if not avoided,
will result in death or injury.
WARNING indicates a potentially hazardous
situation which, if not avoided, could result
in death or injury.
CAUTION indicates a potentially hazardous
situation which, if not avoided, could result
in minor or moderate injury.
CAUTION used without the safety alert
symbol indicates a potentially hazardous
situation which, if not avoided, could result
in property damage.
CAUTION
All safety messages will generally tell you about the type of hazard, what can happen if you do not follow the safety message, and
how to avoid the risk of injury.
PRECAUTIONS
GROUNDING INSTRUCTIONS
3
HYDROGEN GAS (FLAMMABLE)
4
PREPARING FOR THE INSTALLATION
INTRODUCTION
TABLE OF CONTENTS
SAFE INSTALLATION, USE, AND SERVICE ..................................... 2
..................................................................... 2
GENERAL SAFETY INFORMATION................................................... 2
Precautions..................................................................................... 2
Hydrogen Gas (Flammable)...........................................................
INTRODUCTION.................................................................................. 4
Preparing for the Installation ........................................................ 4
DIMENSIONS AND CAPACITIES DATA ............................................. 5
MODEL AND RATING .........................................................................
LOCATING THE NEW WATER HEATER ............................................ 7
Facts to Consider About the Location ......................................... 7
USER CARE ........................................................................................ 7
Draining the Water Heater ............................................................. 7
Filling the Water Heater ................................................................. 7
USER’S INFORMATION ...................................................................... 8
ELECTRONIC CONTROL MODELS OPERATION........................ 8-18
INSTALLATION 19
19
19
19
19
19
19
20
20
20
21
22
22
22
23
OPERATION 32
32
32
Initial Start Up 32
Draining the Water Heater 32
33
33
33
33
34
34
34
34
34
34
35
35
36
39
NOTES 48
Note
USER/OWNER (BOLD TEXT)
5
DIMENSIONS AND CAPACITIES DATA
TABLE 1.
Tank Capacity in
Gallons (Liters)
Max. Working
Pressure in PSI (kPA) A - Inches (mm) B - Inches (mm) C - Inches (mm) Inlet/Outlet
DRE/DVE MODEL DIFFERENCES
TABLE 2. RECOVERY CAPACITIES
Standard
kW Input
Input
BTUH
U. S. Gallons/Hr. and Liters/Hr. at TEMPERATURE RISE INDICATED
30° 40° 50° 60° 80° 90° 100° 110° 120° 130° 140°
22° 28° 33° 39° 44° 50° 56° 61°
6 82 62 49 41 35 31 25 22 21 19 18
Liter 310 235 185 155 132 102 95 83 68
9 123 92 62 53 46 41 34 31 28 26
Liter 466 348 280 235 201 155 140 129 106 98
12 164 123 98 82 61 55 49 45 41 38 35
Liter 621 466 310 265 231 208 185 155 144 132
184 138 111 92 69 62 55 50 46 43 40
Liter 696 522 420 348 299 261 235 208 189 163 151
15 205 154 123 102 88 68 61 56 51 44
Liter 583 466 386 333 291 231 212 193
18 246 184 148 123 105 92 82 61 53
Liter 931 696 560 466 348 310 280 254 231 216 201
24 328 246 164 140 123 109 98 89 82
Liter 1241 931 621 530 466 413 310 288 265
369 221 184 158 138 123 111 101 92 85
Liter 1045 836 696 598 522 466 420 382 348 322 299
30 410 246 205 154 123 112 102 95 88
Liter 1552 1162 931 666 583 519 466 424 386 360 333
36 492 369 295 246 211 184 164 148 134 123 113 105
Liter 1862 931 696 621 560 466 428
554 418 3332 208 1185 166 151 138 128 119
Liter 1582 12612 1048 4485 628 522 484 450
45 615 461 369 263 230 205 184 168 154 142 132
Liter 2328 1162 995 696 636 583 500
54 553 443 369 316 246 221 201 184 158
Liter 2093 1196 1048 931 836 696 643 598
FIGURE 1.
6
MODEL AND RATING
Ph
V
Hz No. of
ISPHCAESTNEMELE)ZTREH()STLOV()ESAHP( kPa
3220-240 50-606 6000 150 1034
US GALl(LITERS)
119.0450.5
IPX1
MAXIMUM
W (WATTS) WORKING PRESSURE
TOTAL
36000
CAPACITY
MODEL NUMBER SERIAL NUMBER ITEM ID / PART NUMBER
XXXXXXXXXX 1116M000575XXXXXXXXXX
COMMERCIAL STORAGE
TANK WATER HEATER
FIGURE 2.
FACTS TO CONSIDER ABOUT THE LOCATION
LOCATING THE NEW WATER HEATER
USER CARE
FILLING THE WATER HEATER
DRAINING THE WATER HEATER
8
USER’S INFORMATION
THERMOSTAT SETTINGS-SURFACE MOUNT CONTROLS
THERMOSTAT SETTINGS - ELECTRONIC CONTROLS
ELECTRONIC CONTROL MODELS OPERATION
CONTROL SYSTEM FEATURES
CONTROL SYSTEM NAVIGATION
FIGURE 4. UIM - USER INTERFACE MODULE
Up & Down Buttons
Operational Buttons
THE DESKTOP SCREEN
Model Information
Tank Temperature
FIGURE 5.
9
Menu
ICON DESCRIPTION
10
TEMPERATURES MENUS
Operating Set Point
STATE DESCRIPTION
Heating
Alert
MENUS DESCRIPTION
Heater Status
Setup
Setup
Display Settings
Defaults
TABLE 4. - OPERATING STATES
TABLE 5. - CONTROL SYSTEM MENUS
11
Differential Settings
Operating Sequence
Tank Temperature
Tank Probe Offset
TEMPERATURE SETTINGS
ACTION DISPLAY
12
HEATER STATUS MENU
Top of Menu
Bottom of Menu
Status
Element Banks On
ECO Contact
Enable / Disable 1 & 2
Element Bank On
Alarm Condition
Alarm Relay Output
ECONOMY MODE SETUP MENU
Desktop Screen During Economy Mode
Economy Mode Setup Menu
Setpoint Adjustment
Current Time
Heater In Economy Mode
Daily Operating Mode (Sun - Mon - Tue - Wed - Thu - Fri - Sat)
13
ECONOMY MODE SETTINGS
Setpoint Adjustment Value
ACTION DISPLAY
14
ECONOMY MODE SETTINGS
Time Clock Settings
ACTION DISPLAY
15
ECONOMY MODE SETTINGS
Daily Operating Mode Settings
ACTION DISPLAY
16
ALARM OUTPUT SETUP MENU
Output Function
DISPLAY SETTINGS MENU
Temperature Units
Backlight Delay
Contrast
Display Settings
Service Note
HEATER INFORMATION MENU
TOP OF MENU
BOTTOM OF MENU
Elapsed Time
Total Heating Time
Bank # Cycles
Bank # On Time
CCB Version
UIM Version
CURRENT FAULT / ALERT MENU
Main Menu - Current Fault Selected
FAULT HISTORY MENU
Fault History Menu
Current / History Fault Message
FAULT OCCURRENCE MENU
Fault Occurrence Menu
RESTORE FACTORY DEFAULTS MENU
18
THE FOLLOWING PAGES ARE FOR INSTALLATION, SERVICE/
MAINTENANCE AND TROUBLESHOOTING.
THESE INSTRUCTIONS ARE TO BE USED AND PERFORMED BY A
Restore Factory Defaults
ACTION DISPLAY
19
INSTALLATION
GENERAL
MIXING VALVE
MIXING VALVES
CONTAMINATED WATER
CIRCULATING PUMP
INSULATION BLANKETS
TEMPERATURE-PRESSURE RELIEF VALVE
20
WATER LINE CONNECTIONS
CLOSED WATER SYSTEMS
THERMAL EXPANSION
Other manuals for 100 SERIES
3
This manual suits for next models
3
Table of contents
Other State Water Heaters Water Heater manuals
State Water Heaters
State Water Heaters SRGSS01806 User manual
State Water Heaters
State Water Heaters GP6 50 YTVIT Application guide
State Water Heaters
State Water Heaters 184671-000 User manual
State Water Heaters
State Water Heaters Premier Residential Water Heaters User manual
State Water Heaters
State Water Heaters TITAN GPG85 540 NEA User manual
State Water Heaters
State Water Heaters SBN 71-120NE Application guide
State Water Heaters
State Water Heaters GP6 50 Series User manual
State Water Heaters
State Water Heaters SSE-120 User manual
State Water Heaters
State Water Heaters CCVIT PR6 50 User manual
State Water Heaters
State Water Heaters Ultra Low Nox Series Product information sheet
State Water Heaters
State Water Heaters 184671-000 Parts list manual
State Water Heaters
State Water Heaters PR6 40 XCVIT User manual
State Water Heaters
State Water Heaters SUF-100-250 User manual
State Water Heaters
State Water Heaters Tankless On-Demand 705 Series 200 Specification sheet
State Water Heaters
State Water Heaters SBL85275NEA How to use
State Water Heaters
State Water Heaters STC-080 How to use
State Water Heaters
State Water Heaters FVIR Product information sheet
State Water Heaters
State Water Heaters 310C User manual
State Water Heaters
State Water Heaters SUF-130- 300/400/500 User manual
State Water Heaters
State Water Heaters Power Direct Vented Gas models User manual
Popular Water Heater manuals by other brands
Nobel
Nobel aelios Technical manual
A.O. Smith
A.O. Smith T-H2S-DV troubleshooting guide
Hatco
Hatco Imperial Series Installation and operating manual
Navien
Navien NPE-180A Quick installation guide
evoheat
evoheat EVO MAX 32 manual
Armstrong
Armstrong Flo-Direct 2.0 AFD-1000 Installation, operation and maintenance manual
A.O. Smith
A.O. Smith ProMax GCV-30 specification
Maytag
Maytag SERIES NINE HE2940L user guide
Zip
Zip VP303 Installation, maintenance and user instructions
xFyre
xFyre 300A Installation & operating instructions
Bosch
Bosch Tronic 1000 Installation and operating instructions
Group DEP
Group DEP Thermodynamic Box Installation instructions and user manual
GEAppliances
GEAppliances GEH50DNSRSA Owner's Manual & Installation Instructions
Bradford White
Bradford White 6A Service manual
Whale
Whale Expanse WW0821U Installation and user instructions
andrews
andrews WHX56 Installation guide, operation and maintenance manual
Rubine
Rubine FORTE Series user manual
Rheem
Rheem Single Element Use & care manual