Swisher L112-195001 User manual

Read and follow all Safety
Precautions and Instructions
before operating this equipment.
LOG SPLITTER
4-WAY WEDGE
OWNER’S
MANUAL
1602 CORPORATE DRIVE, WARRENSBURG, MISSOURI 64093
PHONE [phone] FAX [phone]
MODEL NO.
STARTING SERIAL #:
L112-195001
18840
Compatible with all Swisher log
splitter except those supplied with
permanent log strippers or other
features that will interfere with the
wedge’s operation.
2013 Compatible log splitter
models:
LSRB875281350
LSRB115281350
LSRB125341350
LSEB125341350
Contact customer service for
compatible pre-2013 models.
Manufacturing quality lawn care equipment since 1945
Safety
Assembly
Operation
Maintenance
Replacement Part
Made In The
USA
IMPORTANT
swisherinc.com
18851
Rev. 12-195

2
LIMITED WARRANTY
TABLE OF CONTENTS
WARRANTY………………....….2
SAFETY..………………………...3-4
TOWING..….……..……………...5
ASSEMBLY …...……..……………...5
OPERATION .………………………..6
MAINTENANCE.…………………….6
The manufacturer’s warranty to the original consumer purchaser is: This product is free from defects in
materials and workmanship for a period one (1) year from the date of purchase by the original consumer
purchaser. We will repair or replace, at our discretion, parts found to be defective due to materials or
workmanship. This warranty is subject to the following limitations and exclusions:
Commercial Use The warranty period for this product when used for commercial or rental
is limited to ninety (90) days from the date of original purchase.
Limitation This warranty applies only to products which have been properly
assembled, adjusted, and operated in accordance with the instructions
contained within this manual. This warranty does not apply to any
product of Swisher that has been subject to alteration, misuse, abuse,
improper assembly or installation, shipping damage or to normal wear of
product.
This product is intended to be used in conjunction with Swisher log
splitters only. This warranty is void when this product is use with
any other manufacture’s equipment.
Exclusions Excluded from this warranty are normal wear items, normal or routine
adjustments, and normal or routine maintenance.
In the event you have a claim under this warranty, you must return the product to an authorized service dealer.
All transportation charges, damage, or loss incurred during transportation of parts submitted for replacement or
repair under this warranty shall be borne by the purchaser. Should you have any questions concerning this
warranty, please contact us toll-free at 1-800-222-8183. The model number, serial number, date of purchase,
and the name of the authorized Swisher dealer from whom you purchased the splitter will be needed before any
warranty claim can be processed.
THIS WARRANTY DOES NOT APPLY TO ANY INCIDENTAL OR CONSEQUENTIAL
DAMAGES AND ANY IMPLIED WARRANTIES ARE LIMITED TO THE SAME TIME PERIODS
STATED HEREIN FOR ALL EXPRESSED WARRANTIES. Some states do not allow the limitation of
consequential damages or limitations on how long an implied warranty may last, so the above limitations or
exclusions may not apply to you. This warranty gives you specific legal rights and you may have other rights,
which vary from state-to-state. This is a limited warranty as defined by the Magnuson-Moss Act of 1975.

DANGER:
Your log splitter was built to be operated according to the rules for safe operation in this manual. As
with any type of power equipment, carelessness or error on the part of the operator can result in serious injury. If
you violate any of these rules, you may cause serious injury to yourself or others.
Read and understand the separate log splitter manual and this manual. Learn to operate this equipment
in a safe manner. Familiarize yourself with all of the controls in a safe environment before starting to
work with log splitting equipment.
DO NOT under any circumstances alter this 4-way wedge. This equipment was designed and
engineered in accordance with operating instructions. Altering this equipment, or using this equipment
in such a way as to circumvent its design capabilities and capacities, could result in serious injury or
fatality and WILL VOID THE WARRANTY.
Allow ONLY responsible adults who have read all applicable manuals to operate log splitting
equipment. NEVER allow children to operate log splitting equipment.
NEVER operate or allow someone to operate log splitting equipment while under the influence of
alcohol, drugs or medication. Being coherent is essential for safety.
ALWAYS use outdoors with adequate ventilation. DON’T run the engine in an enclosed area. Exhaust
gases contain carbon monoxide. This odorless gas can be deadly when inhaled.
NEVER use splitter for any other purpose than splitting wood. Any other use can result in injury. Your
splitter is a precision piece of power equipment, not a toy. Therefore, exercise extreme caution at all
times.
ONLY a single operator is to load and operate the log splitter. KEEP all others, including pets and
children, a minimum of 20 feet away from your work area. More accidents occur when more than one
person operates the log splitter than any other time.
ALWAYS wear protective gear such as safety goggles, protective hearing device, steel-toed shoes, and
tight-fitting gloves without drawstrings or loose cuffs.
NEVER wear loose clothing or jewelry that can be caught by moving parts of the splitter and pull you
into it. Keep hair away from moving parts.
NEVER operate your splitter on wet, muddy, or icy surfaces. KEEP work area clean of split wood. Safe
footing is essential in preventing accidents.
 ONLY operate splitter on level ground with wheels blocked, not on the side of a hill. It could tip, or
rolling logs, poor footing, etc. could cause an accident.

NEVER operate your splitter near a flame or spark. Hydraulic oil and gasoline are flammable and can
explode.
NEVER fill gas tank while the engine is hot or running. Allow the engine to cool before refueling.
This Safety Alert Symbol indicates important messages in this manual.
When you see this symbol, carefully read the message that follows and be
alert to the possibility of personal injury.
Read this manual completely. Log splitting equipment can amputate hands, feet, and throw
objects. Failure to observe the following safety instructions could result in serious injury or death.
3
SAFETY PRECAUTIONS

4
Log splitters equipped with an internal combustion engine should not be used on or near any unimproved
forest-covered, brush-covered or grass-covered land unless the engine’s exhaust system is equipped with a
spark arrester meeting applicable local or state laws (if any). If a spark arrester is used it should be
maintained in effective working order by the operator.
-NOTE-
In the state of California, the above is required by law (Section 442 of the California Public Resources Code).
Other states may have similar laws. Federal laws apply on federal lands. A spark arrester muffler (optional by
manufacturer) is available at your nearest engine dealer. Check legal requirements in your area.
ONLY use your hands to operate the control lever. NEVER use foot, knee, rope or any extension device.
Split ONLY one log at a time. NEVER attempt to split two logs on top of each other.
NEVER place hands or feet between log and splitting wedge or between log and ram during forward or
reverse stroke. ALWAYS keep fingers clear of splits that open in log during splitting operation.
DO NOT straddle or reach across the splitting area while operating the splitter.
DO NOT step over splitter when the engine is running. You may trip or accidentally activate the splitting
wedge. Walk around to get to the other side.
NEVER attempt to load splitter while splitting wedge is in motion. When loading log splitter, place hands
on the sides of the log, not the ends.
NEVER attempt to split woods across the grain. Wood may burst or fly out of your splitter and result in
serious injury.
NEVER leave your splitter unattended with the engine running. Shut off the engine if you are leaving
your splitter, even for a short period of time. Someone could accidentally activate the ram and be injured.
Both ends of the log should be cut as squarely as possible to prevent the log from sliding out of the splitter
during operation. Log length should be kept to 24” or less when splitting with 4-way wedge or 25 1/2” or
less when splitting without 4-way wedge.
NEVER operate your splitter while it is attached to the tow vehicle.
NEVER tow splitter with 4-way wedge installed. It can become dislodged and cause serious injuries
and/or damage.
BEFORE towing, be certain that the splitter is securely attached to the towing vehicle and that the support
leg, beam and cylinder are secured in there respective towing positions.
NEVER allow persons to ride on splitter. DO NOT carry any cargo or wood on your splitter. It may fall
off and cause an accident.
DO NOT loosen or remove any hydraulic fitting, line or reservoir cap while your splitter engine is running.
Fluid escaping from a very small hole can almost be invisible. DO NOT check for leaks with your hand.
See maintenance section of separate log splitter manual for instructions. IF injured by escaping fluid,
see a doctor at once. Serious infection or reaction can develop if proper medical treatment is not
administered immediately.
DO NOT operate your splitter in poor mechanical condition or when it is need of repair.
ALWAYS disconnect the spark plug wire and place the wire where it cannot contact the spark plug, to
prevent accidental starting the engine when setting up, transporting, adjusting or repairing.
SAFETY PRECAUTIONS

NEVER tow splitter with 4-way wedge installed. It can become dislodged and cause serious
injuries and/or damage.
REFER to separate log splitter manual for all other towing safety information.
5
TOWING SAFETY
ASSEMBLY
To install 4-way wedge, simply slide it over the top of the log splitter wedge ensuring it is fully seated.
Ensure appendages are safe from any pinch points during installation.
Inspect all components for damage. If you believe you have a damaged part please contact customer
service immediately at 1-800-222-8183.
WARNING: Exercise extreme caution, as this part is heavy. Serious injury can occur should this
product be dropped on any part of the body.

6
OPERATION
INTENDED USE: This 4-way wedge is intended and designed to only split wood. NEVER use for any other purposes. Doing so can
cause injury or VOID THE WARRANTY.
WARNING: DO NOT START OR RUN A LOG SPLITTER WITHOUT OIL IN THE ENGINE AND/OR HYDRAULIC RESERVOIR.
OPERATING LOG SPLITTER
See separate log splitter and engine manuals for starting and operating instructions. The 4-way wedge is intended to increase speed and
efficiency of your Swisher splitter by splitting the log twice during normal operation of the splitter (see separate log splitter manual for
normal operation). The 4-way wedge works best when splitting larger logs requiring more than one split to get desired log size. It may
be more advantageous to remove the 4-way wedge for smaller logs requiring only one split (see assembly instructions for removal and
installation).
MAINTENANCE & STORAGE
See separate log splitter and engine manuals for maintenance instructions. 4-way wedge should be stored in a dry location when not in
use. If the wedge becomes dull or nicked a grinder or sharpening tool can be used to sharpen it.
The operation of any splitter can produce foreign objects to be thrown into the
eyes, resulting in severe eye damage. Always wear certified safety glasses or
wide-vision safety goggles over spectacles before starting any splitting machine
and while operating such a machine.
The operation of any splitter produces sound waves that are damaging to the
human ear. Ear protection is recommended.

7
SWISHER HISTORY
Back before electricity came to rural Missouri Max Swisher was producing lawn mowers
from his mother’s chicken house. Max never liked to mow grass. He installed a
gearbox on his family’s lawn mower creating a self-propelled unit. By tying one end of a
rope to the mower and the other end to a tree in the center of the yard the mower
circled the tree, shortening the rope and guiding the mower in concentric circles. Max
enjoyed relaxing under a shade tree while his invention did all the work.
Max had designed his first self-propelled rotary lawn mower to do his dirty work for him.
Neighbors noticed his new invention and began asking him to make more. Today, 60
years later, Swisher is still producing innovative lawn and garden and ATV/UTV
equipment designed to give us all more “relaxing in the shade” time.
Swisher products have been featured nationally on television programs such as Regis
and Kathie Lee and seen in publications like ATV Magazine, Country Journal, Popular
Mechanics Magazine and others. In January 2000 Popular Mechanics Magazine
named Max’s zero turning radius riding mower one of the 20th century’s top household
inventions.
Swisher offers value and function in its products to meet your grounds maintenance
needs.
CELEBRATINGOVER65YEARSOFINNOVATION
SINCE1945

OWNER’S
MANUAL HOW TO ORDER
REPAIR PARTS:
LOG SPLITTER
Each Log Splitter has its own serial number. Each engine has
its own serial number. The serial number for the Log Splitter
will be found on the right hand side of the hydraulic oil
reservoir. The serial number for the engine will be found on
the top of the blower fan housing.
All Log Splitter parts listed herein may be ordered directly
from Swisher, your nearest Swisher dealer, or from our
website.
All engine parts may be ordered from the nearest dealer of the
engine supplied with your log splitter. Parts subject to change
without notice.
WHEN ORDERING PARTS, PLEASE HAVE THE
FOLLOWING INFORMATION AVAILABLE:
* PRODUCT – SWISHER LOG SPLITTER
* SERIAL NUMBER - _______________
* MODEL NUMBER - _______________
* ENGINE MODEL NUMBER - _______________
TYPE - _______________
* PART NUMBER
* PART DESCRIPTION
www.swisherinc.com
TELEPHONE - 1-800-222-8183
FAX - 1-660-747-8650
SWISHER
1602 CORPORATE DRIVE
WARRENSBURG, MO 64093
SWISHER
MODEL NO.
STARTING SERIAL #:
L112-195001
18840
8