Tesco PM1-204 User manual

Ref No.: P 1-204 1Product size assembled:H115.5 x W116 X D54.5cm1
Produced in China for TESCO Stores Ltd.© Tesco 2012www.tesco.com
Promo 4 Burner Gas Grill with Side Burner
Assembly instructions0359-13:0359CO1365MPIN
-
-Catalogue No.:

Produced in China for TESCO Stores Ltd.© Tesco 2012Further information
www.tesco.com
The barbecue is a gas barbecue for outdoor use. It is designed
to be used exclusively in accordance with these instructions for
preparing foods that are suitable for barbecue cooking.
For private use only!
Leak test all connections after each tank refilled or first use
after a long period, by which the method is described in the
“Operating instructions” part.
This barbecue should be thoroughly cleaned and inspected on
a regular basis, clean and inspect the hose before each use of
the appliance. If there is evidence of abrasion, wear, cuts or
leaks, the hose must be replaced prior to the appliance being
operated.
Use only factory authorized parts. The use of any part that is
not factory authorized is dangerous.
When cooking, fire extinguishing materials shall be readily
accessible. In the event of an oil grease fire, do not attempt to
extinguish with water. Use type B or type C dry chemical fire
extinguisher or smother with dirt, sand or baking soda.
Operate on solid ground only, do not install or use in/on boats
or recreational vehicles.
Always open barbecue lid carefully and slowly as heat and
steam trapped within barbecue can severely burn you.
Move gas hoses as far away as possible from hot surface and
dripping hot grease.
Keep all electrical cords away from a hot barbecue.
Turn off the gas supply at the gas container after use.
When handling particularly hot components, protective gloves
should be used.
Any other application or applications extending beyond the stated
purpose are not authorised. This applies in particular to misuse
involving the following possible scenarios:
9dcdideZgViZi]ZWVgWZXjZl^i]XdVadgVcn[jZadi]Zgi]VcLPG.
9dcdideZgViZi]ZbV^cWVgWZXjZVhVhidkZjh^c\edihVcYpans.
9dcdideZgViZi]ZWVgWZXjZVhV]ZViZg#6cnbdY^[^XVi^dcd[i]ZVeea^VcXZbVnWZYVc\Zgdjh#EVgihhZVaZYWni]ZbVcj[VXijgZgbjhicdiWZVaiZgZYWni]Zuser.
9dcdijhZi]ZWVgWZXjZid]ZVibViZg^VahVcYhjWhiVcXZhdi]Zr
than foods that are suitable for barbecuing.
The barbecue has been manufactured according to the general
engineering rules – that were valid at the time manufacturing was
started – and the requirement of the CE- sign. It is certified and
approved by INTERTEK Testing Services Ltd. (ITS) (Test number CE-
0359). The barbecue left the factory in good order and condition
in terms of its function and safety.
Proper use:
Improper use: CAUTION! HOT SURFACE AND PARTS9jg^c\deZgVi^dchdbZeVgihd[i]ZWVgWZXjZXVcWZXdbZkZgnhot, particularly those close to the fire bowl.
CAUTION! GAS IS HIGHLY FLAMMABLEPossible consequences:
HZkZgZWjgch[gdbidjX]^c\eVgihcZVgi]Z[^gZWdla#;^gZdghbdjaYZg^c\[^gZ^[[aVbbVWaZbViZg^VahdghjWhiVcXZhare
near the barbecue.
Safety measures prior to using the barbecue:
Select a place to set up the barbecue so that:
I]ZgZVgZcdi!VcYl^aacdiWZ![aVbbVWaZbViZg^VadghjWhiVcces
nearby. Minimum distance to material or substances: No
dkZg]ZVYdWhigjXi^dcVWdkZVcY&bidi]Zh^YZ#9^hiVcXZidhighly flammable materials or substances, e.g. walls: min. 1m.
I]ZWVgWZXjZ^hedh^i^dcZY[^gbandcVhj[[^X^ZcianaVg\Zhjgface
area. It must not be moved during operation.
Safety measures during barbecuing:
LZVgegdiZXi^kZWVgWZXjZ\adkZh#CZkZgaZVkZi]Z]diWVgWZXjZjcViiZcYZY#I6@:E6GI>8JA6G86G:ID:CHJG:I=6I8=>A9G:C6C9E:IHARE KEPT AWAY FROM THE BARBECUE.
CZkZg[^ii]Z\VhWdiiaZg^\]iidcZmii]ZWVgWZXjZ#6alVnhelace
the gas bottle at the left hand rear or of the appliance. The
gas bottle should be sited as far away from the appliance as
possible without straining the hose. No part of the hose should
touch any part of the appliance.
Liquid gas is highly flammable and explosive.
Possible consequences:
HZg^djheZghdcVa^c_jgndgYVbV\ZidegdeZgin^[ZhXVe^c\\Vhignites in and environment in which it is not controlled.
Safety measures:
DcanjhZi]ZWVgWZXjZdjiYddghVcYZchjgZi]Vii]ZVgZV^hlZll
ventilated.
EgdiZXii]Z\VhWdiiaZVcYi]Z\Vh]dhZ[gdbY^gZXihjca^\]iand other heat sources (max. 50degree C). Take special care
to ensure that the gas hose does not touch any part of the hot
barbecue.
9DCDIeaVXZi]Z\VhWdiiaZdci]ZadlZgh]Za[!Vh^i^hiddnear
the burner.
CZkZgjhZVcAE\VhiVc`l^i]YVbV\ZYWdYn!kVakZ!XdaaVg!or footing.
9dcdihidgZVheVgZAE\VhiVc`jcYZgdgcZVgi]^hVeea^VcXZ.
I]ZjhZd[VaXd]da!egZhXg^ei^dcdgcdc"egZhXg^ei^dcYgj\hbVy
impair the ability to properly assemble or safely operate the
appliance. Never use charcoal, lighter fluid, lava rocks, gasoline, kerosene,
or alcohol within this product.
9dcdihidgZdgjhZ\Vhda^cZdgdi]Zg[aVbbVWaZa^fj^YhdgkVedrs
within 25 feet (7.6m) from this appliance.
Minimum clearance from sides and back of unit to combustible
XdchigjXi^dc/([ZZi[gdbh^YZVcY([ZZi[gdbWVX`#9dcdijhe
this appliance under overhead combustible surface.
Promo 4 Burner Gas Grill with Side Burner
Assembly instructions2

ww w.tesco.com
Produced in China for TESCO Stores Ltd.© Tesco 2012
>[cZXZhhVgn!ZchjgZi]VindjgZeaVXZi]Z]dhZidbZZil^i]cVi^dcVagZfj^gZbZcih#6alVnhjhZ]dhZ"Xa^ehidhZXjgZi]Z]dhZidi]ZgZ\jaVidgVcY77F#>[i]ZXdccZXi^dch[dgi]Z\VhhjeeanVgZedgdjhdg[Vjain!i]ZWVgWZXjZbjhicdiWZjhZY#I]^hVahdVeea^Zh![dgZmVbeaZ!id]dhZhdg[^ii^c\hi]VibVn]VkZWZXdbZWadX`ZY!Vhi]^hXVcaZVYidVYVc\Zgdjh[aVh]WVX`#CAUTION! GAS DISPLACES OXYGENA^fj^Y\Vh^h]ZVk^Zgi]Vcdmn\Zc#I]ZgZ[dgZ^ihZiiaZhdci]Z\gdjcYVcYY^heaVXZhi]Zdmn\ZcVii]ViaZkZa#Edhh^WaZXdchZfjZcXZh/Hj[[dXVi^dcgZhjai^c\[gdbVaVX`d[dmn\Zc^[i]Z\VhXdcXZcigVi^dc^hVaadlZYidg^hZhj[[^X^Zcian#9dcdijhZi]ZWVgWZXjZjcaZhh^iÉhXdbeaZiZanVhhZbWaZYVcYVaaeVgihVgZhZXjgZan[VhiZcZYVcYi^\]iZcZY#CZkZgdWhigjXii]ZkZci^aVi^dcdeZc^c\hd[i]ZXdciV^cZgXdbeVgibZci#9dcdijhZedlZgiddahidXdchigjXii]^hegdYjXi#9dcdidkZgi^\]iZchXgZlhdgWdaih#9dcdii^\]iZchXgZlhjci^a[jaanVhhZbWaZY#9dcdih^idghiVcYdci]ZegdYjXi#9dcdijhZi]^hegdYjXi^[eVgihVgZb^hh^c\!YVbV\ZYdgldgc#CZkZgjhZhXdjgZgh!VWgVh^kZdgX]Zb^XVaXaZVcZgh#CZkZgXdkZgi]ZZci^gZXdd`^c\VgZV#9dcdibdkZi]ZVeea^VcXZYjg^c\jhZ#9dcdiaZVkZVa^iWVgWZXjZjcViiZcYZY!ZheZX^Vaan`ZZeX]^aYgZcVcYeZihVlVn[gdbWVgWZXjZViVaai^bZh#EaZVhZgZ[Zgidi]ZeVgiha^hiVcYVhhZbWanY^V\gVbVhcZXZhhVgn#6hhZbWand[i]ZWVgWZXjZ^ckdakZhbVcnaVg\ZXdbedcZcih0^i^hVYk^hVWaZid]VkZildeZdeaZVhhZbWaZi]Zjc^i#EaZVhZjhZegdiZXi^kZ\adkZhl]ZcVhhZbWa^c\i]^hegdYjXi#IdVkd^Yadh^c\VcnhbVaaXdbedcZcidg]VgYlVgZ!VhhZbWaZndjgegdYjXidcV]VgYaZkZahjg[VXZi]ViYdZhcdi]VkZXgVX`hdgdeZc^c\h#IdVkd^YYVbV\Zidhd[i[addgdgXVgeZi!YdcdiVhhZbWaZdgbdkZi]ZVeea^VcXZdchd[i[addgdgXVgeZi#;daadlVaahiZeh^cdgYZgidegdeZganVhhZbWaZndjgegdYjXi#BV`ZhjgZVaai]ZeaVhi^XegdiZXi^dcg^ed[[WZ[dgZVhhZbWa^c\#9dcdi[dgXZeVgihid\Zi]ZgVhi]^hXVcgZhjai^ceZghdcVa^c_jgndgYVbV\Zidi]ZegdYjXi#L]ZcVeea^XVWaZ!i^\]iZcVaa]VgYlVgZXdccZXi^dchWn]VcY[^ghi!dcXZi]ZhiZe^hXdbeaZiZY!\dWVX`VcY[jaai^\]iZcVaa]VgYlVgZ#EaZVhZgZVYi]ZhZ^chigjXi^dchXVgZ[jaanWZ[dgZVhhZbWanVcYjhZ#8Vji^dc/L]^ahiZkZgnZ[[dgi]VhbVYZ^cbVcj[VXijgZd[ndjgWVgWZXjZidgZbdkZVcnh]VgeZY\Z!ndjh]djaY]VcYaZVaaXdbedcZcihl^i]XVgZidVkd^YVXX^YZciVa^c_jgn#9DCDIaZVcdkZgi]ZWVgWZXjZl]Zc^\c^i^c\i]Z\Vh[aVbZ#8adhZi]ZkVakZdci]Z\VhWdiiaZV[iZgZVX]jhZ/Ijgci]ZkVakZXadX`l^hZ#6ahdijgcd[[i]ZXdcigda`cdWhIjgc`cdW[jaanXadX`l^hZ#CZkZgaZVkZi]Z]diWVgWZXjZjcViiZcYZY#>[i]Z[aVbZZmi^c\j^h]Zh!gZa^\]i^bbZY^ViZandgXjid[[i]Zhjeean[gdbi]Z\VhWdiiaZ#L]ZcXdccZXi^c\i]Z\VhWdiiaZ!ZchjgZi]Vii]ZgZVgZcd^\c^i^dchdjgXZhl^i]^cV*bgVY^jh#IV`ZheZX^VaXVgZcdiida^\]iVcncV`ZY[aVbZh!Ydcdihbd`Zdghl^iX]dcZaZXig^XVeea^VcXZhYZk^XZh!a^\]ih!YddgWZaah!ZiXheVg`dkZgedhh^WaZ#7Z[dgZZVX]jhZ!X]ZX`idZchjgZi]ViVaaXdccZXi^dchi]gdj\]l]^X]\Vh^hhjeea^ZYVgZhZVaZYVcY^ciVXi#Assembly
9dcdijhZi]^hegdYjXi^[eVgihVgZb^hh^c\!YVbV\ZYdgldgc#CZkZgjhZhXdjgZgh!VWgVh^kZdgX]Zb^XVaXaZVcZgh#L]ZcndjVgZgZVYnidhiVgi!bV`ZhjgZi]Vindj]VkZi]Zg^\]iiddah!eaZcind[heVXZVcYVXaZVc!YgnVgZV[dgVhhZbWan#8]ZX`i]ZeVX`VcYbV`ZhjgZndj]VkZVaai]ZeVgiha^hiZY#9jg^c\VhhZbWanX]^aYgZch]djaYWZ`ZeiVlVn[gdbi]ZegdYjXiYjZidedhh^WaZg^h`d[^c_jgn#:chjgZi]Vii]^hegdYjXi^h[jaanVhhZbWaZYVh^aajhigViZYWZ[dgZjhZ#8]ZX`VaahXgZlhVcYWdaihVgZi^\]iZcZYgZ\jaVgan#Iddahcdi^cXajYZY#Promo 4 Burner Gas Grill with Side Burner
Assembly instructions3

Produced in China for TESCO Stores Ltd.© Tesco 2012www.tesco.com
WARNINGS
GZVYi]Z^chigjXi^dchWZ[dgZjh^c\i]ZVeea^VcXZ#;daadli]ZhiZeh^ci]ZdgYZgi]ZnVgZheZX^[^ZYVcYeaZVhZdWhZgkZi]ZhV[ZinlVgc^c\h#;V^ajgZiddWhZgkZi]ZhZ^chigjXi^dchXVcV[[ZXidgYVbV\Zi]ZYZk^XZVcYdi]ZgdW_ZXihVcYaZVYideZghdcVa^c_jgn#I]ZhZ^chigjXi^dchVgZeVgid[i]ZegdYjXi#I]Znh]djaYValVnhWZhidgZYl^i]i]ZegdYjXiVcYh]djaYWZeVhhZYdcidZVX]hjWhZfjZcijhZg#<gZViXVgZ]VhWZZciV`ZcYjg^c\egdYjXi^dcidgZbdkZh]VgeZY\ZhWjindjh]djaY]VcYaZVaaXdbedcZcihl^i]XVgZidVkd^Yedhh^WaZ^c_jgn#IdVkd^Y^c_jgnVcYYVbV\ZidegdeZgin!WZhjgZid[daadlVaalVgc^c\hVcY^chigjXi^dchXVgZ[jaan!WZ[dgZZkZgnjhZ#C:K:GA:6K:6A>I76G7:8J:JC6II:C9:9#>[ZkZg^cYdjWi!XdchjaiVfjVa^[^ZY\VhZc\^cZZgWZ[dgZjhZ#6hVcZmigVegZXVji^dcL=:CA><=I>C<;DGI=:;>GHII>B:6AL6NHI6@::MIG686G:#@ZZendjg]ZVYVcYVgbh[gdb]Vc\^c\dkZgi]Z77FXdd`^c\hjg[VXZ#6AL6NHbV`ZhjgZWVgWZXjZVeea^VcXZ^hXdbeaZiZanXddaWZ[dgZVeean^c\XdkZgh#>cXdchigjXi^dcd[i]^h77FjhZVaaVcYdcani]ZXdbedcZcihegdk^YZY#9dcdibdY^[n77FdgeVgih#6cnbdY^[^XVi^dcd[i]ZVeea^VcXZbVnWZYVc\Zgdjh#CAUTION!
@::EDJID;G:68=D;8=>A9G:CVcYE:IH9JG>C<VcY6;I:GJH:#9dcdihidgZdgjhZeZigdadgdi]Zg[aVbbVWaZkVedgdga^fj^Yh^ci]Zk^X^c^in#I]^hVeea^VcXZl^aaWZXdbZkZgn]diYjg^c\deZgVi^dc"ValVnhlZVghj^iVWanegdiZXi^kZ]ZViegdd[\adkZhYjg^c\jhZ#L6GC>C</6XXZhh^WaZeVgihbVnWZkZgn]di#@ZZendjc\X]^aYgZcVlVn#Ijgcd[[i]Z\VhhjeeanVii]Z\VhXdciV^cZgV[iZgjhZ#6AL6NHXadhZVcYY^hXdccZXi[gdbbV^c\VhhjeeanXna^cYZgV[iZgjhZVcY[dghidgV\Z#9DCDIBDK:I=:6EEA>6C8:9JG>C<JH:#Dont’s
@::EI=>H6EEA>6C8:8A:6C[daadl^chigjXi^dch]ZgZ^c"Id]ZaeVkd^Y[Vi[aVh][^gZh$[aVgZjehVcYi]ZgZ[dgZedhh^WaZ^c_jgndgYVbV\ZidegdeZgin!^i^hk^iVai]Vii]^hVeea^VcXZ^hXaZVcWZ[dgZ^ijhZY#Before you start
DO NOT USE INDOORSONLY TO BE USED OUTDOORSDo’s
DANGER!
>[ndjhbZaa\Vh/&#H]jid[[\VhhjeeanidVeea^VcXZ#'#:mi^c\j^h]VcndeZc[aVbZ!Vkd^Yjh^c\VcnZaZXig^XVaVeea^VcXZ#(#DeZca^YVcYkZci^aViZi]ZVgZV#)#8]ZX`\VhXdccZXi^dchl^i]hdVehdaji^dc#*#>[dYdghi^aaZm^hih!^bbZY^ViZanXdciVXindjg\Vhhjeea^Zgdg[^gZYZeVgibZci#6alVnhbV`ZhjgZi]ZWVgWZXjZ^h[jaanZmi^c\j^h]ZYVcYXdbeaZiZanXddaWZ[dgZbdk^c\!Veean^c\XdkZghcdi^cXajYZYDGhidg^c\VlVn#6cVYjaih]djaYValVnhWZ^cX]Vg\Zd[i]Z77F#C:K:GaZVkZV]diWVgWZXjZjcViiZcYZY#@ZZeX]^aYgZcVcYeZihVlVn#9dcdijhZ^cYddgh";dgdjiYddgjhZdcan#IldeZdeaZidVhhZbWaZVcYa^[i#9dcdijhZi]Z77FdcVhjg[VXZi]VibVnWZYVbV\ZYWnZmXZhh^kZ]ZVi#I]^h^hV\VhVeea^VcXZ#9dcdijhZVcndi]ZgineZd[[jZa$VXXZaZgVcihdgaVkVgdX`É#86JI>DCC:K:GHIDG:VWVgWZXjZ^cYddghjcaZhh^i^h[jaanXddaZYVcYi]Z\VhhjeeanXna^cYZg^hY^hXdccZXiZY#EgdiZXi[gdbi]ZZaZbZcihVcYYVbe#HiVcYndjgWVgWZXjZdcVhV[Z!aZkZahjg[VXZ!lZaaVlVn[gdb[aVbbVWaZ^iZbhhjX]VhlddYZc[ZcXZhdgdkZg"]Vc\^c\igZZWgVcX]Zh#Number of people required to assemble
Time to assemble
Tools required
notsuppliednotsuppliedLZVgZ]VeenidgZ[jcYdggZeaVXZVcnIZhXdegdYjXil]^X][Vaah7Zadli]Z]^\]hiVcYVgYndjZmeZXi#?jhiVh`VcnbZbWZgd[hiV[[#I]^hYdZhcdiV[[ZXindjghiVijidgng^\]ih#EaZVhZ]VkZi]ZGZ[#cjbWZgVkV^aVWaZidVhh^hil^i]ndjgfjZgn#I]^h^hadXViZYdci]Z[gdcieV\Zd[i]Z^chigjXi^dcbVcjVa#Our Promise
HeVgZeVgihVgZVahdVkV^aVWaZ^ci]Zjca^`ZanZkZcii]ViVcnVgZb^hh^c\#EaZVhZXVaa%-)*+%%))&&LZVgZ]ZgZid]Zae/IZhXdHidgZhAiY#!8]Zh]jci:C-.HA!J#@#;gZZe]dcZ%-%%*%****!Bdc"HVi#Promo 4 Burner Gas Grill with Side Burner
Assembly instructions2 hours4

www.tesco.comProduced in China for TESCO Stores Ltd.© Tesco 20125Promo 4 Burner Gas Grill with Side Burner
Assembly instructionsOperational Elements:
12G1G2G4G3
Control PanelACBFunctionNote

www.tesco.comProduced in China for TESCO Stores Ltd.© Tesco 2012Parts and tools neededPossible consequences:Safety measures:Use a standard leak detector to ensure all connections are tight. Connecting and disconnecting the gas bottle
DANGER! IGNITION OF ESCAPING GAS
3G5G1G2G4
1The tube shall be readily visible across its entire length forinspection after installation.6Confirm all barbecue control knobs are in the off position.Open the gas control valve on gas cylinder. Check for leaks by brushing soap solution over all gas system joints, including all valve connections, hose connections and regulator connections. NEVER USE AN OPEN FLAME to test for leaks at anytime. If bubbles form out of any of the tank there is a leak. If theconnection is not sealed, immediately close the bottle valve(turn the operating level G2 to the 3 o clock position) and tightenthe connection or replace the leaking part. Repeat the leak test annually, and whenever the gas cylinder is repaired or replenished.Promo 4 Burner Gas Grill with Side Burner
Assembly instructions

www.tesco.comProduced in China for TESCO Stores Ltd.© Tesco 20127Shutting off the gas bottle (Fig.2)Connecting and disconnecting the gas bottle
2
3G1G2G4G3
Promo 4 Burner Gas Grill with Side Burner
Assembly instructions

Operation www.tesco.comProduced in China for TESCO Stores Ltd.8Starting up the barbecueCaution:Switching on the side burner:Switching off the barbecue:
12
Control PanelACBEnd of cooking sessionAfter each cooking session, turn the barbecue control knobburners to the “Max” position and burn for 5 minutes.This procedure will burn off cooking residue, thus makingcleaning easier. Make sure the hood is open during this process.6. Push down the first left control knob and keep pressing whilst turning anti-clockwise to position (B) and press the igniter button up to four times in rapid succession.7. When reached position (B),the burner will be ignited.8. If the burner has not lit after two attempts, turn‘OFF’ the gas tap and wait 5 minutes before retrying the ignition sequence.9. When the burner has lit, the burner rate can be adjusted by push down and turn the knob anti-clockwise to any position between the full and low rate position.10. Light the remaining burners from left to right in sequence following the same procedure as above (step 4 to step 6).11. NEVER ATTEMPT TO LIGHT A BURNER THAT DOES NOT HAVE A LIT BURNER DIRECTLY ADJACENT TO IT. THIS COULD CAUSE A HAZARDOUS SITUATION.12. Close the lid and allow the barbecue to heat up at full power. The first time you use the barbecue, heat for about 20 minutes without food so that the food-safe coating is hardened (as with any barbecue). 13. When the barbecue is heated, turn the flame regulator to the sealed setting (size of flame).14. You can now place the food on the grill rack. We recommend that you wear barbecue gloves or other gloves to protect you from the heat.1. Open the side burner lid before lighting the side burner and turn the side burner control knob to the ‘OFF’ position.2. Push down the side burner control knob and keep pressing whilst turning anti-clockwise to the “Full rate” position and press the igniter button up to four times in rapid succession, this will light the burner. If the burner does not light, repeat this process. 3. If the burner has not lit after two attempts, turn off the gas tap, wait 5 minutes and then repeat step 3 in main burner lighting instructions.4. When the burner has lit, the burner rate can be adjusted by push down and turn the knob anti-clockwise to any position between the full and low rate position.5. To turn the barbecue ‘OFF’ turn the cylinder valve or regulator switch to the ‘OFF’position and then turn all of the control knobs on the appliance clockwise to the ‘OFF’ position when the flame have extinguished.When you have finished using your barbecue, turn all thecontrol valves fully clockwise to the “OFF” position, then switchoff the gas at the bottle. Wait until the barbecue is sufficientlycool before closing its hood.PrLIn the event of a gas leak; always turn off the gas supply.Promo 4 Burner Gas Grill with Side Burner
Assembly instructions
G2G1
G4

www.tesco.comProduced in China for TESCO Stores Ltd.www.tesco.comProduced in China for TESCO Stores Ltd.Promo 4 Burner Gas Grill with Side Burner
Assembly instructionsTips for better cookouts and longer barbecue life1, Use the upper cooking grid (warming rack) for keepingcooked food warm, toasting breads or cooking delicate foodsin aluminum foil pouches.2, Use the side burner of this appliance like a normal kitchenrange for boiling, sautéing or frying.3, To reduce flare-up, keep barbecue clean, use lean cuts ofmeat and avoid cooking on very high temperature.4, Place delicate foods like fish and vegetables in aluminum foilpouches and indirect cook or place on upper cooking levels(warming rack).5, To avoid losing natural juice, use long handled tongs orspatulas instead of forks and turn foods over just once duringcooking.6, When direct cooking adjust your burners to different levels sofoods can be prepared to different internal temperatures in thesame time frame.7, Try water pans to reduce flare-ups and cook juicer meats.Before starting barbecue remove cooking grids and place aheavy duty shallow pan directly on heat plates. Fill half waywith water, fruit juices or other flavored liquids. Replacecooking grids and position food over the loaded pan.8, Rotisseries, grill baskets, vertical poultry holders and otheraccessories can enhance your experiences, reduce cookingtime and aid in clean-up.9, Clean cooking grids and racks after every use with a qualitygrill bush designed for your grid material.Wear protectivegloves and gently remove the build-up while grids are hot.10, After every use, allow barbecue to cool down. Then protectclean cooking grids with a light coat of cooking oil, emptygrease pan, wipe outside surfaces with a suitable kitchencleaner and protect surfaces with a quality cover thatproperly fits your barbecue.9

www.tesco.comProduced in China for TESCO Stores Ltd.© Tesco 2012rCleaning and maintenance
Promo 4 Burner Gas Grill with Side Burner
Assembly instructions
       
                                                     
                                                
                                                    
                           !            !           
                                                 
         "              !    
           # $                                    !    
            %        !              
 &  '     (   ) ' * )   + 
                                         !        
    !  "                                         ,  
  -    "                .                            
    /           !                                    
                       
 &  '     (   0 *  1 ( * ' 2
            3                 4 !                          "
       5  ! !                   /                "
                  %        !              
 &  '     (    ' 6 6 2 6 (  7
 8           "             %             3               
     "                    4                         9  
                                 !                 
   :      ; < = < > ? @ A B C D E F < E G < = C F = < H
I'   (   '   
 J               ! !                                  
                                                
             !                :      
I'   ( '      (   ) ' * )   + 
 $                                                
    !     3           4 
 $                                             
                "                   
I'   ( '      (    ' 6 6 2 6 (  7
            !                       !             
         3           K $                               
      L 4 
 8           "                              !       
          -     !     
                                  !         
              
M N
A A @ O F < P
N
D A < Q R < D P < A S
 T                   
U
C V < E W B < C A R > < A S
                                                
                                  !               
        
X Y 6 6  ) &   Y 6  Z +     6 [
 T                   
\ ' ]  ( 2 7  ' 6 + *  6 [
                                                 
^ _  * Y 7   (   ] Y* 7 ' (  Y '  0 0  6 1 Y6 ' & 7  ' 6 + *  6
                       "        !                      
      `          !                    
a b c d e f g h
ijia d k f l if g m c k g ik a b g m imig d
10

Produced in China for TESCO Stores Ltd.© Tesco 201211Troubleshooting
PROBLEMPOSSIBLE CAUSEPREVENTION/CURE
Battery needs to be charged Replace the A A battery. (Follow assembly instruction)
W ires or Elect rode cover ed with
cooking residue
Clean wire and/or electr ode with rubbing alcohol
Electrode and burners are wet W ipe dry with cloth
Electrode cracked or broken –
sparks at crack
Replace electrode
W ire loose or disconnected Reconnect wire or replace electrode/wir eassembly
W ire is shorting (Sparking
between igniter and elect rode)
Replace igniter wire/electrod eassembly
Burner will not lightusing igniter
Bad igniter Replace igniter
N o gas flow Check if L P gas cylind er is empty. If empty, replac e or refill,
or else refer to “sudden drop in gas flow or reduced fl ame
height”
Coupling nut and regulato r not
fully connected
T urning the coupli ng nut about one-half to three quarters
additional turn until solid stop. Tighten by hand only, D o not
use tools.
Obs truction of gas flo w Clear burner tubes, check for bent or kinked hose.
Spider webs or insect nest in
venturi
Clean venturi
Burner ports clogged or blocked Clean burner ports
Out of gas Replace or refill LP gas cylinder
Sudden drop in gasflow or reducedflame height
Exces s flow, safety device may
have been activated
T urn control knobs to “O F F ”, wait 30 seconds and light
barbecue. If flames are still too low, reset the exce ssive flow
safety devic e by turning control knobs “O FF ” and L P gas
cy linder valve to “C L OSED”. Disconnect regulat or. Turn
control knobs to “H IG H ”, wait 1 minute. T hen turn control
knobs to “OFF”, and reconnect regulator and leak check
connections . Slowly turn L P gas cylinde rvalve to “OPEN”,
wait 30 seconds and then light barbecue per lighting
instructions.
Burner ports are clogg ed or
blocked
Clean burner ports.
N ew burner may have residual
manufac turing oils
Burn barbecue for 15 minutes with the lid closed
Spider webs or insect nest in
venturi
Clean venturi
Foo d residue, grease or
seasoning salt on burner
Clean burner
Poor alignment of valve to
injector venturi
As sure burner ven turi is properl y engaged with injector
H igh or gusting winds D o not use barbecue in high winds
Lo w on L P Gas Replace or refill L P gas cylinder
Excess flow valve tripped Adjust (lower) temperature accordingly
Grease trapped by food buildup
around burner system
Turn control knobs to “O F F ”, T urn L P gas tank valve to
“CLOSED”. Leave lid in closed position and let fire burn out.
After barbecue cools, remove and clean all parts
Flashback (fire in
burner tube(s)
Burner and/or burner tubes are
blocked
Clean burner and/or burner tubes
Inside of lid is peeling
(like paint peeling)
The lid is stainless steel, not
painted
Baked on grease buildup has turned to carbon and is flaking
off. Clean thoroughly.
Burner will not lightwith matchIrregular flamepattern, flame doesnot run the fulllength or burnerFlame is yellow ororangeFlame blow outPersistent greasefirewww.tesco.com
Promo 4 Burner Gas Grill with Side Burner
Assembly instructions

12
Produced in China for TESCO Stores Ltd.© Tesco 2012www.tesco.com
Promo 4 Burner Gas Grill with Side Burner
Assembly instructions
n o p q r s o t u s q u v w x o r q
s o t u y z { | u {
'JUUJOHTTVQQMJFEBDUVBMTJ[F'JYUVSFTBOE'JUUJOHT1111111RefQtyVisualVisualDescriptionDescription1141516A16171819236101213111211RefQty$PNQPOFOUTTVQQMJFEOPUBDUVBMTJ[F$PNQPOFOUTTVQQMJFEOPUBDUVBMTJ[F9
y
11254789A4111111
y
} ~ ~  o | p  { o v v    { p u
  {  o | p n   
} ~ ~  o | p  { o v v  s   v v
 v   u    u {
yy y~t 
 u w r s o t u s q u v w
 { u   u  {  
 { ~|r |uv
 u w r s o t u  u p   { ~| r
 u w r s o t u  u p  y   
y~r r ~ y ~ { t
 q u u v  | t } 
 q u u v
  u v
} ~ | r { ~v  | ~ 
} ~ | r { ~v     o   v  r u
n o p q r  o t u  u p   { ~| r
n o p q r  o t u  u p  y   
s o t u y z { | u {
s o t u y z { | u {  { o  u r

13
Produced in China for TESCO Stores Ltd.© Tesco 2012www.tesco.com
YY
'JUUJOHTTVQQMJFEBDUVBMTJ[F'JYUVSFTBOE'JUUJOHTVisualDescriptionRefQty
#
$%')
..Y.Y.Y
.

. .
Promo 4 Burner Gas Grill with Side Burner
Assembly instructions
"
YY
. . .

14
Produced in China for TESCO Stores Ltd.© Tesco 2012www.tesco.com
Promo 4 Burner Gas Grill with Side Burner
Assembly instructions
1
3
4
9A
10
11
6
9B
8
16A
16B
5
14
15
7
12
13
17
18
19
2
(FUUJOHUPLOPXZPVSQSPEVDU

1215
Produced in China for TESCO Stores Ltd.© Tesco 2012www.tesco.com
Promo 4 Burner Gas Grill with Side Burner
Assembly instructions9B
9A
C
1
16B
16A C

3416
Produced in China for TESCO Stores Ltd.© Tesco 2012www.tesco.com
Promo 4 Burner Gas Grill with Side Burner
Assembly instructionsC
C
10
11
12
13
B
F

5617
Produced in China for TESCO Stores Ltd.© Tesco 2012www.tesco.com
Promo 4 Burner Gas Grill with Side Burner
Assembly instructionsH
8
H6

7818
Produced in China for TESCO Stores Ltd.© Tesco 2012www.tesco.com
Promo 4 Burner Gas Grill with Side Burner
Assembly instructionsH
H
A

91019
Produced in China for TESCO Stores Ltd.© Tesco 2012www.tesco.com
Promo 4 Burner Gas Grill with Side Burner
Assembly instructionsH
H
17

111220
Produced in China for TESCO Stores Ltd.© Tesco 2012www.tesco.com
Promo 4 Burner Gas Grill with Side Burner
Assembly instructionsH
H
A