Textron GREENLINE 910 User manual

INSTRUCTION MANUAL
910
Wire Dispenser
52042771 REV 1 6/10
Read and understand all of the instructions and
safety information in this manual before operating
or servicing this tool.
© 2010 Greenlee Textron Inc.
www. .com [e-mail]1.800.561.8187

910 Wire Dispenser
Greenlee / A Textron Company 2
Description
5IF(SFFOMFF8JSF%JTQFOTFSJTJOUFOEFEGPS
transporting and dispensing wire from wire spools.
'PSNPSFJOGPSNBUJPOSFGFSUPi4QFDJàDBUJPOTuPO
page 4.
Safety
4BGFUZJTFTTFOUJBMJOUIFVTFPG(SFFOMFFUPPMTBOE
FRVJQNFOU5IJTJOTUSVDUJPONBOVBMBOEBOZNBSLJOHT
on the tool provide information for avoiding hazards and
unsafe practices related to the use of this tool. Observe
all of the safety information provided.
Purpose of this Manual
This manual is intended to familiarize all personnel with
the safe operation for the Greenlee tool:
8JSF%JTQFOTFS
Keep this manual available to all personnel.
Replacement manuals are available upon request at no
charge.
"MMTQFDJàDBUJPOTBSFOPNJOBMBOENBZDIBOHFBTEFTJHO
improvements occur. Greenlee Textron Inc. shall not be liable for
damages resulting from misapplication or misuse of its products.
KEEP THIS MANUAL
Table of Contents
Description .................................................................... 2
4BGFUZ ............................................................................ 2
Purpose of this Manual ................................................. 2
*NQPSUBOU4BGFUZ*OGPSNBUJPO ........................................ 
1BSUT-JTU ....................................................................... 4
4QFDJàDBUJPOT................................................................ 4
Operation ...................................................................... 4
www. .com [e-mail]1.800.561.8187

910 Wire Dispenser
Greenlee / A Textron Company 
IMPORTANT SAFETY INFORMATION
SAFETY
ALERT
SYMBOL
This symbol is used to call your attention to hazards
or unsafe practices which could result in an injury or
QSPQFSUZEBNBHF5IFTJHOBMXPSEEFàOFECFMPX
indicates the severity of the hazard. The message
after the signal word provides information for pre
venting or avoiding the hazard.
*NNFEJBUFIB[BSETXIJDIJGOPUBWPJEFE8*--SFTVMU
in severe injury or death.
)B[BSETXIJDIJGOPUBWPJEFE$06-%SFTVMUJO
severe injury or death.
)B[BSETPSVOTBGFQSBDUJDFTXIJDIJGOPUBWPJEFE
.":SFTVMUJOJOKVSZPSQSPQFSUZEBNBHF
Read and understand all of the
instructions and safety information
in this manual before operating or
servicing this tool.
Failure to observe this precaution
may result in injury or property
damage.
Keep hands and feet clear when
loading and unloading wire spools.
Failure to oberve this precaution
may result in injury or property
damage.
-PBEBOEVOMPBETJEFTFRVBMMZ
-PBECPUUPNTQJOEMFTàSTUBOE
VOMPBEUPQTQJOEMFTàSTU"OVOCBM
BODFEPSUPQIFBWZMPBEDPVME
DBVTFXJSFEJTQFOTFSUPUJQPWFS
causing injury and property damage.
Failure to observe this precaution
may result in injury or property
damage.
r .BLFTVSFCZTUBOEFSTBSFDMFBSPGUIFXPSLBSFB
XIFOMPBEJOHVOMPBEJOHPSEJTQFOTJOHXJSF
Nearby personnel can be injured if wire dispenser
falls.
rDo not use the wire dispenser for wire with
damaged spools. Damaged spools may not turn
freely and may pull over the dispenser.
r 6TFPOMZPOBIBSEáBUMFWFMTVSGBDF
rDo not exceed the rated capacity of this tool.
Failure to observe these precautions may result in
injury or property damage.
6TFUIJTUPPMGPSNBOVGBDUVSFSTVTFPOMZ6TFPUIFS
than that which is described in this manual may
result in injury or property damage.
Note: Keep all decals clean and legible, and replace
when necessary.
www. .com [e-mail]1.800.561.8187

910 Wire Dispenser
Parts List
Specifications
Height .............................................NN
8JEUI...............................................NN
-FOHUI ................................................NN
8FJHIU ................................................MCLH
$BQBDJUZ
5FONNEJBNFUFSTQPPMTNNXJEF
MCLHQFSTQJOEMFXIFOCBMBODFE
MCLHUPUBMXFJHIUXIFOCBMBODFE
Operation
 -PBEXJSFEJTQFOTFSTJEFTFRVBMMZTUBSUJOHBUUIF
bottom spindles.
 5SBOTQPSUUIFVOJUCZIBOEUPUIFEFTJSFEXPSL
location.
 -PDLUIFTXJWFMDBTUFSTUPQSFWFOUVOXBOUFE
movement.
4. Feed wire through the wire guide and adjust to
desired position.
 6OMPBEXJSFEJTQFOTFSTJEFTFRVBMMZTUBSUJOHXJUI
UIFUPQTQJOEMFTBOEXPSLJOHEPXO
Key Part No. Description Qty
  #BTF......................................................1
  5SFFBTTFNCMZ .......................................1
  )BOEMFBTTFNCMZ ..................................1
 #PMUIFYY .............................1
 /VU/ZMPL.................................1
  $BTUFSSJHJE ......................................2
  $BTUFSTXJWFMMPDL............................2
 4DSFXIFYY........................12
 /VUIFYSFHGVMM ....................12
 8BTIFSMPDL ................................12
  /JQQMFDPOEVJU............................10
  -PDLOVUDPOEVJUTUFFM.................10
 )JUDIQJO..........................................1
 #PMUFZF .................................1
  1JORVJDLSFMFBTF .................................1
  %FDBMJEFOUJàDBUJPO ..............................1
2
1
3
4, 5
6
78, 9, 10
14
15
16
11, 12
13
www. .com [e-mail]1.800.561.8187