Tobbi TH17B0500 User manual

AL
TH17B0500
TH17E0501

1 2
INSTALLATION INSTRUCTION
In order to improve the quality, we may change part of the structure and
appearance of the product without an advance notice.
Please read the instructions carefully before use, it will tell you the
right operation method and installation steps . Incorrect operation may
damage the product, or even hurt your child. Please keep this instruction
ready and easy to find.
The illustrations in this instruction are used for easier understanding of the
operation method of the product and the product structure. Please note there
may be differences between the pictures and the physical item.
！
The owner’s manual contains assembly, use and maintenance instructions.
The vehicle must be assembled by an adult who has read and understands
the instructions in this manual. Keep the pack-aging away from children
and dispose of all packaging before use.
Note: For best performance use on flat, hard surfaces.
The following safety hazards may result in serious injury or death to the
user of the vehicle:
· This product contains small parts that are for adult assembly only.
Keep small children away when assembling. Remove and dispose of all
protective material and poly bags before assembly. Be sure to remove
all packaging materials and parts from underneath the vehicle body.
· Battery posts, terminals and related accessories contain lead and lead
compounds (acids) chemicals known to the state of California
to cause cancer, reproductive harm, and are toxic and corrosive. Never
open the battery.
· Body parts such as hands, legs, hair and clothing can get caught in
moving parts. Never place a body part near a moving part or wear loose
clothing while using the vehicle. Always wear shoes when
using the vehicle.
· This toy does not have brakes or any braking capability. Do not
leave a child unattended while using this toy or allow use of this toy in
any location that requires braking capability, as this couldresult in a
roll away or loss of control, which may cause serious injury or death.
· Using the vehicle near streets, motor vehicles, drop-offs such as: steps,
water (swimming pools) or other bodies of water, sloped surfaces, hills,
wet areas, flammable vapors, in alleys, at night or
in the dark could result in an unexpected accident. Always use
the vehicle in a safe, secure environment with continuous
adult supervision.
• Using the vehicle in unsafe conditions such as snow, rain, loose dirt,
mud, sand or fine gravel may result in unexpected action
such as tip over and skidding, and damage to the electrical system and
battery.
• Using the vehicle in an unsafe manner. Examples include but are not
limited to:
a. Pulling the vehicle with another vehicle or similar device
b. Allowing more than one rider
c. Pushing the user from the back
d. Traveling at an unsafe speed
Always use common sense and safe practices when using the vehicle
The following safety hazards may result in serious injury or death to the
user of the vehicle:
• Use of a battery or charger other than the supplied 12V
rechargeable battery and charger may cause a fire or
explosion. Only use the supplied 12V
rechargeable battery and charger with the vehicle.
• Using the 12V rechargeable battery and charger for
any other product may result in overheating, fire or explosion.
Never use the 12V rechargeable battery and charger with
another product.
• Explosive gases are created during charging. Charge the battery
in a well ventilated area. Do not charge the battery near heat or
flammable materials.
• Contact between the positive and negative terminals may result
in fire or explosion. Avoid direct contact between the terminals.
Picking up the battery by the wires or charger can cause damage
to the battery and may result in a fire. Always pick up the battery
by it’s case or handles.
• Liquids on the battery may cause fire or electric shock. Always
keep all liquids away from the battery
and keep the battery dry.
• Contact or exposure to battery leakage (lead acid) may cause
serious injury. If contact or exposure occurs immediately call
your physician. If the chemical is on the skin or in the eyes, flush
with cool water for 15 minutes. If the chemical was swallowed,

28
37-96 months
34
Pay attention while driving the vehicle, avoid falls or collisions causing
injury to the user or third parties.
Please check the component parts before using, and make regularly
examine the transformers or battery chargers for in the event of any
damage on the cord, plug, enclosure and other parts, the vehicle shall
not be used until the damage has been repaired, to avoid an accident.
immediately give the person water or milk. Do not give water or
milk if the patient is vomiting or has a decreased level of
alertness. Do not induce vomiting.
• Battery posts, terminals and related accessories contain lead
and lead compounds (acid), chemicals
known to the State of California to cause cancer, reproductive
harm and are toxic and corrosive. Never open the battery.
• Tampering or modifying the electric circuit system may cause a
shock, fire or explosion and permanently damage the system.
Exposed wiring, circuitry in the charger may cause electric
shock. Always keep the charger housing closed.
Before using the vehicle the child should understand the vehicle controls
and safety issues. They must also demonstrate the capability to handle the
vehicle and operateits controls.
It is the responsibility of the adult to educate the child and supervise the
vehicles use. Read the following safety warnings to any child using the
vehicle before riding.
Never leave child unattended. Always supervise the child.
Always sit in the seat when using the vehicle.
Keep your hands, hair and clothes away from moving parts.
Always wear shoes when using the vehicle.
Only one rider is allowed on the vehicle at a time.
Children under 3 years of age cannot use the vehicle.
Only drive on level ground.
Do not go near swimming pools or other bodies of water,
drop-offs or up and down steep inclines.
Do not drive the vehicle into loose dirt, mud, sand or fine gravel.
Do not drive the vehicle on streets or near cars.
Not to be used in traffic.
Damage to the battery may occur if it is allowed to drain
completely. Do not allow the battery to drain completely.
Check the battery and charger (supply cord, connector) for wear
and damage before charging. Do not charge the battery if damage has
occurred.
On average you will need to charge the battery between 8 and 12 hours.
Do not charge the batery for more than 20 hours. Failure to charge the
battery as directed could cause permanent damage to the battery and
void the warranty.
Only an adult who has read and understands the safety warnings should
handle, charge and recharge the battery.
Park the vehicle indoors or cover it with a tarp to protect it from wet
weather.
Do not leave the vehicle in the sun for long periods of time or fading may
occur. Store in shade or cover with tarp.
Do not wash the vehicle with a hose.
Do not wash the vehicle with soap and water.

12V 4.5AH(6-FM-4.5（AH）) *1/
Specification
Name specification
Battery
Motor
Suitable age
Max weight
Body size
Speed
Hours of use
Charger
Mainmaterial
37-96 months
28KG
2-4KM/h
charging 8-12 hours，using 1 to 2 hours
Input：110V~240V
PP(polypropylene) and iron
Output: DC 12V500MA/
DC 12V1000MA
*The above parameters contain optional features, specific parameters
please refer to our samples.
Motor:
Steering motor:12V
1050*650*520MM
12V 7AH(6-FM-7（AH）)*1
12V
61
4
8
5
74
91
G(Wheel)H(Wheel Cover)
I(seat)
2
1
31 set 4
2
D(Wheel connecter)
C(rear view mirror)
1
1
1
1
Q (motor R)
1
Y (motor L)
10
11 11 2
12 2
L(M8 spanner)
1
13
R
L
T(Charger)
X (self-tapping screw)

①
②
③③
①②
③③
④ ④
D
D
Q
Y
①
②
①
②②②
③③
③③
R
L
R
Step 1: Loosen the screw, gasket from real axle
Use the L (M8 spanner) to loosen the② (M8 nut) ①(M8 gasket) and ④
(Circular paper tube) from the ③ (real axle) in a counterclockwise
direction. (kindly reminder: please throw the ④ in a recyclable trash can).
Step 2: Install the motor
Insert the ①(motor terminal) into ②, then install the Q (motor R) and
Y(motor L) to ③ (front axle), also should insert the motor part into②, finally
install the D (Wheel connecter) to motor as per shows (pay attention, align
the R/L motor with the car R/L correctly).
①
②
③③③③
①②
L
G
③③①②
H
①
②
③③
G
H
GH
G
H
④④④⑤⑥
⑤
⑥
④
L
Step 3: Loosen the screw,gasket from front axle
Use the L (M8 spanner) to loosen the ②(M8 nut) ① (M8 gasket) from the③
(front axle) in a counterclockwise direction.
L
④

Connect the terminal 1
and 2 , then insert the
terminal 4 into the hole 3
at receiver. Pay attention,
should align the copper
piece of 3 with 5 and 6 at
terminal 4 .
①①
A
SS
MM
F
③③
Step 4: Install the wheel
1. Install the G (wheel) onto the ③ (real axle), put the ① (M8 gasket) , then use the
L (M8 spanner) to ghten the ②(M8 nut) in clockwise direcon. Finally install
the H (wheel cover) on correct posion (align and press the buckle of the wheel
cap with the grooves of the wheel to fix it)
2. The front wheel is also installed in this way.
Step 5: Install the steering wheel
Connect S, M terminal firstly, then align the correct position and press A
(steering wheel) on ①(steering yoke) as shown in figure.
P.S if need to take off the steering wheel, please tighten ③, then pull out the
steering wheel, and disconnect the terminal S,M.
Step 6: Install the
wind deflector
Place F (wind deflector)
onto the corresponding 3
clasp at car body as
shown in figure.
2
1
C2
C1
I
①
X
1
2
6
5
3
4
3
4
5
6
4
②
Step 7: connect the
power
3
Put the I (seat) onto the
right place, fix the two
hooks (at the back of the
seat) into the
corresponding groove on
car body. then fix the N
(seat) with 2 pcs X (self-
tapping screw) as shown
in figure.
Step 8: Install the
seat
Install the C1 (rear view
mirror L), C1 (rear view
mirror R) to the car in
correct placement as
show in figure.
Step 9: Install the
rear view mirror

1. Turn off the Power Switch on the car.
2. Remove the battery cover on the Remote Control and put in 2 AAA
battery, the three LED indicators will flash.
3. Turn on the Power Switch on the car, when the LED indicators stop
flashing and 2 of them are on, matching successes.
4. Once the matching is made, there is no need to match code again
only if the battery is replaced.
5. The Remote Control will enter a sleep mode if not used for a long time
and the LED indicators will be off. Press any buttons to wake up the
Remote Control, and it can be used normally.
+ - + -
LED Indicator
1.Power switch: Turn on or turn off the power.
2.Light switch: I is turn on, O is turn off.
3.Music button: press the button to play music. long press the music button can
increase the volume.
4.Horn button: press the button to play the horn. long press the horn button can
reduce the volume.
5.Forward/Reverse switch: press the button for controlling the Vehicle to move
forward, Reverse.
6.Mp3 multifunctional player
4.Operation guide for Manual control (forward,
Reverse ):
After the driver is seated, press the power switch, the car will send out a
starting sound (2-5seconds). Put the Forward/Reverse switch into the
position of “forward” (Press forward), step on the foot switch the car will
move forward , loosen the pedal the car will stop. Put the Forward/Reverse
switch into the position of “Reverse”, step on the foot switch the car will
move Reverse, loosen the pedal the car will stop.
3. Instruction of each switch and function button
6
Forward
Reverse
The remote control operation alaways prior to the manual control operation
.(The manual control won't work while operating remote control)

Resettable fuse: when
the current exceeds a certain rating,
the recoverable fuse will automatically
cut off the power supply for 5-
10seconds, then the current will be
resupplied.
7
6
high/low
high/low
* ONLY one speed for reverse, the high/low switch can not control
the reverse speed.
RISK OF FIRE. Do not bypass fuse. This may overload and damage the
electrical system. Replace only with original size and type.
WARNING
!
5-1. Instruction for MP3 multifunction player
(Configuration A)
◀◀ ▶
/V-
◀◀
▎▎
▎▎ /V+
5-2. Instruction for MP3 multifunction player
(Configuration B)
◀◀ ▶/V+
/V-
◀◀
▎▎
▎▎ MODE AUX
USB
TF
A B
C D E F G H
◀◀/V-
▎
▶▎▎
/V+
◀◀
▎
▶▎▎
◀◀
▶
/V+
/V-
◀◀
▎
▎
▎▎
A. Voltage display screen: The value on the display be used to determine
whether the battery needs to be charged.
B. USB connector: insert USB will play the music inside. Only MP3 mode is
supported.
C. button: Last channel/volume down: short press to play the last channel,
long press to lower the volume.
D. button: Short press this botton is pause. Note: in FM mode, long press this
botton will search radio station.
E. , Next channel / Volume up: short press to play the next channel, button
long press to increase the volume.
F. Mode switch button: Can switch between different play modes.
G. AUX connector: connect with other removable device to play audio file valid.
I. FM function: press the MODE key to enter the FM mode, long press to
search the channel ( it needs around 1 minute ), after that it will automatically
lock the radio channel, and it has the memory function, the channel info. will
not lose even turn off the power. ( please repo at this operating steps if you
want to research the channel ). Short press is pause, will play next
channel, will play last channel.
H. TF card slot: Plug TF card into the TF card slot, the car will read and play the
audio file in TF card. (Only support MP3 format)
Other functions are same with Configuration A

Trouble elimination methods
The motor
does not
rotate
1. Is the fuse overloaded? (under
the seat)
2. The pedal switch connector is
good?
3. The welding of motor electric
terminal is good?
4. The connector of the motor wire
is good？
5. Remove the motor's plug-in,
change to connect battery directly,
then check if it rotate or not.
1.Yes, the fuse cuts off the power
automatically by 5-20 seconds, then
restart; No, check next reason analysis
2.No, repair foot switch ; Yes, check next
reason analysis
3. No, weld the terminal wire ; Yes, check
next reason analysis
4.No, plug in the plug-in ; Yes, check next
reason analysis
5.Still no rotation, change the motor; If
rotates, it means driving circuit board
needs professional maintenance, please
contact with agent
Only move
frontwards,
or only move
backwards
1. Check the frontward/backward
switch, check the connector is
good or not by multimeter
2. Check the drive line cycle of
frontward/bckwards is workable or
not?
1.No, change the frontward /backward
switch;
Yes, check next reason analysis
2.No, connect the line; Yes, it means
driving circuit board needs professional
maintenance, please contact with agent
slow speed
1. Check the battery voltage is ok
or not.
2. Connect the motor (including
the driving gearbox) to the
battery, then check the speed can
be accelerated or not.
1.No, charger the battery ; Yes it's ok,
check next reason analysis
2. No, check next reason analysis ; Yes, it
means driving circuit board needs
professional maintenance, please
contact with agent
The battery
can not be
recharged
1. The battery connector fall off or
loosened.
2. The charger has a slight heat
when it is charged
1. Yes, reconnect it, No, check next
reason analysis
2.No, the charger is broken, replace it
When car is
moving, the
sound and
light are
useless
1. check the sound/light switch
is ok or not.
2. check the electric wire
connection (from battery to
headstock) is good or not?
1.No, replace the switch; Yes,
check next reason analysis
2. No, reconnect; Yes, check next
reason analysis
When wheel
running, the
car does not
move
1. check the driving wheel can
be rotated or not?
2. Check the gearbox, if any
gear is damaged?
1.Yes, lay the wheel to the ground; No,
checks the next reason analysis
2.Yes, replace the gear box; No,
checks the next reason analysis
Car is
unstable,
moving on
and off
1. Does the driver exceed the
maximum load weight?
2. Does the driver ride on the
rugged road?
3. Check the wheel can rotate
freely?
1.Yes, should follow the instruction, the
car unsuitable for exceed maxweight;
No, check the next reason analysis
2.Yes, should follow the instruction, ride
on the flat cement road ; No, check the
next reason analysis No,
Troubleshooting wheel and axle
8
4
5
2
1
When battery power is low, please charge it immediately. The charging port
is under the seat. (Note: toys can not be operated in the charging state.
Toys should be recharged by adult) .