Toshiba SDP1731 User manual

SERVICE MANUAL
CAUTION : Before servicing this chassis, read the "PRODUCT SAFETY SERVICE FOR VIDEO PRODUCTS" section
on page 2 of this manual.
CONTENTS
SERVICE PRECAUTIONS......................................................2,3
BLOCK DIAGRAMS...................................................................4
TROUBLE SHOOTING...........................................................5,8
BOARD DIAGRAM...............................................................9,10
DVD and CD
PLAYER
MODEL
SDP1731
REPLACEMENT PARTS LIST............................................11,22

Whenthepowersupplyisbeingturnedon,youmaynotremovethislasercautionslabel.Ifitremoves,radiationoflaser
maybereceived.
LASERBEAMCAUTIONLABEL
PREPARATIONOFSERVICING
PickupHeadconsistsofalaserdiodethatisverysusceptibletoexternalstaticelectrocity.
Althoughitoperatesproperlyafterreplacement,ifitwassubjecttoelectrostaticdischargeduringreplacement,
itslifemightbeshortened.Whenreplacing,useaconductivemat,solderingironwithgroundwire,etc.to
protectthelaserdiodeformdamagebystaticelectricity.
Andalso,theLSIandICaresameasabove.
Solderingiron
withgroundwire
orceramictype
Groundconductive
wriststrapforbody.
Conductivemat
Thegroundresistance
betweenthegroundline
andthegroundislessthan10
1M

SAFTY NOTICE
Plug the AC line cord directly into a 120V AC outlet (do
not use an isolation transformer for this check). Use an
AC voltmeter, having 5000 per volt or more sensitivity.
Connect a 1500 10W resistor,paralleled by a 0.15uF
150V AC capacitor between a knomn good earth ground
(water pipe, conduit, etc.) and all exposed metal parts of
cabinet (antennas, handle bracket, metal cabinet
screwheads, metal overlays, control shafts, etc.).
SAFTY PRECAUTIONS
LEAKAGE CURRENT CHECK
Measure the AC voltage across the 1500 resistor.
The test must be conducted with the AC switch on and
then repeated with the AC switch off. The AC voltage
indicated by the meter may not exceed 0.3V.A reading
exceeding 0.3V indicates that a dangerous potential
exists, the fault must be located and corrected.
Repeat the above test with the DVD VIDEO PLAYER
power plug reversed.
NEVER RETURN A DVD VIDEO PLAYER TO THE
CUSTOMER WITHOUT TAKING NECESSARY
CORRECTIVE ACTION.
READING SHOULD NOT EXCEED 0.3V
DVD VIDEO PLAYER
AC OUTLET
AC VOLTMETER
Test all exposed metal.
Voltmeter Hook-up for Leakage Current Check
0.15uF 150V AC
1500
10W
(5000 per volt
or more sensitivity)
Good earth ground
such as a water pipe,
conduit, etc.
The lightning flash with arrowhead symbol, within an
equilateral triangle, is intended to alert the user to the
presence of uninsulated "dangerous voltage" within the
product's enclosure that may be of sufficient magnitude to
constitute a risk of electric shock to persons.
The exclamation point within an equilateral triangle is
intended to alert the user to the presence of important
operating and maintenance (servicing) instructions in the
literature accompanying the appliance.

SERVO & DVD PROCESSOR
MPEG-2 DECODER
& VIDEO ENCODER
D2881
OVERALL BLOCK DIAGRAM
AC
Adapter
DC IN +9V
DC / DC
(R1224)
DC / DC
(R1224) (TPS5100)
(BQ2057C) (TPC8207) (VG202C)
110~240V
50/60Hz
BATTERY
KHM-252
PU mechanism
DRIVER
(BA5954FP)
RF AMP
D2891
8M FlashROM
MX29LV008TTC-70
64M SDRAM
NT56V6620C0T-75S
TC4W53
27MHz
AUDIO D/A
(PCM1742)
UPD5100 TFT MONITOR
AUDIO AMP
(NJM4558)
PHONE AMP
(NJM4580)
SPEAKER AMP
(D2822)
HIGH VOLTAGE ASS'Y
74HCU04
27MHz
VIDEO OUT
AUDIO OUT
PHONE OUT
SPEAKER LOUT
SPEAKER ROUT
L
R
L
R
RL
DRIVER +5V
+5V
AUDIO +/-5V
+3.3V
AUDIO +5V
TFT POWER
+5V -14.5V +16V
S-VIDEO OUT
DC 9V
DC 9V

1. Troubleshooting
1. No power when turned on.
2. The initial screen is not displayed on the LCD.
3. The DVD drive does not work.
4. The operation of the DVD player stops at initializing display.
5. Image output stops during the operation.
6. No sound or abnormal sound comes out form the speakers in the DVD player.
7. No image or sound comes out form the external output.
8. No sound comes out form the headphones.
9. No image or sound is output by external input.
10. The DVD drive does not operate with the battery.
1.1 No power when turned on.
When the power is turned on, and if the LED on the front panel does not light green, check
the following items and repair the defective parts.
(1) Check the power supply cable
If the cable is not the supplied one, replace it with the supplied cable and turn on the
power again.
If the power supply cable is good, the AC adapter may be defective.
If the LED does not light after replacing, check the following items.
(2) Check the AC adapter
If the AC adapter is not the supplied one, replace it with the supplied AC adapter and
turn on the power.
If the AC adapter is good, the power supply boards may be defective.
If the LED does not light after replacing, check the following items.
(3) Check the Power and Play buttons
Press the POWER button or the PLAY button on the DVD player. If the power does
not turn on, check the following:
zCheck the connector of the switch unit in the DVD player.
(If the connection is loose, repair the connection.)
zReplace the switch unit and turn on the power again.
If the LED does not light after replacing, check the following items.
(4) Replace the main board

1.2 The initial screen is not displayed on the LCD.
If the initial screen is not displayed on the LCD, check the following items.
(1) Check the LED on the front
If the LED does not light, proceed to 1.1.
(2) Check the backlight
If the backlight does not light up, separate. The DVD player into top assembly and
bottom assembly, and check the connector harness, and check the connectors for
defects.
If the connector harness is broken:
Replace the broken harness.
If the connector harness is not broken:
Remove the LCD cover and plate of the LCD unit and check the following:
zCheck the connector of the FL harness, repair connectors.
zIf the connectors are good, replace the FL inverter or the LCD.
(3) Check the lighting of LCD
If the LCD does not light, separate the DVD player into the top assembly and bottom
assembly, and check the LCD harness, and check the connectors on the main board.
If the connector is broken:
Replace the LCD harness or the main board.
If the connector is not broken:
Remove the LCD cover and plate of the LCD unit, and check the connection to the
harness of the LCD unit.
zIf a bad connection is found.
Connect the LCD harness to the LCD unit.
zOther than the above
Replace the LCD unit or the main board.

1.3 The DVD drive does not work.
When the DVD drive does not work after the power is turned on, check the following items
and repair or replace the defective parts.
(1) Press the DISC cover switch at the center of the DVD player and turn on the
power. Then check whether or not the optical pick-up lens of the DVD drive
lights.
CAUTION: Visible laser radiation when open and interlock defeated. Do not stare into
Laser beam.
The optical pick-up lens lights dim:
It is caused by deterioration of the optical pick-up lens. Replace the DVD drive.
The optical pick-up lens does not light:
Check the connectors of the DVD-FFC. Also check the connection to the main
board and to the DVD drive.
zLoose connection is found.
Repair the connection, and then check the operation of the DVD drive again.
zThe DVD-FFC is broken.
Replace the DVD-FFC.
zOther than the above.
Replace the DVD drive or the main board.
(2) Insert a DVD disk and turn on the power
The DVD drive does not work:
The motor of the DVD drive or the main board is defective. Replace the DVD drive
or the main board.
The DVD drive works but the initializing operation of the optical pick-up lens
does not start (the optical pick-up lens operates twice), or abnormal noise
sound:
The DVD drive is defective. Replace the DVD drive.
1.4 The operation of the DVD player stops at initializing display.
If the DVD player does not work after the initializing screen is displayed, check the
indication on the screen. Then repair the defect according to it.
(1) Insert a DVD disk and close the DISC cover, and turn on the power. Then check
the LCD screen or use an external display.
zThe message “loading” is not displayed or the operation stops at the
message “Loading”.
Since the DVD drive or the main board is defective, check in the following order:
1) DVD drive
2) Main board
zThe message “CHECK DISK” is displayed.
Check the DVD disk for fingerprints, dirt, etc.
If the DVD disk is OK, then check the following items:
1) Check the DVD-FFC
If a loose connection, repair the connection.
If it is damaged, replace it with new one.
2) Other than above
For other cases, replace the unit in the following order:
zDVD drive (defective optical pick-up)
zMain board

1.5 Image output stops during the operation.
If the image output form the media in the DVD player stops during the operation, replace
the DVD drive.
1.6 No sound or abnormal sound comes out from the speakers in the DVD player.
If no sound comes out form the speakers in the DVD player, check the following:
(1) Check for moving images on the LCD screen
Check whether or not the move of image stops in halfway. If it stops, replace the DVD
drive.
(2) Check the operation of the DVD driver.
Check whether or not the DVD drive works. If it stops, replace the DVD drive.
(3) Check the connection of the speakers in the LCD unit.
Separate the DVD player into the top assembly and bottom assembly, and then check
the connection of the speaker harnesses to the main board. If a bad connection, repair
the connection.
Other than the above, disassemble the LCD unit and replace the speakers or the main
board.
1.7 No image or sound comes out form the external output
If any image or sound is output form the TV connected by the external cable, replace the
main board or the connector.
NOTE: Before this test, make sure the drive works.
1.8 No sound comes out form the headphones.
If no sound comes out form the headphones, replace the main board or the connector.
1.9 No image or sound is output by the external input.
If any image or sound is output by external input, replace the main board or the connector.
1.10 The DVD drive does not operate with the battery.
(1) Check the operation with a good battery.
Install a good battery and make sure the LED lights up orange while the AC adapter is
connected. When the LED does not light up or blinks, check the connection of the
battery harness inside the DVD player. If the connection is loose, repair connection. If
the harness has been connected firmly, replace the main board.
(2) Other than the above, replace the battery.
NOTE:
zFor this check, use a battery which is not fully charged (because the LED does
not light when the battery is fully charged.)
zBefore this check, make sure other function work correctly.

DVD1731-H2-B MAIN PCB BOARD DIAGRAM

DVD1731H(PA) HV POWER PCB BOARD DIAGRAM
DVD1731T(PA) TFT PCB BOARD DIAGRAM

PART No. PART NAME Q'TY
21057 CDQ-4 CHARGE ASS'Y 1
21116 LI-IONCHP-2 PROTECTOR 1
21186 D1731 KEY ASS'Y 1
21265 DVD1731-H2-B MAIN ASS'Y 1
21267 DVD1731T(PA) TFT ASS'Y 1
21268 DVD1731H(PA) HV ASS'Y 1
S2706 ICR18650 LITHIUM BATTERY 1
S5006 SPEAKER 2
S8064 KHM-252 LOADING ASS'Y 1
S0535 CAR CIGARETTE ADAPTER 1
S3421b 20 PIN HARNESS (LE160) 1
S0578e ADPV18A AC POWER ADAPTER 1
S1593g OWNER MANUAL 1
S06024 RC-1730 REMOTE 1
a7187a LTA070B340A TFT LCD 1
S3181 BATTERY CONNECT ASS'Y 1
S3153 RCA CORD VIDEO 1
S3154 RCA CORD AUDIO 1
S3589 SPEAKER CONNECT WIRE 2
S3590 TFT EARTHING WIRE 1
S3545 HV POWER CONNECT WIRE 1
S3431 D5820 LITHIUM BATTERY CATHODE CONNECT WIRE 1
S3592a DVD1731 LITHIUM BATTERY PUTPUT WIRE 1
S3501 FFC-0.5-24-130 1
S3098 DVD960 S-VIDEO WIER 1
S4353 EARPHONE 1
S3633 TFT SIGNAL WIRE 1
ELECTRICAL PARTS LIST
SDP1731

REF No. PART No. PART NAME REF No. PART No. PART NAME
R142 P11015 Resistor chip 15K
¡
R143 P11006 Resistor chip 100
¡
R1 P11038 Resistor chip 39K
¡
R144 P11058 Resistor chip 200K
¡
R2 P11040 Resistor chip 68K
¡
R145 P11008 Resistor chip 470
¡
R3 P11029 Resistor chip 2.2K
¡
R146 P11008 Resistor chip 470
¡
R4 P11029 Resistor chip 2.2K
¡
R147 P11040 Resistor chip 68K
¡
R5 P11029 Resistor chip 2.2K
¡
R148 P11040 Resistor chip 68K
¡
R6 P11029 Resistor chip 2.2K
¡
R149 P11040 Resistor chip 68K
¡
R7 P11013 Resistor chip 10K
¡
R150 P11040 Resistor chip 68K
¡
R8 P11038 Resistor chip 39K
¡
R151 P11142 Resistor chip 6.2K
¡
R9 P11038 Resistor chip 39K
¡
R152 P11019 Resistor chip 100K
¡
R01 P11013 Resistor chip 10K
¡
R153 P11035 Resistor chip 20K
¡
R02 P11013 Resistor chip 10K
¡
R180 P11010 Resistor chip 2K
¡
R10 P11038 Resistor chip 39K
¡
R303 P11048 Resistor chip 120ȍ
R11 P11038 Resistor chip 39K
¡
R304 P11048 Resistor chip 120ȍ
R12 P11006 Resistor chip 100
¡
R305 P11048 Resistor chip 120ȍ
R13 P11006 Resistor chip 100
¡
R306 P11118 Resistor chip 75K
¡
R14 P11039 Resistor chip 56K
¡
R307 P11118 Resistor chip 75K
¡
R15 P11039 Resistor chip 56K
¡
R308 P11022 Resistor chip 470K
¡
R16 P11035 Resistor chip 20K
¡
R309 P11118 Resistor chip 75K
¡
R17 P11038 Resistor chip 39K
¡
R310 P11022 Resistor chip 470K
¡
R18 P11034 Resistor chip 18K
¡
R311 P11022 Resistor chip 470K
¡
R19 P11040 Resistor chip 68K
¡
R312 P11004 Resistor chip 33
¡
R20 P11004 Resistor chip 33
¡
R315 P11003 Resistor chip 10
¡
R21 P11004 Resistor chip 33
¡
R319 P11003 Resistor chip 10
¡
R22 P11013 Resistor chip 10K
¡
R322 P11003 Resistor chip 10
¡
R559 P11012 Resistor chip 4.7K
¡
R338 P11003 Resistor chip 10
¡
R560 P11008 Resistor chip 470
¡
R341 P11003 Resistor chip 10
¡
R567 P11006 Resistor chip 100
¡
R401 P11006 Resistor chip 100
¡
R568 P11019 Resistor chip 100K
¡
R402 P11018 Resistor chip 47K
¡
R570 P11071 Resistor chip 220
¡
R405 P11023 Resistor chip 1M
¡
R571 P11013 Resistor chip 10K
¡
R406 P11003 Resistor chip 10
¡
R575 P11013 Resistor chip 10K
¡
R407 P11013 Resistor chip 10K
¡
R577 P11009 Resistor chip 1K
¡
R413 P11003 Resistor chip 10
¡
R580 P11013 Resistor chip 10K
¡
R414 P11019 Resistor chip 100K
¡
R112 P11018 Resistor chip 47K
¡
R415 P11000 Resistor chip 0
¡
R125 P11010 Resistor chip 2K
¡
R417 P11034 Resistor chip 18K
¡
R129 P11000 Resistor chip 0
¡
R419 P11207 Resistor chip 0.5
¡
R140 P11020 Resistor chip 150K
¡
R421 P11207 Resistor chip 0.5
¡
R141 P11142 Resistor chip 6.2K
¡
R425 P11015 Resistor chip 15K
¡
DVD1731 MAIN ASS'Y
RESISTOR

REF No. PART No. PART NAME REF No. PART No. PART NAME
R426 P11000 Resistor chip 0
¡
R487 P11002 Resistor chip 4.7
¡
R428 P11013 Resistor chip 10K
¡
R488 P11002 Resistor chip 4.7
¡
R429 P11035 Resistor chip 20K
¡
R489 P11004 Resistor chip 33
¡
R430 P11035 Resistor chip 20K
¡
R490 P11004 Resistor chip 33
¡
R432 P11002 Resistor chip 4.7
¡
R491 P11004 Resistor chip 33
¡
R433 P11055 Resistor chip 8.2K
¡
R492 P11013 Resistor chip 10K
¡
R434 P11063 Resistor chip 1ȍR494 P11004 Resistor chip 33
¡
R435 P11029 Resistor chip 2.2K
¡
R501 P11018 Resistor chip 47K
¡
R436 P11035 Resistor chip 20K
¡
R502 P11018 Resistor chip 47K
¡
R438 P11122 Resistor chip 750K
¡
R503 P11000 Resistor chip 0
¡
R440 P11035 Resistor chip 20K
¡
R506 P11000 Resistor chip 0
¡
R442 P11038 Resistor chip 39K
¡
R507 P11020 Resistor chip 150K
¡
R443 P11000 Resistor chip 0
¡
R508 P11020 Resistor chip 150K
¡
R444 P11013 Resistor chip 10K
¡
R509 P11013 Resistor chip 10K
¡
R445 P11015 Resistor chip 15K
¡
R510 P11013 Resistor chip 10K
¡
R449 P11013 Resistor chip 10K
¡
R511 P11002 Resistor chip 4.7
¡
R450 P11013 Resistor chip 10K
¡
R512 P11002 Resistor chip 4.7
¡
R451 P11013 Resistor chip 10K
¡
R513 P11032 Resistor chip 5.1K
¡
R452 P11002 Resistor chip 4.7
¡
R514 P11031 Resistor chip 3.9K
¡
R453 P11002 Resistor chip 4.7
¡
R515 P11013 Resistor chip 10K
¡
R454 P11013 Resistor chip 10K
¡
R516 P11019 Resistor chip 100K
¡
R455 P11019 Resistor chip 100K
¡
R517 P11013 Resistor chip 10K
¡
R456 P11009 Resistor chip 1K
¡
R518 P11006 Resistor chip 100
¡
R457 P11023 Resistor chip 1M
¡
R519 P11032 Resistor chip 5.1K
¡
R458 P11013 Resistor chip 10K
¡
R520 P11013 Resistor chip 10K
¡
R459 P11009 Resistor chip 1K
¡
R521 P11031 Resistor chip 3.9K
¡
R460 P11004 Resistor chip 33
¡
R522 P11019 Resistor chip 100K
¡
R462 P11038 Resistor chip 39K
¡
R523 P11013 Resistor chip 10K
¡
R463 P11013 Resistor chip 10K
¡
R524 P11002 Resistor chip 4.7
¡
R464 P11013 Resistor chip 10K
¡
R525 P11003 Resistor chip 10
¡
R465 P11004 Resistor chip 33
¡
R526 P11009 Resistor chip 1K
¡
R470 P11012 Resistor chip 4.7K
¡
R527 P11009 Resistor chip 1K
¡
R471 P11013 Resistor chip 10K
¡
R529 P11006 Resistor chip 100
¡
R472 P11013 Resistor chip 10K
¡
R530 P11006 Resistor chip 100
¡
R473 P11006 Resistor chip 100
¡
R535 P11034 Resistor chip 18K
¡
R476 P11004 Resistor chip 33
¡
R536 P11009 Resistor chip 1K
¡
R481 P11013 Resistor chip 10K
¡
R540 P11013 Resistor chip 10K
¡
R482 P11003 Resistor chip 10
¡
R541 P11013 Resistor chip 10K
¡
R484 P11057 Resistor chip 51K
¡
R542 P11013 Resistor chip 10K
¡
R485 P11018 Resistor chip 47K
¡
R543 P11019 Resistor chip 100K
¡

REF No. PART No. PART NAME REF No. PART No. PART NAME
R544 P11055 Resistor chip 8.2K
¡
C141 P30014 Electrolytic CAP 100uF/16V
R545 P11019 Resistor chip 100K
¡
C142 P30014 Electrolytic CAP 100uF/16V
R546 P11013 Resistor chip 10K
¡
C143 P30014 Electrolytic CAP 100uF/16V
R547 P11055 Resistor chip 8.2K
¡
C149 P20053 Capacitor chip 68pF
R548 P11002 Resistor chip 4.7
¡
C150 P20035 Capacitor chip 1uF
R550 P11024 Resistor chip 330
¡
C152 P20015 Capacitor chip 0.1uF
R551 P11006 Resistor chip 100
¡
C153 P20035 Capacitor chip 1uF
R554 P11009 Resistor chip 1K
¡
C155 P20035 Capacitor chip 1uF
R555 P11009 Resistor chip 1K
¡
C157 P20015 Capacitor chip 0.1uF
R556 P11009 Resistor chip 1K
¡
C158 P20053 Capacitor chip 68pF
R557 P11009 Resistor chip 1K
¡
C160 P20015 Capacitor chip 0.1uF
R558 P11013 Resistor chip 10K
¡
C161 P20015 Capacitor chip 0.1uF
L4 P11002 Resistor chip 4.7
¡
C162 P20015 Capacitor chip 0.1uF
RN419 P11206 Row of resistor 22
¡
C163 P20015 Capacitor chip 0.1uF
C164 P20053 Capacitor chip 68pF
C3 P20015 Capacitor chip 0.1uF C165 P20029 Capacitor chip 330pF
C4 P20012 Capacitor chip 0.01uF C166 P20015 Capacitor chip 0.1uF
C5 P20012 Capacitor chip 0.01uF C167 P20015 Capacitor chip 0.1uF
C6 P20035 Capacitor chip 1uF C168 P20029 Capacitor chip 330pF
C10 P20033 Capacitor chip 200pF C169 P20015 Capacitor chip 0.1uF
C11 P20015 Capacitor chip 0.1uF C173 P20015 Capacitor chip 0.1uF
C12 P20035 Capacitor chip 1uF C174 P20027 Capacitor chip 150pF
C13 P20035 Capacitor chip 1uF C175 P20015 Capacitor chip 0.1uF
C14 P30003 Electrolytic CAP 100uF/6V C176 P20015 Capacitor chip 0.1uF
C15 P31002 Electrolytic CAP 10uF/16V(Ta) C178 P30014 Electrolytic CAP 100uF/16V
C16 P20015 Capacitor chip 0.1uF C179 P30014 Electrolytic CAP 100uF/16V
C17 P20015 Capacitor chip 0.1uF C181 P30014 Electrolytic CAP 100uF/16V
C18 P20009 Capacitor chip 1000pF C182 P30014 Electrolytic CAP 100uF/16V
C20 P20009 Capacitor chip 1000pF C188 P31088 Electrolytic CAP 220uF/6V
C101 P30014 Electrolytic CAP 100uF/16V C303 P30014 Electrolytic CAP 100uF/16V
C102 P20015 Capacitor chip 0.1uF C304 P20002 Capacitor chip 22pF
C110 P30014 Electrolytic CAP 100uF/16V C305 P20033 Capacitor chip 200pF
C112 P30014 Electrolytic CAP 100uF/16V C307 P20033 Capacitor chip 200pF
C115 P20008 Capacitor chip 470pF C308 P20002 Capacitor chip 22pF
C124 P30014 Electrolytic CAP 100uF/16V C310 P20033 Capacitor chip 200pF
C128 P30003 Electrolytic CAP 100uF/6V C311 P20002 Capacitor chip 22pF
C130 P20015 Capacitor chip 0.1uF C312 P31009 Electrolytic CAP 100uF/4V
C131 P30014 Electrolytic CAP 100uF/16V C313 P31009 Electrolytic CAP 100uF/4V
C132 P30014 Electrolytic CAP 100uF/16V C314 P30006 Electrolytic CAP 47uF/4V
C139 P20015 Capacitor chip 0.1uF C315 P31009 Electrolytic CAP 100uF/4V
CAPACITOR

REF No. PART No. PART NAME REF No. PART No. PART NAME
C317 P30004 Electrolytic CAP 220uF/4V C467 P31002 Electrolytic CAP 10uF/16V(Ta)
C318 P30006 Electrolytic CAP 47uF/4V C471 P20051 Capacitor chip 5.1pF
C319 P30006 Electrolytic CAP 47uF/4V C472 P20009 Capacitor chip 1000pF
C320 P30004 Electrolytic CAP 220uF/4V C473 P20051 Capacitor chip 5.1pF
C321 P30004 Electrolytic CAP 220uF/4V C474 P20002 Capacitor chip 22pF
C322 P30014 Electrolytic CAP 100uF/16V C475 P20015 Capacitor chip 0.1uF
C403 P20061 Capacitor chip 0.015uF C476 P30010 Electrolytic CAP 10uF/16V(Al)
C405 P20034j Capacitor chip 390pF C480 P20015 Capacitor chip 0.1uF
C406 P20015 Capacitor chip 0.1uF C493 P30014 Electrolytic CAP 100uF/16V
C408 P20049 Capacitor chip 33000pF C495 P31002 Electrolytic CAP 10uF/16V(Ta)
C412 P31002 Electrolytic CAP 10uF/16V(Ta) C496 P30006 Electrolytic CAP 47uF/4V
C417 P31002 Electrolytic CAP 10uF/16V(Ta) C498 P31002 Electrolytic CAP 10uF/16V(Ta)
C418 P20035 Capacitor chip 1uF C499 P31002 Electrolytic CAP 10uF/16V(Ta)
C419 P20035 Capacitor chip 1uF C500 P31002 Electrolytic CAP 10uF/16V(Ta)
C420 P20035 Capacitor chip 1uF C501 P30006 Electrolytic CAP 47uF/4V
C421 P20035 Capacitor chip 1uF C502 P30006 Electrolytic CAP 47uF/4V
C426 P20009 Capacitor chip 1000pF C503 P30014 Electrolytic CAP 100uF/16V
C427 P20061 Capacitor chip 0.015uF C505 P30006 Electrolytic CAP 47uF/4V
C433 P20061 Capacitor chip 0.015uF C506 P30006 Electrolytic CAP 47uF/4V
C436 P20061 Capacitor chip 0.015uF C507 P30014 Electrolytic CAP 100uF/16V
C437 P20009 Capacitor chip 1000pF C508 P30006 Electrolytic CAP 47uF/4V
C439 P20009 Capacitor chip 1000pF C509 P30006 Electrolytic CAP 47uF/4V
C441 P20027 Capacitor chip 150pF C510 P30002 Electrolytic CAP 47uF/6V
C442 P20027 Capacitor chip 150pF C511 a3690 Electrolytic CAP 220uF/10V
C443 P31088 Electrolytic CAP 220uF/6V C512 P30010 Electrolytic CAP 10uF/16V(Al)
C444 P31002 Electrolytic CAP 10uF/16V(Ta) C513 P30010 Electrolytic CAP 10uF/16V(Al)
C445 P20009 Capacitor chip 1000pF C514 P30014 Electrolytic CAP 100uF/16V
C446 P20012 Capacitor chip 0.01uF C516 P20030 Capacitor chip 2700pF
C447 P20035 Capacitor chip 1uF C517 P20030 Capacitor chip 2700pF
C448 P20012 Capacitor chip 0.01uF C518 P20048 Capacitor chip 300pF
C449 P20012 Capacitor chip 0.01uF C519 P20048 Capacitor chip 300pF
C450 P20012 Capacitor chip 0.01uF C523 P20015 Capacitor chip 0.1uF
C451 P20012 Capacitor chip 0.01uF C528 P20015 Capacitor chip 0.1uF
C452 P20015 Capacitor chip 0.1uF C529 P20015 Capacitor chip 0.1uF
C453 P31002 Electrolytic CAP 10uF/16V(Ta) C530 P20015 Capacitor chip 0.1uF
C455 P20029 Capacitor chip 330pF C531 P30014 Electrolytic CAP 100uF/16V
C456 P20009 Capacitor chip 1000pF C532 P20043 Capacitor chip 3300pF
C457 P20061 Capacitor chip 0.015uF C533 P20043 Capacitor chip 3300pF
C461 P30003 Electrolytic CAP 100uF/6V C534 P30002 Electrolytic CAP 47uF/6V
C466 P20057 Adjustable capacitor C535 P30002 Electrolytic CAP 47uF/6V

REF No. PART No. PART NAME REF No. PART No. PART NAME
C536 P30014 Electrolytic CAP 100uF/16V CB15 P20015 Capacitor chip 0.1uF
C537 P20015 Capacitor chip 0.1uF CB16 P20015 Capacitor chip 0.1uF
C538 P30014 Electrolytic CAP 100uF/16V CB17 P20015 Capacitor chip 0.1uF
C539 P20015 Capacitor chip 0.1uF CB18 P20015 Capacitor chip 0.1uF
C540 P31002 Electrolytic CAP 10uF/16V(Ta) CB19 P20015 Capacitor chip 0.1uF
C541 P31002 Electrolytic CAP 10uF/16V(Ta) CB20 P20015 Capacitor chip 0.1uF
C544 P20064 Capacitor chip 51pF CB21 P20008 Capacitor chip 470pF
C545 P20064 Capacitor chip 51pF CB22 P20015 Capacitor chip 0.1uF
C546 P20015 Capacitor chip 0.1uF CB23 P20015 Capacitor chip 0.1uF
C550 P20059 Capacitor chip 4700pF CB24 P20015 Capacitor chip 0.1uF
C551 P31002 Electrolytic CAP 10uF/16V(Ta) CB25 P20015 Capacitor chip 0.1uF
C552 P31002 Electrolytic CAP 10uF/16V(Ta) CB26 P20015 Capacitor chip 0.1uF
C553 P31002 Electrolytic CAP 10uF/16V(Ta) CB27 P20015 Capacitor chip 0.1uF
C555 P30004 Electrolytic CAP 220uF/4V CB28 P20015 Capacitor chip 0.1uF
C556 P30004 Electrolytic CAP 220uF/4V CB29 P20015 Capacitor chip 0.1uF
C557 P31002 Electrolytic CAP 10uF/16V(Ta) CB30 P20015 Capacitor chip 0.1uF
C559 P31002 Electrolytic CAP 10uF/16V(Ta) CB31 P20015 Capacitor chip 0.1uF
C560 P20015 Capacitor chip 0.1uF CB32 P20015 Capacitor chip 0.1uF
CB1 P20015 Capacitor chip 0.1uF CB33 P20015 Capacitor chip 0.1uF
CB2 P20015 Capacitor chip 0.1uF CB34 P20015 Capacitor chip 0.1uF
CB4 P20015 Capacitor chip 0.1uF CB35 P20015 Capacitor chip 0.1uF
CB5 P20015 Capacitor chip 0.1uF CB36 P20015 Capacitor chip 0.1uF
CB6 P20015 Capacitor chip 0.1uF CB37 P20015 Capacitor chip 0.1uF
CB7 P20015 Capacitor chip 0.1uF CB38 P20015 Capacitor chip 0.1uF
CB8 P20015 Capacitor chip 0.1uF CB39 P20015 Capacitor chip 0.1uF
CB9 P20015 Capacitor chip 0.1uF CB40 P20015 Capacitor chip 0.1uF
CB01 P20015 Capacitor chip 0.1uF CB41 P20015 Capacitor chip 0.1uF
CB02 P20015 Capacitor chip 0.1uF CB42 P20015 Capacitor chip 0.1uF
CB03 P20015 Capacitor chip 0.1uF CB43 P20015 Capacitor chip 0.1uF
CB04 P20015 Capacitor chip 0.1uF CB44 P20015 Capacitor chip 0.1uF
CB05 P20015 Capacitor chip 0.1uF CB45 P20015 Capacitor chip 0.1uF
CB06 P20015 Capacitor chip 0.1uF CB46 P20015 Capacitor chip 0.1uF
CB07 P20015 Capacitor chip 0.1uF CB48 P20015 Capacitor chip 0.1uF
CB08 P20015 Capacitor chip 0.1uF CB52 P20015 Capacitor chip 0.1uF
CB09 P20015 Capacitor chip 0.1uF CB53 P20015 Capacitor chip 0.1uF
CB10 P20015 Capacitor chip 0.1uF CB54 P20015 Capacitor chip 0.1uF
CB11 P20015 Capacitor chip 0.1uF CB55 P20015 Capacitor chip 0.1uF
CB12 P20015 Capacitor chip 0.1uF CB56 P20015 Capacitor chip 0.1uF
CB13 P20015 Capacitor chip 0.1uF CB58 P20015 Capacitor chip 0.1uF
CB14 P20015 Capacitor chip 0.1uF CB63 P20015 Capacitor chip 0.1uF

REF No. PART No. PART NAME REF No. PART No. PART NAME
CB64 P20015 Capacitor chip 0.1uF L302 P6808 1.0uH
CB65 P20015 Capacitor chip 0.1uF L303 P6808 1.0uH
CB47 P20015 Capacitor chip 0.1uF L304 P6681 100uH
CB57 P20015 Capacitor chip 0.1uF L406 P6659 Impedance at 100MHz:600
¡
CB59 P20015 Capacitor chip 0.1uF L407 P6659 Impedance at 100MHz:600
¡
CB70 P20015 Capacitor chip 0.1uF L409 P6817 Impedance at 100MHz:60
¡
CB71 P20015 Capacitor chip 0.1uF L410 P6659 Impedance at 100MHz:600
¡
CB73 P20015 Capacitor chip 0.1uF L416 P6659 Impedance at 100MHz:600
¡
CB74 P20015 Capacitor chip 0.1uF L419 P6659 Impedance at 100MHz:600
¡
CB77 P20015 Capacitor chip 0.1uF L420 P6659 Impedance at 100MHz:600
¡
CB82 P20015 Capacitor chip 0.1uF L430 P6659 Impedance at 100MHz:600
¡
CB86 P20015 Capacitor chip 0.1uF L435 P6659 Impedance at 100MHz:600
¡
CB87 P20015 Capacitor chip 0.1uF L501 P6659 Impedance at 100MHz:600
¡
CB91 P20009 Capacitor chip 1000pF L502 P6681 100uH
CB92 P20015 Capacitor chip 0.1uF L503 P6659 Impedance at 100MHz:600
¡
CB95 P20015 Capacitor chip 0.1uF L504 P6659 Impedance at 100MHz:600
¡
CB96 P20015 Capacitor chip 0.1uF L600 a7369 LGA0307TB-100K
CB98 P20015 Capacitor chip 0.1uF FB101 P6659 Impedance at 100MHz:600
¡
FB102 P6659 Impedance at 100MHz:600
¡
EM302 P60006 FK2125T186AL FB103 P6659 Impedance at 100MHz:600ȍ
EM401 P60006 FK2125T186AL FB104 P6659 Impedance at 100MHz:600ȍ
EM402 P60006 FK2125T186AL
EM407 P60006 FK2125T186AL VD3 P5073a 2SD601AR
EM503 P60006 FK2125T186AL VD4 P5073a 2SD601AR
EM504 P60006 FK2125T186AL VD5 P5702 XN4601
EM506 P60006 FK2125T186AL VD6 P5702 XN4601
EM507 P60006 FK2125T186AL VD101 P1219 1N5402T
L3 P6659 Impedance at 100MHz:600
¡
VD106 P90092 UPC29M05T-E1
L101 P60003 33uH VD107 P90072 BA033FP
L102 P60003 33uH VD110 P5722 RB060L-40
L105 P6659 Impedance at 100MHz:600
¡
VD111 P5722 RB060L-40
L120 P6681 100uH VD115 P1219 1N5402T
L125 P6659 Impedance at 100MHz:600
¡
VD120 P5709 DTC124EUAT106
L130 P6679 10uH VD122 P5700 2SB709AR
L131 P60039 470uH VD123 P1556 MA152
L132 P60039 470uH VD125 P5073a 2SD601AR
L133 P6679 10uH VD126 P1556 MA152
L137 P6681 100uH VD127 P5073a 2SD601AR
L140 P60003 33uH VD128 P1556 MA152
L301 P6808 1.0uH VD129 P90277 TPS60400
INDUCTOR
TRANSISTOR

REF No. PART No. PART NAME REF No. PART No. PART NAME
VD401 P1200 1SS355TE Switch Diode N1 P4592 TL1453CPW
VD402 P5714 FMC3AT148 N008 P90090 PQ05DZ11
VD403 P5714 FMC3AT148 N102 P5759 IRF7304
VD404 P5067 KTA1298 N106 P90090 PQ05DZ11
VD406 P5067 KTA1298 N112 P90015 TPS5100IPWR
VD407 P5067 KTA1298 N302 P90110 BA7660FS
VD410 P1200 1SS355TE Switch Diode N401 P90205 D2891
VD411 P1200 1SS355TE Switch Diode N402 P90007 BA5954FP
VD420 P5067 KTA1298 N403 P4581 TC4W53FU
VD503 P5709 DTC124EUAT106 N406 a6733 HS0038B
VD504 P5769 2SB1561T100Q N409 P4516 74HCU04
VD509 P5073a 2SD601AR N412 P90157 MX29LV008TTC-90
VD510 P5073a 2SD601AR N413 P4620a BR24C02F-WE2
VD520 P5073a 2SD601AR N417 P90129 PCM1742
VD521 P1200 1SS355TE Switch Diode N419 P90074 NT56V6620COT-75S
VD522 P1200 1SS355TE Switch Diode N501 P4530 NJM4558
VD523 P1200 1SS355TE Switch Diode N502 P4513 NJM4580
VD524 P5067 KTA1298 N503 P4535 CD2822CB
VD525 P1200 1SS355TE Switch Diode N508 P4530 NJM4558
VD526 P1200 1SS355TE Switch Diode N509 P90204 D2881
VD535 P5766 STZ6.2NT146
VD536 P5766 STZ6.2NT146 XS1 P60041 53261-0390 3P SOCKET
VD537 P5766 STZ6.2NT146 XS401 P60061 53261-0690 6P SOCKET
VD538 P5766 STZ6.2NT146 XS402 P6971 FPL0.5B-SMT-24 24P SOCKET
VD539 P5766 STZ6.2NT146 XS403 P60081 53261-0890 8P SOCKET
VD540 P5714 FMC3AT148 XS405 P6981 MOLEX-53261-0490
JS2 P60083 SM20B-SURS-TF SOCKET
F101 P60047 FUSE 452003 JS101 a6663a HEC3600-010110 SOCKET
JS301 a6662 HSJ1715-01-110 SOCKET
FM102 a6916 LV-R0489 FILTER JS302 a6674 HSJ1456-010335 SOCKET
JS402 a6704 HSJ1494-01-010 SOCKET
G401 a6603a 27.000MHz JS502 a7221 GPIFD310TP
JS503 a6704 HSJ1494-01-010 SOCKET
VR2 a0654 WHE10xB-2-20K
SW101 P60078 SSSS710603 R1 P11022 Resistor chip 470K
¡
SW102 a6683 ESE11SV1 R4 P11053 Resistor chip 5.6K
¡
SW103 a6683 ESE11SV1 R5 P11003 Resistor chip 10
¡
SW401 a6846 2W4D-3.5 R6 P11022 Resistor chip 470K
¡
R7 P11013 Resistor chip 10K
¡
POTENTIOMETERS
FILTER
CRYSTAL OSCILLATOR
RESISTOR
FUSE
IC
DVD1731T(PA) TFT ASS'Y
SOCKET
SWITCH

REF No. PART No. PART NAME REF No. PART No. PART NAME
R8 P11013 Resistor chip 10K
¡
R70 P11000 Resistor chip 0
¡
R9 P11000 Resistor chip 0
¡
R72 P11000 Resistor chip 0
¡
R10 P11015 Resistor chip 15K
¡
R73 P11012 Resistor chip 4.7K
¡
R11 P11035 Resistor chip 20K
¡
R74 P11011 Resistor chip 3.3K
¡
R12 P11018 Resistor chip 47K
¡
R75 P11018 Resistor chip 47K
¡
R13 P11074 Resistor chip 180K
¡
R76 P11040 Resistor chip 68K
¡
R14 P11013 Resistor chip 10K
¡
R77 P11029 Resistor chip 2.2K
¡
R17 P11041 Resistor chip 82K
¡
R78 P11006 Resistor chip 100
¡
R18 P11058 Resistor chip 200K
¡
R79 P11036 Resistor chip 22K
¡
R19 P11041 Resistor chip 82K
¡
R80 P11023 Resistor chip 1M
¡
R20 P11013 Resistor chip 10K
¡
R81 P11000 Resistor chip 0
¡
R21 P11006 Resistor chip 100
¡
R85 P11037 Resistor chip 27K
¡
R22 P11023 Resistor chip 1M
¡
R100 P11000 Resistor chip 0
¡
R23 P11013 Resistor chip 10K
¡
R102 P11024 Resistor chip 330
¡
R24 P11011 Resistor chip 3.3K
¡
R103 P11040 Resistor chip 68K
¡
R25 P11032 Resistor chip 5.1K
¡
R104 P11012 Resistor chip 4.7K
¡
R26 P11053 Resistor chip 5.6K
¡
R107 P11017 Resistor chip 33K
¡
R29 P11000 Resistor chip 0
¡
R108 P11015 Resistor chip 15K
¡
R31 P11000 Resistor chip 0
¡
R109 P11059 Resistor chip 330K
¡
R34 P11000 Resistor chip 0
¡
R110 P11005 Resistor chip 75
¡
R37 P11000 Resistor chip 0
¡
R112 P11004 Resistor chip 33
¡
R39 P11053 Resistor chip 5.6K
¡
R113 P11004 Resistor chip 33
¡
R40 P11053 Resistor chip 5.6K
¡
R116 P11012 Resistor chip 4.7K
¡
R41 P11050 Resistor chip 560
¡
R120 P11006 Resistor chip 100
¡
R42 P11000 Resistor chip 0
¡
R166 P11003 Resistor chip 10
¡
R43 P11006 Resistor chip 100
¡
C76 P11000 Resistor chip 0
¡
R45 P11000 Resistor chip 0
¡
C77 P11000 Resistor chip 0
¡
R46 P11000 Resistor chip 0
¡
C78 P11000 Resistor chip 0
¡
R48 P11000 Resistor chip 0
¡
L12 P11000 Resistor chip 0
¡
R49 P11000 Resistor chip 0
¡
L13 P11000 Resistor chip 0
¡
R50 P11006 Resistor chip 100
¡
RN4 P1006 Row of resistor 100
¡
R57 P11000 Resistor chip 0
¡
RN5 P1006 Row of resistor 100
¡
R58 P11000 Resistor chip 0
¡
RN6 P1006 Row of resistor 100
¡
R61 P11000 Resistor chip 0
¡
RN7 P1006 Row of resistor 100
¡
R62 P11000 Resistor chip 0
¡
R64 P11000 Resistor chip 0
¡
C1 P31002 Electrolytic CAP 10uF/16V(Ta)
R66 P11000 Resistor chip 0
¡
C2 P20003 Capacitor chip 27pF
R67 P11010 Resistor chip 2K
¡
C3 P31002 Electrolytic CAP 10uF/16V(Ta)
R68 P11013 Resistor chip 10K
¡
C4 P20084 Capacitor chip 0.15uF
R69 P11000 Resistor chip 0
¡
C6 P20015 Capacitor chip 0.1uF
CAPACITOR

REF No. PART No. PART NAME REF No. PART No. PART NAME
C8 P20035 Capacitor chip 1uF C62 P20015 Capacitor chip 0.1uF
C9 P20035 Capacitor chip 1uF C63 P20012 Capacitor chip 0.01uF
C10 P20035 Capacitor chip 1uF C64 P20015 Capacitor chip 0.1uF
C11 P20085 Capacitor chip 2.2uF C65 P20015 Capacitor chip 0.1uF
C12 P20085 Capacitor chip 2.2uF C66 P20015 Capacitor chip 0.1uF
C13 P20085 Capacitor chip 2.2uF C67 P20015 Capacitor chip 0.1uF
C15 P20012 Capacitor chip 0.01uF C68 P20015 Capacitor chip 0.1uF
C16 P20015 Capacitor chip 0.1uF C69 P20015 Capacitor chip 0.1uF
C17 P20085 Capacitor chip 2.2uF C70 P20015 Capacitor chip 0.1uF
C18 P20040 Capacitor chip 680pF C71 P20015 Capacitor chip 0.1uF
C19 P20040 Capacitor chip 680pF C72 P31002 Electrolytic CAP 10uF/16V(Ta)
C20 P20013 Capacitor chip 0.022uF C73 P20035 Capacitor chip 1uF
C21 P20013 Capacitor chip 0.022uF C74 P20035 Capacitor chip 1uF
C22 P20085 Capacitor chip 2.2uF C75 P20035 Capacitor chip 1uF
C23 P20015 Capacitor chip 0.1uF C79 P31002 Electrolytic CAP 10uF/16V(Ta)
C24 P20002 Capacitor chip 22pF C80 P20084 Capacitor chip 0.15uF
C25 P20015 Capacitor chip 0.1uF C81 P20009 Capacitor chip 1000pF
C26 P20015 Capacitor chip 0.1uF C82 P20009 Capacitor chip 1000pF
C27 P20091 Capacitor chip 0.02uF C83 P20084 Capacitor chip 0.15uF
C28 P20085 Capacitor chip 2.2uF C84 P20084 Capacitor chip 0.15uF
C29 P20086 Capacitor chip 3pF C101 P20039 Capacitor chip 82pF
C30 P20051 Capacitor chip 5.1pF C113 P20015 Capacitor chip 0.1uF
C31 P20015 Capacitor chip 0.1uF
C32 P20015 Capacitor chip 0.1uF VR1 P0620 POZ3AN-1-503N-T00
C33 P20015 Capacitor chip 0.1uF
C34 P20046 Capacitor chip 560pF L1 P60034 2.7uH
C35 P20015 Capacitor chip 0.1uF L2 P6698 33uH
C36 P20042 Capacitor chip 2200pF L3 P6659 Impedance at 100MHz:600
¡
C37 P20009 Capacitor chip 1000pF L4 P6659 Impedance at 100MHz:600
¡
C38 P20015 Capacitor chip 0.1uF L5 P6699 22uH
C45 P20015 Capacitor chip 0.1uF L8 P6699 22uH
C46 P31002 Electrolytic CAP 10uF/16V(Ta) L9 P6699 22uH
C47 P31002 Electrolytic CAP 10uF/16V(Ta) L10 P6699 22uH
C48 P31002 Electrolytic CAP 10uF/16V(Ta) L14 P60034 2.7uH
C49 P31002 Electrolytic CAP 10uF/16V(Ta)
C50 P31002 Electrolytic CAP 10uF/16V(Ta) VD1 P5706 DTC144EUAT106
C51 P20085 Capacitor chip 2.2uF VD3 P1214 MA355
C55 P31002 Electrolytic CAP 10uF/16V(Ta) VD4 P5073a 2SD601AR
C57 P31002 Electrolytic CAP 10uF/16V(Ta) VD5 P5073a 2SD601AR
C58 P20015 Capacitor chip 0.1uF VD6 P5073a 2SD601AR
TRANSISTOR
POTENTIOMETERS
INDUCTOR