Travis Industries 616 GSR Driftwood Log Set 2 User manual


616 GSR Driftwood Log Set 2
Installation Instructions (SKU94500950)


Page 1 of 12 17601916 — 10/30/15 © Travis Industries, Inc.
WARNINGS
MakesurethegascontrolvalveisOFFandtheheateriscoolpriortoconductingservice.
Failuretopositionthepartsinaccordancewiththesediagramsorfailuretouseonlypartsspecificallyapprovedwiththis
appliancemayresultinpropertydamageorpersonalinjury.
Ifusingpropane(LP),converttheappliancebeforeinstallingthelogs(seetheownersmanualfordetails).
Compatibility
616GSR
Packing List
LogSet(9logs,3stones)




RearAirDeflector,RearLog
Support

BagofRockWool,BagofEmbers
Burner Installation
NOTE:Theinsertshouldbeinplace,withthegaslineandventattachedandthefirebacksinstalled(seeowner’smanualfor
furtherdetails).
1. Removetherearburner.
 

Removethisscrew
(
1
/
4”nutdriver
)
.


616 GSR Driftwood Log Set 2
Installation Instructions (SKU94500950)


Page 2 of 12 17601916 — 10/30/15 © Travis Industries, Inc.
2. Removethe3screwsfromthebackoftherearburnerusinga¼”nutdriver.
 
3. Attachtherearairdeflectortotherearburnerwiththescrewsremovedinthepreviousstep.
 
4. Replacetherearburnerandsecurewiththeattachmentscrew.


Thetwotabsontherear
burnerrestontopofthe
frontburner.


616 GSR Driftwood Log Set 2
Installation Instructions (SKU94500950)


Page 3 of 12 17601916 — 10/30/15 © Travis Industries, Inc.
5. Installtherearlogshelf.





616 GSR Driftwood Log Set 2
Installation Instructions (SKU94500950)


Page 4 of 12 17601916 — 10/30/15 © Travis Industries, Inc.
Rock Wool Placement
6. Placetherockwoolasfollows:
a. Brushtherockwoolusingastiffbrushinaloose,gauze‐likelayer.

TIP:Holdtherockwoolinatightwadwithonehandwhilebrushingwiththeother.
 
Notehowtherockwoolisapproximately1/8”thickovertheburnerports.
TIP:Feelfreetoapplyagenerousamountofrockwooltogainadarkerflameandabrightercoalbed.





616 GSR Driftwood Log Set 2
Installation Instructions (SKU94500950)


Page 5 of 12 17601916 — 10/30/15 © Travis Industries, Inc.
Log and Stone Placement
Thelogsarefragile,especiallyafterbeingexposedtoheat.
Theburnermustbecorrectlypositionedbeforeinstallingthelogs.Makesuretheburnerisfullyseated.
7. Placetherearlogasshownbelow.

 
 


NOTE: On LP inserts, push
the log to the back. On NG
inserts, pull the log forward.


616 GSR Driftwood Log Set 2
Installation Instructions (SKU94500950)


Page 6 of 12 17601916 — 10/30/15 © Travis Industries, Inc.
8. Placetheleftmiddlelogasshownbelow.
 
 
9. Placetherightmiddlelogasshownbelow.
 
 



616 GSR Driftwood Log Set 2
Installation Instructions (SKU94500950)


Page 7 of 12 17601916 — 10/30/15 © Travis Industries, Inc.
10. Placeafewembersoverthegapbetweenthetwomiddlelogs.Youmaywishtoflattentheemberbeforeplacement.
  
11. Placethefrontlogasshown.
 
 



616 GSR Driftwood Log Set 2
Installation Instructions (SKU94500950)


Page 8 of 12 17601916 — 10/30/15 © Travis Industries, Inc.
12. Placethe#24stoneasshown.Notehowitrestsontheflatportionoftheleftlogwiththenumberfacingtotherear.

 
13. Placethelogshardasshown.Notehowitrestsontheflatportionoftherightlogwiththesplinterfacingtotheleft.

 


616 GSR Driftwood Log Set 2
Installation Instructions (SKU94500950)


Page 9 of 12 17601916 — 10/30/15 © Travis Industries, Inc.
14. Twoidenticaltwigsareincludedwiththelogset.Placethefirsttwiguprightontheleftsideasshownbelow.Thesecondtwigrests
onthefirsttwigandtheleftlog.

 
 



616 GSR Driftwood Log Set 2
Installation Instructions (SKU94500950)


Page 10 of 12 17601916 — 10/30/15 © Travis Industries, Inc.
15. Twoidenticaltwistedtwigsareincludedwiththelogset.Placethefirsttwiguprightontherightsideasshownbelow.Thesecond
twigrestsononeofthetwigsandtheflatportionoftherearlog.

 
 




616 GSR Driftwood Log Set 2
Installation Instructions (SKU94500950)


Page 11 of 12 17601916 — 10/30/15 © Travis Industries, Inc.
16. Theremainingtwostones(#10and#16)areplacedatthefrontofthefireboxashshownbelow.

 
Thelogset,wheninstalledappearsasbelow:
 



616 GSR Driftwood Log Set 2
Installation Instructions (SKU94500950)


Page 12 of 12 17601916 — 10/30/15 © Travis Industries, Inc.
17. Placeembersinarandompatternalongthefrontedgeofthefireboxasshownbelow.Donotplaceembersoveranyburnerports.
 
18. Checktheexhaustrestrictorsettingbeforefinalizingtheinstallation.
Restrictor Settings
Driftwood Logs
Natural Gas Short Vent
(25’ or less)#1
Natural Gas Tall Vent
(25’ or more)#3 (stock)
Propane Short Vent
(25’ or less)#1
Propane Tall Vent
(25’ or more)#3 (stock)

19. Theinsertshouldbetest‐burnedwiththeglassframeinplacepriortoleavingtheinstallation.Seetheowner’smanualfordetails
onfinalizingtheinstallation(adjustingtheairshutter,etc.).



