Trimline Fires Trimline 140 Panoramic User manual

Trimline 140 Panoramic/Corner Left/Corner Right DB 1140/1141/1142
Trimline 120 Panoramic/Corner Left/Corner Right DB 1145/1146/1147
Trimline 100 Panoramic/Corner Left/Corner Right DB 1156/1157/1158
GBR-IER
INSTALLATION INSTRUCTIONS

Trimline 100-120-140Installation instruction 2
CONTENTS



The Netherlands

 V151019
 
 
 
 
 
 4
 4
 5
 5
 
 7
 8
 14
 15
 15
 15
 15
 
 
 17
 18
 
19
 21
 22
 
 24
 25
 27
  29
 

Trimline 100-120-140Installation instruction 
1 INSTALLATION INSTRUCTIONS
NOTICE


1.1 General instructions
• 


• 


• 




• 




• 


• 




• 

• 
• 




NOTICE
10 Cleaning and maintenace
Distance to ammable materials:




Distance to non-ammable materials:


WARNING








NOTICE






2 PLACING THE APPLIANCE
NOTICE

8 Concentric ue system.
2.1 Connection the gas lines











2.2 Preparation and installation

• 

• 














Trimline 100-120-140Installation instruction 4



NOTICE


• 

• 
• 
1
• 

• 

• 
holders 2
• 

• 


3 

• 


• 

•Situate the unit 
4
• 
5
• 
• 




2.3. Installing gas control GV60.
• 
the ceiling 



NOTICE


2.3 Installing gas control GV60




• 

1

• 
2
• 3and



• 


• 
and also secure it as indicated 4 5 6
• 


7
• 


8
3 PLACEMENT OF THE CERAMIC LOG
• 

• 
 2
• 



 3



NOTE








NOTICE



5
5
1
15
5
1
1

4
4
1
1
2

Trimline 100-120-140Installation instruction 5
3.1 Fitting the ceramic log set

• 




• 

• 

• 

• 7 Concentric chimney lay out. If there is a


 6
• 
 6
• 
2.2 Preparation and installation en 
• 



NOTICE

7Concentric chimney lay out
3.2 Installation of the front window
NOTICE






• 

• 
1

• 
2
3
• 

• 
• 
4
• 
5

• 

1
• 
6

• 


• 
• 


B
A
E
D


B
A
DE
Trimline 100-120-140Installation instruction 
4 TECHNICAL DETAILS GV60
Gas valve type 
Burner control 
Ignition 
Gas connection  A B C
D E
Unit category 
Pilot ame 
Security 
WARNING
Sealed parts must not be adjusted.
Gas inlet front
Gas outlet





 
Gas inlet rear

connection
Piezo connection



Pilot light
connection

Trimline 100-120-140Installation instruction 7
5 INSTRUCTIONS FOR MERTIK MAXITROL GV60 GASCONTROL
WARNING













Heat, moisture and dust are a threat to all
electroniccomponents




WARNING












Only place the batteries AFTER WIRING to the receiver,
gascontrol block and pilot set is connected.


Ensure that the ignition cable is not near the antenna wire
andthat they do not cross each other.



NOTICE





















ON
The I/0I
SPARK









NOTICE







Trimline 100-120-140Installation instruction 8
6 GAS TECHNICAL DATA
Type of indication(s)
Appliance
Concentric ues system
Gastype
Prepressure in mBar
Country
Category
Primary air
Pre pressure mbar
Burner pressure high mbar
Burner pressure low mbar
Injector size Ø mm
Inj. Pilot burner CODE
Low settings size mm
Load Hs kW
Load Hi kW
Consumption m³/h
Nom. Power high kW
Nom. Power low kW
NOx EN613 class
Efciency Class EN613
Useful output (NCV) system **
At nominal heat output %
At minimal heat output %
Additional electricity consumption
Nominal kWh
Stand-by kWh
Energy efciency ***
Energy efciency index EEI
Energy label
NOx Hs mg/kWh
Type of heat output/room temperature control
 No
 No
 No
 No
 
 
 
Other control options
 
 
 



Trimline 140 Panoramic/Corner (1140/1141/1142)
C11, C31, C91
Holetherm CC 100-150
  G20 
25 20 20 
NL DE 




I2EK
I2
I2ELL I22E I2E+
   
25 20 20 
   
   
   
51 51 51 51
   
   
   
   
  11 11
   
5 5 5 5
2 2 2 2
77 77  
   
0 0 0 0
0 0 0 0
78 75 77 77
D 
   

Trimline 100-120-140Installation instruction 9
Type of indication(s)
Appliance
Concentric ues system
Gastype
Prepressure in mBar
Country
Category
Primary air
Pre pressure mbar
Burner pressure high mbar
Burner pressure low mbar
Injector size Ø mm
Inj. Pilot burner CODE
Low settings size mm  
Load Hs kW
Load Hi kW
Consumption m³/h
Nom. Power high kW
Nom. Power low kW
NOx EN613 class
Efciency Class EN613
Useful output (NCV) system **
At nominal heat output %
At minimal heat output %
Additional electricity consumption
Nominal kWh
Stand-by kWh
Energy efciency ***
 EEI

 
Type of heat output/room temperature control:
 No
 No
 No
 No
 
 
 
Other control options:
 
 
 



Trimline 140 Panoramic/Corner (1140/1141/1142)
C11, C31, C91
Holetherm CC 100-150
 
 




I+ I
 
 
 
 
 
 
 
 
 
 
 
5 5
2 2
77 77
 
0 0
0 0
77 77
 
 

Trimline 100-120-140Installation instruction 10
Type of indication(s)
Appliance
Concentric ues system
Gastype
Prepressure in mBar
Country
Category
Primary air
Pre pressure mbar
Burner pressure high mbar
Burner pressure low mbar
Injector size Ø mm
Inj. Pilot burner CODE
Low settings size mm
Load Hs kW
Load Hi kW
Consumption m³/h
Nom. Power high kW
Nom. Power low kW
NOx EN613 class
Efciency Class EN613
Useful output (NCV) system **
At nominal heat output %
At minimal heat output %
Additional electricity consumption
Nominal kWh
Stand-by kWh
Energy efciency ***
Energy efciency index EEI
Energy label
NOx Hs mg/kWh
Type of heat output/room temperature control
 No
 No
 No
 No
 
 
 
Other control options
 
 
 



Trimline 120 Panoramic/Corner (1145/1146/1147)
C11, C31, C91
Holetherm CC 100-150
  G20 
25 20 20 
NL DE 




I2EK
I2
I2ELL I22E I2E+
   
25 20 20 
   
   
   
51 51 51 51
   
   
   
   
   
5  
5 5 5 5
2 2 2 2
  80 80
72 72 72 72
0 0 0 0
0 0 0 0
79 78 80 80
   
   

Trimline 100-120-140Installation instruction 11
Type of indication(s)
Appliance
Concentric ues system
Gastype
Prepressure in mBar
Country
Category
Primary air
Pre pressure mbar
Burner pressure high mbar
Burner pressure low mbar
Injector size Ø mm
Inj. Pilot burner CODE
Low settings size mm
Load Hs kW
Load Hi kW
Consumption m³/h
Nom. Power high kW
Nom. Power low kW
NOx EN613 class
Efciency Class EN613
Useful output (NCV) system **
At nominal heat output %
At minimal heat output %
Additional electricity consumption
Nominal kWh
Stand-by kWh
Energy efciency ***
 EEI

 
Type of heat output/room temperature control:
 No
 No
 No
 No
 
 
 
Other control options:
 
 
 



Trimline 120 Panoramic/Corner (1145/1146/1147)
C11, C31, C91
Holetherm CC 100-150
 
 




I+ I
 
 
 
 
 
 
 
 
 
 
 
4 4
5 5
2 2
75 75
 
0 0
0 0
75 75
D D
 

Trimline 100-120-140Installation instruction 12
Type of indication(s)
Appliance
Concentric ues system
Gastype
Prepressure in mBar
Country
Category
Primary air
Pre pressure mbar
Burner pressure high mbar
Burner pressure low mbar
Injector size Ø mm
Inj. Pilot burner CODE
Low settings size mm
Load Hs kW
Load Hi kW
Consumption m³/h
Nom. Power high kW
Nom. Power low kW
NOx EN613 class
Efciency Class EN613
Useful output (NCV) system **
At nominal heat output %
At minimal heat output %
Additional electricity consumption
Nominal kWh
Stand-by kWh
Energy efciency ***
Energy efciency index EEI
Energy label
NOx Hs mg/kWh
Type of heat output/room temperature control
 No
 No
 No
 No
 
 
 
Other control options
 
 
 



Trimline 100 Panoramic/Corner (1156/1157/1158)
C11, C31 ,C91
Holetherm CC 100-150
  G20 
25 20 20 
NL DE 




I2EK
I2
I2ELL I22E I2E+
   
25 20 20 
 14 14 
   
2 2 2 2
51 51 51 51
   
   
   
   
   
   
5 5 5 5
2 2 2 2
75 75  
   
0 0 0 0
0 0 0 0
75 75  
D D D D
120 120  

Trimline 100-120-140Installation instruction 
Type of indication(s)
Appliance
Concentric ues system
Gastype
Prepressure in mBar
Country
Category
Primary air
Pre pressure mbar
Burner pressure high mbar
Burner pressure low mbar
Injector size Ø mm
Inj. Pilot burner CODE
Low settings size mm
Load Hs kW
Load Hi kW
Consumption m³/h
Nom. Power high kW
Nom. Power low kW
NOx EN613 class
Efciency Class EN613
Useful output (NCV) system **
At nominal heat output %
At minimal heat output %
Additional electricity consumption
Nominal kWh
Stand-by kWh
Energy efciency ***
 EEI

 
Type of heat output/room temperature control:
 No
 No
 No
 No
 
 
 
Other control options:
 
 
 



Trimline 100 Panoramic/Corner (1156/1157/1158)
C11, C31, C91
Holetherm CC 100-150
 
 




I+ I
 
 
 
 
 
 
 
 
 
 
 
 
5 5
2 2
 
 
0 0
0 0
84 84
B B
 

Y
1 m min.
Y
X
Y
X
YX1
X
X
X1
X2
1 m min.
X
A
D
E
B

Trimline 100-120-140Installation instruction 14
7 CONCENTRIC CHIMNEY LAY OUT


Table of concentric chimney lay out
Traject Gas Illustration X total in meter Y total in meter Restriction
X = vertical and Y = horizontal Min* Max* Min* Max* Panoramic/Corner
  A-B 1 0 
   2 12 0 0 
  D12 0 4 
  E 1 12 0 2 




Ø


Restriction conditions all gas types
Vertical lay out
Distance Appliance Bafe plate
NG/LPG
Restriction
NG
Restriction
LPG
1 - 12 meter    80mm
1 - 12 meter    
1 - 12 meter   55mm 50mm
Restriction determination based on horizontal runs
Horizontal max
meter
Length max horizontal Bafe plate
NG/LPG
Restriction
NG
Restriction
LPG
NG LPG Appliance
      80mm
    None None None
      
    None None None
     55mm 50mm
    None None None

Trimline 100-120-140Installation instruction 15
8 CONCENTRIC FLUE SYSTEM





8.1 Components of the concentric
uesystem


Through the roof face and through theexterior wall


conditions:
• 

9 Concentric chimney
lay out
• 
• 
• 


• 
NOTICE






8.2 Construction of concentric ue system
Indirect wall connection
• 


NOTICE




• 







• 


• 



• 


Rooftermination
• 


• 




•One needs to take into account the regulation regarding




• 





• 



8.3 Installation instructions regarding
existing ues

Instructions












Trimline 100-120-140Installation instruction 
8.4 Parts


Appendix 3
Installation examples regarding ues
NOTE

4
5
8
8.5 Installation
• 6
• 5

• 5

• 

• 8to the


• 8to the


•Install the roof terminal J
9
• 5
4


• 

• 


• 2

4

Trimline 100-120-140Installation instruction 17
9 TERMINAL POSITIONS AND CORRECT FUNCTIONING
Dimensions Outlet positions Distance mm
A Room*
B Room*
  Room*
D 500
E Under the eaves 500
F 500
G 
Inside and outside a corner 500
I 1000
 500
  Room*
K Roof drain centre to centre 1000
L 450
  1000
N 1000

Plot boundary
External extension pipe
Roof pass-through

Trimline 100-120-140Installation instruction 18
10 CLEANING AND MAINTENANCE












 
 

 

 








 
Glass holder
Anti Reective glass; AR glass cleaning
instructions 
General






NOTICE

Important




Only use

Procedure
• 

• 

• 
• 
• 
• 

• 
• 

Important






Information







Trimline 100-120-140Installation instruction 19
11 QUICK REFERENCE GUIDE FOR FAULTSSEARCH FOR ENCLOSED
GAS FIRES USING MERTIK GV60 GASCONTROL
Function Possible cause Solution
  0 I
 
 

 
 

 
 
  
 
 
Defective receiver 
 
  



control and gas valve

gas valve


   
 
 

 
   

 

 
 
 
Pilot light head damaged 
   






 
 



minimum
 

 
 

 
False air hatches 
closed
 
regulations

Trimline 100-120-140Installation instruction 20
Function Possible cause Solution
   
correct



 

 
instructions
 
 
  
  

 

 

 
  
 
correct values


 
instructions
  


 


correct value



instructions
 

 

 
 