Unilamp QUARK Square - Asymmetric User manual

1/7
INSTALLATION MANUAL
IP67
No.
Ordering Code
1.
PRODUCT NAME : QUARK Square - Asymmetric
QUARK Square - Bi-Symmetric
9041-1-3/4/5-907-91
2.
3.
4.
3
OD-9042
OD-9041
176
176
9041-1-3/4/5-929-91
9042-7-3/4/5-907-91
9042-7-3/4/5-929-91
Light Emitting Diodes
(LED)
370
420
180 370
370
420
180 370
2
2.1
450
450
Glass Temperature
At Ta 40°C
60.3° C
60.3° C
60.3° C
60.3° C
1
2.2
Last Revised On : 23/11/2022 REV.05
Input voltage
220-240V
~
50-60Hz
FR-DM-17 REV.03 EFF 15/09/17
1-4

2/7
5
Torque/áçºÔ´ : 1.0 Nm.
IP67 COnnection box available separately.
¡Åͧá¡ÊҠᡨíÒ˹ÒÂ
Ordering Code/ÃËÑÊÊÑ觫×éÍ : 0066-0-9-000-00
5.1
5.2
5.3
Cable size : 3x1.00 mm. 8-13mm.
¢¹Ò´ÊÒÂä¿
306
256
2
6
Installation complete
¡ÒõԴµÑé§àÊÃç¨ÊÁºÙó
7
4
Cable pipe
·ÍÊÒÂä¿
Water drainage pipe
·͹éíÒ·Ôé§
Top view
4.1
4.2
Please note the
ground level.
¢ͤÇÃÃÐÇѧ: ¼ÔÇ˹Ò
¢Í§µÑÇâ¤Á¡Ñº¼ÔǾ×é¹
¤ÇÃÍÂÙã¹ÃйҺà´ÕÂǡѹ
6.1
6.2
6.3
Torque/áçºÔ´ : 9.0 Nm.
1
2
3
4
Lock the screws
following this sequence.
¤ÇâѹʡÃÙµÒÁÅíҴѺ¢Í§
ËÁÒÂàÅ¢·ÕèÃкØäÇµÒÁÃÙ»ÀÒ¾
Last Revised On : 23/11/2022 REV.05 FR-DM-17 REV.03 EFF 15/09/17
Use the rubber seal according to the size of the cable.
àÅ×Í¡ãªÅÙ¡ÂÒ§à¤àºÔÅá¡Åç¹´ µÒÁ¢¹Ò´¢Í§ÊÒÂä¿
Cable size dia
Ø
8-9 mm.
¢¹Ò´ÊÒÂä¿
with washer. áËǹÃͧ
9
11
13
Rubber seal size
ÅÙ¡ÂÒ§à¤àºÔÅá¡Åç¹´·Õèãª
dia 9 mm.
Cable size dia
Ø
10-11 mm.
¢¹Ò´ÊÒÂä¿
with washer. áËǹÃͧ
Cable size dia
Ø
12-13 mm.
¢¹Ò´ÊÒÂä¿
with washer. áËǹÃͧ
dia 11 mm.
dia 13 mm.
Cable size :
¢¹Ò´ÊÒÂä¿
L
N

Last Revised On : 23/11/2022 REV.05 FR-DM-17 REV.03 EFF 15/09/17
1. 1.
2.
3.
4.
5.
2.
Remark :
ËÁÒÂà˵Ø
Installation should be carried out by a qualified
electrician in accordance with appropriate national
wiring regulation.
¡ÒõԴµÑé§â¤Áä¿¿ÒáÅÐÍØ»¡Ã³ ¤ÇôíÒà¹Ô¹¡ÒÃâ´Âªҧ俿Ò
·ÕèÁÕ¤ÇÒÁÃÙáÅФÇÒÁªíÒ¹Ò 㹡ÒõԴµÑé§ÍØ»¡Ã³ä¿¿Ò
â´Â੾ÒеÒÁÁÒµÃฐÒ¹¢Í§¡ÒÃä¿¿Ò
Disconnect the power before changing the lamp.
»´ÊÇÔ·ªä¿·Ø¡¤ÃÑ駷Õèà»ÅÕè¹ËÅÍ´ä¿
This is Class1 luminaire, the installation must be
completed with earthing.
â¤Áä¿ÃØ¹¹Õé¶Ù¡¨Ñ´äÇã¹»ÃÐàÀ·¢Í§¡Òûͧ¡Ñ¹ä¿¿ÒÃÑèÇ ÃдѺ 1
·Õè¨ÐµͧµÍÊÒ´ԹµÒÁÁÒµÃฐÒ¹¤ÇÒÁ»ÅÍ´ÀÑÂ
Do not exceed the maximum wattage.
ËÒÁãªËÅÍ´ä¿·ÕèÁÕ¢¹Ò´Çѵµà¡Ô¹¡ÇÒ·ÕèÃÐºØ ËÃ×ÍãªËÅÍ´¼Ô´»ÃÐàÀ·
Don't touch LED while maintaining or cleaning.
ËÒÁÊÑÁ¼ÑÊËÅÍ´ LED ¢³ÐºíÒÃاÃÑ¡ÉÒ ËÃ×Í·íÒ¤ÇÒÁÊÐÍÒ´
Warning :
¢ͤÇÃÃÐÇѧ
The manufacturer will not be liable or held responsible
for any incorrect installation, misuse or improper use
and unauthorised modification to the fittings. Failure
to comply with mentioned warning may cause serious
damage or serious injury to persons, animals or
objects. If any modification is required please consult
your dealer for the details.
·Ò§¼Ù¼ÅÔµäÁÊÒÁÒöÃѺ¼Ô´ªÍºã¹¤ÇÒÁàÊÕÂËÒÂã´æ·Õèà¡Ô´¨Ò¡¡ÒÃ
µÔ´µÑé§äÁ¶Ù¡ÇÔ¸Õ, ãª§Ò¹¼Ô´»ÃÐàÀ·ËÃ×Í´Ñ´á»Å§µÑÇâ¤Áã¹·Ø¡¡Ã³Õ
«Öè§ ÊÔ觼Դ»¡µÔàËÅÒ¹Õé ÍÒ¨·íÒãË à¡Ô´ÍѹµÃÒ¡Ѻ ¤¹ ÊѵÇ ÊÔ觢ͧ
ËÒ¡ÁÕ¢ÍʧÊÑÂËÃ×ÍÁÕ¤ÇÒÁµͧ¡Òûà Ѻáµ§µÑÇâ¤Á
ãËàËÁÒÐÊÁ¡Ñº¡ÒÃãª§Ò¹ ¡ÃسҵԴµ ͵ÑÇá·¹¨íÒ˹ÒÂËÃ×ͼÙ¼ÅÔµ
Where damage has occured to the fittings, please
make the replacement with standard parts before use.
㹡óշÕèÁÕªÔé¹Êǹ»ÃСͺã´à¡Ô´¤ÇÒÁàÊÕÂËÒ¡ÃسÒà»ÅÕè¹
ªÔé¹ÊǹãËÁ¡͹¡ÒÃãª§Ò¹·Ø¡¤ÃÑé§ à¾×èͤÇÒÁ»ÅÍ´ÀÑÂ
NO
Do not touch the LED because it may shorten the life time or the LED can be
breaking down.
ËÒÁÊÑÁ¼ÑÊËÅÍ´ LED â´Âà´ç´¢Ò´ à¾ÃÒШзíÒãËËÅÍ´àÊ×èÍÁÊÀÒ¾
Minimum distance to lighted surface.
ÃÐÂÐËÒ§¢Ñé¹µèíÒ ¨Ò¡Ë¹Òâ¤Á¶Ö§¾×é¹¼ÔÇ·Õè¶Ù¡ÊͧÊÇÒ§
0.5 m
For 1-10V dimming and DALI system.
ÊíÒËÃѺÃкº´ÔÁ1-10V áÅÐÃкºDALI
Cable Size/¢¹Ò´ÊÒÂä¿ : 5x1.00 mm.
Ø
7.1-13 mm.
2
A = 38-40 mm.
B = 8-10 mm.
C = 30-32 mm.
IP68 water tight connecting device 5 Pole.Cable Diameter 7.1-13mm.
Available Separately/ªØ´¢͵ÍÊÒÂ信ѹ¹éíÒIP68, ÊíÒËÃѺÊÒÂä¿ 5 ÊÒÂ
ᡨíÒ˹ÒµÒ§ËÒ¡
Ordering Code : 0413-0-9-000-00
3/7
B
C
A
Green/Yellow :
Brown : L
Blue : N
White : + (DA1)
Black : - (DA2)
Cable Size/¢¹Ò´ÊÒÂä¿ : 3x1.00 mm.
Ø
8-13 mm.
2
For
On-Off System.
ÊíÒËÃѺ Ãкºà»´-»´
In case the supply cable is exposed to sunlight use UV resistant cable.
¡Ã³Õ·ÕèÁÕ¡ÒõԴµÑé§â¤Á俹͡ÍÒ¤Òà ËÃ×Íâ¤Áä¿·ÕèÁÕ¡ÒÃá¼ÃѧÊÕÂÙÇÕ ÊÒÂ俵ͧÊÒÁÒö»ͧ¡Ñ¹ ËÃ×Í ÁÕ¡Òûͧ¡Ñ¹äÁãË¶Ù¡ÃѧÊÕÂÙÇÕä´

4/7
Pic-1
Pic-2
General installation guide ( Highly recommended)
¢Íá¹Ð¹íÒ㹡ÒõԴµÑé§
Cable pipe
·ÍÊÒÂä¿
Place the gravel 20-30 cm.depth underneath the casing for water
drainage (Pic-1).Then do the testing by filling water into the casing
and let it drain.The water should be drained out by 30 minutes.
If not,the additional drainage pipe or other system must be applied
(Pic-2)
¤ÇÃÇÒ§¡͹¡ÃÇ´ãµ¡Åͧ½§¾×é¹·ÕèÃÐÂÐÅÖ¡»ÃÐÁÒ³ 20-30 «Á. à¾×èͪÇÂÃкÒÂ
¹éíÒ·Õè·ÇÁ¢Ñ§µÑÇâ¤Áä¿ ÊÒÁÒö·´Êͺ¡ÒÃÃкÒ¹éíÒâ´Âà·¹éíÒãÊ¡ÅͧãËàµçÁ
¹éíҨеͧÃкÒÂÍÍ¡ËÁ´ÀÒÂã¹àÇÅÒ 30¹Ò·Õ ËÒ¡äÁà»¹µÒÁ¹Ñ鹤ÇÃÁÕ¡ÒõÍ
·ÍÃкÒ¹éíÒà¾ÔèÁàµÔÁ
Installation should not be done under high humidity enviroment i.e.
rainy day or after the rain,foggy weather....ect.
äÁ¤ÇõԴµÑé§â¤Áä¿ã¹ªǧ·ÕèÁÕ¤ÇÒÁª×é¹ÊÙ§àª¹ Çѹ·Õè½¹µ¡µÅÍ´ËÃ×͵ Ô´µÑé§ËÅѧ
½¹ËÂØ´µ¡à¾ÃÒШзíÒãË¤ÇÒÁª×鹶١¢ ѧäÇã¹µÑÇâ¤Áä¿ËÅѧ¨Ò¡¹Ñ鹨Ðà¡Ô´¡ÒÃ
¤Çºá¹¹à»¹ÅÐÍͧËÃ×ÍË´¹éíÒà¡ÒеԴºÃÔàdzãµ¡ÃШ¡ÀÒÂã¹µÑÇâ¤Áä¿
20-30 cm.
Water drainage pipe
·͹éíÒ·Ôé§
Last Revised On : 23/11/2022 REV.05 FR-DM-17 REV.03 EFF 15/09/17
Not using chemical compounds and aggressive agents such as , weed
repellents fertilizers , acid solvent and contaminated irrigation water near
the Luminaires.
ËÒÁãªÊÒÃà¤ÁÕàª¹ »ØÂ, ÂÒ¡íҨѴÈѵÃپת, »Ù¹¢ÒÇ, ÊÒÃÅÐÅÒ·Õèà»¹¡Ã´ áÅйéíÒ»¹à»͹ÊÒÃà¤ÁÕ
ºÃÔàdz·ÕèµÔ´µÑé§â¤Áä¿

5/7
YES/¶Ù¡µͧ NO/äÁ¶Ù¡µͧ
Walk over fittings.Max 2,000 Kg constant pressure load.
Vehicles with pneumatic tyres can drive
over the fittings at the speed of 20 km/h.
Not suitable to be used in traffic lanes.
â¤Ã§ÊÃÒ§¢Í§â¤Á俪¹Ô´¹ÕéÊÒÁÒöà´Ô¹àËÂÕºº¹Ë¹Òâ¤Áä´
áÅÐÃѺáç¡´·Ñºä´ 2,000 ¡¡. ÊÒÁÒöÃѺáçö¹µ·ÕèÇÔè§
¼Ò¹·Õèãª¤ÇÒÁàÃçÇ 20 ¡Á./ªÁ. â¤ÁÃØ¹¹ÕéäÁàËÁÒÐÊÁ¡Ñº¡ÒõԴµÑé§
ºÃÔàdzã¹àÊ¹·Ò§¡ÒèÃÒ¨Ã
Do not let the exposed part of the fittings be covered by the soil,dried weed or
foliage as well as corrosive or aggressive substancechemicals.
ÍÂÒ»ÅÍÂãËÁÕÊÔè§Ê¡»Ã¡àª¹ àÈÉ´ Ô¹ ãºäÁ ËÃ×Í
ËÒáË§ÃÇÁ¶Ö§à¤ÁÕ·Õèà»¹ÊÒÃ-¡Ñ´¡Ã͹ÁÒ»¡¤ÅØÁÊÐÊÁºÃÔàdz˹Ò¾×é¹¼ ÔǵÑÇâ¤Áä¿
Do not throw or drop any hard objects onto the top of fittings.
ÍÂÒãËÇѵ¶Ø·Õèà»¹¢Í§á¢ç§ËÅ¹ ËÃ×͵¡¡ÃÐá·¡ãÊºÃÔàdz˹Ò¾×é¹¼ÔǢͧµÑÇâ¤Á
The surface temperature of the fitting can be very high after continuation in
service.
àÁ×èÍà»´ä¿·Ôé§äÇã¹ÃÐÂÐàÇÅÒ˹Ö觨Ðà¡Ô´¤ÇÒÁÃ͹ÊÐÊÁºÃÔàdz´Ò¹º¹¢Í§µÑÇâ¤Áä¿
¤ÇÃÃÐÁÑ´ÃÐÇѧ¡ÒÃÊÑÁ¼Ñʶ١ºÃÔàdz´ ѧ¡ÅÒÇ
Proper use of this fitting must be observed.
¤ÇþԨÒóҤÇÒÁàËÁÒÐÊÁ¢Í§¾×é¹·ÕèËÃ×͵íÒá˹§·Õè¨ÐµÔ´µÑ駵ÑÇâ¤Áä¿ µÑÇÍÂÒ§ àª¹ ÁÕ
¹éíҢѧà»¹»ÃШíÒ㹺ÃÔàdz¹Ñé¹ËÃ×ÍäÁ? , Çѵ¶ØµÒ§æ àª¹
´Ô¹,àÈÉãºäÁãºËÒÁÕâÍ¡ÒÈ·Õè¨ÐÁÒ»¡¤ÅØÁÊÐÊÁº¹Ë¹Òâ¤Áà»¹»ÃÔÁÒ³ÁÒ¡ËÃ×ÍäÁ?
áÅÐäÁ¤ÇõԴµÑé§ã¹ºÃÔàdz·ÕèÍÒ¨ÁÕâÍ¡Òȶ١ÊÑÁ¼ÑÊâ´Â¤¹ â´Â੾ÒÐà´ç¡àÅç¡ËÃ×ÍÊѵÇàÅÕé§
20KM/H
NO/äÁ¶Ù¡µͧ
Last Revised On : 23/11/2022 REV.05 FR-DM-17 REV.03 EFF 15/09/17
Any damaged safety glass cover must be replaced only with the original spare part.
àÁ×èÍ¡ÃШ¡à¡Ô´¤ÇÒÁàÊÕÂËÒ à¾×èͤÇÒÁ»ÅÍ´ÀѤÇÃÊÑè§ÍÐäËÅá·¨Ò¡¼Ù¼ÅÔµà·Ò¹Ñé¹
LED
Our products are installed with electronic components with the protection against
overvoltage according to IEC 61547. The customers have to install the additional
overvoltage protection devices (against surge, transients, etc) in their electrical
system to avoid the risk of damage.
Failing to do so will end the product warranty.
¼ÅÔµÀѳ±¢Í§àÃÒÁÕ¡ÒõԴµÑé§ÍØ»¡Ã³ÍÔàÅç¡·Ã͹ԡÊÊíÒËÃѺ¡Òûͧ¡Ñ¹áç´Ñ¹ä¿à¡Ô¹µÒÁÁÒµÃฐÒ¹
IEC 61547 áÅÐÅÙ¡¤ÒµͧµÔ´µÑé§ÍØ»¡Ã³»ͧ¡Ñ¹áç´Ñ¹ä¿à¡Ô¹à¾ÔèÁàµÔÁ (»ͧ¡Ñ¹ä¿¡ÃЪҡ
ä¿¿ÒÅѴǧ¨Ã ÏÅÏ)ã¹Ãкºä¿¿Ò´Ç à¾×èÍËÅÕ¡àÅÕ觤ÇÒÁàÊÕ觷Õè¨Ðà¡Ô´¤ÇÒÁàÊÕÂËÒÂ
ËÒ¡äÁ´íÒà¹Ô¹¡Òôѧ¡ÅÒÇ ¡ÒÃÃѺ»ÃСѹ¨ÐÊÔé¹Êشŧ

The luminaire should be positioned so that prolonged staring into the luminaire at
a distance closer than 0.5m in not expected.
µíÒá˹§·ÕèµÔ´µÑ駴ǧâ¤Á¤ÇÃÍÂÙ㹨ش·ÕèáʧäÁÊͧà¢ҴǧµÒâ´ÂµÃ§à»¹àÇÅÒ¹Ò¹ ËÒ¡à¢Òã¡Åã¹
ÃÐÂйÍ¡ÇÒ 0.5 Á.
6/7
Last Revised On : 23/11/2022 REV.05 FR-DM-17 REV.03 EFF 15/09/17
Clean the products regularly to maintain good light output and prolong surface
quality .
Only use solvent-free cleaning solutions on the products.
·íÒ¤ÇÒÁÊÐÍÒ´¼ÅÔµÀѳ±à»¹»ÃШíÒà¾×èÍÃÑ¡ÉÒ¤ÇÒÁÊͧÊÇÒ§·Õè´ÕáÅÐÂ×´ÍÒÂؤسÀÒ¾¾×é¹¼ÔÇ
ãª¹éíÒÂÒ·íÒ¤ÇÒÁÊÐÍÒ´·ÕèäÁÁÕáÍÅ¡ÍÎÍÅËÃ×͵ÑÇ·íÒÅÐÅÒ¡Ѻ¼ÅÔµÀѳ±à·Ò¹Ñé¹
Do not use a high pressure washer to clean the products.
ËÒÁãªà¤Ã×èͧ©Õ´¹éíÒáç´Ñ¹Ê٧㹡Ò÷íÒ¤ÇÒÁÊÐÍÒ´¼ÅÔµÀѳ±
Environmental protection: Waste electrical products should not be disposed of
with household waste. please recycle where facilities exist.check with your local
authority or retailer for recycling advice According to directive 2002/96/CE and
directive 2012/19/EU Waste Electrical and Electronic Equipment (WEEE).
ËÒÁ·Ô駼ÅÔµÀѳ±¹ÕéÃÇÁ¡Ñº¢ÂÐ㹤ÃÑÇàÃ×͹ª¹Ô´Í×è¹æàÁ×èÍÊÔé¹ÊØ´ÍÒÂØ¡ÒÃãª§Ò¹â»Ã´á¡¼ÅÔµÀѳ±ÍÍ¡
¨Ò¡¢Í§àÊÕ»ÃÐàÀ·Í×è¹æáÅÐÃÕä«à¤ÔÅÍÂÒ§àËÁÒÐÊÁà¾×èÍÊ§àÊÃÔÁ¡ÒùíÒ·ÃѾÂҡáÅѺÁÒãª«éíÒ«Ö觨ЪÇÂ
»ͧ¡Ñ¹ÍѹµÃÒµÍÊÔè§áÇ´ÅÍÁËÃ×ÍÊØ¢ÀÒ¾¢Í§Á¹ØÉÂ·Õèà¡Ô´¨Ò¡¡Ò÷Ô駢ÂÐâ´ÂäÁÁÕ¡ÒäǺ¤ØÁ
ÍÒ§ÍÔ§µÒÁÃÐàºÕº 2002/96/CE áÅÐÃÐàºÕº 2012/19/EU Waste Electrical and
Electronic Equipment (WEEE).
LED LED
To replace the LED module or the entrire luminaire.Please consult your
sales representative.
ËÒ¡µͧ¡ÒÃà»ÅÕè¹ LED
module
ËÃ×Íâ¤Áä¿â»Ã´µÔ´µ͵ÑÇá·¹¢Ò¢ͧ¤Ø³
230V
LED

7/7
Last Revised On : 23/11/2022 REV.05 FR-DM-17 REV.03 EFF 15/09/17
1.
2.
3.
4.
5.
6.
Replacing the LED module
ÇÔ¸Õ¡ÒÃà»ÅÕè¹ LED module
Contact your sales representative for replacement LED modules. Make sure that the replacement module
match the initially supplied module. Note the part number printed on the LED module.
àµÃÕÂÁ LED module ãËµÃ§¡ÑºÃØ¹· Õèµͧ¡ÒÃà»ÅÕè¹â´ÂµÃǨÊͺ·ÕèËÁÒÂàÅ¢·Õè¾ÔÁ¾º¹LED modules áÅÐ µÔ´µ͵ÑÇá·¹¢ÒÂà¾×èÍÊÑ觫×éÍ
LED modules ·Õèµͧ¡ÒÃà»ÅÕè¹
The LED module can be replaced by qualified persons using standard tools.
¡ÒÃà»ÅÕè¹ LED module µͧ·íÒâ´ÂªÒ§¼ÙªíÒ¹ÒáÅÐãªà¤Ã×èͧÁ×Í·Õèä´ÁÒµÃฐÒ¹
Disconnect power before opening the luminaire housing.
µÑ´áËÅ§¨ÒÂä¿¡͹·Õè¨Ðà»´µÑÇâ¤Á
Replace the old LED module with the new LED module. Reapply thermal interface material as supplied with the
new LED module.
¶Í´ LED module ·ÕèªíÒÃØ´ÍÍ¡ ¨Ò¡¹Ñ ¹·íÒ¤ÇÒÁÊÐÍÒ´¨Ø´ÇÒ§ËÅÍ´ áÅǨ֧·íÒ¡ÒûÃСͺ LED module ãËÁ áÅе ͧà»ÅÕè¹
á¼¹Thermal Pad ËÃ×Í Thermal Grease ´Ç·ء¤ÃÑé§
Inspect gaskets and if required replace with new gaskets. Defective luminaire covers must be replaced. Inspect
correct wiring of replaced LED module.
µÃǨÊͺ»ÃÐà¡ç¹áÅЪÔé¹Êǹ¢Í§µÑÇâ¤Á ¶ÒªíÒÃØ´àÊÕÂËÒÂãË·íÒ¡ÒÃà»ÅÕè¹ãËÁ áÅеÃǨÊͺ¡ÒÃà¢ÒÊÒÂ俢ͧ LED module
·Õèà»ÅÕè¹ãËÁ¶Ù¡µͧËÃ×ÍäÁ
Close the luminaire housing before reconnecting power.
»´½Ò¤ÃͺÅçͤâ¤Áä¿ãËàÃÕºÃÍ¡͹à»´ä¿