Vapalux R510 Manual

VAPALUX R510
®
INSTRUCTION GUIDE
Radiator

Trademark information
VAPALUX® and WILLIS & BATES® are registered trademarks of Vapalux Co., Ltd. Korea.
NOTICE
No part of the manuals included with this product may be reproduced, transmitted, transcribed, stored in a retrieval system, or trans-
lated into any language in any form, by any means, without Vapalux’s prior written permission.
Vapalux reserves the right to change the specifications of the hardware described in these manuals at any time and without prior
notice.
Vapalux will not be held liable for any damages resulting from the use of this product.
For more information about VAPALUX accessories, please contact a local authorizer VAPALUX dealer.
While every effort has been made to ensure that the information in these manuals is accurate and complete,
We would appreciate it were you to bring any errors or omissions to the attention of the Vapalux representative in your area
(address provided separately).
2

PACKAGE CONTENT
R510 Radiator
3

WARNING NOTICE
WHEN USING VAPALUX® RADIATOR, OR ANY
OTHER KEROSINE(PARAFFIN) OPERATED
APPLIANCE, ALWAYS ENSURE THAT
THE ROOM IS REASONABLY VENTILATED.
4

Thank you for your purchase of a VAPALUX R510 Radiator.
Please be sure to read all instructions thoroughly to get the most from the lamp, and keep them where they will
be read by all those who use the product.
Use Only Vapalux Brand Accessories
Only Vapalux brand accessories certified by Vapalux specifically for use with
your VAPALUX Hurricane Pressure Lamp are engineered and proven to operate within its operational and safety requirements.
THE USE OF NON-VAPALUX ACCESSORIES COULD DAMAGE YOUR LAMP AND MAY VOID YOUR VAPALUX WARRANTY.
OVERVIEW
5

1
5
3
6
2
4
1
5
3
6
2
4
8
7
10
11
9
8
7
10
11
9
Getting to know the VAPALUX Radiator
6
Take a few moments to familiarize yourself with Radiator. You may find it helpful to bookmark this section and refer to it as you read through the rest of the manual.
1 Container
2 Burner Unit
3 Spirit Cup
4 Safety Guard
5 Chromed Reflector
6 Pump Plunger
7 Jet Cleaner
8 JC Knob
9 Filler Cap
10 Handle Base
11 Handle

7
Unscrew filler cap (87) and fill with clean paraffin (kerosene) - never use petrol. Capacity approx. 0.8 litre.
Do not tilt lamp when filling. Screw filler cap on tightly.
To Fill Lamp

To Light Lamp
8
Slacken air-release screw (6).
Turn knob on jet cleaner (74) anti-clockwise.

9
Completely fill pre-heat cup with jelly or spirit not petrol and apply light.

10
Allow to burn until fuel is almost consumed (about 3 minutes).
Tighten air-release screw and operate pump (16) until element lights
(about 12 strokes).
After element lights, allow to burn for half minute. Then pump to
obtain maximum light 20/30 strokes).
There is no advantage in over-pumping!!!

11
If the element flames on starting to pump, immediately turn knob of jet clean-
er (74) a half turn clockwise and quickly release pressure by unscrewing air
release screw (6).
The reason for element not lighting correctly is that insufficient time has
been allows to pre-heat the vaporizer.
Repeat lighting operations as above.

Slacken air release screw (6) and leave it unscrewed.
12
To Extinguish Lamp

1. To fit new vaporizer
2. Washers
3. Spare Parts
Mintenance
13

14
1. Remove safety guard
2. Remove burner unit
3. Remove spirit cup
4. Unscrew vaporizer and re-
place it
To fit new vaporizer

1" Filler Cap
Washer V.811
A1202
Jet Cleaner
Washer V.23
A1046
Pump Valve
Washer(EXT.)
V.33
A1042
Vaporizer Washer
V.44
A1056
Air Release Screw
Washer V.9
A1044
JC Gland Nut
Washer V.28
A1053
Pump Valve
Washer (INT.)
V.34
A1040
Pump Leather
A1039
WASHERS
1” Filler Cap Washer
Jet Cleaner Washer
Pump Valve Washer (EXT.)
Vaporizer Washer
Air Release Screw Washer
JC Gland Nut Washer
Pump Valve Washer (INT.)
Pump Leather
15

Valcanex
Spare Parts
1" Filler Cap
Washer V.811
A1202
Jet Cleaner
Washer V.23
A1046
Pump Valve
Washer(EXT.)
V.33
A1042
Vaporizer Washer
V.44
A1056
Air Release Screw
Washer V.9
A1044
JC Gland Nut
Washer V.28
A1053
Pump Valve
Washer (INT.)
V.34
A1040
Pump Leather
A1039
Burner V78-R Handle Unit
Vaporizer V40 Spirit Cup
Element support Tube Element Support Nut
Fuel Funnel V3 Jet Cleaner V74-R
Washer Set V5
Pump Leather V24
Container E50 Pump Plunger V16 1” Filler Cap V87 Pump Valve V15
16

7
5
6
4
2
3
8
9
1
Description BOM ID Qty
burner 8 1
burner disc 9 1
burner dome 1 1
Description BOM ID Qty
element 3 1
element support cup 6 1
element support nut 7 1
Description BOM ID Qty
element support tube5 1
riveted air tube 2 1
vulcanex 4 1
Burner Unit
17

2
7
1
6
3
4
8
5
Description BOM ID Qty
handle 1 1
handle base 3 1
Description BOM ID Qty
handle frame 4 1
handle nut 2 1
Description BOM ID Qty
handle spindle 5 1
handle spindle nut61
Description BOM ID Qty
handle washer 7 1
slotted screw 8 3
Handle unit
18

Specifications
19
Specifications
Bowl finish : Polished Brass
Reflector : Chromed Brass
Height : 350 mm (15.5")
Heat output : 3,260 B. Th. Us/hour
Fuel capacity : 1 Litre (0.26 US gallon)
Handle finish : Anodized Aluminium
Handle frame finish : Stainless Steel
Country of manufacture : Korea, Republic
Burn time : Approx. 10 hrs
Weight : Approx. 1.85 Kg (4.1 lb)