Viking E-Series User manual

OUTDOOR—COOKING
53”W. Ultra-Premium T-Series/E-Series Gas Grill
PLANNING AND DESIGN GUIDE
VIKINGRANGE.COM • 1-888-VIKING1
R E L E A S E D 0 5 / 1 2 / 0 8
© 2 0 0 7 V R C — INFORMATION SUBJECT TO CHANGE
All mo els inclu e
• 25 000 BTU stainless steel grill burners
produce intense searing heat across
entire grilling surface
• Extra-deep sealed burner box keeps
heat contained in burner area allowing
easier temperature maintenance
• Rotisserie standard on all Ultra-
Premium models; rotisserie system
consists of a 15 000 BTU Gourmet-
Glo™ infrared rear burner heavy-duty
rotisserie motor stainless steel 1/2”
rotisserie rods and two rotisserie forks
• Removable smoker box accommodates
wood chips or large wood chunks
• Smoker box can be replaced with grilling
grate for use of entire grill surface
• Stainless steel flavor-generator plates
catch drippings generate smoke
minimize flare-ups and allow for
better heat control
• Chrome-plated warming rack –
reinforced by heavy-duty rack supports
• Thermometer located on canopy
indicates the best zones for warming
smoking and grilling
• Commercial styling and construction
oDouble wall construction insulates
hood to help keep heat inside and
provides for a cooler sidewall
oAll models can be built into any type
of enclosure without the need of an
insulated jacket – a Viking exclusive
• Easy maintenance and cleanup
o New and improved Grease
Control™ system consists of full-
width removable stainless steel drip
tray and individual removable trays
within main tray
o Extra heavy-duty cooking grids are
porcelain-coated to prevent food
from easily sticking
o Burners are equipped with stainless
steel drip guards to combat burner
clog and aid grease management
by channeling liquids to the drip
tray assisting in flare-up control
VGBQ530 mo els
• 53” W. w/four grill areas – 7.8 sq. ft.
(1 120 sq. in.)
VGBQ532 mo els
• 53” W. w/double side burners and
three grill areas – 5.8 sq. ft. (836 sq. in.)
• Side burners – a double configuration
15 000 BTU side burners w/porcelain
“V” grates and stainless steel cover
VGIQ530 mo els
• 53” W. w/four grill areas – 7.8 sq. ft.
(1 120 sq. in.)
• TruSear™ infrared burner
o Located in far left grill burner position
o Constructed of heavy-duty inconel
stainless steel
o 30 000 BTU high 17 500 BTU low
VGIQ532 mo els
• 53” W. w/double side burners and
three grill areas – 5.8 sq. ft. (836 sq. in.)
• Side burners – a double configuration
15 000 BTU side burners w/porcelain
“V” grates and stainless steel cover
• TruSear™ infrared burner
o Located in far left grill burner position
o Constructed of heavy-duty inconel
stainless steel
o 30 000 BTU high 17 500 BTU low
T-Series only
• Push-button electronic ignition powered
by a 9-volt battery provides a positive
consistent and continuous spark for
easy grill lighting (T-Series only)
E-Series only
• Push and turn 120-volt electric ignition
system provides a positive consistent
and continuous spark for easy grill
lighting (E-Series only)
oAutomatic re-ignition system
(E-Series only)
oHalogen lighting mounted on the
inside of canopy provides ample
lighting for nighttime grilling
(E-Series only)
• E-Series numerical thermometer gives
even more precise temperatures for
grilling smoking and warming
• Brass Trim Option (BR)—nameplate
handle/brackets and knob bezels.
Brass components have a durable
protective coating for maintenance-
free normal use.
FINISH DETAILS FOR ALL MODELS
• Stainless Steel (SS)
o Porcelain-coated cooking grids (and
“V” grates on the 412 model’s side
burners) and black knobs.
Stan ar Features & Accessories
Mo el Options
*T-Series & E-Series models look the same, with the exception o the canopy light switch in the upper right corner o the E-Series control panel.
(See photo o 30”W. E-Series grill or example.)
ORDERING INSTRUCTIONS
You must specify fuel type (“N” or “L”) following model number (VGBQ5304RTNSS). If ordering optional brass trim specify code at end
(VGBQ5304RTNSSBR).
VGBQ530-4RT/E*
T-Series/E-Series
Four-Burner All-Grill
VGBQ532-3RT/E*
T-Series/E-Series
Three -Burner Grill
w/Side Burners
VGIQ530-4RT/E*
T-Series/E-Series
Four -Burner All-Grill
(inc. TruSear™ Burner)
VGIQ532-3RT/E*
T-Series/E-Series
Three-Burner Grill
w/Side Burners
(inc. TruSear™ Burner)

OUTDOOR—COOKING
53”W. Ultra-Premium T-Series/E-Series Gas Grill
PLANNING AND DESIGN GUIDE
VIKINGRANGE.COM • 1-888-VIKING1
R E L E A S E D 0 5 / 1 2 / 0 8
© 2 0 0 7 V R C — INFORMATION SUBJECT TO CHANGE

Please see
Installation Notes
and Accessories for
important
information,
including fuel
conversion kits, carts,
and side burners.
53-3/16”
(135.1 cm)
32-3/4”
(83.2 cm)
41-3/16”
(104.6cm)
26-7/8”
(68.3cm)
VGBQ530-4RT/E VGBQ532-3RT/E VGIQ530-4RT/E VGIQ532-3RT/E
Overall widt 53-3/16” (132.7 cm)
Overall eig t— ood closed 26-7/8” (68.3 cm)
Wit ood fully open 33-3/16” (84.3 cm)
Overall dept —from front of knobs 32-3/4” (83.2 cm)
Approx. s ip wt. lbs. (kg) 460 (208.8) 490 (222.5) 460 (208.8) 490 (222.5)
VGBQ T-Series
grills are Star-K
certi ied or use on
the Jewish Sabbath
or Jewish holidays.
(VGIQ grills are not
Star-K certi ied.)
Dimensions & Specifications
PRODUCT DIMENSIONS
VGBQ530-4RT/E
T-Series/E-Series
Four-Burner All-Grill
VGBQ532-3RT/E
T-Series/E-Series
Three-Burner Grill
w/Side Burners
VGIQ530-4RT/E
T-Series/E-Series
Four-Burner All-Grill
(inc. TruSear™ Burner)
VGIQ532-3RT/E
T-Series/E-Series
Three-Burner Grill
w/Side Burners
(inc. TruSear™ Burner)

OUTDOOR—COOKING
53”W. Ultra-Premium T-Series/E-Series Gas Grill
PLANNING AND DESIGN GUIDE
VIKINGRANGE.COM • 1-888-VIKING1
R E L E A S E D 0 5 / 1 2 / 0 8
© 2 0 0 7 V R C — INFORMATION SUBJECT TO CHANGE
22-15/16”
(58.3cm)
16-5/8”
(42.2cm)
10-1/4”
(26.0 cm)
6”
(15.2 cm)
41-3/16”
(104.6 cm)
8”
(20.3cm)*
5-3/8”
(13.7 cm)
31-9/16”
(80.2 cm)
32-3/4”
(83.2 cm)
3” min.
(7.6 cm) to non-
combustable
surface
24” min.
(61.0cm) to
combustable
surface
Minimum clearances
1. Maintain a min. of 6” (15.2 cm) from
the sides or a min. of 8” (20.3 cm)
from the right side if there is a
rotisserie motor and a min. of
24” (61.0 cm) from the back above the
cooking surface to adjacent vertical
combustible construction. Do not
place grill under unprotected
combustible construction.
2. Maintain a min. of 3” (7.6 cm)
clearance from the back of the grill
with a canopy and a min. of 6” (15.2
cm) from the back of the grill without
a canopy to non-combustible
construction to allow the lid to open
fully and for proper ventilation. (The
grill exhausts combustion products
and cooking greases to the back.)
Never place the grill where the
exhaust is directed at a window less
than 24” (61.0 cm) to combustible
material or any surface that is difficult
to clean. Allow at least 6” side
clearance to non-combustible
construction above the cooking
surface for counter space. If using the
rotisserie option the space is essential
for motor and skewer clearance. The
grill can be placed directly adjacent to
combustible and/or non-combustible
construction below the cooking
surface.
3. When determining a suitable location
for the grill take into account
exposure to wind proximity to traffic
paths and keeping gas supply lines as
short as possible. Place the grill only in
a well-ventilated area. Never place the
grill in a building garage breezeway
shed or other fully enclosed areas.
During heavy use the grill will
produce a lot of smoke; ensure you
have adequate room for smoke to
dissipate.
4. If using a rear wall place the electrical
service on the right-hand side for the
rotisserie motor.
IMPORTANT: Gas fittings regulator and
installer-supplied shut-off valve must be
easily accessible.
Dimensions & Specifications
CLEARANCE DIMENSIONS & HOOD SWING

10-1/4”
(26.0 cm)
36”
(91.4 cm) **Access Door Opening
28”
(71.1 cm)
52-1/4”
(132.7 cm)
3”
(7.6 cm) min.
Electrical Connection
for Rotisserie Motor
(position unit so that
the plug is always
accessible)
Electrical Connection
(E-series only) for
power supply cord to be
located on rear wall with
a maximum distance of
2’ (61.0 cm) beneath
solid bottom support
*Solid Bottom Support
Gas Inlet and Power Cord
Location Area
5”
(12.7 cm)
5”
(12.7cm)
OUTDOOR—COOKING
53”W. Ultra-Premium T-Series/E-Series Gas Grill
PLANNING AND DESIGN GUIDE
VIKINGRANGE.COM • 1-888-VIKING1
R E L E A S E D 0 5 / 1 2 / 0 8
© 2 0 0 7 V R C — INFORMATION SUBJECT TO CHANGE
VGBQ530-4RT/E
T-Series/E-Series
Four-Burner All-Grill
VGBQ532-3RT/E
T-Series/E-Series
Three-Burner Grill
w/Side Burners
VGIQ530-4RT /E
T-Series/E-Series
Four-Burner All-Grill
(inc. TruSear™ Burner)
VGIQ532-3RT
/E
T-Series/E-Series
Three-Burner Grill
w/Side Burners
(inc. TruSear™ Burner)
Installation Requirements
ACCESS REQUIREMENTS
All mo els
Cutout widt 52-1/4” (132.7 cm)
Cutout eig t 10-1/4” (26.0 cm)
Cutout dept 28” (71.1 cm)
*Cabinet Cutout must have a solid bottom to support the full weight of the unit.
**Access Doors sold seperately

VGBQ530-4RT/E
T-Series/E-Series
Four-Burner All-Grill
VGBQ532-3RT/E
T-Series/E-Series
Three-Burner Grill
w/Side Burners
VGIQ530-4RT/E
T-Series/E-Series
Four-Burner All-Grill
(inc. TruSear™ Burner)
VGIQ532-3RT/E
T-Series/E-Series
Three-Burner Grill
w/Side Burners
(inc. TruSear™ Burner)
GAS
Fixe piping installations
• Check with local gas utility
company or with local codes
for instructions on installing gas
supply lines. All gas
connections should be made
by a competent technician and
in accordance with local codes
and or ordinances. In the
absence of codes the
installation must comply with
the National Fuel Gas Code
ANSI Z223.1.
• An installer-supplied gas shut-
off valve must be installed in an
easily accessible location. All
installer-supplied parts must
conform to local codes.
• Must be isolated from the gas
supply piping system by closing
its individual manual shut-off
valve during any pressure
testing of that system at test
pressures equal to or less than
1/2 psi (3.5 kPa).
Natural gas mo els
• Water column pressure
o Operating pressure—4.0”
WCP
o Supply pressure of 6” – 14”
WCP
o If incoming pressure exceeds
14” WCP a step-down
regulator is required.
• Accepts standard residential
1/2” (1.3 cm) ID gas service
line; 1/2” (1.3 cm) NPT male
with 7/8” (2.2 cm) flare adapter.
o If using a Viking GSH12
flexible hose remove the
1/2” (1.3 cm) flare adapter
and attach hose to the 7/8”
(2.2 cm) male flare on the
regulator assembly.
LP/propane mo els
• Water column pressure
o Operating pressure—10”
WCP
o Supply pressure of 11” – 14”
WCP (for fixed piping
installations)
o If incoming pressure exceeds
14” WCP a step-down
regulator is required.
• Accepts standard residential
1/2” (1.3 cm) ID gas service
line; 1/2” (1.3 cm) NPT male
with 3/8” (0.95) flare adapter.
LP/propane tank installations
• Water column pressure
o Operating pressure—10”
WCP
• Includes high-capacity
hose/regulator assembly for
connection to a standard 5-
gal./20-lb. (approx. 12”
diameter/18”H.) LP/propane
gas cylinder equipped with a
Type 1 QCC-1 connector
o The cylinder connection
device must be compatible
with the Type 1 QCC-1
connector on the outdoor
cooking appliance.
o The cylinder must be
provided with a shut-off valve
terminating in an LP/propane
gas supply cylinder valve
outlet specified.
o The cylinder supply system
must be arranged for vapor
withdrawal and provided with
a listed OPD (overfilling
prevention device).
ELECTRICAL
•T-Series models
o 9-volt DC battery for
electronic ignition (not
included?)
o 2’ (61.0 cm) power cord
supply cord with 3-prong
grounded plug attached to
rotisserie
•120 VAC/60 Hz
o Rotisserie motor max. amp
usage—6.0
•E-Series models
o 3’ (91.4 cm) power cord
supply cord with 3-prong
grounded plug attached to
grill
•120 VAC/60 Hz
o Grill max. amp usage—3.0
o 2’ (61.0 cm) power cord
supply cord with 3-prong
grounded plug attached to
rotisserie
•120 VAC/60 Hz
o Rotisserie motor max. amp
usage—6.0
PLUMBING
• Not applicable
PLANNING AND DESIGN GUIDE
VIKINGRANGE.COM • 1-888-VIKING1
R E L E A S E D 0 5 / 1 2 / 0 8
© 2 0 0 7 V R C — INFORMATION SUBJECT TO CHANGE
OUTDOOR—COOKING
53”W. Ultra-Premium T-Series/E-Series Gas Grill
UTILITY
REQUIREMENTS
Installation Requirements
VGBQ530-4RT/E VGBQ532-3RT/E VGIQ530-4RT/E VGIQ532-3RT/E
Burner rating
Standard SS grill burners (eac )
25,000 BTU (7.3 kW) Nat./22,500 BTU (6.5 kW) LP
Smoker burner (split standard) 12,500 BTU (3.7 kW) Nat./10,500 BTU (3.1 kW) LP
GourmetGlo™ rotisserie burner 15,000 BTU (4.4 kW) Nat./13,500 BTU (4.0 kW) LP
Side grill burners (eac ) 15,000 BTU (4.4 kW) Nat./ 15,000 BTU (4.4 kW) Nat./
13,500 BTU (4.0 kW) LP 13,500 BTU (4.0 kW) LP
TruSear infrared burner 3 0,000 BTU (8.8 kW) Nat./LP 3 0,000 BTU (8.8 kW) Nat./LP

R E L E A S E D 0 5 / 1 2 / 0 8
© 2 0 0 7 V R C — INFORMATION SUBJECT TO CHANGE
OUTDOOR—COOKING
53”W. Ultra-Premium T-Series/E-Series Gas Grill
PLANNING AND DESIGN GUIDE
VIKINGRANGE.COM • 1-888-VIKING1
Portable Grill Cart
• See individual product pages for more information and additional specifications.
Out oor Range™cart/oven
• See individual product pages for more information and additional specifications.
Stainless Steel Cabinetry–Grill Bases
• Stainless Steel (SS)
• Must be installed with locally supplied countertop
• See individual product pages (storage section) for more information and additional specifications.
Gas Conversion Kits
• For field conversions
• Conversions should be performed only by an authorized technician
• Kit includes all hardware necessary for conversion
12’ Natural Gas Supply Hose & Quick Disconnect Assembly
• For use with natural gas fuel supply
• For outdoor use only with portable appliances that may be moved for convenience of operation
• Valve in the socket automatically allows full gas flow when the plug is connected and prevents gas flow when the plug is
disconnected
• Kit includes quick disconnect socket with female pipe threads plug/hose assembly and adapter to mate with female
fitting on the grill (remove for mating hose to male fittings)
Vinyl Covers
• Sturdy reinforced vinyl exterior; felt-lined interior for protection
Installation Notes & Accessories
Mo el Description Approx. ship wt. lbs. (kg)
TNK-VGBQ Conversion kit—LP/propane to natural 3 (1.2)
TNK-VGIQ Conversion kit—LP/propane to natural (for TruSear grill) 3 (1.2)
TLPK-VGBQ Conversion kit—natural to LP/propane 3 (1.2)
TLPK-VGIQ Conversion kit—natural to LP/propane (for TruSear grill) 3 (1.2)
Mo el Description Approx. ship wt. lbs. (kg)
GSH12 Supply ose/disconnect assembly 3 (1.4)
Mo el Description Approx. ship wt. lbs. (kg)
BQC530T1-SS Ultra-Premium portable cart (for 53”W. grill) 290 (131.7)
BQC053T1-N 53”W. portable cart & gas oven—natural gas 319 (143.5)
BQC053T1-L 53”W portable cart & gas oven—LP/propane 319 (143.5)
Mo el Description Approx. ship wt. lbs. (kg)
BQC053T1-N 53”W. portable cart & gas oven—natural gas 319 (143.5)
BQC053T1-L 53”W. portable cart & gas oven—LP/propane 319 (143.5)
Mo el Description Approx. ship wt. lbs. (kg)
VQBO5322 Grill base (for 53”W. grill) 279 (126.6)
VQWO5311 Grill base w/ warming drawer access (for 53”W. grill & 36”W. warming drawer) 265 (120.2)
Mo el Description Approx. ship wt. lbs. (kg)
CV53T-BI Cover for 53”W. built-in all grill 13 (5.9)
CV53T-BISB Cover for 53”W. built-in grill w/side burners 13 (3.9)
CV53T-C Cover for 53”W. all grill & cart 15 (6.8)
CV53T-CSB Cover for 53”W. grill w/side burners & cart 15 (6.8)

PLANNING AND DESIGN GUIDE
VIKINGRANGE.COM • 1-888-VIKING1
R E L E A S E D 0 5 / 1 2 / 0 8
© 2 0 0 7 V R C — INFORMATION SUBJECT TO CHANGE
OUTDOOR—COOKING
53”W. Ultra-Premium T-Series/E-Series Gas Grill
Grill Lights
• Light fits all Ultra-Premium Grills
• Heavy-duty construction
•Anodized brushed aluminum handle and visor
• 12-volt 20-watt lamp with 8’ electrical cord
• 22” flexible gooseneck with heat-sealed vinyl protective cover
• Unique Viking design allows light to mount securely to rotisserie motor and to be removed quickly for storage
SS Grill Grates
• Heavy-duty 3/8”- thick stainless steel
Warming Racks
• Every grill can accommodate up to three racks (one rack included with every grill)
• Chrome-plated
• Rack provides additional cooking/warming space
• Single rack
Rotisserie Baskets
• For use with Gourmet-Glo™rotisserie
• Heavy-duty stainless steel construction
• Adjustable meat clamps
• Basket allows you to cook different size/shape items without needing to wire tie or spear
• Limited lifetime warranty
• Single basket
Compliance Information
WARRANTY SUMMARY*
• One-year full warranty—complete product
• Lifetime limited warranty—rust through on all stainless steel components including burners and porcelain grates
• Five-year limited warranty—grill burner assemblies infrared burners and porcelain grill grates (under normal
household use)
• Ninety-day limited warranty—cosmetic parts such as glass painted & decorative items
* For complete warranty see Use & Care Guide. Warranty valid on Viking products shipped within the United States and Canada.
Installation Notes & Accessories
Mo el Description Approx. ship wt. lbs. (kg)
VQL Grill lig ts 5 (2.3)
Mo el Description Approx. ship wt. lbs. (kg)
SS3TG Grill grate set for 53”W. grill w/side burners 30 (13.5)
SS4TG Grill grate set for 53”W. all grill 40 (18.0)
Mo el Description Approx. ship wt. lbs. (kg)
WR3TSS Warming rack for 53”W. grill w/side burners 7 (3.2)
WR4TSS Warming rack for 53”W. all grill 8 (3.6)
Mo el Description Approx. ship wt. lbs. (kg)
BQRB418T 8”W. rotisserie basket (for 53”W. grill w/side burners) 8 (3.6)
BQRB538T 8”W. rotisserie basket (for 53”W. all grill) 10 (4.5)