Wenger GEARBOSS Mobile Kiosk Electric Kit User manual

Owners Manual
Mobile Kiosk
©Wenger Corporation 2006 Printed in USA 05/06 Part #240A121-01
Wenger Corporation, 555 Park Drive, P.O. Box 448, Owatonna, Minnesota 55060-0448
Questions? Call.....USA: [phone] • International (call collect): [phone] • www.wengercorp.com
NOTE: Please read and understand the Mobile Kiosk Operating Instructions before attempting use.
NOTE: Remove the Mobile Kiosk from its shipping container. Refer to the illustrations on the following
pages. If you need additional information about your Mobile Kiosk, contact the Wenger
Corporation using the information listed below.
CONTENTS
Safety . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2
General . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2
Operation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2
Warranty . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3
Important User Information . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3
Operation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3
Intended Use . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3
Unpacking the Mobile Kiosk . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4
Mobile Kiosk Usage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4
Maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .7
Transporting the Mobile Kiosk . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .7
Replacement Parts List . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .8

2
SAFETY
Throughout this manual you will find Cautions and Warnings which are defined as follows.
• Warning means that failure to follow the instruction may result in serious injury or death.
• Caution means that failure to follow the instruction may result in injury or damage to property.
Read and understand the following safety instructions before using or installing any Gearboss Accessory.
GENERAL
OPERATION
Use of the Mobile Kiosk must
always comply with the
information in the “Important
End User Information, Intended
Use” section on page 3 of this
manual.
!CAUTION
When using the Mobile
Kiosk, always observe and
comply with Warnings and
Cautions posted in this
manual and on the Mobile
Kiosk.
!CAUTION
Make sure that anyone who operates the
Mobile Kiosk has read and understands
this manual.
Always use at least two
people to move the Mobile
Kiosk.
Always set the parking brake when
the Mobile Kiosk is parked.
Never move the Mobile Kiosk over
rough or soft terrain.
Never move the Mobile Kiosk
at more than a normal walking
speed.
Never move the Mobile Kiosk
with a motorized vehicle.
Never move the Mobile Kiosk up or
down inclines greater than 5°.
Never move or position the Mobile
Kiosk sideways on an incline.
Never deploy the Mobile Kiosk
when exposed to wind speeds
greater than 20 mph.
Never move the Mobile Kiosk
when deployed.
!CAUTION


>
5
°
Never load the Mobile Kiosk with more than
200 lbs (91 kg).
Never stand or ride on the Mobile Kiosk.
Never supply AC power to the Mobile
Kiosk if the ground is wet or if rain is
expected.
If AC power is supplied to the Mobile
Kiosk, always use an outlet that has
Ground Fault Circuit Interrupter (GFCI)
protection.
Exposing the Mobile Kiosk to rain or
excessive moisture could result in
damage.
C
C
C
C
C

3
IMPORTANT USER INFORMATION
OPERATION
•Personnel operating the Gearboss Mobile Kiosk must read and understand these instructions.
•Personnel operating the Gearboss Mobile Kiosk must comply with the Warnings and Cautions in
these instructions.
•Never leave merchandise inside the Mobile Kiosk when it is parked in an unsecured area.
A locked Mobile Kiosk is relativley secure, but break-ins are better discouraged by parking the
Mobile Kiosk in a locked room or well lighted public area.
INTENDED USE
•The Gearboss Mobile Kiosk is intended to transport and display goods within a facility and outdoors.
•The Gearboss Mobile Kiosk is intended to be moved by people only.
•The Gearboss Mobile Kiosk is intended to be used only as described in this manual.
The Gearboss Mobile Kiosk is guaranteed free of defects in materials and workmanship for five full
years.
Our guarantee assures you of either a full refund or repair or replacement of the defective materials or
workmanship without charge, at the discretion of our Customer Service Department. Just call a
Customer Service Representative at 1-800-887-7145 and state the reason you are dissatisfied. If a
product return is necessary, your representative will issue a return authorization. This is your sole
remedy for breach of this warranty.
Should you have a question or problem with any Wenger product, don’t hesitate to call, even if the
product is past warranty. It’s important to us that all our customers be satisfied.
This is the sole warranty made by Wenger. Wenger disclaims all other warranties, including the
warranties of merchantability and fitness for a particular purpose, as well as all liability for incidental,
consequential, special, and indirect damage. Wenger liability for direct damages shall be limited to the
amount you paid for the product involved. Wenger reserves the right to make product changes without
obligation to incorporate such changes into products previously sold.
Some states do not allow the exclusion or limitation of damages or warranties, so the above may not
apply to you. This warranty gives you specific legal rights. You may also have other rights which vary
from state to state.
WARRANTY

1. Be sure that the Door/Canopy Lock is securing the
Doors and Canopy.
2. Release the Parking Brake:
Push the Handle against the Side Door while pushing in
on the red Release Lever.
3. Using two people, move the Mobile Kiosk into position.
Release
Lever
Door/Canopy
Lock Engaged
Slatwall
Kit
Operating
Instructions
4
MOBILE KIOSK USAGE
Pulling a heavy load at high
speed can cause a crash that
may result in severe injury or
extensive damage to the
Mobile Kiosk.
!CAUTION
Never exceed 10 miles per hour.
Trying to stop a heavy load may
cause a crash. Severe injury or
damage to the Mobile Kiosk
may result.
!CAUTION
Never exceed 5 miles per hour
(a fast walk) if the Mobile Kiosk
is loaded or if the surface is
uneven. An overturned Mobile
Kiosk may result in severe
injury or damage to the Mobile
Kiosk and load.
!CAUTION
Pull the Mobile Kiosk slowly if
turns are tight or if the route
includes ramps or inclines. A
runaway or overturned Mobile
Kiosk may result in severe
injury or damage to Mobile
Kiosk and load.
!CAUTION
UNPACKING THE MOBILE KIOSK
1. Remove the Mobile Kiosk according to the “Mobile Kiosk Unloading Instructions” affixed
to the packaging.
2. Remove the Operating Instructions from the Handle.
3. The Slatwall Kit will be located in one of the Storage Bins.
Always use at least two
people to move the
Mobile Kiosk.
!CAUTION
Side Door

5
MOBILE KIOSK USAGE (CONTINUED)
4. Deploy the two Stabilizer Legs.
a. Flip the Stabilizer Leg until it touches the ground.
b. Slightly push back at the top of the Frame to allow better
floor clearance while pushing the Stabilizer Leg with your
foot until it is straight up and down.
5. To deploy the Mobile Kiosk:
a. Remove padlock (if present). Rotate and slide the Door/Canopy Lock
to unlock to the Upper Tab. Padlock may be stored in the Upper Tab.
b. Raise the Canopy until it latches into the Raised position.
Make sure that both Canopy Latches are engaged.
c. Open the Side Doors by lifting up on the Door Lock on the inside of the Door.
Push the Door open until it latches into the Open position.
d. Raise the Handle all of the way up to set the Parking
Brake.
Stabilizer
Legs
Push at the Top
of the Frame
5a. Rotate and Slide
Door/Canopy Lock
5b. Canopy
Latches Here
5d. Raise the
Handle
5c. Side Door
Latches Here
5c. Side Door
Latches Here
Never hang anything from
the Canopy.
!CAUTION
Door
Locks
Upper
Tab

6
MOBILE KIOSK USAGE (CONTINUED)
6. The Slatwall Kit contains the following accessories.
To install the Slatwall Kit components:
a. Rotate the component back slightly to fit into the Slatwall Extrusion.
Slatwall Extrusions are located on the inside of the Back Panel and Side Doors.
b. Let the component drop down to be flush with the panel surface.
7. To move the Mobile Kiosk:
a. Remove and store any Waterfalls, Sloping Baskets and Display Hooks.
b. Close the Side Doors. Release the latch on each Side Door.
Close the door and secure the Door Lock on each Side Door.
c. Close the Canopy. Release the latch on each side. Slowly lower the Canopy.
d. Rotate and slide the Door/Canopy Lock to the Lower Tab.
Door/Canopy Lock can now be secured with a padlock.
e. Slightly push back at the top of the Frame to allow better floor clearance while pulling each
Stabilizer Leg out with your foot. Rotate each Stabilizer Leg to the Storage position.
f. Release the Parking Brake.
Waterfall Sloping Basket 6”, 4” and 1” Display Hooks
6a
6b
Never hang more than 20 lbs (9 kg)
on any single Waterfall, Sloping
Basket or Display Hook.
!CAUTION
7d. Rotate and Slide
Door/Canopy Lock
7c. Release Latches
and Close Canopy
7b. Release
Side Door
Latch
7f. Release
Parking Brake
7e. Fold up
Stabilizer Legs
7b. Release
Side Door Latch
7b. Secure
Door Lock

7
MAINTENANCE
•Keep tires inflated to 35 psi.
•Once a year, check all fasteners for tightness.
•Once a year, apply light oil to the front axle King Pin.
•Once a year, apply light oil to the Front Door Rods.
•If paint gets chipped or scratched, apply touch-up paint. Call Wenger Customer Service for
recommendations.
TRANSPORTING THE MOBILE KIOSK
The Gearboss Mobile Kiosk may be loaded onto a truck if the following recommendations are observed:
• Load and unload the Gearboss Mobile Kiosk from a loading dock.
•Due to its pneumatic tires, severe road conditions could cause a Mobile Kiosk to bounce radically.
Blocking and strapping the Mobile Kiosk will help prevent damage to the Mobile Kiosk or it’s
contents.
If the Mobile Kiosk is loaded for a long road trip, the following is recommended:
• Wood blocking from the truck floor the Mobile Kiosk frame.
• Heavy duty ratchet strap(s), mounted low on the Mobile Kiosk, anchored to the truck wall.
• Padding between the Mobile Kiosk and the truck wall to limit damage to the paint.
King Pin
Location
A runaway Mobile Kiosk could
cause severe injury to anyone
or anything in its path.
!CAUTION
Front Door
Rods
Front Door
Rods

8
REPLACEMENT PARTS LIST
MOBILE KIOSK REPLACEMENT PARTS LIST 1
4
3
8
7
12
11
21
6
5
10
9
Item Qty Description Item Qty Description
1 1 Cart Chassis 7 1 Right Hand Door
2 4 Wheel/Tire Assembly 838 #10 x 3/4” Wood Screw
3 1 Pull Handle Weldment 9 6 Slatwall Door Extrusion
4 2 Bin Handle 10 2Slatwall Back Panel Extrusion
5 1 Left Hand Door 11 1Upper Back Panel
6 1 Canopy Assembly 12 2Bin Door

9
REPLACEMENT PARTS LIST
MOBILE KIOSK REPLACEMENT PARTS LIST 2
Item Qty Description Item Qty Description
116 3/8”-16 Lock Nut 14 2Roof End Cap
210 3/8”-16 x 7/8 Socket Button Head Screw 15 8#10-16 x 3/4” Screw
3 1 Door Stay Weldment 16 2Slatwall Back Panel Extrusion
4 2 Loop Tube Weldment 17 6Door/Canopy Pivot Bracket
5 4 Inner Telescoping Tube 18 24 1/4”-20 Nut Insert
6 4 Outer Telescoping Tube 19 24 1/4”-20 x 5/8” TH Screw
7 8 3/8”-16 Acorn Nut 20 1Right Hand Door
8 2 5/16” x 2” Clevis Pin 21 8#8 x 5/8” Wood Screw
9 2 3/8” ID Flat Washer 22 2Back Panel Bracket
10 63/8”-16 x 1 1/4” Socket Button Head Screw 23 45/16”-18 x 3/4 Carriage Bolt
11 23/8”-16 x 2” Carriage Bolt 24 85/16”-18 Lock Nut
12 1Roof Panel 25 2Rubber Bumper
13 2Roof Extrusion 26 1Countertop Panel
4
3
8
7
11
10
14
11
17
16
23
21
6
5
9
713
12
7
15
21
20
25
18 19
22
24
26

10
REPLACEMENT PARTS LIST
MOBILE KIOSK REPLACEMENT PARTS LIST 3
Item Qty Description Item Qty Description
1 4 #10-16 x 1 1/2” Drill Screw 724 1/4”-20 Nut Insert
2 2 Bin Door 824 1/4”-20 x 5/8” TH Screw
381 3/16” Rivet 9 2 Right Hand Door Pivot Weldment
4 4 Prop Rod 10 4Door Hinge
5 2 Loop Tube Weldment 11 1Right Hand Door
6 1 Canopy Assembly
2
3
7
6
5
10
2
1
5
4
9
8
11

11
REPLACEMENT PARTS LIST
MOBILE KIOSK REPLACEMENT PARTS LIST 4
Item Qty Description Item Qty Description
1 6 5/16” x 1 1/2” Clevis Pin 9 2 Roof Extrusion
2 6 Door/Canopy Pivot Bracket 10 4Outer Telescoping Tube
3 6 5/16” External Retaining Ring 11 41/4”-20 x 1 1/4” Carriage Bolt
4 2 Front Roof End Cap 12 2Canopy Pivot Bracket
5 2 Rod Canopy Pivot 13 51/4”-20 Lock Nut
6 4 3/8” External Retaining Ring 14 2Door Lock Plate
7 2 Loop Tube Weldment 15 2Door Lock Bracket
881 3/16” Rivet 16 23/16” Rivet 1/4” Long
3
2
6
1
MOBILE KIOSK REPLACEMENT PARTS LIST 5
Item Qty Description Item Qty Description
1 2 Stabilizer Leg 3 2 Left Hand Door Pivot Weldment
2 1 Left Hand Stabilizer Weldment
1
4
7
9
8
4
10
12
11
1
3
13
15
14
3
2
16
5

12
REPLACEMENT PARTS LIST
MOBILE KIOSK REPLACEMENT PARTS LIST 6
Item Qty Description Item Qty Description
1 4 #6-18 x 1/2” Philips Pan Head Screw 6 4 Prop Rod
2 2 Bin Door Handle 724 1/4”-20 x 5/8” TH Screw
3 8 #8-32 Nut Insert 8 4 Prop Rod Plate
4 2 Bin Door 924 1/4”-20 Nut Insert
5 8 #8-32 x 3/4” TH Screw 10 424” Hinge
4
3
2
1
4
7
10
6
5
9
8
MOBILE KIOSK REPLACEMENT PARTS LIST 7
Item Qty Description Item Qty Description
1 1 Canopy Assembly 5 1 Canopy Lock Bracket
281 3/16” Rivet 6 6 Door/Canopy Lock Bracket
3 6 Lock Strap 7 1 Lock Bar Weldment
4 2 Plastic Spacer
4
3
2
1
2
6
5
7

13
REPLACEMENT PARTS LIST
MOBILE KIOSK REPLACEMENT PARTS LIST 8
Item Qty Description Item Qty Description
1 4 Bin Box Shelf Bracket 5 1 Bin Box Front Weldment
2 2 Bin Box End Bracket 6 6 Lock Strap
381 3/16” Rivet 7 1 Bin Box Back Weldment
4 3 Bin Box Shelf Tube
4
3
2
1
7
6
5
MOBILE KIOSK REPLACEMENT PARTS LIST 9
Item Qty Description Item Qty Description
1 2 Edge Cover Bracket 4 1 Lower Panel
2 1 Lower Back Panel 516 3/8”-16 Lock Nut
381 3/16” Rivet 6 4 3/8”-16 x 2 1/2” Carriage Bolt
3
2
1
6
5
4

14
REPLACEMENT PARTS LIST
MOBILE KIOSK REPLACEMENT PARTS LIST 10
Item Qty Description Item Qty Description
1 4 Wheel/Tire Assembly 6 1 Cart Chassis
2 4 Axle 7 1 Cotter Pin
3 4 Screw Socket BHD, 5/16”-18 x 1 1/2” 8 2 Bearing
4 5 5/16”-18 Lock Nut 9 3 Washer
5 2 Logo Plate with Retainers 10 1Front Yoke Weldment
3
2
1
6
4
MOBILE KIOSK REPLACEMENT PARTS LIST 11
Item Qty Description Item Qty Description
1 1 1 1/4” Tube Plug 8 5 1/4”-20 Lock Nut
2 2 Handle Grip 9 1 5/16” x 3/8” Shoulder Bolt
3 1 Pull Handle Weldment 10 1Handle Release Rod
4 1 3/8”-16 x 5 1/4” Capscrew 11 13/8”-16 Nut
5 1 Scrub Brake Weldment 12 16 3/8”-16 Lock Nut
616 3/8”-16 Lock Nut 13 2Extension Spring
7 2 Scrub Brake Grip
4
3
2
1
7
6
5
11
10
8
12
9
5
3
10
48
9
7
13

15
REPLACEMENT PARTS LIST
MOBILE KIOSK REPLACEMENT PARTS LIST 12
Item Qty Description
1 4 Inner Telescoping Tube
2 4 5/16” Snap Button
3 4 Outer Telescoping Tube
3
2
1
MOBILE KIOSK REPLACEMENT PARTS LIST 13
Item Qty Description Item Qty Description
1 2 7/8” Tube Plug 5 2 3/8”-16 x 3/4” Socket Button Head Screw
2 2 Stabilizer Leg 610 3/8”-16 x 7/8” Socket Button Head Screw
3 2 Glide 7 1 RH Stabilizer Weldment
4 2 3/4” OD Flat Washer 8 2 1/4”-20 x 1” Drill Screw
4
3
2
1
7
6
5
MOBILE KIOSK REPLACEMENT PARTS LIST 14
Item Qty Description
1 8 Plastic Bin
1
8