Woodbridge BS5430R Assembly instructions

R
WOODBRIDGE
WOODBRIDGE WOODBRIDGE
WOODBRIDGE
R
WOODBRIDGE
WOODBRIDGE WOODBRIDGE
WOODBRIDGE
R
WOODBRIDGE
WOODBRIDGE WOODBRIDGE
WOODBRIDGE
R
WOODBRIDGE
WOODBRIDGE WOODBRIDGE
WOODBRIDGE
R
WOODBRIDGE
WOODBRIDGE WOODBRIDGE
WOODBRIDGE
R
WOODBRIDGE
WOODBRIDGE WOODBRIDGE
WOODBRIDGE
R
WOODBRIDGE
WOODBRIDGE WOODBRIDGE
WOODBRIDGE
R
WOODBRIDGE
WOODBRIDGE WOODBRIDGE
WOODBRIDGE
R
WOODBRIDGE
WOODBRIDGE WOODBRIDGE
WOODBRIDGE
R
WOODBRIDGE
WOODBRIDGE WOODBRIDGE
WOODBRIDGE
R
WOODBRIDGE
WOODBRIDGE WOODBRIDGE
WOODBRIDGE
R
WOODBRIDGE
WOODBRIDGE WOODBRIDGE
WOODBRIDGE
1
INSTALLATION AND CARE GUIDE
20230618 REV. 1
READ ALL INSTRUCTIONS BEFORE UNPACKING THE PRODUCT
2 PEOPLE ARE REQUIRED TO LIFT AND DURING
ENTIRE INSTALLATION OF THIS PRODUCT
INSTRUCTIONS THAT, IF IGNORED COULD RESULT IN DEATH OR SERIOUS INJURY CAUSED BY INCORRECT HANDLING
OR INSTALLATION OF THE PRODUCT. THESE INSTRUCTIONS MUST BE OBSERVED FOR SAFE INSTALLATION.
Customer Service Phone: [phone]. (Monday - Friday 9 AM - 5 PM Pacific Time)
Or Email: [email protected]

(UL1795)


®(IPC)
®(IRC)
®(UPC)
®(NPC)
This products must be installed by a fully insured and licensed plumber only. Installation of any our product by anyone other
than fully insured and licensed plumber shall void limited warranty. We recommends that such licensed plumber has experience
in the installation of products.
We are not responsible for local code compliance for this product. Building and plumbing codes may vary from state-to-state in
accordance to your location. We are not responsible for providing any compliance certifications.
Under no circumstances we shall not be liable for any incidental damages sustained in connection with this product
Neither manufacture, nor distributor, nor retailer is responsible for water damage or flood caused due to use of this product.
Under no circumstances We shall not be liable for any and all fees, cost of installation/reinstallation/removal, subsequent
damage or transportation in case of the product defect
BS5430R BS5430L
BS6030R BS6030L
BS6032R BS6032L
R
WOODBRIDGE MODERN ALCOVE BATHTUB

R
WOODBRIDGE
WOODBRIDGE WOODBRIDGE
WOODBRIDGE
R
WOODBRIDGE
WOODBRIDGE WOODBRIDGE
WOODBRIDGE
R
WOODBRIDGE
WOODBRIDGE WOODBRIDGE
WOODBRIDGE
R
WOODBRIDGE
WOODBRIDGE WOODBRIDGE
WOODBRIDGE
R
WOODBRIDGE
WOODBRIDGE WOODBRIDGE
WOODBRIDGE
R
WOODBRIDGE
WOODBRIDGE WOODBRIDGE
WOODBRIDGE
R
WOODBRIDGE
WOODBRIDGE WOODBRIDGE
WOODBRIDGE
R
WOODBRIDGE
WOODBRIDGE WOODBRIDGE
WOODBRIDGE
2
TOOLS REQUIRED FOR INSTALLATION (NOT INCLUDED)
OTHER TOOLS MAY BE REQUIRED
Soft Cloth
or Blanket
Silicone Tape
Measure
Pencil/Marker Hammer
Safety Glass LevelKnife Caulk Gun Adjustable
Wrench
Channel
Lock Pliers
First ensure that the subfloor is level.
If needed, level subfloor with leveling compound or mortar over
the entire area of installation.


B
A
C


Hacksaw
Drill
B
A
C
Framing Square
Model A B
C
BS5430R 54''
30''
21-5/8''
BS6030R 60''
30''
BS6032R 60''
32''
21-5/8''
21-5/8''
10-1/4"
10-1/4"
D
9-7/8"
D
D
Model A B
C
BS5430L 54''
30''
21-5/8''
BS6030L 60''
30''
BS6032L 60''
32''
21-5/8''
21-5/8''
10-1/4"
10-1/4"
D
9-7/8"

R
WOODBRIDGE
WOODBRIDGE WOODBRIDGE
WOODBRIDGE
R
WOODBRIDGE
WOODBRIDGE WOODBRIDGE
WOODBRIDGE
R
WOODBRIDGE
WOODBRIDGE WOODBRIDGE
WOODBRIDGE
R
WOODBRIDGE
WOODBRIDGE WOODBRIDGE
WOODBRIDGE
R
WOODBRIDGE
WOODBRIDGE WOODBRIDGE
WOODBRIDGE
R
WOODBRIDGE
WOODBRIDGE WOODBRIDGE
WOODBRIDGE
R
WOODBRIDGE
WOODBRIDGE WOODBRIDGE
WOODBRIDGE
R
WOODBRIDGE
WOODBRIDGE WOODBRIDGE
WOODBRIDGE
3
Tolerance on dimensions: ±1/2"
1"1"
21-5/8"
16-7/8"
R 2-3/8"
6"
7-5/8"
8-1/2"
R 2-3/8"
16-1/8"
3-3/8"
60"
54-1/2"
41-3/4"
3-1/4" 3/8"
2-5/8"
24"
3"
Ø2"
2-3/4" 2-3/4"
30"
27-1/8"
17-3/4"
1-3/8" 35-3/8" 10-1/4"
2-1/2"
1-3/8"
9-1/2"
14-1/2"
2-3/8"
BS6030R
BS5430R
14-1/2"
2-3/8"
16-7/8"
1"
21-5/8"
16-1/8"
6"
8-1/2"
7-5/8"
R 2-3/8"
R 2-3/8"
54"
48-1/2"
2-3/4"
9-1/2" 2-3/4"
2-3/4"
36-1/4" 3/8"
2-5/8"
24"
3"3"
9-7/8"32-1/4"
1-3/8"
2-1/2"
30"
27-1/8"
17-3/4"
1-3/8"
Ø2"
BS5430L
14-1/2"
2-3/8"
16-7/8"
1"
21-5/8"
16-1/8"
6"
8-1/2"
7-5/8"
R 2-3/8"
R 2-3/8"
54"
48-1/2" 2-3/4"
9-1/2"
2-3/4"
2-3/4"
36-1/4"
3/8"
2-5/8"
24"
3"
9-7/8" 32-1/4"
1-3/8"
2-1/2"
30"
27-1/8"
17-3/4"
1-3/8"
Ø2"
Tolerance on dimensions: ±1/2"
Tolerance on dimensions: ±1/2"

R
WOODBRIDGE
WOODBRIDGE WOODBRIDGE
WOODBRIDGE
R
WOODBRIDGE
WOODBRIDGE WOODBRIDGE
WOODBRIDGE
R
WOODBRIDGE
WOODBRIDGE WOODBRIDGE
WOODBRIDGE
R
WOODBRIDGE
WOODBRIDGE WOODBRIDGE
WOODBRIDGE
R
WOODBRIDGE
WOODBRIDGE WOODBRIDGE
WOODBRIDGE
R
WOODBRIDGE
WOODBRIDGE WOODBRIDGE
WOODBRIDGE
R
WOODBRIDGE
WOODBRIDGE WOODBRIDGE
WOODBRIDGE
R
WOODBRIDGE
WOODBRIDGE WOODBRIDGE
WOODBRIDGE
4
BS6030L
1" 1"
21-5/8"
16-7/8"
R 2-3/8"
6"
7-5/8"
8-1/2"
R 2-3/8"
16-1/8"
3-3/8"
60"
54-1/2"
41-3/4"
3-1/4"
3/8"
2-5/8"
24"
3"
Ø2"
2-3/4"2-3/4"
30"
27-1/8" 17-3/4"
1-3/8"
35-3/8"
10-1/4"
2-1/2"
1-3/8"
9-1/2"
14-1/2"
2-3/8"
1"1"
21-5/8"
16-7/8"
R 2-3/8"
6"
7-5/8"
8-1/2"
R 2-3/8"
16-1/8"
3-3/8"
60"
54-1/2"
41-3/4"
3-1/4" 3/8"
2-5/8"
26"
3"
Ø2"
2-3/4" 2-3/4"
32"
29-1/8"
19-3/4"
1-3/8" 35-3/8" 10-1/4"
2-1/2"
1-3/8"
9-1/2"
14-1/2"
2-3/8"
BS6032R
BS6032L
1" 1"
21-5/8"
16-7/8"
R 2-3/8"
6"
7-5/8"
8-1/2"
R 2-3/8"
16-1/8"
3-3/8"
60"
54-1/2"
41-3/4"
3-1/4"
3/8"
2-5/8"
26"
3"
Ø2"
2-3/4"2-3/4"
32"
29-1/8" 19-3/4"
1-3/8"
35-3/8"
10-1/4"
2-1/2"
1-3/8"
9-1/2"
14-1/2"
2-3/8"
Tolerance on dimensions: ±1/2"
Tolerance on dimensions: ±1/2"
Tolerance on dimensions: ±1/2"

R
WOODBRIDGE
WOODBRIDGE WOODBRIDGE
WOODBRIDGE
R
WOODBRIDGE
WOODBRIDGE WOODBRIDGE
WOODBRIDGE
R
WOODBRIDGE
WOODBRIDGE WOODBRIDGE
WOODBRIDGE
R
WOODBRIDGE
WOODBRIDGE WOODBRIDGE
WOODBRIDGE
R
WOODBRIDGE
WOODBRIDGE WOODBRIDGE
WOODBRIDGE
R
WOODBRIDGE
WOODBRIDGE WOODBRIDGE
WOODBRIDGE
R
WOODBRIDGE
WOODBRIDGE WOODBRIDGE
WOODBRIDGE
R
WOODBRIDGE
WOODBRIDGE WOODBRIDGE
WOODBRIDGE
5
The unit must be connected only to a supply circuit that is protected by a Ground-Fault
Circuit Interrupter (GFCI). Such a GFCI should be provided by the installer and should be
tested on a routine basis.
ELECTRICAL REQUIREMENTS
R
WOODBRIDGE
RESET



In the example above, there are 2 Dedicated 120V 15AMP GFCI Breakers.
THESE CANNOT BE SHARED
WHIRLPOOL PUMP
2 Total Breakers
Fill bathtub with water to approximately 40 mm above the jets and trial run pump for 10-15
minutes. Check all the fittings for leaks and test the control functions. Switch off the spa
pump and leave the unit filled with water (pump is not running) for at least another two
minutes. Check the pump and pipes union connections for leaks. Hand tighten union
connections if required.
Connect Power Supply:
Connect power supply to control unit. The electrical connections must comply with local
authority regulations and must be done by an authorized electrician.
IMPORTANT: Your bathtub has been factory tested and approved. It is the responsibility of
the installer to test run the bathtub, check all the fittings for leaks and test the control functions.
NON OBSERVANCE WILL INVALIDATE FACTORY WARRANTY.
WHIRLPOOL ALCOVE BATHTUB
CGFI
Outlet
RESET
Safe zone
12"
safe zone height is 305mm(12")

RESET

1. One (1) Dedicated GFCI Breaker for the Whirlpool Pump
2. One (1) Dedicated GFCI Breaker for the Heater


C




R
WOODBRIDGE
WOODBRIDGE WOODBRIDGE
WOODBRIDGE
R
WOODBRIDGE
WOODBRIDGE WOODBRIDGE
WOODBRIDGE
R
WOODBRIDGE
WOODBRIDGE WOODBRIDGE
WOODBRIDGE
R
WOODBRIDGE
WOODBRIDGE WOODBRIDGE
WOODBRIDGE
R
WOODBRIDGE
WOODBRIDGE WOODBRIDGE
WOODBRIDGE
R
WOODBRIDGE
WOODBRIDGE WOODBRIDGE
WOODBRIDGE
R
WOODBRIDGE
WOODBRIDGE WOODBRIDGE
WOODBRIDGE
R
WOODBRIDGE
WOODBRIDGE WOODBRIDGE
WOODBRIDGE
6











R
WOODBRIDGE
WOODBRIDGE WOODBRIDGE
WOODBRIDGE
R
WOODBRIDGE
WOODBRIDGE WOODBRIDGE
WOODBRIDGE
R
WOODBRIDGE
WOODBRIDGE WOODBRIDGE
WOODBRIDGE
R
WOODBRIDGE
WOODBRIDGE WOODBRIDGE
WOODBRIDGE
R
WOODBRIDGE
WOODBRIDGE WOODBRIDGE
WOODBRIDGE
R
WOODBRIDGE
WOODBRIDGE WOODBRIDGE
WOODBRIDGE
R
WOODBRIDGE
WOODBRIDGE WOODBRIDGE
WOODBRIDGE
R
WOODBRIDGE
WOODBRIDGE WOODBRIDGE
WOODBRIDGE
7











R
WOODBRIDGE
WOODBRIDGE WOODBRIDGE
WOODBRIDGE
R
WOODBRIDGE
WOODBRIDGE WOODBRIDGE
WOODBRIDGE
R
WOODBRIDGE
WOODBRIDGE WOODBRIDGE
WOODBRIDGE
R
WOODBRIDGE
WOODBRIDGE WOODBRIDGE
WOODBRIDGE
R
WOODBRIDGE
WOODBRIDGE WOODBRIDGE
WOODBRIDGE
R
WOODBRIDGE
WOODBRIDGE WOODBRIDGE
WOODBRIDGE
R
WOODBRIDGE
WOODBRIDGE WOODBRIDGE
WOODBRIDGE
R
WOODBRIDGE
WOODBRIDGE WOODBRIDGE
WOODBRIDGE
8
Care and Cleaning
Retain these installation instructions for future reference!
IMPORTANT!
Abrasive cleaners such as: acid, ammonia, bleach, and simmilar solutions. Use of such solutions may cause
corrosion, finish peeling, and/or dull the surface.
Abrasive sponges or cloth. Never use steel, wool, or wired brushes that will permanently scratch the surface.
• Most dirt will wash off with mild soap and warm water.
• For tough spots, use liquid dish washing soap or non-chlorine bleach.
• Do not use abrasive material such steel wool or scouring pads to clean the acrylic surface.
• Always test the cleaning solution on a small area before using it on the entire surface.
• Do not allow cleaning to soak on the acrylic surface.
• Rinse thoroughly with water immediately and wipe dry with soft cloth.
• Use liquid polish compound such as Gel-Gloss Kitchen and Bath Polish(TM) to keep the original shine of acrylic surface.
• Light scratches can be removed with polishing compound for automobiles.
• For deeper scratches use wet sandpaper (1500 grit or higher). Always add water when sanding and lightly sand the area larger
than the scratch in a circular motion to remove the scratches. Repeat until the scratch is removed. Use soft cloth and small
amount of polishing compound to restore shine. Repeat as needed until surface shine is restored.
Repair and Maintenance
The bathtub must be installed and used as described in this manual
Use caution when entering or exiting the bathtub
Do not permit children or persons with infirmities to use the bathtub without supervision of an adult
People using any medications or having adverse medical history must consult a physician prior to use of the bathtub
to avoid potential hyperthermia and possible drowning
Water temperature over 100ºF may cause hyperthermia and/or other health problems. Check water temperature
and adjust it for your personal comfort
Never use bathtub while intoxicated, after taking meals or any alcoholic beverages. Consuming alcoholic beverages
before or during bathing will cause drowsiness and may result in hyperthermia, loss of consciousness, or even
drowning
If you are pregnant or you feel that you are may be pregnant, consult your doctor before using the bathtub
Never use any electrical devices such as hair dryer, lamp, telephone, tv, radio, or others within 5 feet of the bathtub
Do not overfill the bathtub before enetering. Entering the bathtub when filled will cause overflow and slippery
conditions. Use extreme caution when entering and exiting
IMPORTANT SAFETY RULES
ATTENTION! ALWAYS FOLLOW THESE PRECAUTIONS WHEN USING A BATHTUB









Thank you for using WoodBridge products!
Please don't hesitate to contact us if you have any questions or concerns.
Customer Service Phone: [phone]. (Monday - Friday 9 AM - 5 PM Pacific Time)
Or Email: [email protected]