Yamaha SX230 High output Owner's manual

SX230
Owner’s / Operator’s Manual
SX230 Owner’s / Operator’s Manual
LIT-18626-05-71
@2003 Yamaha Motor Corporation, U.S. A. Printed in U.S.A.
*SX230(SRT1000)-'04-OwnMnl 9/17/03 3:06 PM Page 2

Thank you for choosing a Yamaha
Sport Boat. This Owner’s Manual con-
tains information you will need for prop-
er operation, maintenance, and care. A
thorough understanding of these simple
instructions will help you to obtain max-
imum enjoyment from your new
Yamaha. If you have any questions
about the operation or maintenance of
your Sport Boat, please consult a
Yamaha dealer.
Because Yamaha has a policy of con-
tinuing product improvement, this prod-
uct may not be exactly as described in
this Owner’s Manual. Specifications are
subject to change without notice.
This manual should be considered a
permanent part of this Sport Boat and
should remain with it even if the boat is
subsequently sold.
IMPORTANT MANUAL INFORMATION:
In this manual, information of particular
importance is distinguished in the fol-
lowing ways:
The Safety Alert Symbol means
ATTENTION! BECOME ALERT!
YOUR SAFETY IS INVOLVED!
Failure to follow WARNING instruc-
tions could result in severe injury or
death to the machine operator, a
bystander, or a person inspecting or
repairing the Sport Boat.
ACAUTION indicates special precau-
tions that must be taken to avoid
damage to the Sport Boat.
NOTE: ANOTE provides key informa-
tion to make procedures easier or clear-
er.
TO THE OWNER
SX230 SPORT BOAT
SRT1000B/BC
OWNER’S/OPERATOR’S MANUAL
©2003 by Yamaha Motor Corporation, U.S.A.
1st Edition, September 2003
All rights reserved. Any reprinting
or unauthorized use
without the written permission of
Yamaha Motor Corporation,
U.S.A. is expressly prohibited.
Printed in U.S.A.
LIT-18626-05-71
03-464
CAUTION:
WARNING
*SX230(SRT1000)-'04-OwnMnl 9/17/03 3:06 PM Page 4

2
FEATURES & FUNCTIONS
1
SAFETY INFORMATION
3
OPERATION
4
MAINTENANCE & CARE
5
TROUBLESHOOTING & SPECIAL PROCEDURES
6
CONSUMER INFORMATION
SPORT BOAT
SX230
*SX230(SRT1000)-'04-OwnMnl 9/17/03 3:06 PM Page 6

Chapter 1
SAFETY INFORMATION
IDENTIFICATION NUMBER RECORDS . . . . . . . . . . . . . . . . . . . . . . . . . . .1-1
Primary I.D. Number . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1-1
Hull Identification Number (H.I.N.) . . . . . . . . . . . . . . . . . . . . . . . . . . .1-1
Engine Serial Number . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1-1
Star Labels . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-2
Emission Control Information . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-3
IMPORTANT LABELS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1-4
Location . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1-4
Labels . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1-5
SAFETY INFORMATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1-8
Limitations On Who May Operate the Sport Boat . . . . . . . . . . . . . . . .1-8
Required Equipment . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1-9
Additional Equipment Recommendations . . . . . . . . . . . . . . . . . . . . . .1-9
Cruising Limitations . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-10
Operational Requirements . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1-11
Hazard Information . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-12
Sport Boat Characteristics . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1-12
Night Operation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1-13
Water-skiing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1-14
RULES OF THE ROAD . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1-15
Steering and Sailing Rules . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1-15
Rules When Encountering Vessels . . . . . . . . . . . . . . . . . . . . . . . . . .1-16
Other Special Situations . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1-17
Reading Buoys and Other Markers . . . . . . . . . . . . . . . . . . . . . . . . . 1-18
TO GET MORE BOATING SAFETY INFORMATION . . . . . . . . . . . . . . . . .1-19
Boating Education and Training . . . . . . . . . . . . . . . . . . . . . . . . . . . .1-19
ACCIDENT REPORTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1-20
ENJOY YOUR SPORT BOAT RESPONSIBLY . . . . . . . . . . . . . . . . . . . . .1-20
*SX230(SRT1000)-'04-OwnMnl 9/17/03 3:06 PM Page 8

1-1
SAFETY INFORMATION 1
IDENTIFICATION
NUMBER RECORDS
Record your Primary I.D., H.I.N., and
engine numbers in the spaces provided
to assist you in ordering spare parts
from your Yamaha Sport Boat dealer.
Also record and keep these I.D. num-
bers in a separate place in case your
Sport Boat is stolen.
PRIMARY I.D. NUMBER
\\\\\\\\\\\\\\\\\\\\\\
The Primary I.D. number is stamped on
a label 1attached to the inside of the
engine compartment.
HULL IDENTIFICATION NUMBER
(H.I.N.)
\\\\\\\\\\\\\\\\\\\\\\\\\\
The H.I.N. 2 is stamped into the hull
on the right rear corner.
ENGINE SERIAL NUMBER
PORT
STARBOARD
The Engine Serial Numbers are
stamped on a label ➂attached to the
top of the engine oil tank.
\\\\\\\\\\\\\\\\\\\\\\
F1C
\\\\\\\\\\\\\\\\\\\\\\
1
2
3
*SX230(SRT1000)-'04-OwnMnl 9/17/03 3:06 PM Page 10

SAFETY INFORMATION 1
1-3
STAR LABELS
This watercraft is labeled in California
with a California Air Resources Board
(CARB) star label 1. See below for a
desciption of your particular label.
ONE STAR - LOW EMISSION
The one-star label identifies engines
that meet the Air Resources Board’s
2001 exhaust emission standards.
Engines meeting these standards have
75% lower emissions than convention-
al carbureted two-stroke engines.
These engines are equivalent to the
U.S. EPA’s 2006 standards for marine
engines.
TWO STARS - VERY LOW EMISSION
The two-star label identifies engines
that meet the Air Resources Board’s
2004 exhaust emission standards.
Engines meeting these standards have
20% lower emissions that One Star-
Low-Emission engines.
THREE STARS - ULTRA LOW EMISSION
The three-star label identifies engines
that meet the Air Resources Board’s
2008 exhaust emission standards.
Engines meeting these standards have
65% lower emissions than One Star-
Low-Emission engines.
1SAFETY INFORMATION
1-2
EMISSION CONTROL
INFORMATION
This engine family conforms to U.S.
EPA regulations for marine SI engines.
APPROVAL LABEL OF EMISSION
CONTROL CERTIFICATE
This label is attached to the electrical
box.
1Emission control information
label
MANUFACTURED DATE LABEL
2Manufactured date label
EMISSION CONTROL INFORMATION
ENGINE FAMILY :
THIS ENGINE CONFORMS TO U.S. EPA REGULATIONS FOR MARINE S1 ENGINES
FELs g/low - hr SPARK PLUG GAP (mm) :
TROLLING SPEED : rpm
YAMAHA MOTOR CO., CO, LTD.
YAMAHA
Manufactured:
1
2
*SX230(SRT1000)-'04-OwnMnl 9/17/03 3:06 PM Page 1-2

SAFETY INFORMATION 1
1-3
STAR LABELS
This watercraft is labeled in California
with a California Air Resources Board
(CARB) star label 1. See below for a
desciption of your particular label.
ONE STAR - LOW EMISSION
The one-star label identifies engines
that meet the Air Resources Board’s
2001 exhaust emission standards.
Engines meeting these standards have
75% lower emissions than convention-
al carbureted two-stroke engines.
These engines are equivalent to the
U.S. EPA’s 2006 standards for marine
engines.
TWO STARS - VERY LOW EMISSION
The two-star label identifies engines
that meet the Air Resources Board’s
2004 exhaust emission standards.
Engines meeting these standards have
20% lower emissions that One Star-
Low-Emission engines.
THREE STARS - ULTRA LOW EMISSION
The three-star label identifies engines
that meet the Air Resources Board’s
2008 exhaust emission standards.
Engines meeting these standards have
65% lower emissions than One Star-
Low-Emission engines.
1SAFETY INFORMATION
1-2
EMISSION CONTROL
INFORMATION
This engine family conforms to U.S.
EPA regulations for marine SI engines.
APPROVAL LABEL OF EMISSION
CONTROL CERTIFICATE
This label is attached to the electrical
box.
1Emission control information
label
MANUFACTURED DATE LABEL
2Manufactured date label
EMISSION CONTROL INFORMATION
ENGINE FAMILY :
THIS ENGINE CONFORMS TO U.S. EPA REGULATIONS FOR MARINE S1 ENGINES
FELs g/low - hr SPARK PLUG GAP (mm) :
TROLLING SPEED : rpm
YAMAHA MOTOR CO., CO, LTD.
YAMAHA
Manufactured:
1
2
*SX230(SRT1000)-'04-OwnMnl 9/17/03 3:06 PM Page 1-2

SAFETY INFORMATION 1
1-5
1SAFETY INFORMATION
1-4
IMPORTANT LABELS
2
5
6
13
4
7
6 6
14
5
4
6
1
2
3
8
6
6
13
13
12
16
7
15
10
7
9
1 2
3 15
4
11
*SX230(SRT1000)-'04-OwnMnl 9/17/03 3:06 PM Page 1-4

SAFETY INFORMATION 1
1-5
1SAFETY INFORMATION
1-4
IMPORTANT LABELS
2
5
6
13
4
7
6 6
14
5
4
6
1
2
3
8
6
6
13
13
12
16
7
15
10
7
9
1 2
3 15
4
11
*SX230(SRT1000)-'04-OwnMnl 9/17/03 3:06 PM Page 1-4

SAFETY INFORMATION 1
1-7
1SAFETY INFORMATION
1-6
F1C
Do not touch or remove electrical parts
when starting or running engine.
YAMAHA 6R7-83623-40
10
9
11
12
13
16
15
14
8
*SX230(SRT1000)-'04-OwnMnl 9/17/03 3:06 PM Page 1-6