Zodiac Nature2 Express User manual

EQUIPMENT UNDER PRESSURE
• In order to minimize risk of property damage and/or serious injury, including loss of life, always
turn pump off prior to installing or changing Nature2cartridge. Your pump/filter system is
operated under pressure and the pressure must be released before you begin work. Please see
your pump/filter owner’s manual for further instructions.
PREVENT CHILD DROWNING
• Do not let anyone, especially small children, sit, step, lean or climb on any equipment installed as
part of your pool’s operational system. Locate the components of your operational system at least 3
feet from the pool so children cannot use the equipment to access the pool and be injured or drown.
LOW CHLORINE RECIPE
• You must strictly follow the low chlorine recipe included in this manual to maintain proper water
chemistry and avoid health hazards. Failure to follow these instructions can lead to sickness
from bacteria and other noxious organisms.
WARNING
Failure to heed the following can result in
permanent injury or drowning.
!
The Nature2Pool Sanitizer
is designed only for
residential swimming pools.
For Inground Pools and Aboveground Pools
EPA Reg. No. 67712-1
EPA Est. No. 091258-MEX-001
PRECAUTIONARY STATEMENT
HAZARDS TO HUMANS AND DOMESTIC ANIMALS
CAUTION
In the unlikely event that a cartridge breaks, mineral media should not be
ingested by humans or animals as it may cause gastric distress.
FIRST AID
IF INGESTED: Call poison control center or doctor immediately for treatment
advice.
CAUTION
!
Nature2®Express Cartridges have been designed to sanitize swimming pools from 5,000 to 25,000 gallons.
* The Nature2System consists of
the Nature2technology†used in
conjunction with a chlorine delivery
device or 0.5 ppm of an EPA
registered chlorine pool product.
†Nature2technology consists of
the minerals silver and copper.
IMPORTANT
Pool Owner, save this manual. Builders, leave this manual with the pool owner.
Safety Instructions
Important Information Please read prior to installation
ENGLISH
OWNER’S MANUAL
TL-2626 Rev G

Page 2 ENGLISH Zodiac®Nature2® Express Cartridge |Owner’s Manual
DIRECTIONS FOR USE:
It is a violation of Federal law to use this product in a manner inconsistent with its labeling.
NATURE2COMPATIBILITY
Nature2Systems* can be used with all types of pool chemical treatments available except
biguanide products and copper based algaecides.
Important: When converting a biguanide treated pool to the Nature2System*, the pool must be completely
drained and refilled. Then follow the Nature2cartridge start-up procedure below.
Start Up
• Before starting up a new Nature2cartridge, clean debris and algae out of the pool and pool equipment.
Important: Do not install the new cartridge until the pool water is clean and chemically balanced.
• Balance pool water before installing Nature2cartridge.
- pH 7.4-7.8
- Calcium hardness 200-400 ppm
- Total alkalinity 80-150 ppm
Consult with your Nature2Dealer for specific water balance instructions.
We ask you to take the time to get familiar with this manual.
Thank you for purchasing Nature2. We believe the more you know, the more enjoyable your family’s
swimming experience will be – and the more you will reduce the time, effort and cost of maintaining your
pool. Pool owners who switch from conventional chemical programs to the Nature2System* spend less time
maintaining their pools. Every pool has its own characteristics of water type, amount of sunlight, etc. The
recipe included in this manual will help insure good water quality for your pool. Remember, your Nature2
dealer can provide advice and service.
CONTENTS PAGE
Safety Instructions .......................................................................1
Start Up ...............................................................................2
Balance the Water .......................................................................3
Install the Cartridge ......................................................................3
Recipe ................................................................................4
Provide Filtration/Circulation................................................................4
Nature2Cartridge Replacement Intervals......................................................5
Winterizing Your Pool.....................................................................5
Disposal ...............................................................................5
Troubleshooting Guide ...................................................................6
Limited Warranty ........................................................................8

Page 3
ENGLISH
Owner’s Manual |Zodiac®Nature2® Express Cartridge
Balance the Water
To find out if your pool water is balanced:
• take a water sample to your dealer to be tested regularly, or
• ask your dealer to recommend a pool test kit for water balance.
Element: pH
Range: 7.4-7.8
Element: Calcium Hardness
Range: 200-400 ppm
Element: Total Alkalinity
Range: 80-150 ppm
If it’s too low:
How to fix:
If it’s too high:
How to fix:
If it’s too low:
How to fix:
If it’s too high:
How to fix:
If it’s too low:
How to fix:
If it’s too high:
How to fix:
The surface of your pool can become etched.
Metal parts in the pump and plumbing will corrode.
Add pH increaser.
“Scale” forms on the surface of your pool.
The water can become cloudy.
Equipment can become damaged.
Add pH decreaser.
Water is less stable.
In plaster pools, the calcium is taken out of the plaster,
causing the surface to deteriorate.
Add calcium hardness increaser.
Rough, discolored deposits (“scale”) will form on the
pool surface and inside pool equipment.
Drain or dilute the pool water.
Consult your dealer.
It provides no buffer so that you constantly get
fluctuating pH readings, which can damage equipment
and pool surfaces.
Use an alkalinity increaser.
White deposits (“scale”) form on the tile line.
The plaster on pool surface becomes rough or
discolored.
The water becomes cloudy or milky white.
Add acid to bring alkalinity down.
Install the Cartridge
1 Install the cartridge after water is balanced. Refer to your Nature2Express operating manual for
additional instructions.
2 Superoxidize the pool water with chlorine according to manufacturer’s instructions to burn off
contaminants and activate cartridge.
Important: Initial superoxidation with chlorine is required to burn off contaminants and activate cartridge.
3 Run the circulating pump either:
• 24 hours a day for 4 days, maintaining 1-2 ppm free chlorine throughout, or
• 6 hours a day for 14 days, maintaining 1-2 ppm free chlorine throughout.
4 Let chlorine dissipate to 0.5 ppm once start up period is completed.
• Do not enter the pool if the free available chlorine residual is over 3 ppm.

Page 4 ENGLISH Zodiac®Nature2® Express Cartridge |Owner’s Manual
Low-Chlorine Recipe
Ingredients:
• Nature2Cartridge • Calcium hardness increaser, if needed
• Chlorine granules, tablets, liquid or generator • Water test kit
• pH and total alkalinity adjusting chemicals
Once the 4-day or 14-day start-up period is done, allow the free available chlorine residual to drop to 0.5 ppm
(by reducing the amount of chlorine you add) then:
When: What to do:
Every day Run pump and filter at least six (6) hours every day.
Once a week Balance pH and total alkalinity.
Twice a week Check chlorine residual; add chlorine to maintain at least a 0.5 ppm range using the chart below.
As needed If water is hazy, superoxidize with chlorine according to manufacturer’s instructions.
Additional shocking is recommended following rainstorms or heavy bather load.
Do not re-enter the pool if the free available chlorine residual is over 3 ppm.
Recipe
There is one (1) recipe for maintaining clean, clear, sanitized water with minimum time and effort.
This recipe provides the easiest and most economical way to care for your Nature2pool.
Provide Filtration/Circulation
To manage: You need to:
Circulation Follow the manufacturer’s directions for keeping the circulating pump in good working
order and operate it at least six (6) hours a day.
Consult your Nature2dealer for optimum run times.
Filtration Check the pool’s filter periodically and clean it as recommended by the manufacturer.
Add the following amounts of chlorine per 10,000 gallons of water to increase free chlorine by 0.5 ppm.
Type of Chlorine % Active % Available Ounce Quantity Gram Quantity
Containing Compound Ingredient Chlorine Content Required Required
Sodium Hypochlorite Liquid 5.25 5.25 12.7 361
Sodium Hypochlorite Liquid 9.2 9.2 7.3 206
Sodium Hypochlorite Liquid 10 10 6.5 184
Sodium Hypochlorite Liquid 12 12 5.6 158
Calcium Hypochlorite 65 64 1.1 30
Dichloroisocyanurate 99 62 1.1 30
Lithium Hypochlorite 29 35 1.9 54
Trichloro-s-triazintrione 99 90 0.7 21
Chlorine Gas, from any source 100 100 0.7 19
including chlorine generators

Page 5
ENGLISH
Owner’s Manual |Zodiac®Nature2® Express Cartridge
Nature2Cartridge Replacement Intervals
Use the month indicator ring on the top of the cartridge to identify the date on which the cartridge should be
replaced. Always turn pump off prior to installing or changing Nature2Express cartridge. Your pump/filter is
operated under pressure and the pressure must be released before you begin work. Please see your pump/
filter owner’s manual for further instructions.
A cartridge lasts six (6) months or one (1) season, whichever is shorter. The cartridge should not be used
longer than six (6) continuous months.
Disposal
After six (6) months of use, discard Nature2cartridge in household trash. Do not save the cartridge for re-use.
The cartridge is manufactured with the mineral media sealed inside. In the unlikely event a cartridge breaks,
remove it and vacuum out any media introduced into the pool.
Winterizing Your Pool
Use these steps as a guide. Consult your dealer for specific information in your area.
Warm Climate
1 Reduce the number of hours the pump runs since the cooler weather decreases the spread of algae
and other pollutants.
2 There is no need to superoxidize the pool during cool weather unless the water becomes cloudy (as
may occur after a winter storm). See Cloudy Water in Troubleshooting section.
Cold Climate
1 Check total alkalinity and pH of pool to make sure that they are in proper balance.
2 Vacuum the pool bottom to remove any debris or other potential contaminants.
3 Superoxidize the pool with chlorine according to manufacturer’s instructions to clear the water.
4 Add a winter algaecide following manufacturer’s instructions.
Important: Do not use a winter algaecide with copper in it. This will void the Nature2no-stain warranty.
5 Backwash the filter.
6 Drain part of the pool water. The amount to drain varies from one part of
the country to another. Consult your dealer for advice.
7 Remove the Nature2cartridge and discard with household trash.
8 Winterize the pipes with pool antifreeze following manufacturer’s instructions.
9 Drain the water out of all equipment (pump, filter, etc.).
10 Store all baskets, hoses and cleaning equipment, indoors if possible.
11 Cover the pool with a winter cover.

Page 6 ENGLISH Zodiac®Nature2® Express Cartridge |Owner’s Manual
Algae may
be caused by
insufficient levels
of oxidizer and/or
inadequate water
circulation.
Frequently caused by
improper start up. See
section on Start Up and
Install the Cartridge.
Troubleshooting Guide
Problem What to look for
Cloudy water Poor filtration Slow filter turnover rates.
Algae growth Hazy pool water; may have slightly green appearance.
Unbalanced water 1. High hardness
2. High TDS (total dissolved solids)
3. High pH
4. High total alkalinity
Algae Green algae Pea green color; attaches to pool walls; and
sometimes colors the entire body of water.
Black algae Black spots on pool walls.
Mustard algae Yellow or brown film on steps or walls.
Note: Regular algaecide treatments are recommended for outdoor pools
that experience persistent algae problems. Do not use algae treatments
containing copper.
Stains Blue/green Copper or iron from pool equipment
corrosion or water supply.
Red/brown Iron or manganese from equipment
corrosion or water supply..
Black Manganese in water supply.
Metal tarnishing High native mineral content in
water; unbalanced water.
Scale Crusty deposits on High pH and high total alkalinity.
pool surfaces
High TDS (total dissolved solids)
or high hardness levels.

Page 7
ENGLISH
Owner’s Manual |Zodiac®Nature2® Express Cartridge
Consult your Nature2Dealer for additional assistance or call 1-800-822-7933.
Treatment
1 Backwash and clean filter.
2 Run filter for 24 hours.
3 Increase run time per day.
Superchlorinate water with chlorine according to manufacturer’s instructions and brush pool walls.
Balance the pool water.
1 Check pH and adjust if necessary.
2 Superchlorinate water with chlorine according to manufacturer’s instructions and brush pool walls.
3 Repeat steps 1 and 2 until algae is gone.
1 Brush affected areas.
2 Superchlorinate water with chlorine according to manufacturer’s instructions.
3 Add algaecide.
4 Vacuum pool.
5 Repeat steps 1 through 4 until algae is gone.
1 Adjust pH and total alkalinity to ideal ranges.
2 Vigorously brush stained areas.
3 Add sequestrant.
4 Run filter.
5 Twelve hours later, superchlorinate pool.
6 Test and balance water.
7 Test pool water for dissolved metals.
Clean with soft cloth and mild detergent.
Test water for minerals; use a sequestrant;
and maintain water balance.
Adjust pH and total alkalinity to ideal ranges.
1 Replace a volume of pool water with water low in hardness and dissolved solids.
2 Use sequestrant to prevent scale buildup if high hardness levels are a continuing problem.

Limited Warranty
NATURE2® LIMITED WARRANTY
The limited warranties contained within this document are the only warranties given with your Nature2
Express Cartridge and supercede any prior warranties. All other warranties, expressed or implied,
including the implied warranty of merchantability or the implied warranty of fitness for a particular
purpose are hereby disclaimed. Our sole obligation under this warranty, and the purchaser’s sole remedy,
is limited to repair or replacement of the Nature2Express Cartridge. The Nature2warranty applies to the
original owner only.
THE LIMITED WARRANTIES OF THE NATURE2EXPRESS CARTRIDGE ARE:
Nature2Express Cartridges are warranted to be free of defects in materials and to perform satisfactorily for
a period of six (6) months from the date of purchase. Nature2Express Cartridges are warranted not to cause
copper staining in your pool. This limited warranty requires that you exercise reasonable care of your pool
and keep water in balance at all times and not use a copper-based algaecide. This limited warranty does not
cover discoloration to chromium fittings. This warranty does not cover cartridges used with any biguanide
products. If the cartridge is defective and does not perform satisfactorily for the entire six months, we will
make a prorated rebate based on your actual period of use. You are responsible to pay the below-indicated
percentage on the then applicable retail cost: < 1 month-0%; 1-2 months- 25%; 3-4 months-50%; 5-<6
months-75%.
EXCLUSIONS FROM WARRANTY
Nature2Express Cartridges are designed for use on inground and aboveground pools from 5,000 to 25,000
gallons. If it is used in any other application, the warranty is void, and the purchaser and/or pool owner
releases the manufacturer from any and all claims related to the use of the Nature2Express cartridge.
This warranty does not cover problems arising in whole or in part from purchaser’s negligence, misuse or
abuse, improper maintenance or storage, accident, improper installation, improper application, failure to
follow all appropriate safety precautions, Acts of God, abnormal weather conditions, damage from plants or
animals, and improper use of chemicals.
This warranty specifically excludes all incidental or consequential damages, except where state law requires
them to be paid. This warranty gives you specific rights. You may have other rights that vary from state to state.
TO SUBMIT A CLAIM
Report claims to Zodiac Pool Systems LLC by calling 1-800-822-7933. Only the original purchaser may
submit a claim under this limited warranty. All claims must be accompanied by an original purchase receipt.
Zodiac Pool Systems LLC
2620 Commerce Way, Vista, CA 92081
1.800.822.7933 | www.ZodiacPoolSystems.com
©2017 Zodiac Pool Systems LLC. All trademarks
referenced herein are the property of their respective
owners. ZODIAC®is a registered trademark of Zodiac
International, S.A.S.U., used under license.
TL-2626 Rev G