Abrams UG-1200 Manual

Specificaons
120.6mm
32.2mm
14.3
● LED: 3W*12 Spilt/Dual
● LEDs per head : 12
● Voltage : 10-30VDC
● Flash paerns : 69
● Color : Color 1* Color 2
Proper installaon of this product requires the installer to have a good
understanding of automove electronics, systems and procedures.
Failure to use specified installaon parts or hardware will void the
product warranty.
For this product to operate at opmum efficiency, a good electrical
connecon to chassis ground must be made.
It is recommend that these instrucons be stored in a safe place and
referred to when performing maintenance or reinstallaon of this
products.
Do not install and/or operate this safety product unless you have read
and understand the safety informaon contained in this manual.
This document provides all the necessary informaon to allow your product to be properly and
safely installed. Before beginning the installaon and operaon of your new product, the
installaon technician and operator must read this manual completely.
P52 Quad 75FPM is Factory Default.
Phase Operaon: Ph1= Phase 1 / Ph2=Phase 2
Phase 1 (Ph1) flashes simultaneously with Ph1
Phase 2 (Ph2) flashes simultaneously with Ph2
Operaon
Default
Apply BLUE to BLACK wire:
-Less than1 sec. for next paern
-Between 1-3 sec. for previous paern
-Between 3-5 sec. for Factory Default
-More than 5 sec. for Last Paern
INSTALLATIONANDCONFIGURATIONMANUALINSTALLATIONANDCONFIGURATIONMANUAL
MODEL#: UG-1200
ABRAMS INSTALLATION AND CONFIGURATION MANUAL V.1.1
WWW.ABRAMSMFG.COM | [e-mail] 01
IMPORTANT! PLEASE READ THROUGH ALL
PROVIDED INSTRUCTIONS AND ANY LISTED
WARNINGS IN REGARDS TO PRODUCT USE.
Abrams Ultra Grill Lights
844.9.ABRAMS
[email protected]
www.AbramsMFG.com
Abrams Ultra Grill Lights
844.9.ABRAMS
[email protected]
www.AbramsMFG.com

Apply WHITE TO RED (+) wire
- Stop/Turn/Brake/Tail Light Steady Burn paer
Trouble Shoong
Abrams Ultra Grill Lights Mounng Gasket
Opon
Connect all together syncgronizaon
Flash Paen Select
To Chassis Ground
To＋10~30VDC(fuse@2A)
White
Yellow
Blue
Black
Red
Mounng
Wire
RED: Posive (need to add 2A Fuse)
BLACK: Negave
BLUE: Paern Switch
YELLOW: Synchronized Funcon
WHITE: Stop/Turn/Brake/Tail Light Switch(Opon)
*Maximum of 8 pcs can be synchronized
The product has been factory tested and approved. If the funcons of device fail, please check the following:
1. Aer connecng with the power supply, be sure that the power source end is joined in correct way. And then, make sure that there
is no short-circuited power occurring.
2. Ensure Power switch is turned to "ON" posion.
1-DEFAULT 1Single 75FPM Ph1 Color 1 Synchronous Color 3
YES
2 2 Single 75FPM Ph2 Color 1 Synchronous Color 3
YES
3Single 75FPM Ph1 Color 1 Alternately Color 4
YES
4Single 75FPM Ph2 Color 1 Alternately Color 4
YES
1-Default 5Single 75FPM Ph1 Color 2 Synchronous Color 4
YES
2 6 Single 75FPM Ph2 Color 2 Synchronous Color 4
YES
3 3 7Single 75FPM Ph1(Color 1 Synchronous Color 3) Alternately (Color 2 Synchronous Color 4)
YES
4 4 8 Single 75FPM Ph2(Color 1 Synchronous Color 3) Alternately (Color 2 Synchronous Color 4)
YES
5 5 9Single 75FPM (Color 1 Alternately Color 2) Alternately (Color 3 Alternately Color 4)
YES
6 10 Single 375FPM Ph1 Color 1 Synchronous Color 3
YES
711 Single 375FPM Ph2 Color 1 Synchronous Color 3
YES
12 Single 375FPM Ph1 Color 1 Alternately Color 4
YES
13 Single 375FPM Ph2 Color 1 Alternately Color 4
YES
6 14Single 375FPM Ph1 Color 2 Synchronous Color 4
YES
715Single 375FPM Ph2 Color 2 Synchronous Color 4
YES
8 8 16 Single 375FPM Ph1 (Color 1 Synchronous Color 3) Alternately (Color 2 Synchronous Color 4)
YES
9 9 17Single 375FPM Ph2 (Color 1 Synchronous Color 3) Alternately (Color 2 Synchronous Color 4)
YES
10 10 18Single 375FPM (Color 1 Alternately Color 2) Alternately (Color 3 Alternately Color 4)
YES
11 19 Double 75FPM Ph1 Color 1 Synchronous Color 3
YES
12 20 Double 75FPM Ph2 Color 1 Synchronous Color 3
YES
21 Double 75FPM Ph1 Color 1 Alternately Color 4
YES
22 Double 75FPM Ph2 Color 1 Alternately Color 4
YES
11 23 Double 75FPM Ph1 Color 2 Synchronous Color 4
YES
12 24Double 75FPM Ph2 Color 2 Synchronous Color 4
YES
13 13 25Double 75FPM Ph1 (Color 1 Synchronous Color 3) Alternately (Color 2 Synchronous Color 4)
YES
141426 Double 75FPM Ph2 (Color 1 Synchronous Color 3) Alternately (Color 2 Synchronous Color 4)
YES
151527Double 75FPM (Color 1 Alternately Color 2) Alternately (Color 3 Alternately Color 4)
YES
16 28Double 120FPM Ph1 Color 1 Synchronous Color 3
YES
1729 Double 120FPM Ph2 Color 1 Synchronous Color 3
YES
30 Double 120FPM Ph1 Color 1 Alternately Color 4
YES
31 Double 120FPM Ph2 Color 1 Alternately Color 4
YES
16 32 Double 120FPM Ph1 Color 2 Synchronous Color 4
YES
1733 Double 120FPM Ph2 Color 2 Synchronous Color 4
YES
181834Double 120FPM Ph1 (Color 1 Synchronous Color 3) Alternately (Color 2 Synchronous Color 4)
YES
19 19 35Double 120FPM Ph2 (Color 1 Synchronous Color 3) Alternately (Color 2 Synchronous Color 4)
YES
20 20 36 Double 120FPM (Color 1 Alternately Color 2) Alternately (Color 3 Alternately Color 4)
YES
21 37Triple 75FPM Ph1 Color 1 Synchronous Color 3
YES
22 38Triple 75FPM Ph2 Color 1 Synchronous Color 3
YES
39 Triple 75FPM Ph1 Color 1 Alternately Color 4
YES
40Triple 75FPM Ph2 Color 1 Alternately Color 4
YES
21 41Triple 75FPM Ph1 Color 2 Synchronous Color 4
YES
22 42Triple 75FPM Ph2 Color 2 Synchronous Color 4
YES
23 23 43Triple 75FPM Ph1 (Color 1 Synchronous Color 3) Alternately (Color 2 Synchronous Color 4)
YES
2424 44 Triple 75FPM Ph2 (Color 1 Synchronous Color 3) Alternately (Color 2 Synchronous Color 4)
YES
2525 45 Triple 75FPM (Color 1 Alternately Color 2) Alternately (Color 3 Alternately Color 4)
YES
26 46Quad 75FPM Ph1 Color 1 Synchronous Color 3
YES
27 47 Quad 75FPM Ph2 Color 1 Synchronous Color 3
YES
48 Quad 75FPM Ph1 Color 1 Alternately Color 4
YES
49Quad 75FPM Ph2 Color 1 Alternately Color 4
YES
26 50Quad 75FPM Ph1 Color 2 Synchronous Color 4
YES
27 51Quad 75FPM Ph2 Color 2 Synchronous Color 4
YES
2828 52-Default Quad 75FPM Ph1 (Color 1 Synchronous Color 3) Alternately (Color 2 Synchronous Color 4)
YES
29 29 53Quad 75FPM Ph2 (Color 1 Synchronous Color 3) Alternately (Color 2 Synchronous Color 4)
YES
30 30 54 Quad 75FPM (Color 1 Alternately Color 2) Alternately (Color 3 Alternately Color 4)
YES
31 55 Quad 120FPM Ph1 Color 1 Synchronous Color 3
YES
32 56Quad 120FPM Ph2 Color 1 Synchronous Color 3
YES
57 Quad 120FPM Ph1 Color 1 Alternately Color 4
YES
58 Quad 120FPM Ph2 Color 1 Alternately Color 4
YES
31 59Quad 120FPM Ph1 Color 2 Synchronous Color 4
YES
32 60 Quad 120FPM Ph2 Color 2 Synchronous Color 4
YES
33 33 61 Quad 120FPM Ph1 (Color 1 Synchronous Color 3) Alternately (Color 2 Synchronous Color 4)
YES
343462 Quad 120FPM Ph2 (Color 1 Synchronous Color 3) Alternately (Color 2 Synchronous Color 4)
YES
353563 Quad 120FPM (Color 1 Alternately Color 2) Alternately (Color 3 Alternately Color 4)
YES
8
64Modulaon (Color 1 Synchronous Color 3) Alternately (Color 2 Synchronous Color 4)
NO
9
652 Double,2 Quad (Color 1 Synchronous Color 3) Alternately (Color 2 Synchronous Color 4)
NO
10
66 4 Single,2 Triple (Color 1 Synchronous Color 3) Alternately (Color 2 Synchronous Color 4)
NO
11
67
1Doube 1Triple 1Quad (Color 1 Synchronous Color 3) Alternately (Color 2 Synchronous Color 4) NO
36 68Steady burn-Color 1 & 3
NO
36 69 Steady burn-Color 2 & 4
NO
LED Color 2 & Color 4
White line
LED Color 1 & Color 3
LED Color 2 & Color 4
White & Red line
FLASH PATTERN
SYNCH
6
7
12
LED Color 1 & Color 3
Red line
Paern
Inspect the contents to be certain that the following items are included:
A. LIGHT HEAD *1 B. Screw *2 C. Manual *1 D. Mounng Gasket *1
Recommend Operaon Environment
Ambient Temperature: -30 to 50℃
Relave Humidity: 10 to 85% , non-condensing
INSTALLATIONANDCONFIGURATIONMANUAL INSTALLATIONANDCONFIGURATIONMANUAL
ABRAMS INSTALLATION AND CONFIGURATION MANUAL V.1.1
WWW.ABRAMSMFG.COM | [e-mail] 02 ABRAMS INSTALLATION AND CONFIGURATION MANUAL V.1.1
WWW.ABRAMSMFG.COM | [e-mail]
03
Abrams Ultra Grill Lights
844.9.ABRAMS
[email protected]
www.AbramsMFG.com
Abrams Ultra Grill Lights
844.9.ABRAMS
[email protected]
www.AbramsMFG.com