Aewin AW-EM650 Series User manual

Low Power Embedded SBC with VGA, LAN,
TV-out, Card Bus, Audio & SSD
User’s Manual
Version 1.0

© Copyright 2002. All Rights Reserved
Manual edition 1.0, Jan, 2003
This document contains proprietary information protected by copyright. All rights
are reserved, no part of this manual may be reproduced, copied, translated or
transmitted in any form or by any means without prior written permission of the
manufacturer.
The content of this manual is intended to be accurate and reliable, the original
manufacturer assumes no responsibility for any inaccuracies that may be contained in
this manual. The original manufacturer reserves the right to make improvements to
the products described in this manual at any time without prior notice.
Trademarks
IBM, EGA, VGA, XT/AT, OS/2 and PS/2 are registered trademarks of International
Business Machine Corporation
Award is a trademark of Award Software International, Inc
Intel is a trademark of Intel
RTL is a trademark of Realtek
VIA is a trademark of VIATechnologies, Inc
Microsoft, Windows, Windows NT and MS-DOS are either trademarks or registered
trademarks of Microsoft Corporation
All other product names mentioned herein are used for identification purpose only and
may be trademarks and/or registered trademarks of their respective companies
Limitation of Liability
While reasonable efforts have been made to ensure the accuracy of this manual, the
manufacturer and distributor assume no liability resulting from errors or omissions in
this manual, or from the use of the information contained herein.

Table of Contents
Chapter 1. General Information-------------------------------------------------------------2
1.1 Introduction---------------------------------------------------------------------------------2
1.2 Specification---------------------------------------------------------------------------------2
1.3AW-EM650 Package-----------------------------------------------------------------------4
1.4 Board Layout--------------------------------------------------------------------------------5
1.5 Board Dimension---------------------------------------------------------------------------5
Chapter 2. Connectors Location and Configuration------------------------------------8
2.1 Connectors/Jumpers Location and Define--------------------------------------------8
2.2 Onboard rocessors------------------------------------------------------------------------10
2.3 Installing System Memory--------------------------------------------------------------10
2.4 Connector and Jumpers Settings------------------------------------------------------10
CN1:TV-OUT----------------------------------------------------------------------------------10
CN2:AUDIO (SPK & MIC) ---------------------------------------------------------------10
CN3: TV-OUT Header ---------------------------------------------------------------------11
CN4: COM Port ---------------------------------------------------------------------------- 11
CN5:Reset Header---------------------------------------------------------------------------12
CN6:Audio Header ------------------------------------------------------------------------ 12
CN7: VGAHeader ------------------------------------------------------------------------- 12
CN8:USB0 Header ------------------------------------------------------------------------13
CN9:LAN & USB ---------------------------------------------------------------------------
13
CN10:Keyboard Header -------------------------------------------------------------------14
CN11 :Power & HDD Header ------------------------------------------------------------14
CN12:USB1 Header ------------------------------------------------------------------------14
CN13: Mouse Header ----------------------------------------------------------------------15
CN14: COM Port Header ---------------------------------------------------------------- 15
CN15:LAN LED Header ------------------------------------------------------------------15
CN16: VGAHeader ------------------------------------------------------------------------16
CN17:LAN Header -------------------------------------------------------------------------16
CN18: IDE Header ------------------------------------------------------------------------- 17
CN19:Power --- ------------------------------------------------------------------------------17
CN20: PCMCIAConnector ---------------------------------------------------------------18
JP1:TV-OUT Signal Select ---------------------------- -----------------------------------20
JP2: COM Port Select ----------------------------------------------------------------------20
JP3:COM Port Voltage Select ------------------------------------------------------------20
JP4: Clear CMOS -------------------------------------------------------------------------- 21

JP5: Watchdog Timer ----------------------------------------------------------------------21

User’s manual
AW-EM650
1
Chapter 3. BIOS Setup-----------------------------------------------------------------------22
3.1 Quick Setup--------------------------------------------------------------------------------22
3.2 Entering the CMOS Setup Program--------------------------------------------------22
3.3 Menu Options-----------------------------------------------------------------------------24
Standard CMOS Features--------------------------------------------------------------25
Advanced BIOS Features---------------------------------------------------------------26
Advanced Chipset Features------------------------------------------------------------29
Integrated Peripherals------------------------------------------------------------------32
Power Management Setup-------------------------------------------------------------35
PNP/PCI Configuration----------------------------------------------------------------36
PC Health Status-------------------------------------------------------------------------38
Frequency/Voltage Control------------------------------------------------------------39
Load Fail-Safe Default------------------------------------------------------------------39
Load Optimized Default----------------------------------------------------------------39
Set Supervisor & User Password-----------------------------------------------------40
Chapter 4. Drivers and Utilities Installation---------------------------------------------41
4.1 System Driver Installation----------------------------------------------------------41
4.2 VGADriver Installation------------------------------------------------------------43
4.3 Ethernet Driver Installation-------------------------------------------------------45
4.3.1 Intel ® 82559 Ethernet Driver Installation-----------------------------------45
4.3.2 Realtek® 8139C Ethernet Driver Installation-------------------------------50
4.3.3AC’97 Audio Driver ------------------------------------------------------------- 56
AppendixA. System Resources-------------------------------------------------------------58
Appendix B. Optional Cable List----------------------------------------------------------61

User’s manual
AW-EM650
2
Chapter 1. General Information
1.1 Introduction
The AW-EM650 is a full function of 5.25” Embedded format SBC board use Intel®
815E and ICH2 chipset supports Intel® 400/650MHz (Micro-FCBGA packaging)
ultra low power processors and optional Intel® PIII uFCBGA LV processors up to
933MHz and Celeron Socket 479 uFCPGA up to 1.333GHz. The AW-EM650
supports Intel® 82559 Ethernet chipset with RJ45 jack for 10/100Mbps and optional
for Realtek 8139C+.
The onboard features include one RS-232 and one RS-232/422/485 serial port, and
two USB ports. Also the AW-EM650 supports AC-97 audio interface, CardBus
interface with two PCMCIA card slots, TV-out interface with output connector for
providing dual RCA video connector and built in one CompactFlash™ socket and one
DiskOnChip® socket.
Further to CardBus, it supports any combination of 16-bit and CardBus PC Cards in
the two sockets, powered at 5V or 3.3V , as required. It is compliant with the PCI
Local Bus Specification, and its PCI interface can act as either a PCI master device or
a PCI slave device.
About TV-Out interface, the AW-EM650 built in Chrontel digital TV encoder for
TV-Out function; it is a display controller device which accepts a digital graphics
input signal, and encodes and transmits data to a TV output (analog composite,
s-video or RGB). The TV-Out processor will perform non-interlace to interlace
conversion with scaling and flicker filters, and encode the data into any of the NTSC
or PAL video standards. The scaling and flicker filter is adaptive and programmable to
enable superior text display. Eight graphics resolutions are supported up to 1024 by
768 with full vertical and horizontal underscan capability in all modes. Furthermore,
the AW-EM650 built in an low power, single supply, triple video amplifier IC, it can
be used in video multiplexing applications.
1.2 Specification
General Functions
CPU
Intel® 400/650MHz uFCBGAULV processors, PIII uFCBGA
LV processors up to 933MHz and Celeron uFCPGA up to
1.333GHz processors
BIOS Award® 512KB Flash BIOS
Chipset Intel® 815E +ICH2 Chipset
I/O Chipset Winbond 83627HF

User’s manual
AW-EM650
3
Memory Onboard 32/64/128MB and one 144-pin SO-DIMM socket
supports up to 512Mbytes SDRAM
Enhanced IDE Support 2.5” IDE HDD
Serial port One RS-232 and one RS-232/422/485 serial port
KB/Mouse connector Supports PS/2 keyboard and PS/2 mouse
USB connectors Supports two USB ports
Battery Lithium battery for data retention of up to 10 years (under
normal condition)
Watchdog Timer Can generate a system reset, or PIRQ#E. Support software
selectable timeout interval.
CRT Interface
Chipset Intel® 815E chip with integrated 2D/3D/Video
Accelerator
Display type Support dual CRT connectors
Display memory Support max.4MB SDRAM
Ethernet Interface
Chipset Intel®82559 100Base-Tx Fast Ethernet controller and
optional for Realtek 8139C+
Ethernet interface PCI 100/10Mbps Ethernet controller. IEEE802.3U protocol
compatible
SSD Interface One 50-pin CompactFlash™socket and one 32-pin
DiskOnChip®socket
CardBus Interface
Chipset TI PCI 1420 Card Bus controller
Interface
Complies with PCMCIA v.2.10 and JEIDA v.4.1 Provide
full supports for all Type I/II/III PCMCIA memory, I/O and
ATA hard disk cards.
Output connector Two built-in PCMCIA card slots
TV-out Interface
Chipset Chrontel digital TV encoder
TV Format Supports NTSC and PAL signals format

User’s manual
AW-EM650
4
Output connector Provides dual RCA(composite) video connectors
Sound Interface
Chipset AC 97 codec
Audio Controller SoundBlaster Pro Hardware and Direct Sound Ready AC97
Digital Audio
Audio interface Mic in, Speaker out
Mechanical and Environmental
Power supply voltage +12V(11.4 to 12.6V)
Max. power requirements 5A@+12V
Operating temperature 32 to 140 (0 to 60 C)
Board size 8"(L) x 5.75"(W) (203mm x 146mm)
1.3AW-EM650 Package
Please make sure that the following items have been included in the
package before installation.
1. AW-EM650 Low Power Embedded SBC
2. Quick Setup
3. Cable: Please refer to Appendix B Optional Cables
4. CD-ROM which contains the following folders:
(1) Manual
(2) System Driver
(3) VGA Driver
(4) Ethernet Driver
(5) Tools
If any of these items are missing or damaged, please contact your dealer
from whom you purchased the board at once. Save the shipping
materials and carton in the event that you want to ship or store the board
in the future. After you unpack the board, inspect it to assure an intact
shipment. Do not apply power to the board if it appears to have been
damaged.
Leave the board in its original packing until you are ready to install

User’s manual
AW-EM650
5
Precautions
Please make sure you properly ground yourself before handling the AW-EM650 board
or other system components. Electrostatic discharge can be easily damage the
AW-EM650 board.
Do not remove the anti-static packing until you are ready to install the AW-EM650
board.
Ground yourself before removing any system component from it protective anti-static
packaging. To ground yourself, grasp the expansion slot covers or other unpainted
parts of the computer chassis.
Handle the AW-EM650 board by its edges and avoid touching its component.
1.4Board Layout
1.5 Board Dimension

User’s manual
AW-EM650
6
x
y
z

User’s manual
AW-EM650
7
x
y
z
x
y y

User’s manual
AW-EM650
8
Chapter 2. Connectors/Switch Location and Configuration
2.1 Connectors/Jumpers Location and Define
Location Description
CN1 TV-OUT(DUAL) CONNECTOR
CN2 AUDIO(SPK & MIC) CONNECTOR
CN3 TV-OUT HEADER (DUAL)
CN4 COM PORT(DUAL) CONNECTOR
CN5 RESET HEADER
CN6 AUDIO HEADER (SPK&MIC)
CN7 VGA(DUAL) CONNECTOR
CN8 USB0 HEADER
CN9 LAN & USB 0/1 CONNECTOR
CN10 KEYBOARD HEADER
CN11 POWER & HDD LED HEADER
CN12 USB1 HEADER
CN13 MOUSE HEADER

User’s manual
AW-EM650
9
CN14 COM PORT HEADER
CN15 LAN LED HEADER
CN16 VGA HEADER (DUAL)
CN17 LAN HEADER
CN18 IDE HEADER
CN19 POWER HEADER
FAN1 FAN CONNECTOR
FAN2 FAN CONNECTOR
SW1 RESET BUTTON
U20 DISK ON CHIP SOCKET
Location Description
SK1 SODIMM SOCKET
CF_SOCKET1 COMPACT FLASH SOCKET
CN20 PCMCIA SOCKET

User’s manual
AW-EM650
10
2.2. Onboard Processors
The AW-EM650 onboard built-in Intel® 400/650(Micro-FCBGApackaging) ultra low
power processors. The CPU cooler fan will be mounted when board with 650MHz
CPU and the high profile Heatsink will be mounted when 400MHz CPU.
2.3 Installing Memory
To insert a DIMM Memory:
The AW-EM650 supports one 144-pin DIMM sockets, memory up to 512Mbyte.
To Insert a DIMM Memory: Please align the module with the socket key and press
down until the levers at each end of the socket snap close up.
There is only one direction for installing a module in the socket. Do not attempt to
force the module into the socket incorrectly.
To Remove a DIMM Memory: To remove a DIMM, press down on the levers at
both end of the module until the module pops out
There is only one direction for installing a module in the socket. Do not attempt to
force the module into the socket incorrectly.
2.4 Connector and Jumper Settings
CN1: TVOUT ( RCAJACK – DUAL )
CN2:AUDIO (SPK & MIC)

User’s manual
AW-EM650
11
CN3: TVOUT HEADER (DUAL) – 2mm connector
CN4: COM PORT – COM1 & COM 2
Pin Define
1 DCD
2 RXD
3 TXD
4 DTR
5 Ground
6 DSR
7 RTS
8 CTS
9 RI
Pin Assignment
1 TV1
2 GND
3 NC
4 TV2
5 GND

User’s manual
AW-EM650
12
CN5: RESET HEADER – 2mm conncctor
CN6:AUDIO HEADER (SPK & MIC)
CN7: VGA(DUAL)
Pin Assignment
1 HWRST
2 GND
Pin Assignment
1 LINQUTR
2 LINQUTL
3 MIC
4 GND
5 GND
Pin Signal PIN Signal
1 RED 9 NC
2 GREEN 10 Ground
3 BLUE 11 NC
4 NC 12 DDC Data
5 Ground 13 H-SYNC
6 Ground 14 V-SYNC
7 Ground 15 DDC Clock
8 Ground

User’s manual
AW-EM650
13
CN8: USB0 HEADER
CN9: LAN & USB
D2: Speed indicated LED
10 Mbps DIM
100 Mbps GREEN
D1 :Link/Activity LED
Link YELLOW
Activity BLINKING
Pin Assignment
1 USBVCC0
2 USBDATA0 -
3 USBDATA0 +
4 USBGND0
5 GND

User’s manual
AW-EM650
14
CN10: KEYBOARD HEADER
CN11: POWER & HDD LED HEADER
CN12: USB1 HEADER
Pin Assignment
1 KB CLOCK
2 KB DATA
3 NC
4 GND
5 KSMSVCC
Pin Assignment Define
1 GND
2 VCC3
POWER LED
3 IDEACT#
4 VCC3
HDD LED
Pin Assignment
1 USB VCC1
2 USB DATA1 -
3 USB DATA1 +
4 USBGND1
5 GND

User’s manual
AW-EM650
15
CN13: MOUSE HEADER
CN14: COM PORT HEADER
CN15: LAN LED HEADER
Pin Assignment
1 MS CLOCK
2 MSDATA
3 NC
4 GND
5 KBMSVCC
Pin Assignment Pin Assignment
1 DCD0# 2 DSR0
3 RXDD0 4 RTS0
5 TXDD0 6 CTS0
7 DTR0 8 SNRI0#
9 GND 10 NC
11 DCD1# 12 DSR1
13 RXDD1# 14 RTS1
15 TXDD1 16 CTS1
17 DTR1 18 SNRI1#
19 GND 20 NC

User’s manual
AW-EM650
16
CN16:VGAHEADER (DUAL)
CN17: LAN HEADER
Pin Assignment
1 SPEEED
2 VCC3
3 LINK
4 ACTIVE
Pin Assignment Pin Assignment
1 RV0 2 GV0
3 BV0 4 CRT0
5 CRT2 6 CRT3
7 HS0 8 VS0
9 5VDDCCL 10 5VDDCDA
11 RV1 12 GV1
13 BV1 14 CRT1
15 CRT2 16 CRT3
17 HS1 18 VS1
19 GND 20 GND