APURO DC858-A User manual

Model:
DC858-A / DC859-A
Pie Warmer
Instruction manual
DC858-A_DC859-A_A5_v1 2020915.indb 1DC858-A_DC859-A_A5_v1 2020915.indb 1 2020/9/15 10:062020/9/15 10:06

2
AU Telephone Helpline: 1300225960
Safety Tips
• Position on a flat, stable surface.
• A service agent/qualified technician should carry out
installation and any repairs if required. Do not remove any
components on this product.
• Consult Local and National Standards to comply with the
following:
- Health and Safety at Work Legislation
- Fire Precautions
- Wiring Regulations
- Building Regulations
• DO NOT immerse the appliance in water.
• DO NOT clean with jet/pressure washers.
• DO NOT obstruct or cover the appliance in any way when in
use.
• Always allow the Pie Warmer to cool down before cleaning,
maintaining or moving to avoid the risk of burns.
• DO NOT use the appliance for anything other than its intended
use.
• Not suitable for outdoor use.
• Always switch off and disconnect the power supply to the
appliance before cleaning.
• This appliance must only be used in accordance with these
instructions and by persons competent to do so.
• Keep all packaging away from children. Dispose of the
packaging in accordance to the regulations of local authorities.
• If the power cord is damaged, it must be replaced by an
Apuro agent or a recommended qualified technician in order
to avoid a hazard.
DC858-A_DC859-A_A5_v1 2020915.indb 2DC858-A_DC859-A_A5_v1 2020915.indb 2 2020/9/15 10:062020/9/15 10:06

3
AU
Telephone Helpline: 1300225960
• This appliance is not intended for use by persons (including
children) with reduced physical, sensory or mental capabilities,
or lack of experience or knowledge, unless they have been
given supervision or instruction concerning the use of the
appliance by a person responsible for their safety.
• Children should be supervised to ensure that they do not play
with the appliance.
• Apuro recommends that this appliance should be periodically
tested (at least annually) by a Competent Person. Testing
should include, but not be limited to: Visual Inspection,
Polarity Test, Earth Continuity, Insulation Continuity and
Functional Testing.
Introduction
Please take a few moments to carefully read through this manual. Correct maintenance and operation of
this machine will provide the best possible performance from your Apuro product.
Pack Contents
The following is included:
• Pie Warmer
• Sliding glass door x 2
• Glass display panel
• Wire rack x 3
• Element Guard
• Water Reservoir
• Instruction manual
Apuro prides itself on quality and service, ensuring that at the time of packaging the contents are
supplied fully functional and free of damage.
Should you find any damage as a result of transit, please contact your Apuro dealer immediately.
DC858-A_DC859-A_A5_v1 2020915.indb 3DC858-A_DC859-A_A5_v1 2020915.indb 3 2020/9/15 10:062020/9/15 10:06

4
AU Telephone Helpline: 1300225960
Installation
To install the Pie Warmer:
1. Remove the Pie Warmer from the packaging. Make sure that all protective plastic film and coatings
are thoroughly removed from its surfaces.
2. Take the glass display panel and raise it at an angle into the upper track at the rear of the unit [Fig. 1].
3. Once at the top of the track, position the bottom of the glass above the lower track [Fig. 2].
4. Carefully lower the glass into the bottom track [Fig. 3].
5. Slide the wire racks into the bracket on the inner side of the Pie Warmer.
6. Insert the two sliding door panels in the same manner as the display panel. Ensure the handles are
located towards the outside edges of the appliance [Fig. 4].
7. Connect the plug to a suitable mains socket and turn on the power supply.
Operation
Note: This appliance is for maintaining temperature only. It is NOT suitable for
cooking products or heating products from cold.
1. Add water (0.5L) to the water reservoir
2. Set the thermostat to the desired temperature.
3. The unit will cycle on and off to maintain the set temperature.
The green indicator light and the interior lamp will turn on when the unit is switched on.
The green indicator light will turn off when the desired temperature has been reached.
Note: The appliance has a maximum temperature setting of 90°C.
DC858-A_DC859-A_A5_v1 2020915.indb 4DC858-A_DC859-A_A5_v1 2020915.indb 4 2020/9/15 10:062020/9/15 10:06

5
AU
Telephone Helpline: 1300225960
Cleaning, Care & Maintenance
• Always turn Off the appliance and disconnect from the power supply before cleaning.
• Allow the appliance to cool before cleaning.
• The inner body of the appliance should be wiped down at the end of each day’s operation. Additional
cleaning may be required depending on frequency of use.
• Warm soapy water is recommended for cleaning. Cleaning agents may cause damage or leave
harmful residues when used for a prolonged period on stainless steel.
• The Apuro dealer or qualified technician should carry out repairs if required.
Troubleshooting
If your Apuro Pie Warmer develops a fault, please check the following table before making a service call.
Fault Probable Cause Solution
Appliance not
working
The unit is not switched on Check the unit is plugged in correctly and
switched on
Plug and lead are damaged Call Apuro agent or qualified Technician
Power supply Check power supply
Internal wiring fault Call Apuro agent or qualified technician
Appliance heats up
but indicator light
does not come on
Indicator light is faulty Call Apuro agent or qualified technician
Unit not heating up
or heats up slowly
and the indicator
light is On
Incorrect operation Ensure:
• Thermostat has been set correctly
• Doors are closed
• Thermostat sensor bulb has not been
removed or damaged
Thermostat failure Call Apuro agent or qualified technician
Element failure Call Apuro agent or qualified technician
Technical Specifications
Model Voltage Power Current Dimensions
H x W x D mm Weight
Approx.
pie
capacity
Heat up
Time
(to 90°C)
Temp.
Range
DC858-A 220-240V,
50Hz
350W 1.5A 435 x 470 x 365 16kg 30 27 min. 30-90°C
DC859-A 650W 2.8A 435 x 745 x 365 23kg 60 28 min.
DC858-A_DC859-A_A5_v1 2020915.indb 5DC858-A_DC859-A_A5_v1 2020915.indb 5 2020/9/15 10:062020/9/15 10:06

6
AU Telephone Helpline: 1300225960
Electrical Wiring
The plug is to be connected to a suitable mains socket.
This appliance is wired as follows:
• Live wire (coloured brown) to terminal marked L
• Neutral wire (coloured blue) to terminal marked N
• Earth wire (coloured green/yellow) to terminal marked E
This appliance must be earthed.
If in doubt consult a qualified electrician.
Electrical isolation points must be kept clear of any obstructions. In the event of any emergency
disconnection being required they must be readily accessible.
Compliance
The product must not be disposed of as household waste. To help prevent possible harm to human
health and/or the environment, the product must be disposed of in an approved and environmentally safe
recycling process. For further information on how to dispose of this product correctly, contact the product
supplier, or the local authority responsible for waste disposal in your area.
Apuro parts have undergone strict product testing in order to comply with regulatory
standards and specifications set by international, independent, and federal authorities.
Apuro products have been approved to carry the following symbol:
All rights reserved. No part of these instructions may be produced or transmitted in any form or by any means, electronic,
mechanical, photocopying, recording or otherwise, without the prior written permission of Apuro.
Every effort is made to ensure all details are correct at the time of going to press, however, Apuro reserve the right to
change specifications without notice.
DC858-A_DC859-A_A5_v1 2020915.indb 6DC858-A_DC859-A_A5_v1 2020915.indb 6 2020/9/15 10:062020/9/15 10:06

DECLARATION OF CONFORMITY
•Conformiteitsverklaring • Déclaration de conformité • Konformitätserklärung • Dichiarazione di conformità •
• Declaración de conformidad • Declaração de conformidade
Equipment Type • Uitrustingstype • Type d'équipement • Gerätetyp
• Tipo di apparecchiatura • Tipo de equipo • Tipo de equipamento
Model • Modèle • Modell • Modello
• Modelo • Malli
3 Tier Economy Pie Cabinet - 30 Pie Capacity
3 Tier Economy Pie Cabinet - 60 Pie Capacity
DC858-A
DC859-A
Application of Territory Legislation &
Council Directives(s)
Toepassing van Europese Richtlijn(en)
• Application de la/des directive(s) du
Conseil • Anwendbare EU-Richtlinie(n)
• Applicazione delle Direttive
• Aplicación de la(s) directiva(s) del
consejo • Aplicação de directiva(s) do
Conselho
Electrical Safety
AS/NZS 60335.1:2011 +A1:2012 +A2:2014
+A3:2015 +A4:2017
IEC 60335-2-49:2002 +A1:2008
EN 62233:2008
Electromagnetic Compatibility
EN 55014-1:2017
EN 55014-2:2015
EN 61000-3-2:2014
EN 61000-3-3:2013
Producer Name • Naam fabrikant • Nom du producteur • Name des Herstellers
• Nome del produttore • Nombre del fabricante • Nome do fabricante
Apuro
Producer Address • Adres fabrikant •
Adresse du producteur • Anschrift des
Herstellers • Indirizzo del produttore •
Dirección del fabricante • Morada do
fabricante
15 Bagdally Road,
Campbelltown
NSW 2560
I, the undersigned, hereby declare that the equipment specified above conforms to the above Territory Legislation,
Directive(s) and Standard(s).
Ik, de ondergetekende, verklaar hierbij dat de hierboven gespecificeerde uitrusting goedgekeurd is volgens de bovenstaande
Richtlijn(en) en Standaard(en).
Je soussigné, confirme la conformité de l'équipement cité dans la présente à la / aux Directive(s) et Norme(s) ci-dessus
Ich, der/die Unterzeichnende, erkläre hiermit, dass das oben angegebene Gerät der/den oben angeführten Richtlinie(n) und Norm(en)
entspricht.
Il sottoscritto dichiara che l'apparecchiatura di sopra specificata è conforme alle Direttive e agli Standard sopra riportati.
El abajo firmante declara por la presente que el equipo arriba especificado está en conformidad con la(s) directiva(s) y estándar(es)
arriba mencionadas.
Eu, o abaixo-assinado, declaro que o equipamento anteriormente especificado está em conformidade com a(s) anterior(es)
Directiva(s) e Norma(s)
Date • Data • Date • Datum • Data • Fecha • Data
27th August 2020
Signature • Handtekening • Signature • Unterschrift
Firma • Firma • Assinatura
Full Name • Volledige naam • Nom et prénom •
Vollständiger Name • Nome completo
•Nombre completo • Nome por extenso
Ashley Hooper
Josie Holt
Position • Functie • Fonction • Position • Qualifica
•Posición • Função
Technical & Quality Manager
Commercial Manager/
Responsible Supplier
DC858-A_DC859-A_A5_v1 2020915.indb 7DC858-A_DC859-A_A5_v1 2020915.indb 7 2020/9/15 10:062020/9/15 10:06

DC858-A_DC859-A_A5_v1_20200915
DC858-A_DC859-A_A5_v1 2020915.indb 8DC858-A_DC859-A_A5_v1 2020915.indb 8 2020/9/15 10:062020/9/15 10:06