ARJO HUNTLEIGH Century User manual

...with people in mind
Century
0086
04.AK.02_10GB. January 2015
INSTRUCTIONS FOR USE

Design Policy and Copyright
® and ™ are trademarks belonging to the ArjoHuntleigh group of companies.
© ArjoHuntleigh AB 2014.
As our policy is one of continuous improvement, we reserve the right to modify designs
without prior notice.The content of this publication may not be copied either whole or in
part without the consent of ArjoHuntleigh AB.
WARNING
To avoid injury, always read this Instructions for Use and accompanying
documents before using the product.
Mandatory to read the Instructions for Use

3
Foreword ...................................................................................4
Intended Use .............................................................................5
Safety Instructions ....................................................................6
Preparations ..............................................................................7
Parts Designation ......................................................................8
Control Panel ..........................................................................10
Buttons and Displays ..............................................................10
Product Description/Functions ................................................12
Drain Control Knob ..............................................................12
Auto Fill Function .................................................................12
Shampoo/Body Wash and Bath Oil/ArjoSound™
Water Conditioner ...............................................................12
Scalding Protection .............................................................13
Patient Shower ....................................................................13
Disinfection Unit ..................................................................14
Hydromassage™ System .......................................................15
Hydrosound® System .............................................................17
Bathe Patient ...........................................................................19
Cleaning and Disinfection Instructions ....................................21
Care and Preventive Maintenance ..........................................29
Troubleshooting ......................................................................33
Technical Specifications .........................................................37
Labels .....................................................................................40
Approvals and List of Standards .............................................42
Electromagnetic Compatibility .................................................43
Parts and Accessories ............................................................46
ArjoHuntleigh Addresses .............................................Last Page
Contents

4
Foreword
Thank you for purchasing ArjoHuntleigh
Equipment
Your CenturyTM bath is part of a world-wide family of
quality products designed especially for efficient patient
hygiene and good ergonomics for the caregiver.
Please contact us if you have any questions about the
operation or maintenance of your Century bath.
Please read this Instructions for Use
thoroughly!
Please read this Instructions for Use (IFU) in its entirety
before using your Century bath. Information in this IFU
is crucial to the proper operation and maintenance of the
equipment, will help protect your product, and ensure
that the equipment performs to your satisfaction. Some
of the information in this IFU is important for your
safety and must be read and understood to help prevent
possible injury.
Unauthorized modifications on any ArjoHuntleigh
equipment may affect its safety. ArjoHuntleigh will not
be held responsible for any accidents, incidents or lack
of performance that occur as a result of any
unauthorized modification to its products.
Service and Support
A routine service must be performed on your Century
every year by qualified personnel to maintain safety and
reliability of the equipment. See section Care and
Preventive Maintenance on page 29.
If you require further information, please contact
ArjoHuntleigh for comprehensive support and service
programs to maximize the long-term safety, reliability
and value of the product.
Contact ArjoHuntleigh for replacement parts. The
contact information is found on the last page of this
IFU.
Definitions in this IFU
Means:
Safety warning. Failure to understand and obey this
warning may result in injury to you or to others.
Means:
Failure to follow these instructions may cause damage
to all or parts of the system or equipment.
Means:
This is important information for the correct use of this
system or equipment.
Means:
The name and address of the manufacturer.
WARNING
CAUTION
NOTE

5
Intended Use
This bath is intended for assisted bathing
and showering of adult residents in hospital
and care facilities. Century must be used by
appropriately trained caregivers with
adequate knowledge of the care
environment, its common practices and
procedures, and in accordance with the
guidelines in this Instructions for use.
The bath should only be used for the
purpose specified in this Instructions for
Use. Any other use is prohibited.
Resident Assessment
We recommend that facilities establish regular
assessment routines. Caregivers should assess each
resident according to the following criteria prior to use:
• The resident's weight should not exceed 160 kg /
353 lbs (Max Patient Weight)
• Active and semi-active residents (i.e. able to sit
upright self supported on the side of the bed or
toilet) can use the bath. Correct transfer
equipment shall be used if needed.
• The resident should have the ability to understand
and respond to instructions, or have limited
physical capacity to move, to ensure a safe
position during the bathing procedure.
• Hydrosound should not be used by pregnant
women.
If the resident does not meet these criteria an alternative
equipment/system shall be used.
Indication for Use
To relieve pain and itching and as an aid in the healing
process of inflamed and traumatized tissue and it serves
as a setting for removal of contaminated tissue.
Installation & Service Requirements
The equipment must be installed by appropriately
trained personnel according to the Assembly and
Installation Instructions which can only be superseded
by local code.
Expected Lifetime
The expected life of the Century is unless otherwise
stated ten (10) years, if subject to preventive
maintenance being carried out in accordance with the
instruction for Care and Preventive Maintenance on
page 29.

6
Safety Instructions
WARNING
To avoid hair entrapments under water,
always install the Hydromassage system
suction cover before use.
WARNING
To avoid falling, make sure the patient
always remains in a seated position.
WARNING
To avoid explosion or fire, never use the
equipment in oxygen rich environment, in
presence of heat source or flammable
anaesthetic gases.
WARNING
To avoid entrapment or pinching of
genitals, make sure there is enough
clearance during movement over the tub
edge, toilet, bedpan or other furniture.
WARNING
To avoid the device from tipping and the
patient from falling, do not use the
equipment on floor with recessed drains,
holes or slopes exceeding a ratio of 1:50
(1.15°).
WARNING
To avoid falling during transfer, always
make sure that the brakes are applied on all
equipment being used.
WARNING
To avoid entrapment, make sure to keep
the patient's hair, arms and feet close to
the body and use designated grab
supports during any movement.
WARNING
To prevent cross-contamination, always
follow the disinfection instructions in this
IFU.
Safety Practice
For a safe bath and to avoid injuries, make sure the
patient is sitting firmly and facing the control panel.
WARNING
To avoid falling, make sure that the patient
is positioned correctly and that the safety
belt is being used, properly fastened and
tightened.
WARNING
To avoid electric shock, never use other
electrical equipment near this device.
WARNING
To avoid injury, make sure that the patient
is not left unattended at any time.
CAUTION
Do not use the Hydrosound system for
more than 15 minutes at a time with a 15
minute stop in between.

7
Preparations
Site Preparations
Prior to the installation of the Century bath, the floor
and walls within the required area must be finished.
Material: The floor should be water sealed, made of a
slip resistant material and free of bumps.
Floor Slope: When using a floor drain, the slope
towards the drain should not exceed 1:50 (1.15°).
Floor attachments: The floor construction must be
suitable for anchoring the equipment bolts.
Actions Before First Use
(8 steps)
1 Makesurethebathhasbeeninstalledaccordingto
the Assembly and Installation Instructions.
2 Check all parts of the product are supplied.
Compare with section Parts Designation on page
8. If any part is missing or damaged - do NOT use
the product.
3 Read this IFU.
4 Disinfect the product according to section
Cleaning and Disinfection Instructions on page
21.
5 Perform a functionality test according to section
Care and Preventive Maintenance on page 29.
6 Choose a designated area, where the IFU should
be kept and is easily accessible at all times.
Make sure the thermostatic mixer has been
calibratedby an ArjoHuntleighservice technician
according to the Assembly and Installation
Instructions.
8 Make sure to have a rescue plan ready in case of a
patient emergency.
7WARNING
To prevent scalding, make sure that the
water mixer has been calibrated.
Confirm that responsible organization
has established calibration routines.
Actions Before Every Use
(5 steps)
1 Check that all parts are in place. Compare to
section Parts Designation on page 8.
2 Check bath and accessories for damage.
3 If any part is missing or damaged - do NOT use
the product!
4 Check the liquid level of disinfection bottle.
Before every use, make sure the Century bath is
cleaned and disinfected according to section
Cleaning and Disinfection Instructions on page
21.
5WARNING
To prevent cross-contamination, always
follow the disinfection instructions in
this Instructions for Use.
NOTE
If you have any questions, please contact your
local ArjoHuntleigh representative for support
and service. The contact information
(ArjoHuntleigh addresses) is listed on the last
page of this IFU.

8
Parts Designation
1 Bathtub
2Leg
3 Foot
4 Control panel
5 Outlet for bathtub filling
6 Patient shower handle
7 Popup-drain
8Sensors
9 Surface overflow outlet and drain manoeuvring
knob
10 Dispenser for Bath oil or Arjo Sound Water
Conditioner (for Hydrosound system) (optional)
11 Shampoo dispenser (optional)
12 Disinfectant spray handle (behind door)
(optional)
13 Flow meter (optional)
14 Storage container area, left; Disinfectant
15 Storage container area, right; Shampoo and
Bath Oil
Hydromassage™ system (optional)
16 Treatment hose with nozzle
17 Suction inlet screen
18 Hydrosound system outlet
19 Water flow and Air mix control
Hydrosound® system (optional)
20 Hydrosound system transducing plate
21 LED
22 Intensity knob
Type B Applied part.
Degree of Protection - Electrical shock

9
left
11
10
5
9
8
21
22
right
11
10
5
9
8
4
6
16
7
1
17
18
19
13
14
12 20
15 2
3

10
Control Panel
Temperature setting
Disinfection / Autoclean
Tub fill
Hydromassage/
Hydrosound System
Temperature display
Bath Oil
Shampoo & Body wash
or ArjoSound
Water Conditioner
Patient shower Bathtub water
Auto fill
Buttons and Displays
Shampoo & Body Wash Button
Press the Shampoo & Body Wash button to dispense shampoo or
body wash from corresponding outlet
Tub Filling/Auto Fill Button
(2 steps)
1 Press the Tub Fill/Auto Fill button to fill the bathtub. The
auto fill function will automatically stop to fill at a preset
level. The LED is lit while the bathtub is being filled.
2 Press the Tub Fill/Auto Fill button again to manually stop to
fill.
Temperature display
Fill and shower