Astonica 40201119 User manual

071209rev1
Read the instructions and precautions before use of this product
Please keep this instruction manual for future reference
®
Made In China 
©2010 World Factory, Inc.
Distributed By:
World Factory, Inc.
Westlake, TX 76262
Model No: 40201119
Ducking Around Garden Fountain
Instruction Manual
Due to ongoing product development
the actual product or products may vary from
the illustrations or photos shown within this manual.
NOTE: This product is intended for residential, non-commercial use.
For warranty information, please refer to the back page of 
this instruction manual.
Limited Warranty
World Factory, Inc. Products for Home Use
World Factory, Inc. (Seller) warrants to the original Buyer only, that each Astonica Product will be free
from defects in material and workmanship for a period of one (1) year from date of purchase.
SELLER’S SOLE OBLIGATION AND BUYER’S EXCLUSIVE REMEDY UNDER THIS LIMITED
WARRANTY SHALL BE THE REPAIR OR REPLACEMENT OF PARTS, WITHOUT CHARGE, WHICH
ARE DEFECTIVE IN MATERIAL OR WORKMANSHIP. ANY PARTS AS DETERMINED BY THE
SELLER WHICH HAVE BEEN MISUSED; ABUSED OR DAMAGED EITHER DIRECTLY OR INDIRECTLY
FROM REPAIRS OR ALTERATIONS ATTEMPTED BY UNAUTHORIZED PERSONS; IMPROPER
MAINTENANCE, NEGLECT OR ACCIDENT ARE NOT COVERED BY THIS LIMITED WARRANTY. This
warranty does not apply to damage, heat-induced coloration changes, scratching or alteration due to
normal use or weathering. To make a claim under this Limited Warranty, you must return the complete
product with proof of purchase, transportation prepaid, to any World Factory, Inc. authorized service
center. Call 1-888-422-7800 for the location of the nearest authorized service center.
Additional Limitations
THIS LIMITED WARRANTY DOES NOT APPLY TO ACCESSORY OR CONSUMABLE ITEMS RELATED
TO THIS PRODUCT. ALL IMPLIED WARRANTIES SHALL BE LIMITED IN DURATION TO ONE (1)
YEAR FROM DATE OF PURCHASE. IN NO EVENT SHALL SELLER BE LIABLE FOR ANY INCIDENTAL
OR CONSEQUENTIAL DAMAGES, INCLUDING BUT NOT LIMITED TO LIABILITY FOR LOSS OF
PROFITS, ARISING FROM THE SALE OR USE OF THIS PRODUCT. 
If any provision of this Limited Warranty is for any reason held to be invalid or unenforceable, such
provision shall not affect any other provision herein, this Limited Warranty shall be construed as if
such invalid and/or unenforceable provision had never been contained herein.
This warranty gives you special legal rights, and you may also have other rights which vary from state
to state.
This Warranty contains the entire agreement between Seller and Buyer and supersedes any and all
prior agreements, arrangements, or understandings between the parties relating to product warranty.

 WARNING! ELECTRICAL SHOCK. Read and understand all instructions. Failure to follow all
instructions listed below, may result in electrical shock, fire and/or serious personal injury. 
 SAVE THESE INSTRUCTIONS.
Grounding Instructions
This fountain must be plugged into a 3-wire, 3-prong outlet that is properly working and has 
been installed and grounded in accordance with all local, state or federal codes and ordinances.
 DANGER: IMPROPER INSTALLATION OF THE GROUNDING PLUG CAN RESULT IN A RISK OF
ELECTRICAL SHOCK. Check with a qualified electrician or serviceman if the grounding instructions
are not completely understood, or if doubt as to weather the product is properly grounded. Do not
modify the plug provided; if it will not fit the outlet, have a proper outlet installed by a qualified
electrician. Do not use any type of adapter with this product.

ELECTRICAL SAFETY INSTRUCTIONS
41
AMP Load  Volts Extension Cord Length
120V 25' 50'  100'  150'
 AWG
1-5  18 16 16 14
6-10  18 16 14 12
10-12  14 14 14 12
12-16  14 12
Not recommended 

Table 1. Minimum Recommended Extension Cord Gauge (AWG) Chart
Outdoor Use Extension Cords.
1.When product is used outdoors, use only extension cords marked for outdoor use.
2.Use only UL listed extension cords. Never use damaged or altered extension cords. 
3.Follow extension cord manufacturer safety instruction.
Extension Cords
1.Make sure your extension cord is in good condition.
2.When using extension cords, be sure to use one heavy enough to carry the current your product
 requires. An undersized cord will cause a drop in line voltage resulting in power loss and
 overheating. Reference Table 1 at the bottom of the page for the correct size to use depending
 on cord length and nameplate Ampere rating. If in doubt, use the next heavier gage. The smaller
 the gage number, the heavier the cord.
Figure 5
G
Figure 6
6.(SEE FIGURE 6) Fill the fountain basin (A) 
 with water; if possible use distilled water
 to fill basin if possible.
7.Plug power cord into properly grounded
 120V AC outlet.
Adjust Speed of Water Flow
1.Unplug pump (J) from AC power outlet.
2.Move adjustment switch on pump (G)
 toward "+" positive to increase water
 flow, or "-" to decrease water flow.
Maintenance
1.Check water level periodically, add
 water if necessary.
2.If water is not flowing, check electric pump (G),
 and water tube for clogs. 
NOTE: Pump may build up calcium after a
 long period of time and stop running when
 tap water is used. Any calcium remover can
 be used to clean pump.
Grounded
Outlets
A
5.(SEE FIGURE 5) Place the electric pump (G)
 inside basin securing with suction cups.
 Connect the clear tube from duck 1 to the
 hole on top of pump. Guide the power cord
 plug through the hole on rim of basin,

ASSEMBLY INSTRUCTIONS
23
A Basin 1
B Duck 1 1
C Duck 2 1
D Ornament Holder 1
E Cat Tails 1
F Reeds 1
G Electric Pump Preinstalled 1
PARTS & HARDWARE LIST
PART # DESCRIPTION QUANTITY
A
Carefully remove the contents from the package. If any parts are missing do not
attempt to use the product until they have been obtained and correctly installed.
Parts Detail
BCD
E
F
G
Figure 1
B
C
D
A
Figure 2
EF
1.(SEE FIGURE 1) Place the ornament holder (D)
 into basin. Install duck 1 (B) by inserting tabs on
 duck feet into guides on the sidewall of basin.
 Repeat this step for duck 2 (C).
2.(SEE FIGURE 2) Attach the cat tails (E) and
 reeds (F) to the ornament holder (D) by
 inserting guides into studs as shown.