BCP SKY1788 User manual

SKY1788 + SKY1789Ver. 2
INSTRUCTION
MANUAL
Kids Ride-On ATV

Please retain these instructions for future reference.
SAFETY
BATTERY WARNINGS
Pg. 2
This vehicle must be assembled by an adult who has read and understood the instructions in this manual.
Keep the packaging and bags away from children and dispose of all packaging before use. Always use
common sense and safe practices when operating this vehicle. This product contains or emits chemicals
known in the state of California to cause cancer or birth defects or other reproductive harm.
NOTE: For best performance, only use this vehicle on flat and hard surfaces.
Age Range: 18 months to 4 years old
Weight Capacity: 66 lbs.
The following safety hazards may result in serious injury or death:
• This product contains small parts. Keep children away during assembly. Make sure to remove all
packaging material and parts from underneath the vehicle body.
•Never open the battery. Batteries contain lead and lead compounds (acids) that are toxic and corrosive,
and known to the state of California to cause cancer and reproductive harm.
•Limbs, hair, and clothing can get caught in moving parts. Always wear shoes, keep limbs away from
moving parts, and do not wear loose clothing while operating this vehicle.
•This vehicle does not have brakes or braking capability. Do not leave a child unattended during
operation. Do not use this in a location that may require braking capability, as this could result in loss of
control, which may cause serious injury or death.
•Use of this vehicle near streets, motor vehicles, steps, bodies of water, sloped surfaces, hills, wet areas,
flammable vapors, in alleys, at night, or in the dark could result in an unexpected accident.
•Use of this vehicle in unsafe conditions such as snow, rain, loose dirt, mud, sand, or gravel may result in
an unexpected accident such as tipping over, and could damage the electrical system or battery.
•Do not operate this vehicle in an unsafe manner. Examples include but are not limited to:
- Pulling the vehicle with another vehicle or similar device
- Allowing more than one rider
- Pushing the user
- Traveling at an unsafe speed
The following safety hazards may result in serious injury or death:
•Use of a battery or charger other than the supplied rechargeable battery and charger may cause a fire or
explosion. Only use the supplied battery and charger.
•Use of the rechargeable battery and charger for any other product may result in overheating, fire, or
explosion. Never use the supplied rechargeable battery and charger with another product.
•Explosive gases are created during charging. Charge the battery in a well-ventilated area. Do not charge
the battery near heat or flammable materials.
•Contact between the positive and negative terminals may result in fire or explosion. Avoid direct contact
between the terminals. Picking up the battery by the wires or charger can cause damage to the battery
and may result in a fire. Always pick up the battery by its case or handles.
•Liquids on the battery may cause fire or electric shock. Always keep all liquids away from the battery and
keep the battery dry. Contact or exposure to battery leakage (lead acid) may cause serious injury. If
contact or exposure occurs immediately call your physician. If the chemical is on the skin or in the eyes,
flush with cool water for 15 minutes. If the chemical was swallowed, immediately give the person water or
milk. Do not give water or milk if the patient is vomiting or has a decreased level of alertness. Do not
induce vomiting.
•Battery posts, terminals, and related accessories contain lead and lead compounds (acid) – chemicals
known to the State of California to cause cancer, reproductive harm, and are toxic and corrosive. Never
open the battery.
•Tampering or modifying the electric circuit system may cause a shock, fire or explosion and permanently
damage the system. Exposed wiring and circuitry in the charger may cause electric shock. Always keep
the charger housing closed.

USER WARNINGS
SPECIFICATIONS
Pg. 3
•Never leave a child unattended.
•Always sit in the seat when using this vehicle.
•Keep your hands, hair, and clothes away from moving parts.
•Always wear shoes when operating this vehicle.
•Only one rider is allowed on the vehicle at a time.
•Toddlers under 18 months cannot use the vehicle.
•Only drive on level ground.
•Do not go near swimming pools or other bodies of water, drop-os, or up and down steep inclines.
•Do not drive the vehicle into loose dirt, mud, sand, fine gravel, or on wet surfaces.
•Do not drive the vehicle on streets or near cars.
Overall Dimensions
Weight
Weight Capacity
Age Range
Max Speed
Charging Time
Run Time
Battery Type
26"(L) x 16"(W) x 18.5"(H)
11 lbs.
66 lbs.
18 months to 4 years old
2.0 mph.
9-10 hours
1 – 2 hours
6V 4.5AH
Charger
Materials
Output: DC 8V 600MA
Plastic, Metal

HARDWARE
PARTS
Pg. 4
TOOLS REQUIRED
PHILLIPS
SCREWDRIVER
1
1 PCS
HANDLEBAR SCREW
5X33
5
2 PC
NUT 5MM
8
1 PC
RUBBER SPACER
4
6 PC
LARGE SCREW
4X15
7
1 PC
SEAT SCREW
3.5x12
3
3 PC
SMALL SCREW
3.5X12
6
4 PC
WASHER
2
2 PC
FRONT AXLE FRAME
BOLT 5X13
9
1 PC
PLASTIC WASHER
APPROXIMATELY
25 MIN.
ASSEMBLY
1 PERSON
ASSEMBLY
66 LBS
CAPACITY
LBS
SMALL
WRENCH
A
1 PCS
HANDLE BARS B
1 PC
BUMPER
H
1 PC
SPOILER
G
1 PC
SEAT
F
4 PC
WHEEL
E
1 PC
STEERING COLUMN
J
1 PC
CHARGER
I
1 PC
REAR AXLE
D
1 PC
FRONT AXLE
FRAME
C
1 PC
FRONT WHEEL
FRAME
WRENCH TOOL
(PROVIDED)

PRODUCT ASSEMBLY
Pg. 5
1
Insert the center of the part B bumper into the front wheel frame, and then attach the bumper with three
part 3 small screws.
Flip the vehicle over and lay it on a level surface. Insert the part C front wheel frame into the designated
slots and secure it with six part 4 large screws. Cut the zip ties securing the axles and flip them outwards.
2
C
44
B
3
3
3

Insert the part E steering column through the front wheel frame and vehicle body.
4
PRODUCT ASSEMBLY
Pg. 6
3
Remove the nut and bolt on the end of the steering column. Slide the part D front axle frame onto the
steering column and secure it to the front wheel frame with two part 2 bolts and two part 5 nuts. Replace
the nut and bolt on the steering column.
D
2
2
5
5
E

Pg. 7
PRODUCT ASSEMBLY
5
Remove the nuts on the left/right front wheel axles. Slide a part F wheel and part 6 washer onto the front
wheel axle, then replace the nut to secure the wheel. Repeat on the other side. Note: Use the wrench tool
and screwdriver to tighten the nuts.
Cut the zip tie attaching the gear box to the vehicle body. Remove the nuts on the part I rear axle,
and then slide the rear axle through the gear box and vehicle body.
6
F
F
6
6
On the gear box side, slide on a part 9 plastic washer, a part F wheel, and a part 6 washer, then replace the
nut secure the wheel. On the other side of the rear axle, slide on the part 8 rubber spacer, a part F wheel,
and a part 6 washer, then replace the nut to secure the wheel.
6
6
F
F
9
8

Pg. 8
PRODUCT ASSEMBLY
7
Flip the vehicle over. Slide the part A handlebars onto the steering column and route the connector from
the handlebars into the vehicle body. Secure the handlebars to the steering column with the part 1 handle-
bar screw.
8 9
A
1
Underneath the vehicle, join the connector from
the handlebars to the connecter leading from the
battery.
Within the seat, join the red wire to the red terminal
on the battery.

Pg. 9
PRODUCT ASSEMBLY
10
Place the part G seat in position and secure it with the part 7 seat screw.
11
G
Snap the part H spoiler onto the rear of the vehicle.
H
7

CHARGING INSTRUCTIONS & WARNINGS
CARE AND MAINTENANCE
DASHBOARD DIAGRAM
Pg. 10
• Charging socket is located on the back of the vehicle on the right side. Insert one end of the part J
charger into the charging socket and plug the other end into a wall outlet.
• On average, you will need to charge the battery between 9 and 10 hours. Do not charge the battery for
more than 15 hours. Failure to charge the battery as directed could cause permanent damage to the
battery and void the warranty.
• Damage to the battery may occur if it is allowed to drain completely. Do not allow the battery to drain
completely.
• To maintain the health of the battery, charge the battery at least once a month.
• Check the battery and charger (supply cord, connector) for wear and damage before charging. Do not
charge the battery if damage has occurred.
• Only an adult who has read and understood the safety warnings should handle, charge and recharge the
battery.
• Park the vehicle indoors or cover it with a tarp to protect it from wet weather.
• Do not leave the vehicle in the sun for long periods of time or fading may occur. Store in shade or cover with tarp.
• Do not wash the vehicle with a hose.
• Do not wash the vehicle with soap.
Press a button to drive forward/reverse. Release the button to slow down and stop.
REVERSE
FORWARD

TROUBLESHOOTING
Pg. 11
Reason
Low battery
Electrical protection
Switch not in the correct
position
Battery connectors
disconnected
Charger not connected to
socket or outlet Completely plug in the charger
Battery connectors
disconnected
Battery does not have a full
charge
Problem
Battery does not last
Battery does not recharge
Vehicle does not move
Solution
Fully charge the battery
Stop use for several minutes and restart
Completely press in switches
Plug in battery connectors
Plug in battery connectors
Fully charge the battery
Low battery
Loose connection to motor
Steering wheel is not properly
connected
Slow speed
Vehicles shakes while
driving
Vehicle is silent
Fully charge the battery
Overloaded vehicle Reduce the weight on the vehicle
Uneven or sloped road Drive on flat pavement
Ensure the motor is properly connected
to the battery
Properly connect the steering wheel
connector
Normal
Battery is warm and
makes a slight noise while
charging
Normal

ASSEMBLY IS COMPLETE!
All items can be returned for any reason within 60 days of the receipt and will receive a full refund as long as the
item is returned in its original product packaging and all accessories from its original shipment are included. All
returned items will receive a full refund back to the original payment method. All returned items will not be charged
a re-stocking fee.
All returned items require an RA (Return Authorization) number, which can only be provided by a Best Choice
Products Customer Service Representative when the return request is submitted. Items received without an RA
may not be accepted or may increase your return processing time. Once an item has been received by Best Choice
Products, refunds or replacements will be processed within 5 business days.
All returns must be shipped back to the Best Choice Products Return Center at the customer’s expense. If the
reason for return is a result of an error by Best Choice Products then Best Choice Products will provide a pre-paid
shipping label via email. Boxes for return shipping will not be provided by Best Choice Products, and is the
customer’s responsibility to either use the original shipping boxes or purchase new boxes.
Pictures may be required for some returns to ensure an item is not damaged prior to its return. Items returned are
not considered undamaged until they are received by Best Choice Products and verified as such. All damages to
items are the customer’s responsibility until the item has been received by and acknowledge by Best Choice
Products as undamaged.
CONTACT US; WE’RE HERE 7 DAYS A WEEK TO HELP YOU!
WARNING
Manufacturer and seller expressly disclaim any and all liability for personal injury, property damage or
loss, whether direct, indirect, or incidental, resulting from the incorrect attachment, improper use,
inadequate maintenance, or neglect of this product.
PRODUCT WARRANTY INFORMATION
bestchoiceproducts.com customerservice@
bestchoiceproducts.com 844.948.8400 LEARN MORE!