Briggs & Stratton 613200 - Setup guide

Not for
Reproduction
COPYRIGHT by BRIGGS & STRATTON CORPORATION
All rights reserved. No part of this material may be reproduced or transmitted,
in any form or by any means, electronic or mechanical, including photocopying,
recording or by any information storage and retrieval system, without permission
in writing from Briggs & Stratton Corporation.
PRINTED IN U.S.A.
FORM MS--3907--03/17/2010
REPLACE FORM MS--6177--08/31/2007
FILE IN SECT. 2 OF SERVICE MANUAL
613200
Illustrated Parts List
Model Series
613200
AIR COOLED
Liquid Propane/Natural Gas
TYPE NUMBERS
0110 (NG), 0112 (NG), 0113 (LP/NG),
0115 (LP/NG), 0151 (LP) 0155 (NG), 0156 (NG).
TABLE OF CONTENTS
Air Cleaner ..........................
Blower Housing ......................
Camshaft ............................
Carburetor/Mixer .....................
Controls .............................
Crankcase Cover/Sump ...............
Crankshaft ...........................
Cylinder Head ........................
Electric Starter .......................
Engine Gasket Set ...................
Flywheel .............................
Fuel Supply ..........................
Ignition ..............................
Lubrication ..........................
Piston/Rings/Connecting Rods ........
Springs ..............................
Valve Gasket Set .....................

Not for
Reproduction
613200
3907- 2 Assemblies include all parts shown in frames. 03/17/2010
2
3
15
718
1
718A
239
404
616
691
615A
1400
1399
1398
439
1330 REPAIR MANUAL 1319 WARNING LABEL
REQUIRED when replacing
parts with warning labels affixed.
3
15
718
1A
718A
439
1B 718A
718
3
15
439
1346
1027
615A
615A
404
616
691
615A
615A
615A
490 1013
1058 OPERATOR’S MANUAL

Not for
Reproduction
613200
3907- 3 Assemblies include all parts shown in frames. 03/17/2010
3
32
27
26
25
28
29
27
146
16
46
741
523
22
12
273
750
596
468
479
1024
1017
965
332
75
24
12
439
20
220
219
615
221
45
20
220
219
615
221
965
750
273
1024
596
1017 468
479 439
18
18A

Not for
Reproduction
613200
3907- 4 Assemblies include all parts shown in frames. 03/17/2010
4
383
635
337
45
1026
1022
1100
1029
40
36
192
868
35
5
13
7
1077
806
871
798
1022
580
1023A
914
21
1376
1023 708
1263
708
1375
1022
51 883
33
34
1171
40
40
40
812

Not for
Reproduction
613200
3907- 5 Assemblies include all parts shown in frames. 03/17/2010
5
51A
50
290 290A
51
51A
1130
1174
51
125
813
461
51B
431
773
163
431A
431B
98
163
163A
122 51C
51C
125A 1169
95
131 987
137
1127
418
672
276
975
947
276
117
125B
131A 987 95
163A
51C
51D
53
1357

Not for
Reproduction
613200
3907- 6 Assemblies include all parts shown in frames. 03/17/2010
6
829
601A
417
1155
400
448
1373
1374
1366
186
186
300
883
613 613A
728
725
883

Not for
Reproduction
613200
3907- 7 Assemblies include all parts shown in frames. 03/17/2010
7
467A
968
467
643
445
167
996
711
161
163
601B
11
717
1395
601
11A
161A
493
646
607
931
961
796
890
999
163A

Not for
Reproduction
613200
3907- 8 Assemblies include all parts shown in frames. 03/17/2010
8
24
363
1006
23
1005
934
304
1212
1335
879
506
215 215B
215D
215C
197
215A
573
668
1334
1334A
1334C
1334B
332
75
1036 EMISSIONS LABEL
879A
1070
1334D

Not for
Reproduction
613200
3907- 9 Assemblies include all parts shown in frames. 03/17/2010
9
333
1054
334
851
309
1009
920
635
789
587
344
474
501
526
209
232
227
278
562
505
212
188
222
267
265
278
562
505
227A
587A
529
578
222A
789A
1119
1059
212A

Not for
Reproduction
613200
3907- 10 Assemblies include all parts shown in frames. 03/17/2010
10
868
3
163
404
468
691
1022
883
358 ENGINE GASKET SET
7
12
20
439
51
1095 VALVE GASKET SET
868
1022
7883
51
51A
51B
273
580
51B

Not for
Reproduction
613200
3907- 11 Assemblies include all parts shown in frames. 03/17/2010
11
1 843437 Cylinder Assembly
1A 842785 Cylinder Assembly
Used on Type No(s).
0110, 0112.
1B 844410 Cylinder Assembly
Used on Type No(s).
0113.
3 841596 Seal--Oil
(Magneto SIde)
5 843708 Head--Cylinder
(Cylinder #1)
-- -- -- -- -- -- -- N o t e -- -- -- -- --
842181 Head--Cylinder
(Cylinder #2)
7 809730 Gasket--Cylinder Head
11 843457 Tube--Breather
11A 809736 Tube--Breather
Used on Type No(s).
0113, 0115.
12 844107 Gasket--Crankcase
13 809784 Screw
(Cylinder Head)
15 690946 Plug--Oil Drain
-- -- -- -- -- -- -- N o t e -- -- -- -- --
807392 Plug--
Oil Drain
Used on Type No(s).
0110.
16 843445 Crankshaft
-- -- -- -- -- -- -- N o t e -- -- -- -- --
844409 Crankshaft
Used on Type No(s).
0113.
18 842458 Cover--Crankcase
18A 844408 Cover--Crankcase
Used on Type No(s).
0113.
20 841596 Seal--Oil
(PTO Side)
21 843464 Cap--Oil Fill
22 807362 Screw
(Crankcase
Cover/Sump)
23 844387 Flywheel
Used on Type No(s).
0151.
-- -- -- -- -- -- -- N o t e -- -- -- -- --
843330 Flywheel
Used on Type No(s).
0115, 0155, 0156.
843329 Flywheel
Used on Type No(s).
0110.
24 222698s Key--Flywheel
25 809790 Piston Assembly
(Standard)
-- -- -- -- -- -- -- N o t e -- -- -- -- --
841931 Piston
Assembly
(.020” Oversize)
26 809972 Ring Set
(Standard)
-- -- -- -- -- -- -- N o t e -- -- -- -- --
841932 Ring Set
(.020” Oversize)
27 807351 Lock--Piston Pin
28 807361 Pin--Piston
29 841838 Rod--Connecting
32 807363 Screw
(Connecting Rod)
33 843729 Valve--Exhaust
34 843730 Valve--Intake
35 809374 Spring--Valve
(Intake)
36 809374 Spring--Valve
(Exhaust)
40 844788 Retainer--Valve
-- -- -- -- -- -- -- N o t e -- -- -- -- --
807492 Retainer--
Valve
45 809785 Tappet--Valve
46 809879 Camshaft
50 843451 Manifold--Intake
-- -- -- -- -- -- -- N o t e -- -- -- -- --
841591 Manifold--
Intake
Used on Type No(s).
0113, 0115.
51 841592 Gasket--Intake
(Intake Manifold)
51A 843456 Gasket--Intake
(Adapter to
Carburetor)
51B 843455 Gasket--Intake
(Adapter to
Intake Manifold)
51C 841882 Gasket--Intake
(Carburetor Spacer)
Used on Type No(s).
0113, 0115.
51D 809910 Gasket--Intake
Used on Type No(s).
0113, 0115.
53 843769 Stud
(Mixer to
Carburetor Adapter)
Used on Type No(s).
0110, 0112, 0151,
0155, 0156.
75 842548 Washer
(Flywheel)
95 690718 Screw
(Throttle Valve)
98 841842 Kit--Idle Speed
(Intake Elbow)
117 844499 Jet--Main
(Contains Both
L/P and N/G Jets)
122 844713 Spacer--Carburetor
Used on Type No(s).
0113, 0115.
125 843527 Carburetor
(Liquid Propane)
Used on Type No(s).
0151.
-- -- -- -- -- -- -- N o t e -- -- -- -- --
843528 Carburetor
(Natural Gas)
Used on Type No(s).
0110, 0112, 0155,
0156.
125A 844415 Carburetor
(Liquid Propane/
Natural Gas)
Used on Type No(s).
0113.
125B 842183 Carburetor
(Liquid Propane/
Natural Gas)
Used on Type No(s).
0115.
131 844817 Kit--Throttle Shaft
Used on Type No(s).
0113.
131A 841551 Kit--Throttle Shaft
Used on Type No(s).
0115.
137 841651 Gasket--Float Bowl
146 691639 Key--Timing
161 843446 Base--Air Cleaner
161A 843118 Base--Air Cleaner
Used on Type No(s).
0113, 0115.
163 843448 Gasket--Air Cleaner
163A 843117 Gasket--Air Cleaner
Used on Type No(s).
0113, 0115.
167 841855 Seal--Air Cleaner Nut
186 841511 Connector--Hose
(Oil Diverter)
188 692062 Screw
(Control Bracket)
192 690083 Adjuster--Rocker Arm
197 841233 Screw
(Back Plate)
REF. PART REF. PART REF. PART
NO. NO. DESCRIPTION NO. NO. DESCRIPTION NO. NO. DESCRIPTION

Not for
Reproduction
613200
3907- 12 Assemblies include all parts shown in frames. 03/17/2010
12
209 841845 Spring--Governor
(Gold)
Used on Type No(s).
0151.
-- -- -- -- -- -- -- N o t e -- -- -- -- --
842250 Spring--
Governor
(Light Blue)
Used on Type No(s).
0110, 0112, 0156.
841500 Spring--
Governor
(Purple)
Used on Type No(s).
0115, 0155.
212 843454 Link--Throttle
215 809728 Guide--Air
(Cylinder #1)
215A 809739 Guide--Air
215B 809737 Guide--Air
(Cylinder #2)
215C 809738 Guide--Air
(Cylinder #1)
215D 809897 Guide_Air
(Cylinder #2)
219 809426 Gear--Governor
220 841608 Washer
(Governor Gear)
221 841026 Cup--Governor
222 843535 Bracket--Control
222A 844420 Bracket--Control
(Air Cleaner Support)
Used on Type No(s).
0113.
227 809984 Lever--
Governor Control
227A 844815 Lever--
Governor Control
Used on Type No(s).
0115.
232 690545 Spring--
Governor Link
239 841281 Switch--Oil Pressure
265 841673 Clamp--Casing
(Control Bracket)
267 841672 Screw
(Casing Clamp)
273 690681 Seal--O Ring
(Oil Pump)
276 806998 Washer--Sealing
Used on Type No(s).
0113.
278 842122 Washer
(Governor
Control Lever)
290 809911 Screw
(Intake Elbow)
(M6x55mm)
290A 807421 Screw
(Intake Elbow)
(M6x25mm)
300 809983 Muffler
Used on Type No(s).
0110.
304 843442 Housing--Blower
309 807383 Motor--Starter
332 842222 Nut
(Flywheel)
333 843327 Armature--Magneto
334 692066 Screw
(Magneto Armature)
337 692051 Plug--Spark
-- -- -- -- -- -- -- N o t e -- -- -- -- --
797434 Plug--Spark
Used on Type No(s).
0110.
344 692539 Screw
(Cable Clamp)
Used on Type No(s).
0110, 0112, 0113.
358 843711 Gasket Set--Engine
363 19203 Puller--Flywheel
383 19576s Wrench--Spark Plug
400 841501 Cooler--Oil
404 809436 Washer
(Governor Crank)
417 810074 Screw
(Oil Cooler)
418 844589 Plate--
Carburetor Cover
431 843452 Elbow--Intake
431A 841539 Elbow--Intake
(Intake Manifold)
Used on Type No(s).
0113, 0115.
431B 843116 Elbow--Intake
(Air Cleaner)
Used on Type No(s).
0113, 0115.
439 692154 Seal--O Ring
(Crankcase
Cover/Sump)
(Cylinder)
445 841856 Filter--
Air Cleaner Cartridge
448 841504 Bracket--Oil Cooler
461 843858 Hose--Gaseous
Fuel Connector
(32.5 Inches Long)
-- -- -- -- -- -- -- N o t e -- -- -- -- --
843293 Hose--
Gaseous Fuel
Connector
(31 Inches Long)
844412 Hose--
Gaseous Fuel
Connector
(20 Inches Long)
467 691985 Knob--Air Cleaner
467A 841846 Knob--Air Cleaner
468 690690 Seal--O Ring
(Oil Pump Screen)
474 696579 Alternator
Used on Type No(s).
0110, 0112, 0113.
479 807084 Screw
(Oil Pump Screen)
490 843433 Bearing--Magneto Side
493 844419 Bracket--Mounting
(Actuator)
Used on Type No(s).
0113.
501 691573 Regulator
Used on Type No(s).
0110, 0112, 0113.
505 690238 Nut
(Governor
Control Lever)
506 809957 Screw
(Carburetor Cover)
523 841007 Dipstick
526 691547 Screw
(Regulator)
Used on Type No(s).
0110, 0112, 0113.
529 690744 Grommet
562 843344 Bolt
(Governor
Control Lever)
573 842712 Plate--Back
578 844407 Wire Assembly
Used on Type No(s).
0113.
580 809894 Seal--O Ring
(Oil Fill Cap)
REF. PART REF. PART REF. PART
NO. NO. DESCRIPTION NO. NO. DESCRIPTION NO. NO. DESCRIPTION

Not for
Reproduction
613200
3907- 13 Assemblies include all parts shown in frames. 03/17/2010
13
587 807386 Clamp--Cable
Used on Type No(s).
0110, 0112, 0113.
587A 844414 Clamp--Cable
Used on Type No(s).
0115.
596 691492 Screw
(Oil Pump)
601 841499 Clamp--Hose
(Breather Tube)
601A 841597 Clamp--Hose
(Oil Hose)
601B 691145 Clamp--Hose
(Breather Tube)
607 841233 Screw
(Air Cleaner Brace)
613 692062 Screw
(Muffler)
(M8x18mm)
613A 809743 Screw
(Muffler)
(M8x25mm)
615 698290 Retainer--
Governor Shaft
(Crankcase
Cover/Sump)
615A 809533 Retainer--
Governor Shaft
(Cylinder)
616 844180 Crank--Governor
635 692076 Boot--Spark Plug
643 841850 Retainer--Air Filter
646 841849 Brace--Air Cleaner
Used on Type No(s).
0115.
668 841974 Spacer
(Blower Housing)
672 843102 Gasket--
Carburetor Plate
691 809287 Seal--Governor Shaft
708 841301 Seal--O Ring
(Breather Reed)
711 807385 Screw
(Carburetor Shield)
Used on Type No(s).
0113.
717 843449 Bracket--Air Cleaner
718 690959 Pin--Locating
(Crankcase
Cover/Sump)
718A 809508 Pin--Locating
(Cylinder Head)
725 841132 Shield--Heat
Used on Type No(s).
0110.
728 692067 Screw
(Heat Shield)
Used on Type No(s).
0110.
741 809432 Gear--Timing
750 692539 Screw
(Oil Pump Cover)
-- -- -- -- -- -- -- N o t e -- -- -- -- --
841233 Screw
Used on Type No(s).
0113.
773 843643 Retainer
(Carburetor)
789 809906 Harness--Wire
Used on Type No(s).
0110, 0112.
789A 844406 Harness--Wire
Used on Type No(s).
0113.
796 690260 Washer
(Actuator)
798 691492 Screw
(Rocker Arm)
806 807357 Screw
(Lifting Bracket)
812 690939 Nut
(Rocker Cover)
813 843438 Clamp
(Gaseous Fuel
Connector Hose)
829 841503 Hose--Oil
(Oil Cooler)
851 493880s Terminal--Spark Plug
868 691963 Seal--Valve
871 692057 Bushing--Valve Guide
879 843450 Cover--Carburetor
879A 842188 Cover--Carburetor
Used on Type No(s).
0113, 0115.
883 809872 Gasket--Exhaust
890 841614 Bracket--Support
Used on Type No(s).
0115.
914 807357 Screw
(Rocker Cover)
920 825418 Solenoid--Starter
931 844417 Actuator
Used on Type No(s).
0113.
934 841205 Screw
(Fan Retainer)
947 844422 Solenoid--Fuel
Used on Type No(s).
0113.
961 841233 Screw
(Air Cleaner Bracket
to Actuator Bracket)
965 809422 Cover--Oil Pump
968 843447 Cover--Air Cleaner
975 844423 Bowl--Float
Used on Type No(s).
0113.
987 808183 Seal--Throttle Shaft
996 843119 Shield--Carburetor
999 797483 Screw
(Actuator)
Used on Type No(s).
0113.
1005 809950 Fan--Flywheel
-- -- -- -- -- -- -- N o t e -- -- -- -- --
843436 Fan--Flywheel
Used on Type No(s).
0113.
1006 809999 Retainer--Fan
1009 690711 Screw
(Starter Motor)
1013 841602 Nipple--Oil Filter
1017 809421 Screen--Oil Pump
1022 809732 Gasket--
Rocker Cover
1023 809731 Cover--Rocker
(Rocker Cover #1)
1023A 809789 Cover--Rocker
(Rocker Cover #2)
1024 841291 Pump--Oil
1026 809783 Rod--Push
1027 842921 Filter--Oil
1029 807323 Arm--Rocker
1036 Label--Emissions
(Available from a
Briggs & Stratton
Authorized Dealer)
1054 280275 Tie--Cable
1058 279551 Operator’s Manual
REF. PART REF. PART REF. PART
NO. NO. DESCRIPTION NO. NO. DESCRIPTION NO. NO. DESCRIPTION

Not for
Reproduction
613200
3907- 14 Assemblies include all parts shown in frames. 03/17/2010
14
1059 698516 Kit--Screw/Washer
(Alternator)
1070 807435 Screw
(Flywheel Fan)
1077 809729 Bracket--Lifting
1095 843713 Gasket Set--Valve
1100 791959 Pivot--Rocker Arm
1119 691552 Screw
(Alternator)
Used on Type No(s).
0110, 0112, 0113.
1127 841621 Screw
(Float Bowl)
1130 841590 Stud
(Intake Manifold)
1155 806647 Washer
(Oil Cooler)
(Top)
1169 841620 Screw
(Carburetor
Cover Plate)
1171 844813 Stud
(Rocker Cover)
Used on Type No(s).
0115, 0155, 0156.
1174 842067 Nut
(Intake Manifold)
1212 809958 Stud
(Blower Housing)
1263 841324 Reed--Breather
1319 794467 Label--Warning
1330 272144 Repair Manual
1334 690677 Screw
(Air Guide)
(M4x12mm)
1334A 807435 Screw
(Air Guide)
(M6x20mm)
1334B 807084 Screw
(Air Guide)
(M6x14mm)
1334C 841233 Screw
(Air Guide)
(M6x10mm)
1334D 692062 Screw
(Air Guide)
(Valley)
1335 690939 Nut
(Blower Housing)
1346 844802 Valve--
Oil Drain Shut Off
Used on Type No(s).
0113.
1357 844816 Sleeve--Fuel Line
Used on Type No(s).
0115.
1366 841510 Diverter--Oil Cooler
1373 692539 Screw
(Oil Cooler Bracket)
1374 841506 Seal--O Ring
(Oil Cooler Diverter)
1375 841550 Cover--Breather/Reed
1376 806421 Screw
(Breather/Reed Cover)
1395 807385 Screw
(Air Cleaner Base)
1398 842191 Cover--Fuel Pump
1399 690932 Screw
(Fuel Pump Cover)
1400 809894 Seal--O Ring
(Fuel Pump Cover)
REF. PART REF. PART REF. PART
NO. NO. DESCRIPTION NO. NO. DESCRIPTION NO. NO. DESCRIPTION

Not for
Reproduction

Not for
Reproduction