Brinkmann SpotLight Operation manual

OWNER’S MANUAL & OPERATING INSTRUCTIONS
WARNING
READ AND FOLLOW ALL WARNINGS
AND INSTRUCTIONS IN THIS
MANUAL TO AVOID PERSONAL
INJURY OR PROPERTY DAMAGE.
• Never place spotlight face down when light is on or is still hot
from recent use. Doing so could burn/ignite surfaces such as
seats, carpeting, etc. and cause major property damage.
Always turn spotlight off when not in use.
• To prevent serious damage to eyesight, never look into
spotlight when light is on. Do not shine light into the face of
someone else.
• Do not touch lens of spotlight when light is on or if it was
recently on. The lens will be hot and could cause serious
burns.
• Do not place spotlight in water. Keep all components dry and
out of water at all times.
• Do not allow children to handle or operate this spotlight.
• Do not use this product for other than its intended use.
• Do not operate in close proximity of combustible or
flammable materials.
• Do not attempt to operate spotlight if cord, plug, bulb or any
part of the spotlight is damaged or corroded.
• Only use AC charger and DC lighter plug that are provided
with the L.E.D./Xenon spotlight or their replacements.
• A damaged battery can leak acid. Avoid contact with eyes
and skin. If contact occurs, flush immediately with large
amounts of water. DO NOT ingest. If contact with eyes or
ingestion occurs, consult physician immediately.
IMPORTANT SAFETY WARNINGS
READ AND FOLLOW ALL SAFETY WARNINGS AND INSTRUCTIONS IN THE OWNER’S MANUAL
BEFORE OPERATING SPOTLIGHT.
WARNING
USE CAUTION AND COMMON SENSE WHEN OPERATING YOUR SPOTLIGHT.
FAILURE TO ADHERE TO THE SAFETY WARNINGS AND GUIDELINES IN THIS MANUAL
COULD RESULT IN BODILY INJURY OR PROPERTY DAMAGE.
SAVE THIS MANUAL FOR FUTURE REFERENCE.
™
WARNING
TO PREVENT DAMAGE TO
EYESIGHT, NEVER LOOK INTO
SPOTLIGHT WHEN LIGHT IS ON. DO
NOT SHINE LIGHT INTO THE FACE
OF SOMEONE ELSE.
INSTR-800-2222-0_LED_Xenon.qxd 8/31/05 5:47 PM Page 2

XENON
LED
Step 1: Make sure trigger switch is not locked in the ON position.
Step 2: Plug the AC charger or DC charger/adapter into the socket located on
the base of the spotlight handle as illustrated.
Step 3: For DC Charger/Adapter:
Plug the other end of the DC charger/adapter into a cigarette lighter
receptacle.
For AC Charger:
Plug the other end of the AC charger into a wall outlet.
Parts List
1 L.E.D./Xenon spotlight
2 120-volt AC charger
3 12-volt DC charger/adapter lighter plug
Owner’s Manual
OPERATING INSTRUCTIONS
READ AND FOLLOW ALL SAFETY WARNINGS AND INSTRUCTIONS IN THE OWNER’S MANUAL
BEFORE OPERATING SPOTLIGHT.
Inspect contents of the box to ensure all parts are included and undamaged.
Step 1: Depress trigger switch in handle to turn spotlight ON.
Step 2: Release trigger switch to turn spotlight OFF.
Continuous Beam Using Lock Button:
Step 1: For a continuous beam, depress trigger switch and slide the lock button
to the LOCKED position.
Step 2: To unlock and turn spotlight OFF, slide the lock button to the
UNLOCKED position.
NN
NNOO OOTT TTEE EE:::: To lock the L.E.D./Xenon in the OFF position, release trigger switch, then
slide the lock button to the LOCKED position.
WARNING: Always turn spotlight off when not in use.
Switching Between Xenon and L.E.D. Beams:
Step 1: For Xenon beam, slide switch on back of light to Xenon dot, as
illustrated.
Step 2: For L.E.D. beam, slide switch on back of light to L.E.D. dot, as
illustrated.
NN
NNOO OOTT TTEE EE:::: The L.E.D./Xenon will burn for approximately 85 minutes if using Xenon
beam, or approximately 80 hours if using L.E.D. beam.
1
2
3
To Operate
2
Trigger
Switch
LED Indicator
Lock
Button
Beam
Switch
Xenon
Beam
L.E.D.
Beam
Unlocked
Locked
To Charge
INSTR-800-2222-0_LED_Xenon.qxd 8/31/05 5:47 PM Page 3

Step 4: Allow the spotlight to charge for at least 8 hours. Do not allow to
charge more than 12 hours.
NN
NNoo oottttee ee:::: LED indicator on base of handle turns off automatically when battery
is fully charged.
Step 5: Remove spotlight from the charger before operating.
SS
SSee eeee ee cc cchh hhaa aarr rrtttt ffffoo oorr rr rr rree eecc ccoo oomm mmmm mmee eenn
nndd ddee eedd dd cc cchh hhaa aarr rrgg ggee ee ttttiiii mm mmee eess ss....
3
Charge Times
Charge time is dependent on usage of the
product. See chart below for recommended charge time.
Glass
Retainer Rubber Cap
To Replace Bulb
Only use Brinkmann xenon bulb that is designed for the L.E.D./Xenon
spotlight as a replacement. Use of any other bulb may result in poor
performance and may damage your spotlight.
NOTE: Handling the bulb can leave oil from your fingers on the bulb. To
extend the life of the new bulb and maximize brightness, gently
clean off bulb with soft cloth or tissue. Make sure the reflector
does not touch or bend the bulb while replacing spotlight head.
Step 1: Disconnect spotlight from charger.
Step 2: Remove front rubber cap from barrel of spotlight.
Step 3: Pinch the wings of the glass retainer together and lift as illustrated.
Step 4: Pull glass and reflector away from rear housing.
Step 5: Pull old bulb straight out of bulb holder.
Step 6: Make certain that "legs" on new bulb are straight. Insert "legs"
into the two holes in the bulb holder.
Step 7: Gently push bulb straight in until fully seated and centered.
Step 8: To reassemble, place the glass and reflector on the rear housing.
Insert the glass retainer into the rear housing.
Step 9: Replace rubber cap.
WARNING: Do not touch the lamps when light is on or if it was recently
on. The lamps will be hot and could cause serious burns.
Glass &
Reflector
Rear
Housing
40
4812
85
40
4812
80
Battery Charge
Battery Charge
CHARGE TIME (Hours)
USAGE (Hours)
CHARGE TIME (Hours)
XENON MODE
L.E.D. MODE
USAGE (Minutes)
Contains lead-acid (Pb)
batteries. Batteries must
be recycled or disposed of
properly.
INSTR-800-2222-0_LED_Xenon.qxd 8/31/05 5:47 PM Page 4

For 1-year from date of purchase, The Brinkmann Corporation warrants the L.E.D./Xenon spotlight against defects due to workmanship or
materials to the original purchaser. The Brinkmann Corporation’s obligations under this warranty are limited to the following guidelines:
• This warranty does not extend to the bulb or batteries.
• This warranty does not cover spotlights that have been altered or damaged due to: normal wear, abuse, improper maintenance, improper
use, disassembly of parts and/or attempted repair by anyone other than an authorized employee of The Brinkmann Corporation.
• This warranty does not cover surface scratches or weathering as this is considered normal wear.
• Warranty service is limited to repair or replacement of spotlights which prove defective under normal use and which upon examination
shall indicate to Brinkmann’s satisfaction, they are defective. If Brinkmann confirms the defect and approves the claim, Brinkmann will
elect to repair or replace the spotlight as covered by the terms of this warranty.
• This warranty extends to the original purchaser only and is not transferable or assignable to subsequent purchasers.
The Brinkmann Corporation requires reasonable proof of purchase. TT
TThh hhee eerr rree eeffffoo oorr rree ee,,,, ww wwee ee ss ssttttrr rroo oonn nngg ggllll yy yy rr rree eecc ccoo oomm mmmm mmee eenn nndd dd tttthh hhaa aatttt yy yyoo oouu uu rr rree eettttaa aaiiii nn nn yy yyoo oouu uurr rr ss ssaa aallll ee eess ss rr rree eecc ccee eeiiii pp pptttt
oo
oorr rr iiii nn nnvv vvoo ooiiii cc ccee ee.... To obtain repair or replacement of your L.E.D./Xenon spotlight under the terms of this warranty, please call Customer Service
Department at 1-800-527-0717 for a Return Authorization Number and further instructions. AA
AA rr rree eecc ccee eeiiii pp pptttt ww wwiiii llll llll bb bbee ee rr rree eeqq qquu uuiiii rr rree eedd dd.... AA AA RR RRee eettttuu uurr rrnn nn
AA
AAuu uutttthh hhoo oorr rriiii zz zzaa aattttiiii oo oonn nn NN NNuu uumm mmbb bbee eerr rr mm mmuu uuss sstttt bb bbee ee cc ccllll ee eeaa aarr rrllll yy yy mm mmaa aarr rrkk kkee eedd dd oo oonn nn tttthh hhee ee oo oouu uuttttss ssiiii dd ddee ee oo ooffff tttthh hhee ee bb bboo ooxx xx.... Spotlights returned to Brinkmann must include your name,
address and telephone number. Please make sure the light is properly packed, postage prepaid, and insured. The Brinkmann Corporation will
not be responsible for any spotlights forwarded to us without a Return Authorization Number.
EXCEPT AS ABOVE STATED, THE BRINKMANN CORPORATION MAKES NO OTHER EXPRESS WARRANTY.
THE IMPLIED WARRANTIES OF MERCHANTABILITY AND FITNESS FOR A PARTICULAR PURPOSE ARE LIMITED IN DURATION TO 1-YEAR FROM
THE DATE OF PURCHASE. SOME STATES DO NOT ALLOW LIMITATIONS ON HOW LONG AN IMPLIED WARRANTY LASTS, SO THE ABOVE
LIMITATION MAY NOT APPLY TO YOU.
ANY LIABILITY FOR INDIRECT, INCIDENTAL OR CONSEQUENTIAL DAMAGES ARISING FROM THE FAILURE OF THE L.E.D./XENON SPOTLIGHT TO
COMPLY WITH THIS WARRANTY OR ANY IMPLIED WARRANTY IS EXCLUDED. CUSTOMER ACKNOWLEDGES THAT THE PURCHASE PRICE
CHARGED IS BASED UPON THE LIMITATIONS CONTAINED IN THE WARRANTY SET OUT ABOVE. SOME STATES DO NOT ALLOW THE EXCLUSION
OR LIMITATION OF INCIDENTAL OR CONSEQUENTIAL DAMAGES, SO THE ABOVE LIMITATION OR EXCLUSION MAY NOT APPLY TO YOU. THIS
WARRANTY GIVES YOU SPECIFIC LEGAL RIGHTS, AND YOU MAY ALSO HAVE OTHER RIGHTS WHICH VARY FROM STATE TO STATE.
1-YEAR LIMITED WARRANTY
140-2222-0
6/04, 8/05
For Model 800-2222-0
Tips to Avoid Damage to
Your L.E.D./Xenon Spotlight
• Never attempt to wipe or clean the inner reflective surface of the reflector.
Touching or wiping the surface will damage it permanently.
• The lens is made of tempered glass. Avoid dropping or sharp impact on
spotlight to prevent damage.
• Do not allow hot lens to come in contact with water or materials subject to
heat damage.
• The spotlight is weather resistant. It is not waterproof. Do not use the
spotlight under water or store outdoors.
• Use only Brinkmann xenon bulb that is designed for your L.E.D./Xenon
spotlight. Use of any other bulb may result in poor performance and may
damage your spotlight.
• After months of use, cigarette lighters can build up corrosion that may
prevent the DC lighter plug from making good contact. It may be necessary
to clean the inside of your cigarette lighter receptacle with a fine emery
cloth. Before cleaning receptacle, remove the fuse to prevent it from
shorting out.
The retractable hanging ring allows spotlight to hang while in use or
during storage.
To Hang/Store L.E.D./Xenon
© 2004 The Brinkmann Corporation
Dallas, TX 75244
www.brinkmann.net
INSTR-800-2222-0_LED_Xenon.qxd 8/31/05 5:47 PM Page 1