Codan 3033 User manual

HF RADIO COMMUNICATIONS
USER GUIDE
Telephone Interconnect
3033

No part of this guide may be reproduced, transcribed,
translated into any language or transmitted in any form
whatsoever without the prior written consent of Codan
Limited.
© Copyright 2008 Codan Limited.
Codan part number 15-04156-EN Issue 1, May 2008
NGT®, CALM®and Easitalk®are registered trademarks of
Codan Limited. Brand, product, and company names
mentioned in this document are trademarks or registered
trademarks of their respective holders.
The English version takes precedence over any translated
versions.

Telephone Interconnect 3033 User Guide i
Table of contents
Introduction
Overview of this guide . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1
1Overview
General . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
Typical layouts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
Interfaces. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10
Front panel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10
Rear panel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12
Web interface . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13
Call logs . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17
Power supply. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17
Compatibility . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18
Operating modes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19
2 Installation
Unpacking the equipment . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22
Setting up the RS232 [15way] Mode/Speed for the Codan HF
transceiver. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23
Installing the 3033 Telephone Interconnect . . . . . . . . . . . . . . . . . . . . . . . . 24
Required equipment and information . . . . . . . . . . . . . . . . . . . . . . . . . . 24
Installing the telephone interconnect . . . . . . . . . . . . . . . . . . . . . . . . . . 25
Switching on the telephone interconnect . . . . . . . . . . . . . . . . . . . . . . . 28
Setting up the telephone interconnect . . . . . . . . . . . . . . . . . . . . . . . . . . 28
Performing a functional test on the installation . . . . . . . . . . . . . . . . . . . . . 33
Performing an operational test on the installation . . . . . . . . . . . . . . . . . . . 34

Table of contents
ii Telephone Interconnect 3033 User Guide
3 Making and receiving calls
General. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 36
Call activity at a remote HF transceiver . . . . . . . . . . . . . . . . . . . . . . . . . . . 39
Making an HF call to a telephone . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 39
Receiving a call . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 41
Call activity at a telephone within a PSTN . . . . . . . . . . . . . . . . . . . . . . . . . 42
Making a call to an HF transceiver . . . . . . . . . . . . . . . . . . . . . . . . . . . . 42
Leaving a call-back telephone number at a remote HF transceiver. . . . 45
Receiving an HF call . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 45
Connecting calls manually. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 47
Monitoring the telephone interconnect . . . . . . . . . . . . . . . . . . . . . . . . . . . . 49
Using the call logs . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 50
Accessing the call logs. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 50
Using the information in the call logs . . . . . . . . . . . . . . . . . . . . . . . . . . 51
4 Managing the telephone station
Planning considerations . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 54
Telephone users . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 54
HF users . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 54
Setting up access to the web interface . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 58
Connecting a PC directly to the telephone interconnect . . . . . . . . . . . . 58
Connecting a PC via a modem to the telephone interconnect . . . . . . . . 60
Logging into the web interface . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 63
Setting up call log parameters . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 64
Setting up telephone users . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 65
Setting up HF user call groups. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 67
Setting up HF user access rights . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 70
Controlling access to the telephone interconnect . . . . . . . . . . . . . . . . . . . . 75
Setting up how the telephone interconnect receives calls . . . . . . . . . . . . . . 77
Setting up how the telephone interconnect makes calls . . . . . . . . . . . . . . . 78
Setting up inactivity timeouts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 82
Setting up speed dial telephone numbers. . . . . . . . . . . . . . . . . . . . . . . . . . . 83
Setting volume levels. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 85

Table of contents
Telephone Interconnect 3033 User Guide iii
Setting up the telephone line. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 87
Loading a telephone line configuration file . . . . . . . . . . . . . . . . . . . . . 87
Setting up telephone line values for your region . . . . . . . . . . . . . . . . . 88
Backing up the setup. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 94
Upgrading firmware . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 95
Changing web interface passwords. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 96
5 Advanced setup of the Codan HF transceiver
Channel names . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 98
Networks and channels . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 101
Self address of the Codan HF transceiver. . . . . . . . . . . . . . . . . . . . . . . . . 102
Address List entries in the transceiver connected to the telephone
interconnect. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 103
6 Troubleshooting
Appendix A—Voice prompts
Overview. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 110
Menu for voice prompts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 111
Creating your own voice prompts. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 113
Loading your own voice prompts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 123
Appendix B—Factory defaults
Appendix C—Specifications
Appendix D—Connectors
Appendix E—RTU–292 Compatibility Mode
Appendix F—Support for non-Phone call
transceivers

Table of contents
iv Telephone Interconnect 3033 User Guide
Appendix G—Compliance
Introduction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 142
European R&TTE Directive . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 142
EMC and safety notices . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 144
FCC compliance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 145
A-tick compliance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 146
Register of hazardous substances . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 147
Appendix H—Definitions
Standards and icons . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 149
Acronyms and abbreviations . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 150
Glossary . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 152
Units. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 153
Unit multipliers . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 153
About this issue . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 154
Index

Telephone Interconnect 3033 User Guide v
List of figures
Figure 1: Basic layout for a Codan telephone station . . . . . . . . . . . 7
Figure 2: Trunked layout for Codan telephone stations. . . . . . . . . . 9
Figure 3: The front panel of the 3033 Telephone Interconnect . . . 10
Figure 4: The rear panel of the 3033 Telephone Interconnect. . . . 12
Figure 5: The web interface . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14
Figure 6: Basic menu in the web interface. . . . . . . . . . . . . . . . . . . 15
Figure 7: Advanced menu in the web interface . . . . . . . . . . . . . . . 16
Figure 8: 3033 Telephone Interconnect with a 2010 RF Unit,
2030 Junction Box and handset . . . . . . . . . . . . . . . . . . . 26
Figure 9: 3033 Telephone Interconnect with a 2012 RF Unit
and handset . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 27
Figure 10: Remote connection to telephone interconnect . . . . . . . . 60
Figure 11: Menu for voice prompts . . . . . . . . . . . . . . . . . . . . . . . . 111
Figure 12: External view of the Transceiver connector. . . . . . . . . 133

List of figures
vi Telephone Interconnect 3033 User Guide
This page has been left blank intentionally.

Telephone Interconnect 3033 User Guide vii
List of tables
Table 1: Buttons on the front panel . . . . . . . . . . . . . . . . . . . . . . . 11
Table 2: LEDs on the front panel . . . . . . . . . . . . . . . . . . . . . . . . . 11
Table 3: Connectors/ports on the rear panel . . . . . . . . . . . . . . . . . 13
Table 4: Information required by a telephone user. . . . . . . . . . . . 42
Table 5: Telephone call log . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 51
Table 6: Transceiver call log . . . . . . . . . . . . . . . . . . . . . . . . . . . . 52
Table 7: Default call groups . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 55
Table 8: Default usernames and passwords for the web
interface . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 63
Table 9: Suggested call groups . . . . . . . . . . . . . . . . . . . . . . . . . . . 67
Table 10: Access levels in the web interface . . . . . . . . . . . . . . . . . 96
Table 11: Troubleshooting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 107
Table 12: Voice prompts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 114
Table 13: Factory defaults for General Configuration, Volume
Controls, Voice Menus and Timeouts . . . . . . . . . . . . . 126
Table 14: Factory defaults for Telephone Users (including
Access Codes) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 127
Table 15: Factory defaults for HF Users (including Call
Groups and Access Rights) . . . . . . . . . . . . . . . . . . . . . 128
Table 16: Factory defaults for Speed Dial . . . . . . . . . . . . . . . . . . 128
Table 17: Factory defaults for Telephone Line Configuration . . . 129
Table 18: Factory defaults for Web Interface Passwords. . . . . . . 130
Table 19: General specifications . . . . . . . . . . . . . . . . . . . . . . . . . 131
Table 20: Telephone interface specifications . . . . . . . . . . . . . . . . 132
Table 21: Pinouts of the Transceiver connector . . . . . . . . . . . . . . 133
Table 22: DTMF commands for RTU–292 Compatibility
Mode. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 135
Table 23: Earth symbol. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 144
Table 24: 有毒有害物质列表 (Register of hazardous
substances) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 147

List of tables
viii Telephone Interconnect 3033 User Guide
This page has been left blank intentionally.