Contec PC-HDD40S User manual

1 PC-HDD40S
2.5-inch 40GB SATA Hard Disk Drive
PC-HDD40S User’s Guide
CONTEC CO.,LTD.
Thank you for purchasing the CONTEC PC-HDD40S. Please use this product in accordance with the
procedures described in this document.
Product Configuration
- Hard Disk Drive [PC-HDD40S]…1
About the adjustment model
This is an optional product for BX-100n series
By the product specifications, this product can be used only with the model(s) listed below
- BX-100n-DC5xxx-C01
Disposal
When disposing of the product, follow the disposal procedures stipulated under the relevant laws and
municipal ordinances.
Safety Information
This document provides safety information using the following symbols to prevent accidents resulting in
injury or death and the destruction of equipment and resources. Understand the meanings of these labels
to operate the equipment safely.
DANGER DANGER indicates an imminently hazardous situation which, if not avoided, will
result in death or serious injury.
WARNING WARNING indicates a potentially hazardous situation which, if not avoided, could
result in death or serious injury.
CAUTION CAUTION indicates a potentially hazardous situation which, if not avoided, may result
in minor or moderate injury or in property damage.

PC-HDD40S User’s Guide
PC-HDD40S 2
Handling Precautions
CAUTION
- Do not apply pressing force on the top of cover (See Figure 1.).
- Do not cover the breathing hole on the top cover (See Figure 2.).
Figure 1. Figure 2.
- Do not touch the interface connector pins and the surface of printed circuit board.
- Hard disk is precision instruments. Be extremely careful in handling during and after assembly.
- The drive can be easily damaged by shocks or ESD (Electrical Static Discharge), so any damages
applied to the drive after taking out from shipping package and opening ESD protective bag are user’s
responsibilities.
- Be sure to turn off the power of the unit when plugging in or unplugging connectors.
- CONTEC bears absolutely no responsibility for use if modified hard disk.
- Excessive impact (greater than 900G; 1ms or 120G; 11ms), if this hard disk is subjected to, might
cause a fatal error that is not recoverable.
- The life of a hard disk drive changes with environment or operating conditions. As a standard,
power time below 30,000 hours (power time) or five years, or an early thing.
- When the surface temperature exceeds 70°C, the service life will drop significantly. Beware that
the temperature of the surface temperature measurement point must be kept below 60°C.
Surface temperature measurement point

PC-HDD40S User’s Guide
3 PC-HDD40S
Specification
Item Specification
Total recording capacity 40GByte
Interface ATA8-ACS, Serial-ATA Revision 2.5 (Genli)
Data-transfer velocity (Gbps) 1.5 (Max.)
Input voltage +5VDC (±5%)
Spin up *1 5.0W (Max.)
Read / Write / Seek 1.9W / 1.9W / 2.1W (typ.)
Idle 0.60W (typ.)
Standby 0.13W (typ.)
Consumed
power
Sleep 0.13W (typ.)
Temperature -15 - 80°C
-15 - 85°C (Surface)
Humidity 8 - 90%RH (With no condensation)
Maximum wet bulb
temperature
29°C (With no condensation)
Temperature change
gradient
20°C/h or less
(With no condensation from temperature gradient)
Altitude Above the sea -300 - 3000m
Swept sine vibration 1.0G or less (5 - 500Hz)
Operating
Conditions
Shock 325G or less (2ms)
Temperature -40 - 85°C
Humidity 5 - 95%RH (With no condensation)
Maximum wet bulb
temperature
40°C (With no condensation)
Temperature change
gradient
20°C/h or less
(With no condensation from temperature gradient)
Altitude Above the sea -300 - 12000m
Swept sine vibration 5.0G or less (5 - 500Hz)
Non operating
Conditions
Shock 900G or less (1ms) / 120G or less (11ms)
Weight 96g (Max.)
*1 Maximum power consumption at motor startup
Drive Characteristics
Logical block address (Default value)
Head Sector Cylinder
Formatted capacity
/Block (byte)
Number of user
sectors
Total recording capacity
(byte)
PC-HDD40S 16 63 16,383 512 78,140,160 40,000,000,000

PC-HDD40S User’s Guide
Copyright 2009 CONTEC CO., LTD. ALL RIGHTS RESERVED.
CONTEC CO., LTD.
3-9-31, Himesato, Nishiyodogawa-ku, Osaka 555-0025, Japan
Japanese http://www.contec.co.jp/
English http://www.contec.com/ NA00373 (LYKX461)
Chinese http://www.contec.com.cn/ [10012009]
No part of this document may be copied or reproduced in any form by any means without prior written
consent of CONTEC CO., LTD.
Physical Dimensions