Cooke & Lewis CLGH60ALL User manual

3663602494379
CLGH60ALL
V10721 BX220IM
211827_s1_s6-3663602494379-C&L-A5-SM-Safety-V04-Multi.indd 1211827_s1_s6-3663602494379-C&L-A5-SM-Safety-V04-Multi.indd 1 16-07-2021 16:13:4716-07-2021 16:13:47

Safety 02
EN Before you start
• To avoid the risks that are
always present when you use
a gas appliance it is important
that this appliance is installed
correctly and that you read
the safety instructions
carefully to avoid misuse and
hazards.
• Please keep this instruction
booklet for future reference
and pass it on to any future
owners. After unpacking the
appliance please check that
it is not damaged. If in doubt,
do not use the appliance but
contact Customer Services
on 0800 324 7818 (UK) and
1800 932 230 (Eire).
• Check the package and make
sure you have all of the parts
listed.
• Decide on the appropriate
location for your product.
• The specifications plate is
available on this appliance.
This plate displays all the
necessary identification
information for ordering
replacement parts. If you
sell the appliance, give it
away leave it behind when
you move house, make sure
you also pass on this manual
so that the new owner can
become familiar with the
appliance and its safety
warnings.
Safety
These instructions are for your
safety. Please read through
them thoroughly prior to
installation and retain them for
future reference.
WARNING: The connection
of the hob to the gas network
or gas cylinder must be
made by means of a rigid
copper or steel pipe with
fittings complying with local
regulations supplied.
THIS OPERATION MUST BE
MADE BY A QUALIFIED GAS
INSTALLER.
• This appliance complies
with all current European
safety legislation, however
the Manufacturer must
emphasise that this
compliance does not prevent
the surfaces of the appliance
from heating up during use
and remaining hot during its
operation.
211827_s1_s6-3663602494379-C&L-A5-SM-Safety-V04-Multi.indd 2211827_s1_s6-3663602494379-C&L-A5-SM-Safety-V04-Multi.indd 2 16-07-2021 16:13:4716-07-2021 16:13:47

Safety 03
• Accessible parts may become
hot during use. Young children
should be kept away.
• Care should be taken to avoid
touching the appliance when
it is hot.
• The Manufacturer highly
recommends that this
appliance be kept out of the
reach of babies and small
children.
• This appliance can be used
by children aged from 8 years
and above and persons with
reduced physical, sensory
or mental capabilities or
lack of experience and
knowledge if they have
been given supervision or
instruction concerning use
of the appliance in a safe way
and understand the hazards
involved.
• Children shall not play with
the appliance.
• Cleaning and user
maintenance shall not be
made by children unless they
are older than 8 years and
supervised.
• Keep the appliance and its
cord out of reach of children
less than 8 years.
• Means for isolating
the appliance must be
incorporated in the fixed
wiring in accordance with the
current wiring regulations.
An omnipolar circuit breaker
having a contact separation
of at least 3 mm in all poles
should be connected in the
fixed wiring.
• If the supply cord is damaged,
it must be replaced by the
manufacturer, its service
agent or similarly qualified
persons in order to avoid
ahazard.
• Make sure that the power
cord is not caught under or
in the appliance and avoid
damage to the power cable.
• Do not allow the electric
cables to touch the hot parts
of the appliance.
• Do not install the appliance
outdoors, in any damp place
or in an area which may be
prone to water leaks such as
under or near a sink unit. In
the event of a water leak allow
the machine to dry naturally.
• Please dispose of the packing
material carefully.
211827_s1_s6-3663602494379-C&L-A5-SM-Safety-V04-Multi.indd 3211827_s1_s6-3663602494379-C&L-A5-SM-Safety-V04-Multi.indd 3 16-07-2021 16:13:4716-07-2021 16:13:47

Safety 04
• Do not use flammable
sprays in close vicinity to the
appliance.
• We also recommend that
great care be taken during
use and cleaning. Read the
cleaning and maintenance
sections for this appliance
carefully.
• A steam cleaner is not to be
used.
• The appliance is not intended
to be operated by means of
external timer or separated
remote-control system.
• The appliance is for domestic
use only.
• When a cooking zone has
been on for a long time, the
surface remains hot for some
time afterwards so do not
touch the metal surface.
• Do not store detergents or
flammable materials beneath
the hob.
• Do not leave hot oils or fats
unattended as they may catch
light.
• The Manufacturer declines
all liability for personal or
material damage as a result
of misuse or incorrect
installation of this appliance.
WARNING! Unattended
cooking on a hob with fat or
oil can be dangerous and may
result in fire.
• Never try to extinguish a
fire with water, but switch
off the appliance and then
cover the flame with a lid or
afireblanket.
WARNING! Risk of fire!
Do not store items on
thecookingsurfaces.
• Prior to installation, ensure
that the local distribution
conditions (nature of the gas
and gas pressure) and the
adjustment of the appliance
are compatible.
• The adjustment conditions for
this appliance are stated on
the label (or data plate).
• This appliance is not
connected to a combustion
products evacuation device.
• It shall be installed and
connected in accordance
with current installation
regulations. Particular
attention shall be given to
the relevant requirements
regarding ventilation.
211827_s1_s6-3663602494379-C&L-A5-SM-Safety-V04-Multi.indd 4211827_s1_s6-3663602494379-C&L-A5-SM-Safety-V04-Multi.indd 4 16-07-2021 16:13:4716-07-2021 16:13:47

Safety 05
CAUTION: This appliance
is for cooking purposes
only. Itmust not be used for
other purposes, for example
roomheating.
• Don’t put cooking vessels on
the hotplate that overlap its
edges.
CAUTION: The use of a gas
cooking appliance results
in the production of heat,
moisture and products of
combustion in the room in
which it is installed.
• Ensure that the kitchen is
well ventilated especially
when the appliance is in
use: keep natural ventilation
holes open or install a
mechanical ventilation device
(mechanicalextractor hood).
• Always use flat-bottomed
cookware during cooking.
• Never use cookware with
a diameter larger then the
diameter of the cooking zone.
• This appliance shall be
installed in accordance with
the regulations in force and
only used in a well ventilated
space.
• Read the instructions before
installing or using this
appliance.
CAUTION: The use of a hob
guard is not permitted with
this appliance. Do not attempt
to fit or use a hob guard as
this can cause accidents.
• The minimum distance
between this separation
and the underneath of the
worktop shall be stated
and this minimum distance
declared shall not exceed
150mm.
CAUTION:
This hob has a glass cooking
surface. In the event of any
breakage to the glass:
• Stop use of the appliance
immediately.
• Switch off all gas burners.
• Turn off the gas hob at the
mains power supply.
• Do not touch the glass
surface.
211827_s1_s6-3663602494379-C&L-A5-SM-Safety-V04-Multi.indd 5211827_s1_s6-3663602494379-C&L-A5-SM-Safety-V04-Multi.indd 5 16-07-2021 16:13:4716-07-2021 16:13:47

Safety 06
Gas connection
WARNING: The connection
of the hob to the gas network
or gas cylinder must be
made by means of a rigid
copper or steel pipe with
fittings complying with local
regulations. These fittings are
NOT supplied.
THIS OPERATION MUST
BE MADE BY A QUALIFIED
GASINSTALLER.
•A connecting elbow is
pre-fitted to the hob.
This elbow terminates
in an external 1/2” BSP
connecting thread complying
with ISO 228-1:2003. The
connection made to the pre-
fitted elbow MUST be suitable
for connecting to this thread. If
ANY other connection type or
thread size is used a suitable
adaptor MUST be fitted.
•The qualified gas installer must
ensure that the operation
of the burners has been
correctly verified before use.
CAUTION: The gas connection
must be installed in compliance
with applicable regulations in
the country of installation.
Gas supply requirements
• The appliance installation
must be carried out in
accordance with relevant
local regulations.
• The installation must be
carried out by an authorised
gas appliance installer and
tested to local regulations.
• We are not legally able to
offer advice on the installation
of gas appliances to un-
authorised personnel.
Ventilation
• This appliance must not be
connected to a combustion
products evacuation device.
It shall be connected and
installed in accordance with
local installation regulations
paying particular attention
to the relevant requirements
regarding ventilation.
211827_s1_s6-3663602494379-C&L-A5-SM-Safety-V04-Multi.indd 6211827_s1_s6-3663602494379-C&L-A5-SM-Safety-V04-Multi.indd 6 16-07-2021 16:13:4716-07-2021 16:13:47

Safety 07
What to do if you smell gas?
CAUTION:
• Do not try to light any appliance.
• Do not touch any electrical switch.
• Do not use phones in the building.
• Immediately call your gas supplier from a different property.
WARNING: Read the instructions before using theappliance.
THIS APPLIANCE MUST BEEARTHED.
THIS HOB MUST BE INSTALLED BY A QUALIFIED GAS
TECHNICIAN!
Electrical connection
All installation must be carried out by a qualified electrician.
Before connecting the mains supply ensure that the mains
voltage corresponds to the voltage on the rating plate.
Direct Connection
The appliance must be connected directly to the mains using
an omnipolar circuit breaker with a minimum opening of 3mm
between the contacts.
The installer must ensure that the correct electrical connection
has been made and that it complies with the wiring diagram.
The cable must not be bent or compressed.
Regularly check the power cord for damage. If the supply cord
is damaged, it must be replaced by the manufacturer, its service
agent or similarly qualified persons in order to avoid a safety hazard.
WARNING: This is a Class I appliance and MUST be earthed.
211827_s1_s6-3663602494379-C&L-A5-SM-Safety-V04-Multi.indd 7211827_s1_s6-3663602494379-C&L-A5-SM-Safety-V04-Multi.indd 7 16-07-2021 16:13:4716-07-2021 16:13:47

Safety 08
• This appliance is supplied with a 3 core mains cable coloured as
follows:
Brown = L or Live
Blue = N or Neutral
Green and Yellow = E or Earth
This appliance should be connected directly to the consumer
unit with a 3 Amp Residual Current Device (RCD) protecting its
circuit.
To avoid the risks that are always present when you use an
electrical appliance it is important that this appliance is installed
correctly and that you read the safety instructions carefully to
avoid misuse and hazards. Please keep this instruction booklet
for future reference and pass it on to any future owners. After
unpacking the appliance please check that it is not damaged. If in
doubt, do not use the appliance but contact Customer Services.
The manufacturer declines all liability for damage caused to
persons and objects due to incorrect or improper installation of
the appliance. Any permanent electrical installation must comply
with the latest wiring regulations applicable to your country and
for your own safety a qualified electrician or contractor must
undertake the electrical installation.
Technical data
Supply voltage: 220-240 V~ 50 Hz
Total heat input (Natural gas): 7.5 kW
Total heat input (LPG): 7.5 kW (545 g/h)
Electric power 1.3W
External dimensions (W x H x D): 590 x 101 x 510 mm
Net Weight: 10.6 kg
211827_s1_s6-3663602494379-C&L-A5-SM-Safety-V04-Multi.indd 8211827_s1_s6-3663602494379-C&L-A5-SM-Safety-V04-Multi.indd 8 16-07-2021 16:13:4716-07-2021 16:13:47

Safety 09
Injector Table
Type of gas used Type of
burner Injector marking Rated thermal
flow
rate kW
Rated
consumption Reduced heat
capacity
kW
Gas
pressure
rating
(mbar)
NATURAL GAS
(Methane)
G20
Auxiliary 0.74mm 1 95lt/h 0.28
20
Semi-Rapid 0.98mm 1.75 167lt/h 0.49
Wok 1.24mm 3 286lt/h 0.75
NATURAL GAS
(Methane/
Nitrogen)
G25
Auxiliary 0.74mm 1 110It/h 0.28
25
Semi-Rapid 0.98mm 1.75 194It/h 0.49
Wok 1.24mm 3 332It/h 0.75
LIQUIFIED
PETROLEUM GAS
(Butane)
G30
Auxiliary 0.51mm 1 73g/h 0.28
28-30Semi-Rapid 0.69mm
1.75
127g/h 0.49
Wok 0.88mm 3 218g/h 0.75
LIQUIFIED
PETROLEUM GAS
(Butane)
G30
Auxiliary
37Semi-Rapid
Wok
LIQUIFIED
PETROLEUM GAS
(Propane)
G31
Auxiliary 0.51mm 171g/h 0.28
37Semi-Rapid 0.69mm 1.75 125g/h 0.49
Wok 0.88mm 3214g/h 0.75
NATURAL GAS
(Methane/
Nitrogen)
G2.350
Auxiliary
13Semi-Rapid
Wok
211827_s1_s6-3663602494379-C&L-A5-SM-Safety-V04-Multi.indd 9211827_s1_s6-3663602494379-C&L-A5-SM-Safety-V04-Multi.indd 9 16-07-2021 16:13:4716-07-2021 16:13:47
0.50 mm
0.63 mm
0.84 mm
1.0 mm
1.30 mm
1.70 mm
1
232 lt/h
397 lt/h
1.75
3
3
1.75
1132 lt/h 0.28
0.49
0.75
73g/h
127g/h
218g/h
0.28
0.49
0.75
Gas Category
GB & IE: II2H3+ (G20 20 mbar, G30 28-30 mbar, G31 37 mbar)
FR: II2E+3+ (G20 20 mbar, G25 25 mbar, G30 28-30 mbar, G31 37 mbar)
ES & PT: II2H3+ (G20 20 mbar, G30 28-30 mbar, G31 37 mbar)
RO: II2H3B/P (G20 20 mbar, G30 30 mbar, G31 30 mbar)
PL: II2ELS3B/P (G20 20 mbar, G2.350 13 mbar, G30 37 mbar, G31 37 mbar)

Safety 10
Burner Minimum Pan Diameter (cm) Maximum Pan Diameter (cm)
Auxiliary ≥ 10 ≤ 14
Semi-rapid ≥ 16 ≤ 20
Triple Ring ≥ 24 ≤ 28
Energy efficiency
Product information according to EU 66/2014
Model Identification CLGH60ALL
Type of hob Built-in hob
Number of gas burners 4
Energy efficiency per gas
burner (EE gas burner)
Auxiliary Not Applicable
Triple Ring 56.0%
Semi-Rapid 57.5% x 2
Energy efficiency for the gas hob
(EE gas burner) 57.0%
EN 30-2-1: Domestic cooking appliances burning gas - Part 2-1: Rational use of energy - General
211827_s1_s6-3663602494379-C&L-A5-SM-Safety-V04-Multi.indd 10211827_s1_s6-3663602494379-C&L-A5-SM-Safety-V04-Multi.indd 10 16-07-2021 16:13:4816-07-2021 16:13:48