Core 40147 User manual

1Extend Shelter Frame
CAUTION: Avoid pinch points
when opening or closing
the shelter frame.
• Expand and spread out
SHELTER FRAME
halfway.
4Telescoping Steel Frame Legs
6
Secure Shelter
∙ Locate FOOT at the bottom of
each SHELTER LEG POLE (4 total).
• Slide STAKE through HOLE at each location (fig. 6).
• Locate GUYLINES attached to the shelter and unroll.
• Slide STAKE through loop at each location, extend out and drive in to secure (fig 7).
NOTE: Extend four corner GUYLINES out at a 45º angle from shelter.
• Adjust GUYLINES as needed by adjusting the SLIDER up the cord.
Model #40147
Carry Bag (91742)
Canopy Top (91741)
Stakes (90014)
x 8
Contents & Repair Parts
8x8 Instant Canopy
8ft x 8ft x 107in
2 People Rubber Mallet Level Area
We Recommend...
(continued on back)
Need some help?
1-888-775-5628
coreequipment.com
Attach Canopy
∙ Unfold CANOPY TOP then drape over SHELTER FRAME with corners
positioned over SHELTER LEGS.
∙ Locate HOOK & LOOP FASTENER on underside of the corner
of the CANOPY TOP; then attach to material located at the top of the
STEEL SHELTER LEG (fig. 1).
• Repeat for remaining 3 corners of the CANOPY TOP.
Raising Roof Support Brackets
∙ To finish expanding the frame, grasp the LEG POLE and push up
on the ROOF SUPPORT BRACKET until the GREEN BUTTON “clicks”
into locked position (fig. 2).
• Repeat for remaining 3 ROOF SUPPORT BRACKETS to fully raise
the ROOF PEAK.
3
2
∙Place foot on the LEG FOOT; then grasp and extend TELESCOPING
LEG POLE until the METAL PUSH PIN “clicks” into locked position (fig. 3).
• Repeat for remaining 3 LEG POLES.
NOTE: When telescoping the legs, the
METAL PUSH PIN will lock in the lowest
setting first. Push in the METAL
PUSH PIN and extend the leg
further to desired shelter
height (fig. 4).
5
Secure Canopy to Frame
∙ Locate HOOK & LOOP FASTENERS along the
seam of the underside of the CANOPY TOP; then
wrap around METAL BRACKET to secure (fig. 5).
• Repeat for remaining 3 sides of the shelter
CANOPY TOP.
• Position the shelter in its
final position before
securing with
stakes and
guylines.
fig. 1
fig. 5
fig. 6
fig. 1
fig. 2
fig. 7
Apex Support Pole
(91739)
Lower
Roof Pole
(91737)
Upper Roof Pole
(91736)
Center Hub
(91738)
Gazebo
Leg
(91740)
Scissor Pole
A (91734)
B (91735)
fig. 3
fig. 4
3-Stage Height
Adjustability
LOW
HIGH
MEDIUM METAL
PUSH
PIN

Elevate LLC
Overland Park, KS 66223
Made in China
Take Down Instructions:
WARNING: KEEP ALL FLAME AND HEAT SOURCES AWAY FROM THIS
SHELTER FABRIC
This shelter is made of flame-resistant fabric which meets CPAI-84
specifications. IT IS NOT FIREPROOF. The fabric will burn if left in
continuous contact with any flame source. The application of any foreign
substance to the product fabric may render the flame-resistant
properties ineffective.
DO NOT use fuel burning devices inside or near shelter materials.
DO NOT permit children to light matches, operate burning appliances or
handle any flame sources in or near the shelter.
• Do not smoke, use matches, candles or open flames of any kind in or
near the shelter.
• Do not refuel lanterns, stoves or heaters inside shelter.
• Do not cook inside shelter.
• Do not store flammable liquids inside shelter.
WARNING: Keep clear of overhead power lines.
• Do not set up your shelter under trees because of potential
lightning strikes or falling tree limbs in inclement weather.
• Secure with all stakes and guylines provided to prevent property
damage or personal injury.
• Never store shelter, even for a short period of time, without drying it
thoroughly and brushing off caked dirt. Do not pack stakes inside your
shelter. Use a separate storage bag.
• STAKES SHOULD BE REMOVED BY PULLING ON THE STAKE
ITSELF. NEVER PULL ON THE SHELTER TO REMOVE STAKE.
• Do not leave your shelter set up for weeks at a time. Be aware that
exposure to ultraviolet rays from the sun can seriously damage
material and/or cause it to become discolored.
IMPORTANT:
THE ORIGINAL FIRE RETARDANT AND WATER-REPELLENT PROTECTIVE
COATINGS MAY BE COMPROMISED IF SPRAYS OR OTHER CHEMICAL
TREATMENTS ARE USED ON THE SHELTER. THE CANOPY FABRIC HAS BEEN
FACTORY TREATED. IT IS HIGHLY WATER-REPELLENT; HOWEVER, IT IS
NOT WATERPROOF. ALL SHELTERS CAN EXPERIENCE SEAM LEAKAGE
DURING WET WEATHER. IF YOU WANT ADDITIONAL MOISTURE
PROTECTION, TRY A SEAM SEALING COMPOUND ONLY; STRICTLY
FOLLOW THE MANUFACTURER’S DIRECTIONS. IT IS RECOMMENDED
THAT YOU SEAL THE SHELTER DURING THE INITIAL SETUP AS WELL AS
PRIOR TO EACH CAMPING SEASON. SEAM SEALER COMPOUNDS CAN BE
PURCHASED AT YOUR LOCAL CAMPING PRODUCTS OUTLET. FOR
MISSING PARTS CALL 1-888-775-5628.
PLEASE DO NOT RETURN THIS PRODUCT TO THE RETAIL STORE.
DO NOT SPRAY!
Warnings and Cautions:
• Are replacement parts available? Yes, please call Customer Service
at 1-888-775-5628 for replacement parts. All parts can be replaced.
• Why are my shelter legs not locking into place? Be sure that the
metal push pins are secure. Extend pole further if it is not locked.
It will “click” into place.
• How do I clean my canopy top? Clean the canopy top with a soft
sponge, a mild soap and tepid water. Be sure to scrub gently and
remove all soap. Let dry in sunlight, which also naturally cleans the
canopy.
• Why is it difficult to extend the roof assembly on my frame?
Be sure to stretch the frame out fully, and lock the roof assembly into
place before raising the shelter legs.
• When should I attach the canopy fabric? Attach the canopy fabric
after the frame is expanded, before extending the roof assembly or
shelter legs.
Frequently Asked Questions:
CORE®Equipment and Elevate LLC warrants for a period of one year
from the original date of purchase this product against any defects in
materials or workmanship. At its discretion, CORE®Equipment may
provide replacement parts to original purchaser. Original
receipt or proof of purchase as well as proof of defect in the form of a
photograph or video is required. CORE®Equipment will not be
responsible for shipping costs incurred outside the continental USA.
Warranty is valid for the original purchaser one year from the date of
purchase and is not transferable. This warranty does not cover any
product purchased through unauthorized dealers/distributors and/or
unauthorized resellers on online auction websites. CORE®uses
approved and authorized distributors to furnish quality products, and
CORE®provides warranty coverage only on products purchased from
those distributors. If the product was purchased from an unauthorized
reseller, this warranty does not apply. Unauthorized resellers may sell
products that are used, defective, counterfeit, or which may not be
designed for use in that specific country. To determine whether the
seller of a CORE®Equipment product is one that has been approved
and authorized by Elevate LLC owner of the CORE®Equipment brand,
please contact [email protected] or call customer service at
1-888-775-5628.
This 1-Year Limited Warranty does NOT cover normal wear and tear,
abuse or misuse of this product including damage from inclement
conditions, such as wind, rain or hail. In case of inclement weather,
remove all valuables and persons and seek appropriate shelter. Under
no circumstances will CORE®Equipment or Elevate LLC be liable or
responsible for any incidental or consequential damages.
This product is designed and intended for recreational use only.
Prolonged exposure to UV rays will cause any fabric to fade and
deteriorate and is NOT covered by this 1-Year Limited Warranty. All
replacement products or parts will assume the remaining warranty of
the original product. This warranty gives you specific legal rights. You
may also have other rights which vary from state to state. To obtain
Warranty Service: Call Toll Free 1-888-775-5628 for warranty service,
repair parts or product questions. Monday - Friday, 8:00 a.m. - 5:00 p.m.
Central Time.
1-Year Limited Warranty:
Revised 1/15/20
Follow the previous steps and illustrations on other side of this tag in the
reverse order:
• Remove stakes and place in their storage bag
• Disconnect CANOPY TOP and SUN WALL from the LEG POLES
• Push the PUSH PINS and telescope down the 4 LEG POLES
• Push the 4 GREEN BUTTONS to release the ROOF SUPPORT BRACKET
• Fold CANOPY TOP and place into carry bag.
• Fold up SHELTER FRAME and place into carry bag.
Storing the Shelter
• Store in a clean, dry area.
• All stakes must be placed in their own storage bag before placing
in carrying case to prevent damage to the shelter fabric
• For short term storage (1-2 weeks), it is acceptable to leave the
CANOPY TOP attached to the STEEL SHELTER FRAME.
• NOTE: For long term storage, remove the CANOPY TOP & store
separately.