CRL LD188 User manual

Keep this manual in a safe and dry place for future reference.
You will need this manual to read the safety instructions, operating and
maintenance procedures, and parts diagram.
Safety Warning and recautions.
Warning: When using this tool, basic safety precautions should always be
followed to reduce the risk of personal injury and damage to the equipment.
Visit us at for international toll free information 1
AVDB3039_03/12
AC.R. LAURENCE Co., INC.
Cordless Caulking Gun

CAT. NO. LD188

NOTE: Thewarningsandinstructionscontainedinthismanualcannotcoverallpossible
conditionsandsituationsthatmayoccurwhenusingthisproduct.Itmustbeunderstood
thatcommonsenseandcautionarefactorswhichcannotbeignoredbytheperson
operatingthetool.
Visit us at for international toll free information 2
A
SAFETY INSTRUCTIONS
Read these Operating Instructions carefully before use!
1. Keep work area clean.
2. Do not use machines or power tools in damp or wet locations. Donotexposetorain.
3. Work in a well lighted area. Donotusetoolsinthepresenceofflammablegasesorliquids.
4. Keep children away from work area. Childrenmustneverbeallowedintheworkarea.Donot
letthemhandlemachines,tools,orextensioncords.
5. Storing equipment. Whennotinuse,toolsmustbestoredinadrylocationtominimizerusting.
Alwayslockuptoolsandkeepoutofthereachofchildren.
6. Do not force the tool. Powertoolsperformbetterattherateofwhichtheyareintended.Donot
useinappropriateattachmentsinanattempttoexceedthetoolcapacity.Usewithlightweightlow
viscositysealantsonly.
7. Use the right tool for the ob. Donotattempttoforceasmalltoolorattachmenttodothework
ofalargerindustrialtool.Donotusetoolforanypurposesforwhichitwasnotintended.
8. Dress properly. Donotwearlooseclothingorjewelry.Theycanbecaughtinmovingparts.
Protective,electricallynon-conductiveclothesandnon-skidfootweararerecommendedwhen
working.Wearrestrictivehaircoveringtocontainlonghair.
9. Use eye and ear protection.
10. Disconnect power. Removebatterywhennotinuse.
11. Stay alert. Watchwhatyouaredoing,usecommonsense.Donotoperateanytoolwhen
youaretired.
12. Replacement parts and accessories. Onlyuseaccessoriesintendedforusewiththistool.
• Battery: 12V DC, 1300mAH Ni-cd
• Speed: 5/8"-6-1/4"/min (15-160mm/m)
• Thrust: 110lbs. (50kg)
• 3-5 Hours Charge Time
S ECIFICATIONS

Visit us at for international toll free information 3
A
SAFETY INSTRUCTIONS
Unpacking
Whenunpacking,checkthepartsdiagramandpartsnumberlistingtomakesurethatallparts
areincluded.Ifanypartofthetoolismissingorbroken,pleasecontactCRLCustomerServicefor
instructions.
1.TheBatteryPackrequirescharging.Thefirstchargerequires5hourschargingtimepriortousing
theCaulkingGun.
2.WhentheBatteryPackrequiresre-charging,3to5hourschargeallowsthetooltooperateatfull
power.Donotre-chargetheBatteryPacklongerthan5hours,asdamagetotheBatteryPack
and/orChargerwilloccur.
3.InserttheBatteryPackintothechargingsocketoftheCharger.Then,plugtheChargerintothe
nearestgroundedelectricaloutlet.
4.BoththegreenlightandredlightontheChargerwillautomaticallyturnon,indicatingtheCharger
hasswitchedtothechargemode.
5.TheBatteryPackwillbefullychargedinapproximately5hours.Boththegreenandredlights
willstillbeon.RemovetheBatteryPackfromtheCharger,anddisconnecttheChargerfromits
electricaloutlet.
NOTE: ThetemperatureoftheBatteryPackmayincreaseduringuseandshortlyafteruse.
TheBatteryPackmaynotacceptafullchargeifitischargedimmediatelyafteruse.Allowthe
BatteryPacktocooltoroomtemperaturebeforechargingforbestresults.
Battery Safety Warnings and Precautions
1. ReadallinstructionsandwarningsontheBatteryPackbeforecharging.
2. Toavoidaccidents,chargethesuppliedBatteryPackonly.DonotuseadifferentCharger
withthisbattery.
3. DonotexposetheBatteryPacktorainorwetconditions.
4. Toavoiddamageofcableandplug,neverpullonthecabletodisconnecttheCharger.
5. DonotusetheChargerifthecableorplugaredamaged.
6. Repairsshouldonlybecarriedoutbyexperts.
7. Donottouchthebatterypoleswithanyconductivesource.
8. DonotstoretheBatteryPackinaboxwithothermetalobjects.
9. DonotthrowtheBatteryPackinafire.Disposeoforrecycleproperly.

Visit us at for international toll free information 4
A
SAFETY INSTRUCTIONS
Operation
Toinstallatubeofsealantfollowthestepsshownbelow:
1.RemovetheBatteryPackfromthegunhousing.
2.Depresstheplungerreleaseswitchandpullbackon
theplungeruntilitstopsattheTubeHolderCap(#30).
3.UnscrewtheTubeHolderCover(#31).
4.PutthenewsealanttubeintotheAluminumTubeHolder(#32).
5.Cuttipofcartridgenozzletodesiredwidth.
6.TightlyscrewontheTubeHolderCover(#31).
7.PutthebatteryintotheGunHousing(#2).
8.ToactivatethegundepresstheTriggerSwitch(#4).
9.Tostoptheflowofsealant,releasethetrigger.Flowwillslowoncetriggerisreleased.
TocompletelystoptheflowslightlyloosentheTubeHolderCover(#31).Ifdesired,
pushPlungerReleaseSwitch(#33)forwardandretractPlunger(#28).
10.Whenfinishedusingthegun,alwaysfullychargetheBatteryPackbeforethenextuse.
11. AlwaysremovetheBatteryPackbeforemakinganyadjustmentstothegun.
CHARGERBATTERY PACK
Figure A
Red
Light Green
Light

Visit us at for international toll free information 5
A
SAFETY INSTRUCTIONS
ARTS DIAGRAM CHART
ITEM NO. DESCRIPTION QTY.
1 HousingA 1
2 HousingB 1
3 InsertedSheet 1
4 Switch 1
5 PCBboard 1
6 SpeedGear 1
7 HeatSink 1
8 otor 1
9 otorGear 1
10 TappingScrew 2
11 CoverGear 1
12 Spring 1
13 Washer 1
14 Spacer 1
15 CoverPlate 1
16 CoverGear 1
17 Nut 1
18 PositionJoint 1
19 Washer 1
20 Bushing 1
21 CopperSleeve 1
22 SpringBracing 1
ITEM NO. DESCRIPTION QTY.
23 LongSpring 1
24 DrivingPlate 1
25 ShortSpring 1
26 Stop-DrivingPlate 1
27 HexShaft 1
28 Puller 1
29 TappingScrew 2
30 TubeHolderCap 1
31 TubeHolderCover 1
32 AluminumTubeHolder 1
33 ovingLock 1
34 TappingScrew 5
35 BatteryHousingPlate 1
36 Battery 1
37 BatteryHousing 1
38 BatteryButton 2
39 SteelSheet 2
LD188C 110VoltCharger
LD188C240VEU 220VoltCharger
LD188C240VAU 240VoltCharger
Maintenance
1. Whenfinishedusingthegun,alwaysremovetheTubeHolder(#31)andtheTubeHolderCap(#30).
2. RegularlyinspectscrewsandTubeHolderCaptoassurethattheyareproperlytightened.
3. KeeptheTubeHolder(#31)andPistonJoint(#18)cleanandinproperworkingorder.
4. AlwaysreleasetheForwardingShaft(#27)backtothecorrectpositionafteruse.
5. Keepmotorairventscleanofdustanddebris;vacuumperiodically.
6. Ifthetoolisnotoperatingnormally,makingunusualnoises,orappearsdefective,
stopusingitimmediatelyandhaveitrepairedbyaqualifiedtechnician.
7. Cleantoolwithadampclothandlightdetergent.Donotusesolventsas
theycandamageandcracktheplasticparts.

Visit us at for international toll free information 6
A
ARTS DIAGRAM