Cuisinart CCG-216 User manual

Cuisinart grills Grilling tools and
accessories Cast iron outdoor cookware Gadgets and thermometers
Cuisinart® is a registered
trademark under license to
the Fulham Group
Distributed by The Fulham
Group, Newton, MA. U.S.A.
MADE IN CHINA
1 Year Limited Warranty
Operating Your Grill
Select a Proper Location
Once you have assembled your new grill, nd a
suitable location for use.
mDANGER
• Never use this outdoor grill inside any building,
garage, shed or breezeway, under an over-
hang or inside any boat, trailer or recreational
vehicle, to prevent possible re and to prevent
the possibility of carbon monoxide poisoning
or asphyxiation.
• Always place your grill on a hard and level sur-
face far away from combustible materials and
structures.
• Do not use this grill under overhead combus-
tible surface or covered are (e.g., awnings, um-
brellas, porches or gazebos). Keep all combus-
tible surfaces at least 10 feet (3 meters) away.
• Locate the grill away from any combustible and
non-combustible material or construction by at
least 10 feet (3m).
• Never store or use gasoline or other ammable
or volatile substances in the vicinity of this grill
or in the vicinity of any other heat-generating
appliance, because of the danger of starting
a re.
• Do not obstruct the ow of combustion and
ventilation air.
mDANGER
• Do not use gasoline, kerosene or alcohol for
lighting. Use only charcoal lighter uid. Follow
manufacturer’s instructions.
• Do not add charcoal lighter uid or charcoal
impregnated with charcoal lighter uid to hot or
warm charcoal.
• Do not overll charcoal tray. Excess charcoal
may cause a re, or may cause damage to
your grill.
mDANGER
• Never use water to extinguish charcoal.
• Do not remove ashes until all charcoal is com-
pletely burned out or completely extinguished.
AIR VENT OPERATION
Your grill has two airow control vents; an inlet
vent on the bottom of the rebox above the ash
collection tray, and an air exhaust vent at the top
of the lid. By adjusting the amount of vent open-
ing, you can adjust the temperature of your grill.
mDANGER
• The vents and vent controls and the metal
surfaces around them will become very hot
during grill use. Use grill mitts or hot pads to
adjust vents when grill is in use.
See our full line of premium CuisinartTM Outdoor Cooking Products at www.cuisinart.com

16” Portable Charcoal Grill
MODEL NO: CCG-216
ASSEMBLY AND OPERATING INSTRUCTIONS
mDANGER
Do not store or use gasoline, alcohol or
other ammable liquids to light charcoal.
Use only charcoal lighter uid following the
manufacturer’s instructions
mDANGER
Failure to follow these instructions could
result in re, explosion or burn hazard,
which could cause property damage,
personal injury or death.
mDANGER – CARBON MONOXIDE HAZARD
Do Not Use Indoors! Burning charcoal releases carbon monoxide gas. If used indoors or in a
poorly ventilated area, the gas can accumulate and cause serious injury or death.
m DANGER
1. Never operate this grill unattended.
2. Never operate this grill within 10 feet (3.05m) of any ammable material
3. Never operate this grill with 25 feet (7.5m) of any ammable liquid.
4. If a re should occur, keep away from the grill and immediately call your re
department . Do not attempt to extinguish an oil or grease re with water.
m DANGER
Failure to follow these instructions could result in re, explosion or burn hazard,
which could cause property damage, personal injury or death.
mWARNING: FOR OUTDOOR USE ONLY
m This instruction manual contains important information necessary for
the proper assembly and safe use of the appliance
m Read and follow all warnings and instructions before assembling and
using the appliance
m Follow all warnings and instructions when using the appliance
m Keep this manual for future reference
Note to installer: Leave this Owner’s Manual with the consumer after delivery and/or installation.
Note to customer: Leave this Owner’s Manual in a convenient place for future reference.

Exploded View & Hardware Parts
PRE-ASSEMBLY CHECK LIST
1. To assure fast and easy assembly, follow the instructions below in their proper sequence.
2. Check all parts carefully and compare them to the parts list.
3. Report any missing parts to the company from with you purchased the product.
STOP! if you experience any missing or broken parts or have any questions regarding assembly,
please call our Customer Service team at 1-866-994-6390.

ASSEMBLY STEPS
Step 1:
Put the legs (10) through hole of
ash tray (9) and attach to the
rebowl (6). Finger tighten to hold
them together one by one. Tighten
the screws using a screwdriver.
Do not twist leg too tighten.
Step 2:
1. Install the bottom air vent (8)
to re bowl (6).
Step 3:
1. Attach the lid handle (1) to the lid (3).
2. Attach the lid air vent (2) to the lid (3).
Step 4:
Place charcoal grid (5) onto rebowl (6).
Place cooking grid (4) on rebowl (6).