Daikin RZQ180MY1 User manual

SPLIT SYSTEM Air Conditioner
OPERATION MANUAL
RZQ180MY1
RZQ200MY1
00_CV_3P529409-2B.indd 1 30/10/2019 16:48:00

Thank you for purchasing this Daikin air
conditioner. Carefully read this operation
manual before using the air conditioner. It
will tell you how to use the unit properly
and help you if any trouble occurs. After
reading the manual, keep it in your custody
for future reference.
See also the operation manual included
with the indoor unit for details on the indoor
unit.
Store the operation manual included with
the indoor unit together with this operation
manual in a safe place.
After receiving the warranty card from the
dealer, store it in a safe place.
00_CV_3P529409-2B.indd 2 30/10/2019 16:48:00

1
Contents Page
1. Denitions ...................................................... 1
1.1 Meaningofwarningsandsymbols................ 1
1.2 Meaningofusedterms.................................. 1
1.3 Safetyprecautions......................................... 2
2. Introduction .................................................... 6
2.1 Systemlayout................................................ 6
3. Beforeoperation............................................. 6
4. Remotecontroller........................................... 6
5. Operationrange ............................................. 7
6. Operationprocedure ..................................... 7
6.1 Cooling,heating,fanonly,automatic
operationanddryoperation .......................... 7
6.2 Programdryoperation .................................. 8
7. Energysavingandoptimumoperation........... 9
8. Maintenance .................................................. 9
8.1 Maintenanceafteralongstopperiod
(e.g.,atthebeginningoftheseason)............ 9
8.2 Maintenancebeforealongstopperiod
(e.g.,attheendoftheseason) ................... 10
9. Symptomsthatarenotairconditioner
troubles ........................................................ 10
9.1 Thesystemdoesnotoperate...................... 10
9.2 Fanoperationispossible,butcooling/
heatingdonotwork..................................... 10
9.3 Whitemistcomesoutofaunit .................... 10
9.4 Theremotecontrollerdisplayshows
“U4”or“U5”andstops,butthenrestarts
afterafewminutes ...................................... 10
9.5 Noiseofairconditioners.............................. 10
9.6 Dustcomesoutoftheunit .......................... 11
9.7 Theunitscangiveoffodours ...................... 11
9.8 Theoutdoorunitfandoesnotoperate.
Butcompressorstillrunning........................ 11
9.9 Thecompressorintheoutdoorunit
doesnotstopafterashortheating
operation ..................................................... 11
9.10Theinsideofanoutdoorunitiswarm
evenwhentheunithasstopped.................. 11
9.11Doesnotcoolverywell ............................... 11
10.Troubleshooting............................................ 11
11.After-salesserviceandwarranty.................. 12
11.1Warrantyperiod........................................... 12
11.2After-salesservice....................................... 12
11.3Shorteningof“maintenancecycle”and
“replacementcycle”needstobe
consideredinfollowingsituations................ 13
11.4Malfunctioncodes ....................................... 14
1. Denitions
1.1 Meaning of warnings and symbols
Warningsinthismanualareclassiedaccording
totheirseverityandprobabilityofoccurrence.
DANGER
Indicatesanimminentlyhazardoussituation
which,ifnotavoided,willresultindeathor
seriousinjury.
WARNING
Indicatesapotentiallyhazardoussituation
which,ifnotavoided,couldresultindeath
orseriousinjury.
CAUTION
Indicatesapotentiallyhazardoussituation
which,ifnotavoided,mayresultinminoror
moderateinjury.Itmayalsobeusedtoalert
againstunsafepractices.
NOTICE
Indicatessituationsthatmayresultin
equipmentorproperty-damageaccidents
only.
INFORMATION
Thissymbolidentiesusefultipsor
additionalinformation.
Sometypesofdangerarerepresentedby
specialsymbols:
Electric current.
Danger of burning and scalding.
1.2 Meaning of used terms
Installation manual:
Instructionmanualspeciedforacertainproduct
orapplication,explaininghowtoinstall,congure
andmaintainit.
Operation manual:
Instructionmanualspeciedforacertainproduct
orapplication,explaininghowtooperateit.
Operation manual
01_EN_3P529409-2B.indd 1 15-Nov-19 3:02:26 PM

2
Maintenance instructions:
Instructionmanualspeciedforacertainproduct
orapplication,whichexplains(ifrelevant)howto
install,congure,operateand/ormaintainthe
productorapplication.
Dealer:
Salesdistributorforproductsasperthesubjectof
thismanual.
Installer:
Technicalskilledpersonwhoisqualiedtoinstall
productsasperthesubjectofthismanual.
User:
Personwhoisowneroftheproductand/or
operatestheproduct.
Service company:
Qualiedcompanywhichcanperformor
coordinatetherequiredservicetotheunit.
Applicable legislation:
Allinternational,European,nationalandlocal
directives,laws,regulationsand/orcodeswhich
arerelevantandapplicableforacertainproduct
ordomain.
Accessories:
Equipmentwhichisdeliveredwiththeunitand
whichneedstobeinstalledaccordingto
instructionsinthedocumentation.
Optional equipment:
Equipmentwhichcanoptionallybecombinedto
theproductsasperthesubjectofthismanual.
Field supply:
Equipmentwhichneedstobeinstalledaccording
toinstructionsinthismanual,butwhicharenot
suppliedbyDaikin.
1.3 Safety precautions
To gainfulladvantageoftheairconditioner’s
functionsandtoavoidmalfunctiondueto
mishandling,werecommendthatyoureadthis
instructionmanualcarefullybeforeuse.
Readtheprecautionsthoroughlytoavoidmisuse
oftheequipment.
Thisairconditionerisclassiedunder
“appliancesnotaccessibletothegeneralpublic”.
• Theprecautionsdescribedhereinareclassied
asWARNINGandCAUTION.Theybothcontain
importantinformationregardingsafety.
Besuretoobserveallprecautionswithoutfail.
• Therearetwokindsofsafetyprecautionand
tipslistedinthefollowing.
WARNING ..... •Failuretofollowthese
instructionsproperlymay
resultinpersonalinjuryor
lossoflife.
•Thisunitcontainselectrical
andhotparts.
•Beforeoperatingtheunit,
besuretheinstallationhas
beencarriedoutcorrectly
byaninstaller.Ifyoufeel
unsureaboutoperation,
contactyourinstallerfor
adviceandinformation.
CAUTION ...... •Failuretoobservethese
instructionsproperlymay
resultinpropertydamageor
personalinjury,whichmay
beseriousdependingonthe
circumstances.
• Afterreading,keepthismanualinaconvenient
placesothatyoucanrefertoitwhenever
necessary.Iftheequipmentistransferredtoa
newuser,besurealsotohandoverthemanual.
WARNING
• If you detect any abnormality such as smell
of re, turn off the power supply and call
your dealer for instructions.
• Do not place objects in direct proximity of
the outdoor unit and do not let leaves and
other debris accumulate around the unit.
Leavesareahotbedforsmallanimalswhich
canentertheunit.
Onceintheunit,suchanimalscancause
malfunctions,smokeorrewhenmaking
contactwithelectricalparts.
• Consult your local dealer about installation
work.
Doingtheworkyourselfmayresultinwater
leakage,electricshocksorrehazards.
• Do not insert ngers, rods or other objects
into the air inlet or outlet. When the fan is
rotating at high speed, it will cause injury.
• Never let the indoor unit or the remote
controller get wet.
Itmaycauseanelectricshockorare.
• Be sure to use fuses with the correct ampere
reading.
Donotuseimproperfuses,copperorother
wiresasasubstitute,asthismayresultin
electricshock,re,injuryordamagetotheunit.
01_EN_3P529409-2B.indd 2 15-Nov-19 3:02:27 PM

3
• Consult your local dealer regarding what to
do in case of refrigerant leakage.
Whentheairconditioneristobeinstalledina
smallroom,itisnecessarytotakeproper
measuressothattheamountofanyleaked
refrigerantdoesnotexceedtheconcentration
limitintheeventofleakage.Otherwise,thismay
leadtoanaccidentduetooxygendepletion.
• Beware of re in case of refrigerant leakage.
If the air conditioner is not operating
correctly, i.e. not generating cool or warm
air, refrigerant leakage could be the cause.
Consultyourdealerforassistance.The
refrigerantwithintheairconditionerissafeand
normallydoesnotleak.However,intheeventof
aleakage,contactwithanakedburner,heater
orcookermayresultingenerationofnoxious
gas.Donotlongeruseairconditioneruntila
qualiedservicepersonconrmsthatthe
leakagehasbeenrepaired.
• Do not use the air conditioner until a service
person conrms that the portion where the
refrigerant leaks is repaired.
• Turn off any combustible heating devices,
ventilate the room and contact the dealer
where you purchased the unit.
• Improper installation or attachment of
equipment or accessories could result in
electric shock, short circuit, leaks, re or
other damage to the equipment.
• Consult your local dealer regarding
modication, repair and maintenance of the
air conditioner.
Improperworkmanshipmayresultinwater
leakage,electricshocksorrehazards.
• Consult your local dealer regarding
relocation and reinstallation of the air
conditioner.
Improperinstallationworkmayresultinleakage,
electricshocksorrehazards.
• Do not place a ammable spray bottle near
the air conditioner and do not use sprays.
Doing so may result in a re.
• Before cleaning, be sure to stop the
operation, turn the breaker off or pull out the
supply cord.
Otherwise,anelectricshockandinjurymay
result.
• Do not operate the air conditioner with wet
hands.
Anelectricshockmayresult.
• Do not place appliances which produce
open re in places exposed to the air ow
from the unit or under the indoor unit. It may
cause incomplete combustion or
deformation of the unit due to the heat.
• Do not wash the air conditioner with water,
as this may result in electric shocks or re.
• Be sure to install an earth leakage breaker.
Failuretoinstallanearthleakagebreakermay
resultinelectricshocksorre.
Inordertoavoidelectricshockorre,make
surethatanearthleakdetectorisinstalled.
• Consult the dealer if the air conditioner
submerges owing to a natural disaster, such
as a ood or typhoon.
Donotoperatetheairconditionerinthatcase,
orotherwiseamalfunction,electricshock,orre
mayresult.
• Do not start or stop operating the air
conditioner with the power supply breaker
turned ON or OFF.
Otherwise,reorwaterleakagemayresult.
Furthermore,thefanwillrotateabruptlyifpower
failurecompensationisenabled,whichmay
resultininjury.
• Do not use the product in the atmosphere
contaminated with oil vapour, such as
cooking oil or machine oil vapour.
Oilvapourmaycausecrackdamage,electric
shocks,orre.
• Do not install the air conditioner at any place
where there is a danger of ammable gas
leakage.
Intheeventofagasleakage,build-upofgas
neartheairconditionermayresultinre
hazards.
• Contact professional personnel about
attachment of accessories and be sure to
use only accessories specied by the
manufacturer.
Ifadefectresultsfromyourownworkmanship,
itmayresultinwaterleaks,electricshockofre.
•
Do not use the product in places with
excessive oily smoke, such as cooking room,
or in places with ammable gas, corrosive
gas, or metal dust.
Usingtheproductinsuchplacesmaycausere
orproductfailures.
01_EN_3P529409-2B.indd 3 15-Nov-19 3:02:27 PM

4
• When the air conditioner is malfunctioning
(giving off a burning odour, etc.) turn off
power to the unit and contact your local
dealer.
Continuedoperationundersuchcircumstances
mayresultinafailure,electricshocksorre
hazards.
• Do not place ammable sprays or operate
spray containers near the unit as this may
result in re.
• Do not clean the product with organic
solvents such as paint thinner.
Theuseoforganicsolventsmaycausecrack
damagetotheproduct,electricshocks,orre.
• Be sure to use a dedicated power supply for
the air conditioner.
Theuseofanyotherpowersupplymaycause
heatgeneration,re,orproductfailures.
• Consult your dealer regarding cleaning the
inside of the air conditioner.
Impropercleaningmaycausebreakageof
plasticparts,waterleakageandotherdamage
aswellaselectricshocks.
• Be sure the air conditioner is electrically
earthed.
Inordertoavoidelectricshock,makesurethat
theunitisgroundedandthattheearthwireis
notconnectedtogasorwaterpipe,lightning
conductorortelephoneearthwire.
•
Do not place a ower vase or anything
containing water on the unit. Water may enter
the unit, causing an electric shock or re.
• Avoid placing the controller in a spot which
can be splashed with water. Water entering
the machine may cause an electric leak or
may damage the internal electronic parts.
•
Be aware that prolonged, direct exposure to
cool or warm air from the air conditioner, or to
air that is too cool or too warm can be harmful
to your physical condition and health.
CAUTION
• Do not remove the outdoor unit’s fan guard.
Theguardprotectsagainsttheunit’shighspeed
fan,whichmaycauseinjury.
• Do not place objects that are susceptible to
moisture directly beneath the indoor or
outdoor units.
Undercertainconditions,condensationonthe
mainunitorrefrigerantpipes,airlterdirtor
drainblockagemaycausedripping,resultingin
foulingorfailureoftheobjectconcerned.
• To avoid oxygen depletion, ensure that the
room is adequately ventilated if equipment
such as a burner is used together with the
air conditioner.
• Do not place ammable sprays near the unit
as this can cause explosions.
• Do not place appliances that produce naked
ames in places exposed to the air ow from
the unit as this may impair combustion of
the burner.
• Do not place burners or heaters in places
exposed to the air ow from the unit as this
may impair combustion of the burner or
heater.
• Do not place heaters directly below the unit,
as resulting heat can cause deformation.
• Do not allow a child to mount on the outdoor
unit or avoid placing any object on it.
Fallingortumblingmayresultininjury.
• Do not block air inlets or outlets.
Impairedairowmayresultininsufcient
performanceortrouble.
• Arrange the drain hose to ensure smooth
drainage.
Imperfectdrainagemaycausewettingofthe
building,furnitureetc.
• Arrange the drain hose to ensure smooth
drainage.
Imperfectdrainagemaycausewetting.
• Be sure that children, plants or animals are
not exposed directly to air ow from the unit,
as adverse effects may ensue.
• Do not put ammable containers, such as
spray cans, within 1 m from the blow-off
mouth.
Thecontainersmayexplodebecausethewarm
airoutputoftheoutdoorunitwillaffectthem.
• Arrange the drain to ensure complete
drainage.
Ifproperdrainagefromtheoutdoordrainpipe
doesnotoccurduringairconditioneroperation,
therecouldbeablockageduetodirtanddebris
build-upinthepipe.
Thismayresultinawaterleakagefromthe
indoorunit.Underthesecircumstances,stopair
conditioneroperationandconsultyourdealerfor
assistance.
•
The appliance is not intended for use by
unattended young children or inrm persons.
Impairmentofbodilyfunctionsandharmto
healthmayresult.
01_EN_3P529409-2B.indd 4 15-Nov-19 3:02:27 PM

5
• Children should be supervised to ensure
that they do not play with the unit or its
remote controller.
Accidentaloperationbyachildmayresultin
impairmentofbodilyfunctionsandharmhealth.
• To avoid injury, do not touch the air inlet or
aluminium ns of the unit.
Thesensaresharpandcouldresultincutting
injuries.
• Never touch the internal parts of the
controller.
Donotremovethefrontpanel.Touchingcertain
internalpartswillcauseelectricshocksand
damagetotheunit.Pleaseconsultyourdealer
aboutcheckingandadjustmentofinternalparts.
• Do not leave remote controller wherever
there is a risk of wetting.
Ifwatergetsintotheremotecontrollerthereisa
riskofelectricalleakageanddamageto
electroniccomponents.
• Turn off the main power switch when the air
conditioner is not to be used for prolonged
periods.
Whenthemainpowerswitchislefton,some
electricpower(watts)isstillconsumedevenif
theairconditionerisnotoperating.Therefore,
switchoffthemainpowerswitchtosaveenergy.
Whenresumingoperation,toensuresmooth
running,turnonthemainpowerswitch6hours
beforeoperatingtheairconditioneragain.
• Watch your steps at the time of air lter
cleaning or inspection.
High-placeworkisrequired,towhichutmost
attentionmustbepaid.
Ifthescaffoldisunstable,youmayfallortopple
down,thuscausinginjury.
•
Take care of scaffolding and exercise caution
when working high above ground level.
• Do not operate with the control panel lid
open.
Ifwatergetsinsidethepanel,itmayresultin
equipmentfailureorelectricshock.
• It is not good for your health to expose your
body to the air ow for a long time.
Inordertoavoidinjury,donotremovethefan
guardoftheoutdoorunit.
• Do not sit or place objects on the outdoor
unit.
Fallingyourselfofobjectscouldcauseinjury.
• Do not let children play on or around the
outdoor unit.
Iftheytouchtheunitcarelessly,injurymaybe
caused.
• Never operate remote controller buttons with
hard, pointed objects.
Thismayresultinremotecontrollerdamage.
• Do not pull or twist remote controller cord.
Thismaycausemalfunctioning.
• Do not use the air conditioner for purposes
other than those for which it is intended.
Donotusetheairconditionerforcooling
precisioninstruments,food,plants,animalsor
worksofartasthismayadverselyaffectthe
performance,qualityand/orlongevityofthe
objectconcerned.
• After prolonged use, check the unit stand
and its mounts for damage.
Ifleftinadamagedcondition,theunitmayfall
andcauseinjury.
• Do not place items which might be damaged
by moisture under the indoor unit.
Condensationmayfromifthehumidityisabove
80%,ifthedrainoutletisblockedorthelteris
polluted.
• Ensure that remote controller is not exposed
to direct sunlight.
ThiswillcausediscolorationoftheLCDdisplay
withresultinglossofreadability.
• Do not wipe the controller panel with
benzene or other organic solvent.
Thiswillcausediscolorationand/orpeeling.
Ifthepanelneedscleaning,useadampcloth
withsomewater-dilutedneutraldetergent.
Wipewithadryclothafterwards.
• Do not operate the air conditioner when
using a room fumigation type insecticide.
Fumigationchemicalsdepositedintheunit
couldendangerthehealthofthosewhoare
hypersensitivetotouchchemicals.
01_EN_3P529409-2B.indd 5 15-Nov-19 3:02:27 PM

6
Installation Site
Regarding places for installation
• Install the air conditioner in a well-ventilated
place that is free of obstructions.
• Do not use the air conditioner in the
following kinds of places:
a.Wherethereisconsiderableuseofmineraloil
suchascuttingoil.
b.Wherethereismuchsaltsuchasabeach
area.
c.Wherethereissulphurgassuchasina
hot-springresort.
d.Wherethereareconsiderablevoltage
uctuationssuchasafactory.
e.Wheretherearemotorvehiclesormarine
vessels.
f. Wherethereisconsiderableatmosphericoil
suchasincookingareas.
g.Wheretherearemachinesgenerating
electromagneticradiation.
h.Wheretheaircontainsacidicoralkaline
steamoravapour.
• Protection against snow
Fordetails,consultyourdealer.
Wiring
• All wiring must be performed by an
authorized electrician.
Alwaysconsultyourdealeraboutwiring.
Neverdoitbyyourself.
• Only use the dedicated power supply circuit
provided for this air conditioner.
Also pay attention to operating noise.
• Select the following kinds of location:
a.Aplacethatcansufcientlywithstandthe
weightoftheairconditionerwithlessrunning
noisesandvibrations.
b.Aplacewherewarmairowfromtheairoutlet
oftheoutdoorunitandoperatingnoisedonot
causeanuisancetoneighbours.
• Be sure there are no obstructions near the
air outlet of the outdoor unit.
• Obstructions may result in poor
performance and increased operating noise.
Ifabnormalnoiseoccur,askyourdealerfor
advise.
System relocation
• Consult your Daikin about remodelling and
relocation.
2. Introduction
2.1 System layout
4
3
2
1
1 Outdoorunit
2 Refrigerantpiping
3 Indoorunit
4 Remotecontroller
3. Before operation
Thisoperationmanualisforthefollowingsystems
withstandardcontrol.Beforeinitiatingoperation,
contactyourdealerfortheoperationthat
correspondstoyoursystemtypeandmark.
Ifyourinstallationhasacustomizedcontrol
system,askyourdealerfortheoperationthat
correspondstoyoursystem.
Operationmodes:
“ , ”HeatingandCooling(airtoair).
“ ”Fanonlyoperation(airtoair).
“ ”Dryoperation.
“ ”Automaticoperation.
Dedicatedfunctionsexistdependingonthetypeof
indoorunit,refertodedicatedinstallation/operation
manualformoreinformation.
4. Remote controller
Thisoperationmanualwillgiveanon-exhaustive
overviewofthemainfunctionsofthesystem.
Detailedinformationonrequiredactionstoachieve
certainfunctionscanbefoundinthededicated
installationandoperationmanualoftheindoorunit.
Refertotheoperationmanualofremotecontroller.
01_EN_3P529409-2B.indd 6 15-Nov-19 3:02:27 PM

7
5. Operation range
Usethesysteminthefollowingtemperatureand
humidityrangesforsafeandeffectiveoperation.
Outdoortemperature -5~43°CDB -20~15.5°CWB
Indoortemperature 21~32°CDB
14~25°CWB 15~27°CDB
Indoorhumidity ≤80%(a)
(a)To avoidcondensationandwaterdrippingoutoftheunit.
Ifthetemperatureorthehumidityisbeyondtheseconditions,
safetydevicesmaybeputinactionandtheairconditionermay
notoperate.
6. Operation procedure
• Operationprocedurevariesaccordingtothe
combinationofoutdoorunitandremote
controller.
Readthechapter“3. Before operation”
• To protecttheunit,turnonthemainpower
switch6hoursbeforetheairconditioneris
operatedtowarmupthecompressorbecause
ofsmoothlystartup.
• Ifthemainpowersupplyisturnedoffduring
operation,operationwillrestartautomatically
afterthepowerturnsbackonagain.
6.1 Cooling, heating, fan only, automatic
operation and dry operation
• Thefanmaykeeponrunningforabout1minute
aftertheheatingoperationstopsforremoving
theheatintheindoorunit.
• Theairowratemayadjustitselfdependingon
theroomtemperatureorthefanmaystop
immediately.Thisisnotamalfunction.
6.1.1 For System without COOL/HEAT
changeover remote control switch
STARTING THE SYSTEM
2,5
1Presstheoperationmodeselectorbutton
severaltimesandselecttheoperationmode
ofyourchoice
“
”Coolingoperation
“ ”Heatingoperation
“
”Fanonlyoperation
“ ”Dryoperation
“ ”Automaticoperation.
2PresstheON/OFFbuttonontheremote
controller.Theoperationlamplightsupand
thesystemstartsoperation.
ADJUSTMENT
Foradjustmentthedesiredtemperature,fanspeed
andairowdirection(onlyfortheremotecontroller),
followtheprocedureshownbelow.
3Pressthetemperaturesettingbutton
Eachtimethisbuttonispressed,
thetemperaturesettingrisesor
lowers1°C.
NOTE
• Setthetemperaturewithintheoperationrange.
• Thetemperaturesettingisimpossibleforfan
onlyoperation.
4To controlfanspeed,Pleaserefertothe
instructionintheremotecontrollermanual.
STOPPING THE SYSTEM
5PresstheON/OFFbuttononceagain.
Theoperationlampgoesoffandthesystem
stopsoperation.
01_EN_3P529409-2B.indd 7 15-Nov-19 3:02:28 PM

8
NOTICE
• Donotturnoffthepowerimmediately
aftertheunitstops,butwaitforatleast5
minutes.
• Thesystemneedatleast5minutesfor
residualoperationofdrainpumpdevice.
Turningoffthepowerimmediatelywill
causewaterleakortrouble.
6.1.2 Explanation of heating operation
Itmaytakelongertoreachthesettemperaturefor
generalheatingoperationthanforcoolingoperation.
Thefollowingoperationisperformedinorderto
preventtheheatingcapacityfromdroppingorcold
airfromblowing.
Defrost operation
• Inheatingoperation,freezingoftheoutdoor
unit’saircooledcoilincreasesovertime,
restrictingtheenergytransfertotheoutdoor
unit’scoil.Heatingcapabilitydecreasesandthe
systemneedstogointodefrostoperationtobe
abletodeliverenoughheattotheindoorunits.
• Whenaoutdoorunitisinstalled,theindoorunit
willstopfanoperation,therefrigerantcyclewill
reverseandenergyfrominsidethebuildingwill
beusedtodefrosttheoutdoorunitcoil.
• Theindoorunitwillindicatedefrostoperationon
thedisplays“ ”.
Hot start
• Inordertopreventcoldairfromblowingoutof
anindoorunitatthestartofheatingoperation,
theindoorfanisautomaticallystopped.
Thedisplayoftheremotecontrollershows
“ ”.Itmaytakesometimebeforethefan
starts.Thisisnotamalfunction.
INFORMATION
• Theheatingcapacitydropswhenthe
outsidetemperaturefalls.Ifthishappens,
useanotherheatingdevicetogetherwith
theunit.(Whenusingtogetherwith
appliancesthatproduceopenre,
ventilatetheroomconstantly).
Donotplaceappliancesthatproduce
openreinplacesexposedtotheairow
fromtheunitorundertheunit.
• Ittakessometimetoheatuptheroom
fromthetimetheunitisstartedsincethe
unitusesahot-aircirculatingsystemto
heattheentireroom.
• Ifthehotairrisestotheceiling,leaving
theareaabovetheoorcold,we
recommendthatyouusethecirculator
(theindoorfanforcirculatingair).
Contactyourdealerfordetails.
6.2 Program dry operation
• Thefunctionofthisprogramistodecreasethe
humidityinyourroomwithminimaltemperature
decrease(minimalroomcooling).
• Themicrocomputerautomaticallydetermines
temperatureandfanspeed
(cannotbesetbytheremotecontroller).
• Thesystemdoesnotgointooperationifthe
roomtemperatureislow(<20°C).
6.2.1 For Systems without COOL/HEAT
changeover remote control switch
STARTING THE SYSTEM
2-3
1
1Presstheoperationmodeselectorbutton
severaltimesandselect“ ”(programdry
operation).
2PresstheON/OFFbuttonoftheremote
controller.Theoperationlamplightsupand
thesystemstartsoperating.
01_EN_3P529409-2B.indd 8 15-Nov-19 3:02:28 PM

9
STOPPING THE SYSTEM
3PresstheON/OFFbuttonoftheremote
controlleronceagain.Theoperationlamp
goesoffandthesystemstopsoperating.
NOTICE
Donotturnoffpowerimmediatelyafterthe
unitstops,butwaitforatleast5minutes.
INFORMATION
Foranotherremotecontroller,refertothe
operationmanualoftheremotecontroller.
7. Energy saving and optimum
operation
Observethefollowingprecautionstoensurethe
systemoperatesproperly.
• Adjusttheairoutletproperlyandavoiddirectair
owtoroominhabitants.
• Adjusttheroomtemperatureproperlyfora
comfortableenvironment.Avoidexcessive
heatingorcooling.
• Preventdirectsunlightfromenteringaroom
duringcoolingoperationbyusingcurtainsor
blinds.
• Ventilateoften.
Extendeduserequiresspecialattentionto
ventilation.
• Keepdoorsandwindowsclosed.Ifthedoors
andwindowsremainopen,airwillowoutof
yourroomcausingadecreaseinthecoolingor
heatingeffect.
• Becarefulnottocoolorheattoomuch.To save
energy,keepthetemperaturesettingata
moderatelevel.
• Neverplaceobjectsneartheairinletortheair
outletoftheunit.
Itmaycausedeteriorationintheeffectorstop
theoperation.
• Tu r n offthemainpowersupplyswitchtotheunit
whentheunitisnotusedforlongerperiodsof
time.Iftheswitchison,itconsumeselectricity.
Beforerestartingtheunit,turnonthemain
powersupplyswitch6hoursbeforeoperationto
ensuresmoothrunning.(Referto“Maintenance”
intheindoorunitmanual.)
• Whenthedisplayshows“ ”(timetoclean
theairlter),askaqualiedservicepersonto
cleanthelters.(Referto“Maintenance”inthe
indoorunitmanual.)
• Keeptheindoorunitandremotecontrollerat
least1mawayfromtelevisions,radios,stereos,
andothersimilarequipment.Failingtodoso
maycausestaticordistortedpictures.
• Donotplaceitemsundertheindoorunit,
theymaybedamagedbywater.
• Condensationmayformifthehumidityisabove
80%orifthedrainoutletgetsblocked.
Yoursystemisequippedwithadvancedenergy
savingfunctionality.Dependingonthepriority
emphasisescanbeputonenergysavingor
comfortlevel.Severalparameterscanbeselected,
resultingintheoptimalbalancebetweenenergy
consumptionandcomfortforyourparticular
application.
Severalpatternsareavailableandroughly
explainedbelow.Contactyourinstallerordealer
foradviceortomodifytheparameterstothe
needsofyourbuilding.
Detailedinformationisgivenfortheinstallerinthe
installationmanual.Hecanhelpyoutorealizethe
bestbalancebetweenenergyconsumptionand
comfort.
8. Maintenance
CAUTION
Payattentiontothefan.
Itisdangeroustoinspecttheunitwhilethe
fanisrunning.
Besuretoturnoffthemainswitchandto
removethefusesfromthecontrolcircuit
locatedintheoutdoorunit.
8.1 Maintenance after a long stop period
(e.g., at the beginning of the season)
• Checkandremoveeverythingthatmightbe
blockinginletandoutletventsofindoorunits
andoutdoorunits.
• Cleanairltersandcasingsofindoorunits.(b)
Refertotheoperationmanualsuppliedwiththe
indoorunitsfordetailsonhowtoproceedand
makesuretoinstallfordetailsonhowto
proceedandmakesuretoinstallcleanedair
ltersbackinthesameposition.
• Tu r n onthepoweratleast6hoursbefore
operatingtheunitinordertoensuresmoother
operation.Assoonasthepoweristurnedon,
theremotecontrollerdisplayappears.
(b)Contactyourinstallerorservicepersontocleanairltersand
casingsoftheindoorunit.Maintenancetipsandproceduresfor
cleaningareprovidedintheinstallation/operationmanualsof
dedicatedindoorunits.
01_EN_3P529409-2B.indd 9 15-Nov-19 3:02:28 PM

10
8.2 Maintenance before a long stop
period (e.g., at the end of the season)
• Lettheindoorunitsruninfanonlyoperationfor
abouthalfadayinordertodrytheinteriorofthe
units.
Referto“6.1 Cooling, heating, fan only,
automatic operation and dry operation”
onpage7.
• Tu r n offthepower.Theremotecontrollerdisplay
disappears.
• Cleanairltersandcasingsofindoorunits.
Refertotheoperationmanualsuppliedwiththe
indoorunitsfordetailsonhowtoproceedand
makesuretoinstallcleanedairltersbackin
thesameposition.
9. Symptoms that are not air
conditioner troubles
Followingsymptomsarenotairconditionertroubles:
9.1 The system does not operate
• Theairconditionerdoesnotstartimmediately
aftertheON/OFFbuttonontheremotecontroller
ispressed.Iftheoperationlamplights,the
systemisinnormalcondition.To prevent
overloadingofthecompressormotor,theair
conditionerstarts5minutesafteritisturnedON
againincaseitwasturnedOFFjustbefore.
Thesamestartingdelayoccursafterthe
operationmodeselectorbuttonwasused.
• Thesystemdoesnotstartimmediatelyafterthe
powersupplyisturnedon.Waitoneminuteuntil
themicrocomputerispreparedforoperation.
9.2 Fan operation is possible, but cooling/
heating do not work
• Immediatelyafterthepoweristurnedon.
Themicrocomputerisgettingreadytooperate
andisperformingacommunicationcheckwith
indoorunit.Pleasewait12minutes(max.)till
thisprocessisnished.
9.3 White mist comes out of a unit
1 Indoorunit
• Whenhumidityishighduringcooling
operation.Iftheinteriorofanindoorunitis
extremelycontaminated,thetemperature
distributioninsidearoombecomesuneven.
Itisnecessarytocleantheinteriorofthe
indoorunit.Askyourdealerfordetailson
cleaningtheunit.Thisoperationrequiresa
qualiedserviceperson.
• Immediatelyafterthecoolingoperation
stopsandiftheroomtemperatureand
humidityarelow.Thisisbecausewarm
refrigerantgasowsbackintotheindoor
unitandgeneratessteam.
2 Indoorunit,outdoorunit
• Whenthesystemischangedoverto
heatingoperationafterdefrostoperation.
Moisturegeneratedbydefrostbecomes
steamandisexhausted.
9.4 The remote controller display shows
“U4” or “U5” and stops, but then
restarts after a few minutes
• Thisisbecausetheremotecontrolleris
interceptingnoisefromelectricappliancesother
thantheairconditioner.Thenoiseprevents
communicationbetweentheunits,causingthem
tostop.
Operationautomaticallyrestartswhenthenoise
ceases.
9.5 Noise of air conditioners
1 Indoorunit
• A“zeen”soundisheardimmediatelyafter
thepowersupplyisturnedon.
Theelectronicexpansionvalveinsidean
indoorunitstartsworkingandmakesthe
noise.Itsvolumewillreduceinaboutone
minute.
• Acontinuouslow“shah”soundisheard
whenthesystemisincoolingoperationor
atastop.Whenthedrainpump(optional
accessories)isinoperation,thisnoiseis
heard.
• Alow“sah”,“choro-choro”soundisheard
whiletheindoorunitisstopped.
Whentheotherindoorunitisinoperation,
thisnoiseisheard.Inordertopreventoil
andrefrigerantfromremaininginthe
system,asmallamountofrefrigerantiskept
owing.
•
A“pishi-pishi”squeakingsoundisheardwhen
thesystemstopsafterheatingoperation.
Expansionandcontractionofplasticparts
causedbytemperaturechangemakethis
noise.
01_EN_3P529409-2B.indd 10 15-Nov-19 3:02:28 PM

11
2 Indoorunit,outdoorunit
• Acontinuouslowhissingsoundisheard
whenthesystemisincoolingordefrost
operation.Thisisthesoundofrefrigerant
gasowingthroughbothindoorandoutdoor
units.
• Ahissingsoundwhichisheardatthestart
orimmediatelyafterstoppingoperationor
defrostoperation.Thisisthenoiseof
refrigerantcausedbyowstoporow
change.
3 Outdoorunit
• Whenthetoneofoperatingnoisechanges.
Thisnoiseiscausedbythechangeof
frequency.
9.6 Dust comes out of the unit
• Whentheunitisusedforthersttimeina
longtime.
Thisisbecausedusthasgottenintotheunit.
9.7 The units can give off odours
• Theunitcanabsorbthesmellofrooms,
furniture,cigarettes,etc.,andthenemititagain.
9.8 The outdoor unit fan does not
operate. But compressor still running
• Thespeedofthefaniscontrolledinorderto
optimiseproductoperation.
9.9 The compressor in the outdoor unit
does not stop after a short heating
operation
• Thisistopreventoilandrefrigerantfrom
remaininginthecompressor.Theunitwillstop
after5to10minutes.
9.10 The inside of an outdoor unit is warm
even when the unit has stopped
• Thisisbecausethecrankcaseheateris
warmingthecompressorsothatthecompressor
canstartsmoothly.
9.11 Does not cool very well
• Programdryoperation.
Programdryoperationisdesignedtolowerthe
roomtemperatureaslittleaspossiblereferto
“6.2 Program dry operation”
10. Troubleshooting
Ifoneofthefollowingmalfunctionsoccur,takethe
measuresshownbelowandcontactyourdealer.
WARNING
Stopoperationandturnoffthepowerif
anythingunusualoccurs(burningsmellsetc.)
Leavingtheunitrunningundersuch
circumstancesmaycausebreakage,electric
shockorre.Contactyourdealer.
Thesystemmustberepairedbyaqualied
serviceperson:
• Ifasafetydevicesuchasafuse,abreakeror
anearthleakagebreakerfrequentlyactuatesor
theON/OFFswitchdoesnotproperlywork.
Measure:Tu r n offthemainpowerswitch.
• Ifwaterleaksfromtheunit.
Measure:Stoptheoperation.
• Theoperationswitchdoesnotworkwell.
Measure:Tu r n offthepower.
• Iftheremotecontrollerdisplay“ ”
indicatestheunitnumber,theoperationlamp
ashesandthemalfunctioncodeappears.
Measure:Notifyyourinstallerandreportthe
malfunctioncode.
If the system does not properly operate except
for the above mentioned cases and none of the
above mentioned malfunctions is evident,
investigate the system according to the
following procedures. If it is impossible to x
the problem yourself after checking all the
above items, contact your dealer.
Let him know the symptoms, system name,
and model name (listed on the warranty card).
1 Ifthesystemdoesnotoperateatall:
• Checkifthereisnopowerfailure.
Waitunitpowerisrestored.Ifpowerfailure
occursduringoperation,thesystem
automaticallyrestartsimmediatelyafterthe
powersupplyisrecovered.
• Checkifnofusehasblownorbreakerhas
worked.Changethefuseorresetthe
breakerifnecessary.
• Tu r n thepoweronwith
thebreakerswitchin
theoffposition.
Donotturnthepower
onwiththebreaker
switchinthetrip
position.
(Contactyourdealer.)
ON
OFF
Switch
Breaker
Tr i p position
01_EN_3P529409-2B.indd 11 15-Nov-19 3:02:28 PM

12
2 Ifthesystemgoesintofanonlyoperation,
butassoonasitgoesintocoolingoperation,
thesystemstops:
Checkifairinletoroutletofoutdoororindoor
unitisnotblockedbyobstacles.Removeany
obstacleandmakeitwell-ventilated.Checkif
theremotecontrollerdisplayshows“ ”
(timetocleantheairlter).
Referto“theoperationmanualoftheindoor
unitandcleantheairlter”.
3 Thesystemoperatesbutcoolingorheatingis
insufcient:
• Checkifairinletoroutletofoutdooror
indoorunitisnotblockedbyobstacles.
• Removeanyobstacleandmakeit
well-ventilated.
• Checkiftheairlterisnotclogged(referto
“Maintenance”intheindoorunitmanual).
• Checkthetemperaturesetting.
• Checkthefanspeedsettingonyourremote
controller.
• Checkforopendoorsorwindows.
Shutdoorsandwindowstopreventwind
fromcomingin.
• Checkiftherearetoomanyoccupantsin
theroomduringcoolingoperation.Checkif
theheatsourceoftheroomisexcessive.
• Checkifdirectsunlightenterstheroom.
Usecurtainsorblinds.
• Checkiftheairowangleisproper.
Ifthecheckingallaboveitems,itisimpossibleto
xtheproblemyourself,contactyourinstallerand
statethesymptoms,thecompletemodelnameof
theairconditioner(withmanufacturingnumberif
possible)andtheinstallationdate(possiblylisted
onthewarrantycard).
11. After-sales service and
warranty
11.1 Warranty period
• Thisproductincludesawarrantycardthatwas
lledinandprovidedbythedealeratthetimeof
installation.
Thecompletedcardhastobecheckedbythe
customerandstoredcarefully.
• Ifrepairstotheairconditionerarenecessary
withinthewarrantyperiod,contactyourdealer
andkeepthewarrantycardathand.
11.2 After-sales service
11.2.1 Recommendations for maintenance and
inspection
Sincedustcollectswhenusingtheunitforseveral
years,performanceoftheunitwilldeteriorateto
someextent.Astakingapartandcleaninginteriors
ofunitsrequirestechnicalexpertiseandinorderto
ensurethebestpossiblemaintenanceofyour
units,werecommendtoenterintoamaintenance
andinspectioncontractontopofnormal
maintenanceactivities.Ournetworkofdealershas
accesstoapermanentstockofessential
componentsinordertokeepyourairconditioner
inoperationaslongaspossible.Contactyour
dealerformoreinformation.
When asking your dealer for an intervention,
always state :
• Thecompletemodelnameoftheairconditioner.
• Themanufacturingnumber(statedonthe
nameplateoftheunit).
• Theinstallationdate.
• Thesymptomsormalfunction,anddetailsofthe
defect.
01_EN_3P529409-2B.indd 12 15-Nov-19 3:02:28 PM

13
WARNING
• Donotmodify,disassemble,remove,
reinstallorrepairtheunityourselfas
incorrectdismantlingorinstallationmay
causeanelectricshockorre.Contact
yourdealer.
• Incaseofaccidentalrefrigerantleaks,
makesuretherearenonakedames.
Therefrigerantitselfisentirelysafe,
non-toxicandnon-combustible,butitwill
generatetoxicgaswhenitaccidentally
leaksintoaroomwherecombustibleair
fromfanheaters,gascookers,etc.is
present.Alwayshavequaliedservice
personnelconrmthatthepointof
leakagehasbeenrepairedorcorrected
beforeresumingoperation.
• Donotremoveorreinstalltheunitby
yourself.Incorrectinstallationmaycause
electricalshockorre.Contactyourdealer.
11.2.2 Recommended inspection and
maintenance cycles
Beawarethatthementionedmaintenanceand
replacementcyclesdonotrelatetothewarranty
periodofthecomponents.
Table1assumesthefollowingconditionsofuse:
• Normalusewithoutfrequentstartingand
stoppingoftheunit.
Dependingonthemodel,werecommendnot
startingandstoppingthemachinemorethan
6times/hour.
• Operationoftheunitisassumedtobe10hours/
dayand2,500hours/year.
Table1:“InspectionCycle”and“Maintenance
Cycle”list
Component Inspection
cycle
Maintenance cycle
(replacements and/or
repairs)
Electricmotor
(fan,damper,etc.)
1year
20,000hours
PCBboards 25,000hours
Heatexchanger 5years
Sensor(thermistor,etc.) 5years
Remotecontrollerand
switches 25,000hours
Drainpan 8years
Expansionvalve 20,000hours
Electromagneticvalve 20,000hours
NOTICE
1 Table1indicatesmaincomponents.
Refertoyourmaintenanceand
inspectioncontractformoredetails.
2 Table1indicatesrecommended
intervalsofmaintenancecycles.
However,inordertokeeptheunit
operationalaslongaspossible,
maintenanceworkmayberequired
sooner.Recommendedintervalscanbe
usedforappropriatemaintenance
designintermsofbudgeting
maintenanceandinspectionfees.
Dependingonthecontentofthe
maintenanceandinspectioncontract,
inspectionandmaintenancecyclesmay
inrealitybeshorterthanlisted.
11.3 Shortening of “maintenance cycle”
and “replacement cycle” needs to be
considered in following situations
The unit is used in locations where:
• Heatandhumidityuctuateoutoftheordinary.
• Poweructuationishigh(voltage,frequency,
wavedistortion,etc.)(theunitcannotbeusedif
poweructuationisoutsidetheallowablerange).
• Bumpsandvibrationsarefrequent.
• Dust,salt,harmfulgasoroilmistsuchas
sulphurousacidandhydrogensulphidemaybe
presentintheair.
• Themachineisstartedandstoppedfrequently
oroperationtimeislong(siteswith24hour
airconditioning).
Recommendedreplacementcycleofwearparts
Table2:“ReplacementCycle”list
Component Inspection
cycle
Maintenance cycle
(replacements and/or
repairs)
Airlter
1year
5years
Highefciencylter
(Optionalaccessory) 1years
Fuse 10years
Crankcaseheater 8years
01_EN_3P529409-2B.indd 13 15-Nov-19 3:02:28 PM

14
NOTICE
• Table2:“ReplacementCycle”list
indicatesmaincomponents.Refertoyour
maintenanceandinspectioncontractfor
moredetails.
• Table2:“ReplacementCycle”list
indicatesrecommendedintervalsof
replacementcycles.However,inorderto
keeptheunitoperationalaslongas
possiblemaintenanceworkmaybe
requiredsooner.Recommendedintervals
canbeusedforappropriatemaintenance
designintermsofbudgetingmaintenance
andinspectionfees.Contactyourdealer
fordetails.
INFORMATION
Damageduetotakingapartorcleaning
interiorsofunitsbyanyoneotherthanour
authorizeddealersmaynotbeincludedin
thewarranty.
Moving and discarding the unit
• Contactyourdealerforremovingand
reinstallingthetotalunit.Movingunitsrequires
technicalexpertise.
• Thisunituseshydrouorocarbon.Contactyour
dealerwhendiscardingthisunit.Itisrequiredby
lawtocollect,transportanddiscardthe
refrigerantinaccordancewiththe
“hydrouorocanboncollectionanddestruction”
regulations.
11.4 Malfunction codes
Incaseamalfunctioncodeappearsontheindoor
unitremotecontrollerdisplay,contactyourinstaller
andinformthemalfunctioncode,theunittype,and
serialnumber(youcanndthisinformationonthe
nameplateoftheunit).
Foryourreference,alistwithmalfunctioncodesis
provided.Yo u can,dependingonthelevelofthe
malfunctioncode,resetthecodebypushingthe
ON/OFFbutton.Ifnot,askyourinstallerforadvice.
Malfunction
code Contents
Main code
A0 Externalprotectiondevicewasactivated
A1 EEPROMfailure(indoor)
A3 Drainsystemmalfunction(indoor)
A6 Fanmotormalfunction(indoor)
A7 Swingapmotormalfunction(indoor)
A9 Expansionvalvemalfunction(indoor)
AF Drainmalfunction(indoorunit)
Ah Filterdustchambermalfunction(indoor)
AJ Capacitysettingmalfunction(indoor)
C1 TransmissionmalfunctionbetweenmainPCBand
subPCB(indoor)
C4 Heatexchangerthermistormalfunction(indoor;liquid)
C5 Heatexchangerthermistormalfunction(indoor;gas)
C9 Suctionairthermistormalfunction(indoor)
CA Dischargeairthermistormalfunction(indoor)
CE Movementdetectororoortemperature
sensormalfunction(indoor)
CJ Remotecontrollerthermistormalfunction(indoor)
e1 PCBmalfunction(outdoor)
e2 Currentleakagedetectorwasactivated(outdoor)
e3 Highpressureswitchwasactivated
e4 Lowpressuremalfunction(outdoor)
e5 Compressorlockdetection(outdoor)
e7 Fanmotormalfunction(outdoor)
e9 Electronicexpansionvalvemalfunction(outdoor)
F3 Dischargetemperaturemalfunction(outdoor)
f4 Abnormalsuctiontemperature(outdoor)
f6 Refrigerantoverchargedetection
H3 Highpressureswitchmalfunction
H4 Lowpressureswitchmalfunction
H7 Fanmotortrouble(outdoor)
H9 Ambienttemperaturesensormalfunction(outdoor)
J1 Pressuresensormalfunction
J2 Currentsensormalfunction
J3 Dischargetemperaturesensormalfunction(outdoor)
J4 Heatexchangergastemperaturesensormalfunction
(outdoor)
J5 Suctiontemperaturesensormalfunction(outdoor)
J6 De-icingtemperaturesensormalfunction(outdoor)
J7 Liquidtemperaturesensor(aftersubcoolHE)
malfunction(outdoor)
J8 Liquidtemperaturesensor(coil)malfunction(outdoor)
J9 Gastemperaturesensor(aftersubcoolHE)
malfunction(outdoor)
JA Highpressuresensormalfunction(S1NPH)
JC Lowpressuresensormalfunction(S1NPL)
L1 INVPCBabnormal
L4 Fintemperatureabnormal
L5 InverterPCBfaulty
L8 Compressorovercurrentdetected
L9 Compressorlock(startup)
Lc Transmissionoutdoorunit-inverter:INVtransmission
trouble
P1 INVunbalancedpowersupplyvoltage
01_EN_3P529409-2B.indd 14 15-Nov-19 3:02:28 PM

15
Malfunction
code Contents
Main code
P4 Finthermistormalfunction
pj Capacitysettingmalfunction(outdoor)
u0 Abnormallowpressuredrop,faultyexpansionvalve
u1 Reversedpowersupplyphasemalfunction
u2 INVvoltagepowershortage
u3 Systemtestrunnotyetexecuted
u4 Faultywiringindoor/outdoor
u5 Transmissionerrorbetweenremotecontrollerand
indoorunit
u7 FaultywiringtoQ1/Q2
u8 Abnormalmain-subremotecontrollercommunication
u9
Systemmismatch.Wrongtypeofindoorunitscombined.
Indoorunitmalfunction.
ua Connectionmalfunctionoverindoorunitsortype
mismatch
uf Autoaddressmalfunction(inconsistency)
uh Autoaddressmalfunction(inconsistency)
01_EN_3P529409-2B.indd 15 15-Nov-19 3:02:28 PM

16
NOTE
01_EN_3P529409-2B.indd 16 15-Nov-19 3:02:28 PM

01_EN_3P529409-2B.indd 17 15-Nov-19 3:02:28 PM

3P529409-2B M19N102 (1911) HT
The two-dimensional bar code is
a manufacturing code.
00_CV_3P529409-2B.indd 3 30/10/2019 16:48:01