Dickson PW8 Series User manual

Quick Start
This manual applies to: PW860/861/864/865/866/867/875
1. This recorder comes with one (1) AA battery installed.
2. When installing recorder (1/4 in male NPT pressure connection) always tighten the fitting instead of twisting the
instrument case. Use a 5/8 in wrench. We recommend wrapping the pressure fitting with pipe tape before installing to
prevent leaks.
3. Replace chart paper with a new chart.
4. Set the time by inserting a coin into the chart hub and turning clockwise until the correct hour is referenced by the time
indicator. (Time indicator is directly to the right and below the pen tip.)
5. Remove protective pen cap.
6. Turn the recorder On. The “On/Off” switch is located inside the door on the dial plate.
PW8Water Resistant Enclosure
The PW8 features an IP66 enclosure. In order to maintain the IP66 rating, the battery/switch cover on the back of the unit,
must be screwed down tightly at all points. The door must be closed tightly using the two side latches.
It is strongly recommended that the case door gasket be greased occasionally using a standard silicone rubber grease. The
more the door is opened and closed, the more frequently grease should be applied.
The Door and Battery Cover gaskets should maintain the IP66 rating for 1 year under normal use. To replace gaskets,
contact Dickson Customer Service
Phone: [phone] or 1-630-543-3747 | Fax: [phone] | Email: [e-mail] | Website:DicksonDate.com
PW8
8”(101mm) Pressure Chart Recorder

Warranty
Dickson warrants that this line of instruments will be free from defects in material and workmanship under normal use and
service for a period of twelve months after delivery.
This warranty does not cover routine calibration and battery replacement. For Specifications and Technical Support go
to www.DicksonData.com
Factory Service & Returns
Contact Customer Service 630.543.3747 for a Return Authorization Number (RA) before returning any instrument. Please
have the model number, serial number and a PO ready before calling
5 screws
Battery
Compartment