Electrolux EHGF93CX User manual

user manual
gas cooktops
EHGC93CI, EHGF93CX

Congratulations
Congratulations and thank you for choosing our gas cooktop.
We are sure you will find your new cooktop a pleasure to
use and a great asset to your cooking. Before you use the
cooktop, we recommend that you read through the whole
user manual which provides the description of the cooktop
and its functions. To avoid the risks that are always present
when you use a gas appliance, it is important that the
cooktop is installed correctly and that you read the safety
instructions carefully to avoid misuse and hazards.
For future reference, please store this booklet in a safe place.
Contents
 
 2
 3
 4
 5
 6
 7
 8
 
 
 
 
 
Information on disposal for users
• Mostofthepackagingmaterialsarerecyclable.Please
dispose of these materials through your local recycling
depot or by placing them in appropriate collection
containers.
• Ifyouwishtodiscardthisproduct,pleasecontactyour
local authorities and ask for the correct method of disposal.
contents
environmental tip

part names
EHGC93CI EHGF93CX
1. removable cast iron trivet side
2. removable cast iron wok trivet
3. gas burners – each unit has a small, medium
and wok burner
4. control knob
5. ceramic glass hob – the glass hob is resistant to heat,
cold and rapid temperature changes, but is vulnerable
to impact. A pepper mill falling on the hob could crack
it. Never stand or put heavy loads on the hob, or use
as a storage space.
6. enamelled burner skirts
1. removable cast iron trivet side
2. removable cast iron wok trivet
3. gas burners – each unit has a small, medium
and wok burner
4. control knob
5. stainless steel hob
6. stainless steel burner skirts
2
4 5
3
Figure 1
1 6

Cleaning
• Alwaysensuretheapplianceisturnedoff
beforecleaning.
• Thisappliancecontainsaluminiumfittings.
Do not use caustic based cleaners.
• Donotusesteamcleanersasthismaycausemoisture
builduponelectricalcomponents.
• Alwayscleantheapplianceimmediatelyafter
anyfoodspillage.
• Donotplaceburnerbodiesandcapsinadishwasher.
caution
• Donotplaceburnersinadishwasher.
tips and information
• Inordertoavoidare,thisappliancemustbekeptclean.
• Pothandlesshouldbeturnedawayfromthefrontofthe
benchtoavoidspillageaccidents.
• Formaximumstability,ensurepotsandpansarecentrally
locatedonthetrivets.
• Keepallairventsclearofobstructionsontheundersideof
thisproduct.
• Removestickersandlmfromtheglassceramicor
stainlesssteelsurfacesbeforeusingtheappliance.
• Theglassceramiccanbedamagedbyobjectsfalling
ontoit.
• Theedgeoftheglassceramiccanbedamagedbybeing
knockedbythecookware.
• Cookwaremadeofcastiron,stainlesssteelorwith
damagedbottomscanscratchtheglassceramicifpushed
orpulledacrossthesurface.
• Spillagefromcookwarecanburnontotheglassceramic
orstainlesssteelandshouldberemovedattheearliest
opportunity.
• Donotusethecookingzoneswithemptycookwareor
withoutcookware.
• Toavoiddamagingcookwareandglassceramics,donot
allowsaucepansorfryingpanstoboildry.
• Donotallowlargecookwaretooverhangtheappliance
ontoadjacentbenchtop.Thiswillcausescorchingtothe
benchtopsurface.
• Donotallowcookingpotsorpanstointrudeintothearea
whichisclosetothecontrols.
• Ensureburnerbodiesandtrivetsareproperlylocated.
2electrolux gas cooktops burners
Description of the burner
Installation
• Anauthorisedpersonmustinstallthisapplianceand
MUST provide a certificate of compliance.
This
certificateshouldberetainedalongwithpurchase
information.
• Beforeusingtheappliance,ensurethatallpacking
materialsareremovedfromtheappliance.
• Inordertoavoidanypotentialhazard,theinstallation
instructionsinthisbooklet,andanylabelsonthe
appliancemustbefollowed.
• Ensurethatallspecifiedvents,openingsandairspaces
arenotblocked.
• Wheretheapplianceisbuiltintoabenchtop,the
benchtopmaterialmustbecapableofwithstanding85°C.
•Ensurethattheduplicateratinglabel(intheinstruction
pack)isattachedtoareadilyaccessibleadjacent
surface,sothatthecooktopcanbeeasilyidentifiedin
thecaseofaservicecall.
Servicing
• ServicingMUSTonlybecarriedoutbyauthorised
personnel.
• Tomaintainsafeoperation,itisrecommendedthatthe
productbeinspectedeveryfiveyearsbyanauthorised
serviceperson.
• Ifthesupplycordisdamaged,itmustbereplacedbyan
authorisedservicepersoninordertoavoidahazard.
1. burner 
2. skirt
3. flamesafeguardsensor
4. injector
5. ignitionsparkplug
Figure2
1
2
3
5
4
Burners

3electrolux gas cooktops usingyourcooktop
Choice of flame height
Incorrect–flametoohigh
andwillcausegaswaste
andpossiblehandledamage.
Correctflameheight.
Gassaved.
Choice of cooking utensils
Foralargeburner,
usealargeutensil.
Forasmallburner,
useasmallutensil.
3
7
3
3
Figure4
Toconservegasplacethepancentrallyovertheburner
andadjusttheflamesothatitdoesnotextendpastthe
edgeofthepan(Figure4).Donotboilfoodtoorapidly.
Avigorousboilwillnotcookfoodanyfaster,andwill
wasteenergy.
Pots and pans
Allcommonpotsandpans;aluminium,stainlesssteel,
castiron,ceramic,etc.,maybeusedonthegasburners.
Ensurethatthepotsorpansaresteadyandhaveflat
basestoavoiddangerousspill-overofhotliquidsand
wastedenergy.
caution
Neveruseasbestosmats,wirematsorgrids,aluminium
foilasitcanleadtooverheating,crackedenamelorbroken
glass.Thewarrantywillbevoidiftheseitemsareused
andcauseafailure.Woksshouldonlybeusedonthewok
burnerandwoksupporttrivet.
Usingyourcooktop
Gas Controls
Eachburneriscontrolledbyacontrolknob.Themarkingson
thecontrolpanelindicatewhichburnertheknobcontrols,and
thesettingforthatburner(seeFigure3).
NOTE! Gas controls turn anticlockwise from ‘OFF’ and have
limited movement.
Lighting burners
Electronicignition:Thesecooktopsarefittedwitha
mainspowered,zeroignitiontimedeviceconnectedto
thermoelectricsafetygasvalves.Whentheappliancehas
beenconnectedandthepowerison,depressinganyknob
willreleasesparkstoallburners.
Tolightaburner,theknobmustbeturnedtothe
‘HIGH’position,thenpusheddown.Thereisnoneed
toholdtheknobdown,theignitionwillbeinstantaneous.
Thesparkwillcontinuefor5seconds.Iftheflamegoesout
whentheknobisreleasedsimplydepresstheknobagain.
Theheightoftheflamecanbevariedbyturningthecontrol
knobtowardthe ‘LOW’position.
caution
• Keephandsclearofburnerswhenlighting.
• Ifburnerdoesnotlightwithin5seconds,turnknob
to‘OFF’position,allowgastodisperse,thentry
lightingagain.
• BurnersMUSTbeoperatedbetween‘HIGH’and‘LOW’
settingsonly.
Intheabsenceofelectricalpower,carryouttheignition
directlytotheburnerwithahandheldignitionsource.Push
theknobdownasfaraspossibleforapprox.5seconds.
Iftheflamegoesoutwhentheknobisreleased,simply
depresstheknobagain,thistimeholdingitdownwith
slightlymoreforceforthesamelengthoftime.
Choice of gas burner
Foryourconveniencethereisachoiceofburners–
• Asmallburnerforspeciallowheatandslowcooking
• Amediumburnerfornormalcookingandsimmering
• Awokburnerforveryfastheatingusingawokorlarge
potorpan.
Figure3

electrolux gas cooktops cleaningandcare4
caution
Ensure the appliance is off and cool before cleaning.
Enamel (on burner skirts and trivets)
Persistentstainsmayrequirerubbingwithanylonscourer
orcreamedpowdercleansers.Householdenamelcleaners
areavailable,followthemanufacturer’sinstructionsintheir
use.Harsh abrasive cleaners, powder cleaners, steel
wool or wax polishes should not be used.
Stainless steel (model EHGF93CX)
Simplywipewithasoftclothusingwarmwaterandamild
detergentandrinsewithcleanwater.Wherestainlesssteel
hasbecomeextremelydirtyordiscoloured,useastainless
steelcleaner–butbesuretofollowthebrushinglines.
caution
DO NOTuse abrasive cleaners or harsh solvents.
Ceramic glass (model EHGC93CI)
Thespeciallytreatedglassintheproductismanufactured
usingthelatesttechnologytothehighestpossible
standardsforbothsafetyandreliability.However,itmustbe
rememberedthatasitisCERAMIC GLASS,itmaybreak.
Treatitaccordingly.Tocleantheceramicglasshobusea
softclothorspongewithdetergentandwarmwater.
warning
Ifthesurfaceiscracked,switchofftheappliance
immediatelytoavoidthepossibilityofelectricshock.
If the hob is very soiled:
1. Removesoilageusingtherazorbladescraper.
2. Useahobcleanerproductaftertherehasbeen
sufficienttimeallowedforthehobtocool.Shakethe
bottleandapplyasmallquantityofcleanerdirectlyonto
thehob.Rubcleanusingadampclothorpapertowels.
3. Useadampclothtoremoveallremainingtracesofthe
cleaner,whichcouldotherwiseburnonwhenthehobis
nextused.Wipethehobdry.
caution
Use the scraper supplied to remove spillages
immediately, while the hob is still hot! Especially sugar
and foods with a high sugar content (eg. jam), melted
plastics and foil, all of which can damage the hob if left.
Razor blade scraper
Usethescrapertoremovespillagesfromtheceramichob.
Cleaningandcare
How to use the razor blade scraper:
1. Pullbacktheprotectivecoveruntilthebladeisvisible.
2. Makesurethattherazorbladeiscleanandnotworn.
Thereisarisk,otherwise,thatitmightdamagethehob.
Newrazorbladescanbeboughtfrompharmacies.
3.Anglescraperatapprox.45°andscrapeawaythe
spillage.Therazorbladecanbepresseddownhard
ontothehobwithoutcausinganydamage.
4. Carefullycleanthebladebywipingitwithapapertowel.
5. Whenyouhavefinished,presstheprotectivecover
forwardsasfarasitwillgo.Keepthescraperoutofthe
reachofchildren.
Changing the razor blade:
1. Openthescraperbycompletelyunscrewingthescrew
andthenplacethenewrazorbladeatthefrontedge.
2. Putthescrapertogetheragainandscrewthescrew
backintoplace.
3. Presstheprotectivecoverforwardsasfarasitwillgoto
covertherazorblade.
caution
THE RAZOR BLADE SCRAPER SHOULD BE KEPT
WELL OUT OF THE REACH OF CHILDREN. Use the
razor blade scraper carefully, as the razor blade is
extremely sharp.
Trivets and burners
Thesecanallbeliftedoffandremovedforseparate
cleaning.
NOTE! When retting the burners, ensure that they are
correctly seated.
Ensureburnersarethoroughlydriedaftercleaningor
spillage.Whencleaningtheburners,ensurethatallthe
flameportsarefreeofanyblockage.Ifnecessary,usea
toothpickorbrushtoclearports.Theoutersurfaceofthe
burnercapshaveapolishedfinishandextracareneedsto
betakentoavoidscratchingthissurfaceduringcleaning.In
instancesofheavysoiling,itmaybenecessarytoapplya
non-abrasivecleaningcompoundandrubwithaclothuntil
thesoilingisremovedandthenfinishwithasoft,drycloth.
NOTE! DO NOT place trivets or burners in the dishwasher.
Ignition spark plug and flame safeguard sensor
GENTLYcleantheignitionsparkplugandflamesafeguard
sensorwithadampclothtoavoidlightingdifficulties.
Ensurethattheyaredrybeforeuse.
Injector
Ensuretheinjectorremainsfreeofanyforeignmaterial.
Ifnecessary,useathinpieceofwiretocleartheorifice.

5electrolux gas cooktops troubleshooting
Ifyouhaveaproblemwiththecooktop,checkthetable
below.Youmaybeabletosolvetheproblemandthiswill
saveyoufrompayingforaservicecall.Youmayhaveto
payforaservicecalleveninthewarrantyperiodifthe
problemisonelistedbelow.
Troubleshooting
Fault Possible Cause Remedy
Burnerwillnotlighteventhough
thesparkerisworking.
Gassupplyvalveturnedoff. Turnongassupplytoappliance.
Wrongknobturned. Ensuretheknobyouareturning
correspondstotheburneryouwanttolight.
Portblockageinignitionarea. Ensurethatportsinignitionareaareclean
anddry.
Ignitionsparkplugswetordirty. Dryorcleanignitionsparkplugs.
Nosparkisobtainedwhen
controlknobisactivated.
Electricitysupplyisdisconnectedor
switchedoff. Switchonelectricityorcheckfuses.
Ignitionsparkplugswetordirty. Dryorcleanignitionsparkplugs.
Flamesunevenortendingtolift.
Flameportsblockedorwet. Cleanordryameports.
Burnercapincorrectlytted. Ensurethiscomponentisttedcorrectly.
Flamesnotstayingon
whenknobisreleased.
Knobnotsetbetween‘HIGH’and
‘LOW’.
KnobMUSTbesetbetweenthese
positions.
Dirtorspillageonamesafeguard
sensor. Cleanamesafeguardsensortip.
Lowheat,slowcooking. Incorrectcookingpotorpanbeing
used.
RefertoFigure4(page3).
Benchtoporknobsoverheating.
Incorrectcookingpotorpanused. CheckFigure4(page3)forcorrectpotor
pantobeused.
Potorpannotlocatedonburner
properly.
Ensurepotorpaniscentrallylocatedon
burner.
Table1

electrolux gas cooktops technicaldata6
We reserve the right to alter these specifications.
This appliance conforms to AS 4551.
Technicaldata
Features EHGC93CI EHGF93CX
Cookingzones 3 3
Wok Yes,triplering Yes,triplering
Ignition 220-240V 220-240V
Trivet Cast Cast
Hobmaterial Ceramicglass Stainlesssteel
Features Ignitionthroughknobs Ignitionthroughknobs
Flamesafeguard Yes Yes
Colours Black Stainlesssteel
Gastypes NG,(LPconversion
kitsupplied)
NG,(LPconversion
kitsupplied)
Cooktop dimensions mm
Width 910 910
Depth 410 410
Height 58 58
Cut out dimensions mm
Width 880 880
Depth 380 380
Energy rating (NG) – MJ/h
Smallburner 5.1 5.1
Mediumburner 9.0 9.0
Wokburner 15.0 15.0
TotalMJ/h 29.1 29.1
Table2

7electrolux gas cooktops installation
Thisappliancemustbeinstalledbyanauthorisedperson
andincompliancewith:
1. AS 5601 ‘Gas Installations’ (Australia) or NZS
5261 ‘Installation of Gas Burning Appliances and
Equipment’ (New Zealand)ortherelevantinstallation
codeforgasappliancesofyourcountry.
2. Thelocalgasfittingregulations,municipalbuilding
codes,electricalwiringregulationsandanyother
relevantstatutoryregulations.
3. Theparticularinstructionsasgivenbelow.
Installationinstructions
caution

Cooktopsaresuppliedsetupfornaturalgas(NG).
TouseonLPG,theinjectorsmustbechangedusing
theconversionkitsupplied.ReferLPconversionon
page10.
4. AcertificateofcomplianceMUSTbegiventothe
customeraftertheapplicationissuccessfullyinstalled.
Figure5a–ProudFit
17
914
414
17
110min*
880
380
133min*
+1
0
+1
0
Gassupply
connection
location
R7TYP
*tocombustiblesurface
Figure5b–FlushFit
Gassupply
connection
location
Theflushfitrecessis5mmdeep.ReferFigure6bforside
viewdetail.
Figure6b–FlushFit
Hob
Benchtop
Springclip
Burnerbox
positioningclip
location
Figure6a–ProudFit
Foamseal Hob
Springclip
Burnerbox
Benchtop
Silicone
5mm
+0.5
0
Figure7
2mm
46mm

46mm
electrolux gas cooktops installation8
Installationprocedure Installationprocedure
Figure8
1. Thebenchcutoutshouldbemadeaspercutout
dimensionsinTable2andFigure5.
2. Adjacent walls, cupboards and protection for
combustible materials:Ensurethattheapplianceis
installedwithSection5.12.1ofAS5601(Australia)or
Section14.1ofNZS5261(NewZealand),regarding
clearancestocombustiblesurfacesandmaterials,and
clearancetorangehoodsandexhaustfans.
 Toensureclearancesof200mmfromburnerstovertical
combustiblesurfacesobservethedimensionsshownin
Figure8.
 Clearancestocombustiblematerialsmaybereducedif
combustiblesurfacesareprotectedinaccordancewith
clause5.12.1.2ofAS5601(Australia)orsection14.1.2
ofNZS5261(NewZealand).
3. Optional barrier:Abarriercanbeinstalledtoprevent
accidentalcontactwiththecooktopbase,wherethe
baseofthecooktopisaccessiblefrombelow(ieinside
acupboard,etc).Aminimumclearanceof15mmis
requiredbetweenthebaseandthebarrier.Thisbarrier
maybemadeofanynon-combustible,rigidmaterial.
4. AFOAMSEALhasbeenprovidedandistobeapplied
alongtheperimeterofthehob.
5. Fitthepositioningclipssuppliedtoensurethatthe
cooktopcannotmoveafterinstallation.
warning
Failure to fix the positioning clips could result in
loosening of the gas connection through movement
of the cooktop and a gas leak may result.
Installeightpositioningclipsintospecialholesonthesides
oftheappliance(seefigure7).Placeapplianceintocut-out
andcheckthefit.Theapplianceshouldbeagoodfitand
notmoveinanydirection.
96mm
Combustiblesurface
66mm
106mm
Flush fit installation method
Important note:Allcut-outsinthebenchtopareaareto
becarriedoutataspecialistworkshop.
Thecutmustbecleanandprecise,sincethecutedgeis
visibleonthebenchtopsurface.Thestabilityoffurniture
beingworkedonmustbeensuredfollowingthecut-outs.
Usespecialheatandwaterresistantbenchtops(e.g.
naturalstoneortiled).Seefigures5band6bforcutting
dimensions.
Placethehobintothecut-outandalignit,ensuringthe
gapsaroundtheedgesbetweenthehobandthebenchtop
areevenonallsides.Fitpositioningclipsasshowninfigure
6atthelocationpointsshowninfigure7.
Checkthefunctionandlocationofthehob.
Fillthegapsbetweenthehobandbenchtopwithasuitable
commercialsiliconesealantinacolourofyourchoice.
caution

Use of an unsuitable silicone sealant on natural stone
benchtops can cause permanent discolouration.
Beforethesiliconesealantstartstoformaskin,moisten
abladeoryourfingerwithasoapysolutionandsmooth
itover.Thehobshouldonlybeusedoncethesilicone
sealanthashardened.
Do not use foam seal in this application.

9electrolux gas cooktops gasconnection
Gas connection
This appliance is supplied for use with Natural Gas.
However, it can be converted for use with LPG. Refer
to LP conversion on page 10.
Supply pipe sizing
Thetotalhourlygasconsumptionfortheapplianceis
shownonthedatalabel.Therequiredsupplypressure
(i.e.atinlettoapplianceregulator)foreachgastypeis
shownonthedatalabel,andgiveninTable3(page10).
Usethisinformationinconjunctionwiththelengthofrun,
numberofelbows,teesandbends,theavailableservice
pressureandthesupplyrequirementsofotherinstalled
appliancestodetermineasuitablepipesize.
Forassistanceinthismatterrefertotheappropriate
sectionoftheInstallationCodeAS5601.
AnAGAcertifiedclassBorDflexibleconnectionmay
beusedtoconnectthecooktopinaccordancewith
theAS5601andinparticularsection4.8.Whereahose
assemblyisusedandthecooktopisintheinstalled
position,thehoseassemblyshallbesuitableforconnection
toafixedconsumerpipingoutletlocatedatapoint
800–850mmabovethefloorandintheregionoutside
thewidthoftheappliancetoadistanceof250mm.The
pointofconnectiontoconsumerpipingmustbeaccessible
withapplianceinstalled.
Elbow positioning
Itispossibletorepositiontheelbowifrequiredby
looseningthelockingnutandelbowbyusingtwo
spanners.Re-tightentheentireassemblyaftertheelbow
hasbeenrepositioned.Whenfittingelbowtoappliance,
ensurethatthesealingwasherisfitted.
Regulator
Anapplianceregulatorisprovided.Theregulatormustbe
positionedsothatthepressuretestnippleisaccessible
whentheapplianceisinstalled.
Connectthegassupplytothe½”B.S.P.internalthread
inletoftheregulator.Referto‘benchcutout’(Figure6)for
connectionpointposition.
Regulatorsaresuppliedpre-adjustedandconfiguredbythe
componentmakerforusewithNaturalGas.
Theapplianceinstallerisnotrequiredtomakean
adjustmenttoobtainthecorrectoutletpressuresetting.
Anarrowonthebaseoftheregulatorindicatesthe
directionofgasflowwhentheinletandoutletofthe
regulatorisorientatedcorrectly.Whentheregulatorhas
beenfittedcheckforleaksfromtheconnectionswith
soapywater.
OperationonN.G./S.N.G. OperationonN.G./S.N.G.
Assembly of Regulator
Theassemblyoftheregulatortothecooktopmanifoldis
achievedviatheelbowunionandsealingwashersupplied,
refertofigure9.
The½”parallelthreadconnectstothemanifold,andthe
sealingwasherisplacedbetweenthemanifoldendand
theflatfaceontheelbow.
The½”taperedthreadconnectstotheoutletofthe
regulator,andissealedonthethreadusingapproved
threadsealingtapeorapprovedthreadsealingcompound.
Theinletoftheregulatorisa½”parallelthreadand
isconnectedtoconsumerpipingorhoseassembly.
Regulatorsaresuppliedpre-adjustedandconfigured
bythecomponentmakerforusewithNaturalGas.
Theapplianceinstallerisnotrequiredtomakean
adjustmenttoobtainthecorrectoutletpressuresetting.
Anarrowonthebaseoftheregulatorindicatesthedirection
ofgasflowwhentheinletandoutletoftheregulatoris
orientatedcorrectly.Whentheregulatorhasbeenfitted
checkforleaksfromtheconnectionswithsoapywater.
Figure9
½”Taperedthread
Sealusingapproved
sealingtapeor
approvedthread
sealingcompound
Manifold
endform
Femalenut Flatface
Sealing
washer
½”Parallel
thread
Regulator
Outlet
Inlet

electrolux gas cooktops LPGasConversion10
Checkingthegassupply
1. Checkthemanometerzeropointiscorrect.
2. Connectthemanometertothecooktoppressurepoint.
Thisislocatedontheregulator.
3. Turnonthegassupplyandelectricityandtrytoignite
thegas.
NOTE! It will take additional time to light the gas for the first
time as air needs to be purged from the pipes.
4. Withtheapplianceoperatingchecktheoutletpressure
 • whenallburnersoftheapplianceareoperatingat
maximum,
 • whenthesmallestburneroftheapplianceis
operatingatminimum.
Undertheseconditionstheoutletpressureshouldnot
varyfromthenominaloutletpressureof1.00kPaby
morethan ± 0.20kPa.
Iftheregulatorappearstonotbeperformingsatisfactorily,
thencheckthefollowingpoints.
1. Iftheoutletpressureisconsistentlytoolowthenthe
inletpressuremaybetoolowandadjustmentofan
upstreamregulatormaybeneeded,oranupstream
regulatororvalvewithinsufficientflowcapacitymay
bepresentinthegassupplyline.Ifthisissuspected
thenitmaybenecessarytorepeatthecheckswhilst
measuringboththeinletandoutletpressureto
determineiftheinletpressureisintherange
1.13–5kPa.
2. Checkthattheregulatorhasbeenfittedtothegas
supplylineinthecorrectorientation,thearrowonthe
baseofthebodyindicatesthedirectionofgasflow.
Oncethesecheckshavebeencompleted,iftheregulator
stillfailstoperforminasatisfactorymanneritshouldbe
replaced.
Table3
Burner type
Natural Gas (Nominal test point pressure: 1.00kPa) LPG (Nominal test point pressure: 2.60kPa)
Injector size (mm) Gas consumption (MJ/h) Injector size (mm) Gas consumption (MJ/h)
Smallburner 1.00 5.1 0.55 4.2
Mediumburner 1.35 9.0 0.70 6.5
Wokburner 1.80 15.0 1.00 13.2
LPConversion–Important
This appliance is fitted with Natural Gas
burner injectors.
Pleasefollowtheprocedurebelowifaconversiontosuit
LPgasisrequired.
TheconversionkitcontainsappropriateLPGinjectorsand
1LPGsticker.
1. Removethehotplateburnerstoaccessthehotplate
injectors.ReplacethefactoryfittedNGinjectorswiththe
appropriateinjectors,assupplied(seeTable3).
2. Unscrewthehexnutfromtheregulator.Thehexnut,
brasswasherandnyloninsertwilldisengageasan
assembly.
3. Unclipthenyloninsertandnutassemblybyrotatingthe
insert¼turn,andpullingitfree.
4. Turnovertheinsertandclipbackintoposition.
5. Refitthehexnutassemblytotheregulatorensuringthat
itisfullyscreweddown.Theregulatorisnowsetfor
connectiontoLP.
6. Turnonthegassupplyandateachnewconnection
checkforleaksusingsoapywater:eachhotplatevalve
shouldbeturnedon,oneatatime,andtheinjector
holeblankedoffforseveralseconds.
7. Theoperationoftheregulatorcanbeconfirmedby
connectingamanometertothepressuretestpoint
locatedonthesideoftheregulatorbodyadjacentto
theoutlet.
Withtheapplianceoperatingchecktheoutletpressure
 • whenallburnersoftheapplianceareoperating
atmaximum,
 • whenthesmallestburneroftheapplianceisoperating
atminimum.
Undertheseconditionstheoutletpressureshouldnotvary
fromthenominaloutletpressureof2.60kPabymorethe
+/-0.52kPa.
8. Iftheregulatorappearstonotbeperforming
satisfactorilythencheckthefollowingpoints.
 • Iftheoutletpressureisconsistentlytoolowthenthe
inletpressuremaybetoolowandadjustmentofan
upstreamregulatormaybeneeded,oranupstream
regulatororvalvewithinsufficientflowcapacitymay
bepresentinthegassupplyline.Ifthisissuspected
thenitmaybenecessarytorepeatthecheckswhilst
measuringboththeinletandoutletpressureto
determineiftheinletpressureisintherange
2.75–7.00kPa.

11electrolux gas cooktops LPGasConversion
Hexnut
assembly,fully
screweddown
Hexnutassembly,
removed
fromregulator
andinsert
disassembled
Insert
oriented
forLPG
operation
Figure10
Insert
orientedfor
naturalgas
operation
 • Checkthattheinserthasbeenfittedcorrectly
  asperdiagramfigure10.Checkthatthehexnutis
fullyscreweddown.
 • Checkthattheregulatorhasbeenfittedtothegas
supplylineinthecorrectorientation,thearrowonthe
baseofthebodyindicatesthedirectionofgasflow.
Oncethesecheckshavebeencompleted,iftheregulatorstill
failstoperforminasatisfactorymanneritshouldbereplaced.
9. Onebyone,turntheknobstominimumandscrew
inthebypassscrew(accessiblewhentheknobis
removed)untilasmallstableflameresults.Turnthe
knobtomaximumandthenbacktominimumtoensure
thatthecorrectminimumflameismaintained.
10.AttachtheLPGstickertothecooker,nearthegassupply
inlet.CovertheNaturalGaslabelthatisfactoryfitted.

electrolux gas cooktops electricalconnection12
Electricalconnection(220-240Volts)
Appliancesaresuppliedwithastandard7.5Amp
servicecordterminatedbya3-pinplugforconnection
toastandardhouseholdsocket.Theelectricalsupplyis
requiredtopowertheelectronicignitionsystem.
NOTE! It will be necessary for servicing purposes to
disconnect the electrical power supply. The power
point should therefore be accessible after the appliance
is installed, as specified in the local wiring regulations.
Diagram1belowisaschematicofthewiringinthe
appliance.
WEIGHT oftheunitisprintedontheappliance
packaginglabel.
Use of hose assemblies
Ensurethatthehoseassemblyisrestrainedfromaccidental
contactwiththeflueoutletofanunderbenchovenorany
otherhotsurfaceofanadjacentappliance.
Diagram1
DANGER
220-240V VOLTS AC
DISCONNECT FROM SUPPLY
BEFORE REMOVING PANEL
E
EBODY
2200W
INDUCTION
MODULE
1400W
INDUCTION
MODULE
220-240V
T- ZERO MODULE
220-240V
IGNITION BOX
KNOB IGNITION SWITCH
TO BURNER
THERMOCOUPLE
THERMOCOUPLE
COIL
TO BURNER
SPARK PLUG
BODY
EMC
POWER
FILTER
NL
E
NL
E
E
N
NN L
LN
LSw Sw
LL
N
L
N
NL 15A
TO BURNER
SPARK PLUG
BODY
220-240V
IGNITION BOX
LN
KNOB
IGNITION
SWITCHES
TO BURNER
THERMOCOUPLE
THERMOCOUPLE
COILS
NN LLSw Sw
220-240V
T-ZERO MODULE
E
DANGER
220-240V VOLTS AC
DISCONNECT FROM SUPPLY
BEFORE REMOVING PANEL
NLE
BODY

13electrolux gas cooktops testingtheappliance
Afterinstallation,testtheapplianceandensurethatit
operatescorrectlybeforehandingitovertothecustomer.
Thefollowingprocedureisrecommended:
1. Turnonthegasandelectricitysupplyandattempt
ignitiononallburners,bothseparatelyandin
combination.(Forcorrectprocedurerefertopage3
LightingBurners).Notethatadditionaltimeneedsto
beallowedfortheinitiallightingasairhastobepurged
fromthepipes.
2. Observetheflameappearanceoneachburner
(Figure11).Ifitismuchlargerormuchsmallerthan
expected,theinjectorsizeandsupplypressurerequire
checking.Whereaflameisunsatisfactory,refertothe
TroubleshootingGuide(page5)tocorrectthefault.If
theTroubleshootingGuidedoesnotsolvetheproblem,
calltheServiceCentre.
3. Whenalltheforegoingissatisfactory,checkthe
turndown(minimumorlow)settingoneachburner,
asthismayneedadjustment.Valveshaveabypass
controllingscrew,whichmaybeaccessedbyremoving
theknob.Thisscrewwillbelocatedonaparticulararea
ofthevalve(referFigure12).Normally,thiswillhave
beencorrectlysetatthefactoryforuseonNaturalGas
(NG)andshouldnotrequireadjustment.
tips and information
 IftheappliancehasbeenconvertedtoLPG,thenthe
bypassscrewwillHAVE tobescrewedinuntilasmall,
stableflameresults.
Please ensure the supply pressure has been
checked PRIOR to any adjustment.
4. Iftheappliancecannotbeadjustedtoperformsafely
informthecustomeroftheproblemandaffixan
appropriatewarningnoticetotheappliance.Ifthefault
appearstobedangeroustheapplianceshouldbe
disconnected.Ifaminorfaultexists,thecustomermay
wishtousetheappliancewhileawaitingservice.
 Ifafaultcannotbefixed,pleasecalltheServiceCentre.
5. Thecustomershouldbeadvisedthat,intheevent
ofafault,thelocalserviceorganisationortheretailer
fromwhomtheappliancewaspurchasedshouldbe
contacted.
6. Whensatisfiedthattheunitisoperatingcorrectly,turn
offandinstructthecustomeroncorrectoperationas
outlinedinthisbooklet.Askthecustomertooperate
thecontrolstoensurethatthecorrectprocedureis
understood.
Testingapplianceoperation
Flamesizeadjustedtomaximum
Flamesizeadjustedtominimum
Bypassscrew
Figure11
Figure12
caution
Servicing must only be carried out by an authorised
service person.
Injectorsizesrequiredforvariousgastypesareshownin
Table3(page10).Theappliancetestpointpressurefor
eachgastypeisalsoshown.
Formodelidentificationafterinstallation,anadditionaldata
platestickerhasbeenprovided.Thisstickeristobestuck
ontoadjacentcabinetry.

caution


It is important to use your cooktop safely. Check these
safety points before using your cooktop.
This appliance has been designed for built in application
only. It may only be used after correct installation into suitable
bench top which complies with all mandatory standards.
In the event of faults with this appliance or damage to the
glass ceramic (cracks, or breakages), the appliance must
be switched off and disconnected from the electrical sup-
ply, to prevent the possibility of an electric shock.
Repairs to the appliance must only be carried out by
trained registered service technicians.
Cables from electrical appliances must not touch the hot
surface of the appliance or hot cookware.
The appliance must always be attended during use as
overheated fats and oils can ignite very quickly and is a
potential fire hazard.
This appliance should be used only for normal domestic
cooking and heating of food.
Ensure burner caps and crowns are in their correct position.
This appliance is not intended for use by persons (including
children) with reduced physical, sensory or mental capabili-
ties, or lack of experience and knowledge, unless they have
been given supervision or instruction concerning use of the
appliance by a person responsible for their safety.
Children should be supervised to ensure they do not play
with this appliance.
During use, this appliance becomes hot. Care should be
taken to avoid touching hot surfaces. To avoid burns,
young children should be kept away.
This appliance must not be used as a space heater.
Keep vents clear of obstructions.
In order to avoid a fire, this appliance must be
kept clean.
Do not spray aerosols in the vicinity of this appliance
while it is in operation.
Do not store flammable materials on or under this
appliance, eg. aerosols.
Do not remove the trivet and enclose the burner with a
wok stand as this will concentrate and deflect heat onto
the burner.
Do not use large pots or heavy weights which can
bend the trivet or deflect flame onto the burner.
Do not place anything, eg. asbestos mat between pan
and trivet as serious damage to the cooktop
may occur.
For maximum stability, ensure pots and pans are
centrally located on the trivets.
Handles should be turned away from the front of the
bench to avoid accidents.
Do not modify this appliance.
General Warnings
safety instructions 1
Pleasereadtheusermanualcarefullyandstoreinahandy
placeforlaterreference.Passtheusermanualontopos-
sible new owners of the cooktop.
The symbols you will see in this booklet have these meanings:
warning
This symbol indicates information concerning your
personal safety
caution
This symbol indicates information on how to avoid damag-
ing the cooktop
tips and information
This symbol indicates tips and information about use of
the cooktop
environmental tip
This symbol indicates tips and information about economi-
cal and ecological use of the cooktop
Meaningsofsymbolsusedinthismanualareshownbelow:
This symbol indicates never to do this
This symbol indicates always do this
warning
•Donotallowpotstoboildry,asdamagetobothpanand
cooktop may result.
•Donotoperatethecooktopforanextendedperiodof
time without a pot or pan on the burner.
•Donotallowlargecookwaretooverhangthecooktop
onto adjacent benchtop. This will cause scorching to the
benchtop surface.
•Donotallowcookingpotsorpanstointrudeintothe
area which is close to the controls.
•Ensureburnerbodiesandtrivetsareproperlylocated
(see Figure 3).
warning
The appliance may only be installed and connected by a
qualified person.
warning
ThisapplianceMUSTbeconnectedtoanearthed
power socket.


-
-




BeforeCallingaServiceTechnicianpleasecheckcarefullytheoperatinginstructions,servicebookletandthewarrantytermsandconditions.

or to find the address of your nearest
state service centre in Australia

For the cost of a local call (Australia only)

ELECTROLUXHOMEPRODUCTS
www.electrolux.com.au

or to find the address of your nearest
state spare parts centre in Australia

For the cost of a local call (Australia only)

or to find the address of your nearest
authorised service centre in New Zealand

(New Zealand only)

ELECTROLUXHOMEPRODUCTS
www.electrolux.co.nz

or to find the address of your nearest
state spare parts centre in New Zealand

(New Zealand only)






1. In this warranty
 (a) ‘Electrolux’meansElectroluxHomeProductsPtyLtdABN51
004 762 341 in respect of Appliances purchased in Australia and
Electrolux (NZ) Limited in respect of Appliances purchased in New
Zealand;
(b) ‘Appliance’ means any Electrolux product purchased by you
accompanied by this document;
 (c) ‘WarrantyPeriod’means
(i) where you use the Appliance for personal, domestic or household
purposes in Australia the period of ‘24’ months and in New
Zealand the period of ‘24’ months;
(ii) where you use the Appliance for commercial purposes, in
Australia the period of ‘3’ months and in New Zealand the period
of ‘3’ months, (if the period stated is 0 months you are not
covered by this product warranty) following the date of original
purchase of the Appliance;
(d) ‘you’ means the purchaser of the Appliance not having purchased
the appliance for re-sale, and ‘your’ has a corresponding meaning.
2. This warranty only applies to Appliances purchased and used in
Australia or New Zealand and is in addition to (and does not exclude,
restrict, or modify in any way) any non-excludable statutory warranties
in Australia or New Zealand.
3. Electrolux warrants that, when dispatched from an Electrolux
warehouse, the Appliance is free from defects in materials and
workmanshipfortheWarrantyPeriod.
4. DuringtheWarrantyPeriodElectroluxoritsAuthorisedServiceCentre
will, at no extra charge if your appliance is readily accessible without
special equipment, and subject to these terms and conditions, repair
or replace any parts which it considers to be defective. Electrolux or
itsASCmayusereconditionedpartstorepairyourappliance.You
agree that any replaced Appliances or parts become the property of
Electrolux. This warranty does not apply to light globes, batteries, filters
or similar perishable parts.
5. PartsandAppliancesnotsuppliedbyElectroluxarenotcoveredbythis
warranty.
6. Where you are within an Electrolux service area, this warranty covers
thecostoftransportoftheAppliancetoandfromAuthorisedService
Centres of Electrolux and travelling costs for representatives of the
AuthorisedServiceCentretoandfromyourhomeorbusiness.Ifyou
are outside an Electrolux service area, you will bear these costs. For
information about whether you are within an Electrolux service area,
please phone 13 13 49 in Australia, or 0800 10 66 10 in New Zealand.
7. Proofofpurchaseisrequiredbeforeyoucanmakeaclaimunderthis
warranty.
8. Youmaynotmakeaclaimunderthiswarrantyunlessthedefect
claimed is due to faulty or defective parts or workmanship. Electrolux is
not liable in the following situations (which are not exhaustive):
(a) The Appliance is damaged by:
(i) accident
(ii) misuse or abuse, including failure to properly maintain or service
(iii)normal wear and tear
(iv) power surges, electrical storm damage or incorrect power
supply
(v) incomplete or improper installation
(vi) incorrect, improper or inappropriate operation
(vii) insect or vermin infestation.
(b) The Appliance is modified without authority from Electrolux in
writing.
(c) The Appliance’s serial number or warranty seal has been removed
or defaced.
(d) The Appliance was serviced or repaired by anyone other than
ElectroluxoritsAuthorisedServiceCentres.
9. This warranty, the contract to which it relates and the relationship between
you and Electrolux are governed by the law applicable in the Australian
StatewheretheAppliancewaspurchasedorthelawapplicableinNew
Zealand if the Appliance was purchased in New Zealand. Where the
Appliance was purchased in New Zealand for business purposes the
Consumer Guarantee Act does not apply.

10.To the extent permitted by law:
(a) Electrolux excludes all warranties other than as contained in this
document;
(b) Electrolux shall not be liable for any loss or damage whether direct
or indirect or consequential arising from your purchase, use or non-
use of
the Appliance.
11.ProvisionsoftheTradePracticesActandStateconsumerlegislation
inAustralia,andtheConsumerGuaranteesAct,theSaleofGoods
Act and the Fair Trading Act in New Zealand, imply warranties or
conditions, or impose obligations, upon Electrolux which cannot be
excluded, restricted or modified. To the extent permitted by law, the
liability of Electrolux (if any) arising out of or in relation to the Appliance
or any services supplied by Electrolux shall be limited (where it is fair
and reasonable to do so),:
(a) in the case of Appliances, at its option, to the replacement or
repair of the Appliances or the supply of equivalent products or
the payment of the cost of replacing the Appliances or having the
AppliancesrepairedorofacquiringequivalentAppliances.Upon
being replaced, parts and Appliances become the property of
Electrolux; or
(b) in the case of services, at its option, to the supply of the services
again or the payment of the cost of having the services re-supplied;
and in the case of Appliances or services supplied in New Zealand, loss
or damage whether direct or indirect or consequential that is reasonably
foreseeable.

Youacknowledgethatintheeventthatyoumakeawarrantyclaimitwillbe
necessaryforElectroluxanditsAuthorisedServiceCentrestoexchange
information in relation to you to enable Electrolux to meet its obligations
under this warranty.
Warranty
FORSALESINAUSTRALIAANDNEWZEALAND
APPLIANCE:ELECTROLUX3BURNERGASCOOKTOPS
warranty 19


telephone: [phone]
fax: [phone]
email: [e-mail]
web: www.electrolux.com.au

phone: [phone]
fax: [phone]
email: [e-mail]
web: www.electrolux.co.nz

Do you remember the last time you opened a gift that made you say
“Oh! How did you know? That’s exactly what I wanted!” That’s the kind of
feeling that the designers at Electrolux seek to evoke in everyone who chooses
or uses one of our products. We devote time, knowledge, and a great deal of
thought to anticipating and creating the kind of appliances that our customers
really need and want.
This kind of thoughtful care means innovating with insight. Not design for
design’s sake, but design for the user’s sake. For us, thoughtful design means
making appliances easier to use and tasks more enjoyable to perform, freeing
our customers to experience the ultimate 21st century luxury: ease of mind.
Our aim is to make this ease of mind more available to more people in more
parts of their everyday lives, all over the world.
The “Thinking of you” promise from Electrolux goes beyond meeting the needs
of today’s consumers. It also means we’re committed to making appliances
safe for the environment – now and for future generations.

Sharemoreofourthinkingatwww.electrolux.com.au
P/No.305505000Rev.A
Printcode:EMAN_GASCT_Apr10
©Copyright20010ElectroluxHomeProductsPtyLtdABN51004762341