Elkay LK3001 Operating instructions

(2) 1/2 in Supply Lines
SAVE FOR CONSUMER
INSTALLATION / OWNER'S MANUAL
Groove joint pliers Wrench
You choose the flow rate!
This faucet ships with an
eco-friendly 1.5GPM flow regulator
installed.
If you desire higher flow rate, a
2.2GPM flow regulator has also
been included in the box.
Switching the flow regulator is
simple! See the "Flow Regulator
Replacement" section for details.
Important!
Plumber's Putty
Screwdriver Sealant Tape
OPTIONAL 2.2GPM
AERATOR INSERT
Single Handle Kitchen Faucet
Model # LK3001

Place handle assembly through side hole in sink.
Secure handle assembly with washer (1) and nut
(2). Make sure that the slot on nut is facing up.
Make sure handle is facing forward and it swings
equally in both directions.
Shut off water supplies. Place spout through
mounting hole in sink. Secure spout with rubber
washer (1), metal washer (2) and nut (3).
Push diverter connector (1) all the way up until
completely seated onto tube (2). Slide clip (3) into
diverter holes (4) to secure unit.
1
42
Insert hose guide (1) through the sink hole. From
underneath sink, secure hose guide (1) by screwing
mounting nut (2). Do not overtighten.
3
1
2
WARNING: Please carefully read and properly follow the instructions for installation found in this manual.
3-Ø1 3/8" (Ø35mm)
3
1
2
STEPS:
2
1

Insert side spray hose (1) through hose guide
and sink. Align block (2) and tabs (3) on quick
connect (4). Push quick connect housing firmly
upward and snap onto receiving block. Pull down
moderately to ensure connection has been made.
If it is necessary to remove quick connect,
squeeze tabs on hose between index finger and
thumb, then pull down to disconnect.
Make connections to water lines. Use 1/2" I.P.S.
faucet connections (1) or use coupling
nuts (3) with 3/8" O.D.ball-nose riser (2).Use
wrenches to tighten connections.
Do not overtighten.
Important: After installation is completed, remove
aerator assembly. Turn on hot and cold water
supplies. Turn handle to full open position for one
minute. Check for leaks. Replace aerator.
WARNING: Please carefully read and properly follow the instructions for installation found in this manual.
STEPS:
2
3
4
1
1
3
2

FLOW REGULATOR REPLACEMENT
CARE AND CLEANING INSTRUCTIONS
Congratulations on your purchase of an Elkay product.
Although your product is extremely durable, attention should
be given to the care, cleaning and maintenance of this
product. Cleaning agents and abrasives may cause damage,
which may result in oxidation and discoloration.
By following these simple guidelines for proper care and
cleaning, it will give you years of enjoyment:
TO CLEAN: Simply wipe gently with a damp cloth and blot dry
with a soft towel. A common rule of thumb is: when you dry off,
dry off your product.
·Avoid build-up of soap, toothpaste or mineral deposits, as
these tend to have an adverse effect on the appearance of
the product.
·NEVER use cleaning products of any kind on this product -
especially those containing ammonia, bleach or alcohol - or
those with any form of abrasive.
Shut off water supply. Remove set screw plug (1).
With valves in "closed" position, unscrew set screw
(2) and remove handle (3) from valve stem (4).
Loosen the screw (7) from valve stem (4). Loosen
the cap (5) from the cartridge nut (6).
2
1
3
3
7
5
4
6
2
1
FOR CARE AND MAINTENANCE:
·The water in certain areas of the world can be very caustic -
standing water around the product can cause damage. Be
sure to remove standing water with a dry, soft cloth as soon
as possible.
·For polished brass finishes, as often as once a week, you
can apply a paste wax or special, non-abrasive, brass
coating (DO NOT APPLY POLISH).
·Before applying a protective coating, gently brush the entire
fixture using a soft tooth brush. This will remove any dirt or
deposit build-up.
·These simple steps will add temporary protective coating to
your faucet and extend the life of the finish.
Failure to follow care and cleaning will void your warranty.
For additional information, please visit elkayusa.com.
Loosen cartridge nut (1) by turning it
counter-clockwise and lift out the cartridge (2).Insert
new cartridge and retighten the cartridge nut. Reinstall
the handle.
This faucet ships with a 1.5GPM aerator installed. An
optional 2.2GPM aerator is also included in the box.
To switch the flow rate of the faucet:
1. Disassemble aerator assembly by separating the
aerator shell (1), aerator (2) and washer (3). Remove
existing aerator (2) and install the new aerator.
(2.2GPM=Red, 1.5GPM=Green)
2. Reinstall the aerator assembly.
2
1
CARTRIDGE REPLACEMENT

P28137 Diverter
P70070 Clip
P48060 Diverter Connector and Hose
P46466 Block
P37142 O-Ring
Elkay
elkayusa.com
P35304 Rubber Washer
P35305 Metal Washer
P36167 Nut
P37146 O-Ring
P37142 O-Ring
P35299 Washer
P36166 Nut
P46466 Block
Model # LK3001
P99354 (Rev. date: 04/2011)
©2011 Elkay
P05138* 1.5GPM Aerator (Green)
ELKAY LIMITED LIFETIME WARRANTY
Elkay warrants that all parts and finishes of the Elkay Residential brand
faucets are free from defects in materials and workmanship for the life of
the product, if purchased after 1996. This warranty covers the
original consumer purchaser of the product only.
If the product should leak or drip during normal use, Elkay will provide,
free of charge, a replacement cartridge. For other defects in material or
workmanship, Elkay will, at its option, supply replacement parts (or if no
longer available a comparable product). Elkay reserves the right to
examine product in question and its installation prior to replacement.
What is not covered:
1. Damage caused by accident, negligence, misuse, abuse, improper
installation or operation or failure to follow care or installation instructions
enclosed with your product.
2. Damage occurring during shipment of the product (claims must be
presented to the carrier).
3. Normal wear and tear.
4. Labor charges, costs of removal and reinstallation, and any damages
to other property.
5. All industrial, commercial and business use whose purchasers are
hereby extended a limited lifetime on mechanical parts and 5 years on
finish.
P05139* 2.2GPM Aerator (Red)
ELKAY LIMITED LIFETIME WARRANTY
REPLACEMENT PARTS
What you must do to obtain warranty service:
Either write to Elkay, attention Customer Care, 2222 Camden Court,
Oak Brook, IL 60523 or call 1-800-223-5529. Please provide date of
purchase and installation, description of nature of the defect, and
model number or description of model and/or component part.
THIS LIMITED WARRANTY IS EXPRESSLY IN LIEU OF ANY
OTHER WARRANTIES, EXPRESSED IMPLIED, ARISING BY LAW
OR OTHERWISE, INCLUDING WITHOUT LIMITATION, ANY
IMPLIED WARRANTY OF MERCHANTABILITY OR FITNESS FOR
A PARTICULAR PURPOSE. THIS LIMITED WARRANTY MAY NOT
BE ALTERED, VARIED, OR EXTENDED, EXCEPT BY A WRITTEN
INSTRUMENT EXECUTED BY ELKAY. THE REMEDY OF REPAIR
OR REPLACEMENT AS PROVIDED UNDER THIS LIMITED
WARRANTY IS EXCLUSIVE. IN NO EVENT SHALL THE
MANUFACTURER BE LIABLE FOR ANY CONSEQUENTIAL OR
INCIDENTAL DAMAGES TO ANY PERSON, WHETHER OR NOT
OCCASIONED BY NEGLIGENCE OF ELKAY, INCLUDING WITHOUT
LIMITATION DAMAGES FOR LOSS OF USE, COSTS PROPERTY
DAMAGE OR OTHER MONETARY LOSS.
Some states do not allow the exclusion or limitation of incidental or
consequential damages or limitations on how long an implied warranty
lasts, so the above limitations or exclusions may not apply. This
warranty gives you specific legal rights and you may also have other
rights which vary from state to state.
This warranty covers product installed in the United States and Canada.
P01297* Handle Kit
Spout
RP70023 Clip
RP60008 O-Ring
RP64158 Wearable Ring
LK3001 Spout Base
P36163 Screw
RP80004* Cap
P29247 Cartridge
RP70085 Cartridge Nut
P45746* Spray
LK3001 Handle Base
P38112 Set Screw Plug
P38111 Set Screw
P01296* Handle
WARRANTY