Empire Comfort Systems PIONEER LPR36-1 User manual

35989-0-0615 Page 1
EMPIRE
EMPIRE
Comfort Systems
INSTALLATION
INSTRUCTIONS
IMPORTANT! Read these instructions carefully
before installing or operating this gas appli-
ance. These instructions should be left with the
homeowner for future reference.
WARNING: If the information in this manual
is not followed exactly, a re or explosion
may result causing property damage, per-
sonal injury or loss of life.
WARNING: This log set is to be installed only
in a solid-fuel burning replace with a working
ue constructed of non-combustible material.
The vent damper must also have a damper
clamp attached to it to keep the damper from
accidentally closing during operation.
PIONEER
VENTED DECORATIVE GAS LOG SET
MODELS
LPR36-1
For use on burner model:
BX36N-1
CONGRATULATIONS on the purchase
of your new DECORATIVE VENTED GAS
LOG SET! Your Decorative Gas Log Set is
designed and intended for installation in
an approved, existing, fully vented, wood-
burning replace, with a gas hook-up.
Once you place the brick riser and base
logs, you are free to arrange the remaining
logs to suit your taste and even re-arrange
them from time to time to suit your whimsy.
The log placement shown in this manual
replicates the set-up shown in the brochure
and provides a great ame pattern.

35989-0-0615Page 2
LOG A - Rear Log
Part No. R12194
LOG B - Front Left Log
Part No. R12192
LOG C - Front Right Log
Part No. R12193
LOG D - Left Log
Part No. R12190
LOG E - Curved Log
Part No. R12189
LOG F - Forked Log
Part No. R12191
LOG G - Curved Branch
Part No. R12187
LOG H - Charred Chunk
Part No. R12185
LOG I - Large Knotted Log
Part No. R12188
LOG IDENTIFICATION

35989-0-0615 Page 3
LOG IDENTIFICATION
LOG J - Short Y Log
Part No. R12183
LOG K - Pegged Y Log
Part No. R12186
LOG L - Y Branch
Part No. R12181
LOG M - Curvy Y Log
Part No. R12182
LOG N - Straight Log
Part No. R12184
LOG O - Small Knotted Log
Part No. R12195
LOG P - O Log
Part No. - R12196
LOG Q - Small Charred Log
Part No. - R12197
Note: Logs are not shown to scale.
Note: Logs may differ from those shown.

35989-0-0615Page 4
LOG PLACEMENT
1. Attention: The placement of the logs in this step is mandatory. Place Logs A through G as shown.
G
D
B
A
C
FE
2. Empire recommends placing the remaining logs as shown. However, placement of Logs H through Q is at the discretion of the
homeowner.
Note: Log A is hidden behind logs.
H
BC
D
E
F
G
I
J
K
LM
N
OPQ

35989-0-0615 Page 5
To Order Parts Under Warranty, please contact your local Empire dealer. See the dealer locator at www.empirecomfort.
com. To provide warranty service, your dealer will need your name and address, purchase date and serial number, and the
nature of the problem with the unit.
To Order Parts After the Warranty Period, please contact your dealer or one of the Master Parts Distributors listed below.
This list changes from time to time. For the current list, please click on the Master Parts button at www.empirecomfort.com.
Please note: Master Parts Distributors are independent businesses that stock the most commonly ordered Original
Equipment repair parts for Heaters, Grills, and Fireplaces manufactured by Empire Comfort Systems Inc.
MASTER PARTS DISTRIBUTOR LIST
Parts Not Under Warranty
Parts can be ordered through your Service Person, Dealer, or a Master Parts Distributor. See this page for the Master Parts Distribu-
tors list. For best results, the service person or dealer should order parts through the distributor. Parts can be shipped directly to the
service person/dealer.
Warranty Parts
Warranty parts will need a proof of purchase and can be ordered by your Service Person or Dealer. Proof of purchase is required for
warranty parts.
All parts listed in the Parts List have a Part Number. When ordering parts, rst obtain the Model Number and Serial Number from the
name plate on your equipment. Then determine the Part Number (not the Index Number) and the Description of each part from the fol-
lowing illustration and part list. Be sure to give all this information . . .
Appliance Model Number Part Description
Appliance Serial Number Part Number
Type of Gas (Propane or Natural)
Do not order bolts, screws, washers or nuts. They are standard hardware items and can be purchased at any local hardware store.
Shipments contingent upon strikes, res and all causes beyond our control.
HOW TO ORDER REPAIR PARTS
Dey Distributing
1401 Willow Lake Boulevard
Vadnais Heights, MN 55101
Phone: [phone]
Toll Free: 800-397-1339
Website: www.deydistributing.com
Parts: Heater, Hearth and Grills
Victor Division of F. W. Webb Company
200 Locust Street
Hartford, CT 06114
Phone: [phone]
Toll Free: 800-243-9360
Fax: [phone]
Toll Free Fax: [phone]
Websites: www.fwwebb.com & www.victormfg.com
Parts: Heater, Hearth and Grills
East Coast Energy Products
10 East Route 36
West Long Branch, NJ 07764
Phone: [phone]
Toll Free: 800-755-8809
Fax: [phone]
Website: www.eastcoastenergy.com
Parts: Heater, Hearth and Grills

35989-0-0615Page 6
APPLIANCE SERVICE HISTORY
Date Dealer Name Service Technician Name Service Performed/Notes

35989-0-0615 Page 7
APPLIANCE SERVICE HISTORY
Date Dealer Name Service Technician Name Service Performed/Notes

35989-0-0615Page 8
EMPIRE
EMPIRE
Comfort Systems
Empire Comfort Systems Inc.
918 Freeburg Ave. Belleville, IL 62220
If you have a general question about our products, please e-mail us at
[email protected].
If you have a service or repair question, please contact your dealer.
www.empirecomfort.com