Empire Comfort Systems Boulevard LS41THF-1 Quick start guide

LOG SET FOR USE WITH
DIRECT VENT FIREPLACE
MODELS:
DVTL41BP90(N,P)-1
WARNING: If not installed, operated and maintained
in accordance with the manufacturer's instructions,
this product could expose you to substances in fuel
or from fuel combustion which can cause death or
serious illness.
INSTALLER: Leave this manual with the appliance.
CONSUMER: Retain this manual for future
reference.
GAS-FIRED
INSTALLATION INSTRUCTIONS
AND
OWNER’S MANUAL
EMPIRE
EMPIRE
Comfort Systems
LS41THF-1
CHARRED LOGS
WARNINGS
If the information in this manual is not followed ex-
actly, a re or explosion may result causing property
damage, personal injury or loss of life.
– Do not store or use gasoline or other ammable
vapors and liquids in the vicinity of this or any
other appliance.
– Installation and service must be performed by a
qualied installer, service agency or the gas sup-
plier.
WHAT TO DO IF YOU SMELL GAS
• Do not try to light any appliance.
• Do not touch any electrical switch; do not use any
phone in your building.
• Immediately call your gas supplier from neighbor’s
phone. Follow the gas supplier’s instructions.
• If you cannot reach your gas supplier, call the re
department.
Page 1
fire-parts.com

33636-0-0314Page 2
TABLE OF CONTENTS
Important Installation Guidelines..............................................................................3
General Information .................................................................................................3
Log Identication ......................................................................................................4
Log Placement ..................................................................................................5 - 10
Master Parts Distributor List................................................................................... 11
How To Order Repair Parts ....................................................................................11
SECTION PAGE
fire-parts.com

33636-0-0314 Page 3
Proper Log Placement
Log placement is critical to proper burner performance. Logs must
be correctly positioned. The photos in this manual show the proper
pinned position for logs on this set. Owners need to be shown proper
log placement and instructed not to move the logs.
Logs must t rmly onto the burner when positioned as shown in
the photos. Misformed logs or logs with sloppy pin holes must be
replaced.
Proper Placement of Glowing Embers
Glowing embers can be added to burners for a glowing ember effect.
It must be positioned only on top of the burner. The photos in this
manual show the proper placement of glowing embers.
Make Owners Aware of Proper Log Set Operation
Properly installed and properly maintained log sets do not deposit
soot on the logs. If users see soot appear on a log, call for service.
Do not continue to operate the log set.
Qualied Installing Agency
Installation and replacement of gas piping, gas utilization
equipment or accessories and repair and servicing of equip-
ment shall be performed only by a qualied agency. The term
"qualied agency" means any individual, rm, corporation,
or company that either in person or through a representa-
tive is engaged in and is responsible for (a) the installation,
testing, or replacement of gas piping or (b) the connection,
installation, testing, repair, or servicing of equipment; that is
experienced in such work; that is familiar with all precautions
required, and that has complied with all the requirements of
the authority having jurisdiction.
The installation must conform with local codes or, in the
absence of local codes, with the National Fuel Gas Code,
ANSI Z223.1/NFPA54.*
*Available from the American National Standards Institute, Inc. 11 West
42nd St., New York, N.Y. 10018.
State of Massachusetts: The installation must be made
by a licensed plumber or gas tter in the Commonwealth
of Massachusetts.
Sellers of unvented propane or natural gas-red supple-
mental room heaters shall provide to each purchaser a
copy of 527 CMR 30 upon sale of the unit.
Appliance Certication
This logset is design certied in accordance with American National
Standard/CSA Standard ANSI Z21.88/CSA 2.33 and by Underwrit-
ers Laboratories for use with a Direct Vent Gas Fireplace Heater
and shall be installed according to these instructions.
IMPORTANT INSTALLATION GUIDELINES
GENERAL INFORMATION
fire-parts.com

33636-0-0314Page 4
LOG IDENTIFICATION
TOP VIEW FRONT VIEW DESCRIPTION PART
NUMBER
REAR LOG (A) 33582
RIGHT LOG (C) 33583
LEFT LOG (B) 33584
TOP BRANCH (D) 33585
LEFT FRONT TWIG (E) 33586
fire-parts.com

33636-0-0314 Page 5
Before you begin: Do not, handle these logs with your bare hands! Always wear gloves to prevent skin irritation. After handling
logs, wash your hands gently with soap and water.
All Logs
The positioning of the logs is critical to the safe and clean operation of this heater. Sooting and other problems may result if
the logs are not properly and rmly positioned in the appliance.
Refer to Figure 1 for the following warning.
Warning: Failure to position the parts in accordance with this diagram or failure to use only parts specically approved
with this appliance may result in property damage or personal injury.
A
BC
D
E
Log Placement - Figure 1
LOG PLACEMENT
Attention: Refer to Page 4 Parts List and Parts View to order logs
for your appropriate model number.
Glowing embers should be dime-sized pieces that are uffed up
prior to placement onto the burner. A single layer of glowing embers
is sufcient; do not over-apply.
NOTE: Once the installation is complete with the log set and glowing
embers in place, operate the replace to verify ame appearance.
If there are ames directly impinging a log, turn off replace, then
remove the glowing ember material directly below where the ame
impingement occurred. This should eliminate sooting on the log,
and provide a more pleasing ame appearance.
Replacement of glowing embers must be purchased from Empire
Comfort Systems, Inc. Application of excess glowing embers may
adversely affect performance of the heater. WARNING: All previously
applied loose material must be removed prior to reapplication.
Replacement glowing embers Part Number
LS41THF 15999
PLACE GLOWING EMBERS (ROCK WOOL)
IN SHADED AREA ONLY.
FRONT VIEW - COMPLETED LOG SET INSTALLATION (WITHOUT EMBERS)
fire-parts.com

33636-0-0314Page 6
TOP VIEW
FRONT VIEW
1. Place the Rear Log (A) onto the rear of the burner cover so that it rests against the back of the rebox. Center the log so the ends
of the log are approximately 1 inch from the sides of the rebox.
Note: The back log may require some rotation so it rests against the rear wall of the rebox.
LOG PLACEMENT
fire-parts.com

33636-0-0314 Page 7
TOP VIEW
FRONT VIEW
2. Place Left Log (B) onto the left pin on the Rear Log (A) and angled down so that it rests on the front of the burner cover and
against the left wall of the rebox.
LOG PLACEMENT
fire-parts.com

33636-0-0314Page 8
TOP VIEW
FRONT VIEW
3. Place Right Log (C) onto the right pin on the Rear Log (A) and angled down so that it rests on the front of the burner cover and
against the right wall of the rebox.
LOG PLACEMENT
fire-parts.com

33636-0-0314 Page 9
TOP VIEW
FRONT VIEW
4. Place Top Branch (D) onto the pin on the Left Log (B) and angled down so that it is pinned and rests on the front of the burner
cover.
LOG PLACEMENT
fire-parts.com

33636-0-0314Page 10
TOP VIEW
FRONT VIEW
5. Place Left Front Log (E) onto the left two pins on the burner cover.
LOG PLACEMENT
fire-parts.com

33636-0-0314 Page 11
To Order Parts Under Warranty, please contact your local Empire dealer. See the dealer locator at www.empirecomfort.
com. To provide warranty service, your dealer will need your name and address, purchase date and serial number, and the
nature of the problem with the unit.
To Order Parts After the Warranty Period, please contact your dealer or one of the Master Parts Distributors listed below.
This list changes from time to time. For the current list, please click on the Master Parts button at www.empirecomfort.com.
Please note: Master Parts Distributors are independent businesses that stock the most commonly ordered Original Equip-
ment repair parts for Heaters, Grills, and Fireplaces manufactured by Empire Comfort Systems Inc.
MASTER PARTS DISTRIBUTOR LIST
Parts Not Under Warranty
Parts can be ordered through your Service Person, Dealer, or a Master Parts Distributor. See this page for the Master Parts Distribu-
tors list. For best results, the service person or dealer should order parts through the distributor. Parts can be shipped directly to the
service person/dealer.
Warranty Parts
Warranty parts will need a proof of purchase and can be ordered by your Service Person or Dealer. Proof of purchase is required for
warranty parts.
All parts listed in the Parts List have a Part Number. When ordering parts, rst obtain the Model Number and Serial Number from the
name plate on your equipment. Then determine the Part Number (not the Index Number) and the Description of each part from the fol-
lowing illustration and part list. Be sure to give all this information . . .
Appliance Model Number Part Description
Appliance Serial Number Part Number
Type of Gas (Propane or Natural)
Do not order bolts, screws, washers or nuts. They are standard hardware items and can be purchased at any local hardware store.
Shipments contingent upon strikes, res and all causes beyond our control.
HOW TO ORDER REPAIR PARTS
Dey Distributing
1401 Willow Lake Boulevard
Vadnais Heights, MN 55101
Phone: [phone]
Toll Free: 800-397-1339
Website: www.deydistributing.com
Parts: Heater, Hearth and Grills
Victor Division of F. W. Webb Company
200 Locust Street
Hartford, CT 06114
Phone: [phone]
Toll Free: 800-243-9360
Fax: [phone]
Toll Free Fax: [phone]
Websites: www.fwwebb.com & www.victormfg.com
Parts: Heater, Hearth and Grills
East Coast Energy Products
10 East Route 36
West Long Branch, NJ 07764
Phone: [phone]
Toll Free: 800-755-8809
Fax: [phone]
Website: www.eastcoastenergy.com
Parts: Heater, Hearth and Grills
Able Distributors
2501 North Central Avenue
Chicago, IL 60639
Phone: [phone]
Toll Free: 800-880-2253
Fax: [phone]
Website: www. abledistributors.com
Parts: Heater
fire-parts.com

33636-0-0314Page 12
EMPIRE
EMPIRE
Comfort Systems
Empire Comfort Systems Inc.
918 Freeburg Ave. Belleville, IL 62220
If you have a general question about our products, please e-mail us at
[email protected].
If you have a service or repair question, please contact your dealer.
www.empirecomfort.com
fire-parts.com