England's Stove Works 17?VL User manual

TRANQUILITYWOODSTOVE
INSTALLATION&OPERATIONMANUAL
17‐VL,50‐SVL17&50‐TVL1717‐VLP,50‐SVL17P&50‐TVL17P







CAUTION
Pleasereadthisentiremanualbeforeinstallationanduseofthiswoodfuel‐
burningappliance.Keepchildren,furniture,fixturesandallcombustiblesaway
fromanyheatingappliance.
SAFETYNOTICE
Failuretofollowtheseinstructionscanresultinpropertydamage,bodilyinjury
orevendeath.Foryoursafetyandprotection,followtheinstallation
instructionsoutlinedinthismanual.Contactyourlocalbuildingorfireofficials
aboutrestrictionsandinstallationinspectionrequirements(includingpermits)
inyourarea.
SAVETHESEINSTRUCTIONS
ManufacturedBy:
England’sStoveWorks,Inc.
POBox206
Monroe
,
VA24574
Rev. 12/13/2013

Page | 2
Retainforyourfiles

ModelNumber________________________
DateofPurchase_______________________
DateofManufacture____________________
SerialNumber_________________________

*Thisinformationcanbefoundonthesafetytagattachedtotherearoftheunit.
Havethisinformationonhandifyouphonethefactoryoryourdealerregardingthis
product.
IMPORTANT:IFYOUHAVEAPROBLEMWITHTHISUNIT,DO
NOTRETURNITTOTHEDEALER.CONTACTTECHNICAL
SUPPORT@1‐800‐245‐6489
MobileHomeUse:
Thisfreestandingwoodunitisapprovedformobilehomeor
doublewideinstallationwiththeoutsidecombustionairhook‐
up.Seethe“Installation”sectionofthismanualfordetails
pertainingtomobilehomeinstallations.Mobilehome
installationmustbeinaccordancewiththeManufactured
HomeandSafet
y
Standard
(
HUD
)
,CFR3280,Part24.
CAUTION
Keepchildrenaway.
Supervisechildreninthesameroomasthisappliance.
Alertchildrenandadultstothehazardsofhightemperatures.
DoNOToperatewithprotectivebarriersopenorremoved.
Hotwhileinoperation!Keepclothing,furniture,draperiesandother
combustiblesaway.Contactmaycauseskinburns!
InstallationMUSTcomplywithlocal,regional,stateandnationalcodesand
regulations.
Consultlocalbuilding,fireofficialsorauthoritieshavingjurisdictionabout
restrictions,installationinspection,andpermits.

Page | 3
TABLEOFCONTENTS

Introduction
Introduction.................................4

Specifications
HeatingSpecifications..................5
Dimensions...................................5
EPACompliance...........................5

Installation
InstallationOverview...................6
ClearancestoCombustibles.........7
VentingIntroduction....................8
VentingGuidelines.......................8
AdditionalVentingInformation...9
WallPass‐Throughs....................10
ApprovedVentingMethods
oThroughtheWall...........11
oThroughtheCeiling........12
oMasonryChimney..........13
MobileHomeInstallation..........14
OutsideAirHook‐Up..................14
FloorProtection.........................15
RvalueCalculations...................16




Operation
Break‐InFires.............................17
LightingaFire.............................17
ContinuousOperation................18
SafetyNotes...............................19

Maintenance
ImportantNotes.........................20
InspectingGaskets.....................21
GlassandGasketReplacement..22

TroubleshootingGuide
Troubleshooting.........................23

OptionalAccessories
AC‐16Blower.............................24

IllustratedPartsDetail
PartsList.....................................24
ExplodedPartsDiagram.............25


Warranty
WarrantyDetails...................26‐27
WarrantyReg.Form..............28‐29

DONOTCONNECTTOANYAIRDISTRIBUTIONDUCTORSYSTEM.
DONOTUSECHEMICALSORFLUIDSTOSTARTTHEFIRE.
DONOTBURNGARBAGEORFLAMMABLEFLUIDSSUCHASGASOLINE,NAPHTHAOR
ENGINEOIL.

Page | 4
INTRODUCTION

ThankyouforpurchasingthisfineproductfromEngland’sStoveWorks!

England’sStoveWorkswasstarted,andisstillownedby,afamilythat
believesstronglyina“DoItYourself”spirit;that’sonereasonyou
foundthisproductatyourfavorite“DoItYourself”store.

Weintentionallydesignandbuildourstovessothatanyhomeowner
canmaintaintheirunitwithbasictools,andwe’realwaysmorethan
happytoshowyouhowtodothejobaseasilyandasinexpensivelyas
possible.However,whileremainingsimple,ourstovesaredesignedto
performextremelyefficiently,helpingdelivermoreheatfromlessfuel.

PleaselookatourvastHelpsectiononourwebsiteandcallour
TechnicalSupportDepartmentat(800)245‐6489ifyouneedanyhelp
withyourunit.Wearenearlyalwaysableto“walkyouthrough”any
installationissues,repairs,problemsorotherquestionsthatyoumay
have.

Wishingyouyearsofefficient,qualityand“comfy”heating,

EVERYONEATENGLAND’SSTOVEWORKS


PleaseNote:Whileinformationobtainedfromourwebsiteand
throughourTechnicalSupportlineisalwaysfreeofcharge,therewill
beaservicechargeincurredwithany“on‐site”repairsormaintenance
thatwemayarrange.

Page | 5
SPECIFICATIONS

HeatingSpecifications
MaximumHeatOutput......................................................................40,000BTU/hr
MaximumBurnTime**................................................................................6hours
ApproximateSquareFootageHeated***.....................................500‐1200sq.ft.
FireboxCapacity.......................................................................................45pounds
FlueCollar.............................................................................................6.0in.round

Dimensions

















EPAandSafetyComplianceSpecifications
EPACompliance...........................................................................................Certified
ParticulateEmissions............................................................................4.3grams/hr
Efficiency*...........................................................................................................63%
TestedTo...............................................................................UL‐1482,ULC‐S627‐00


*‐Thisunitwasnottestedforefficiency;theefficiencyshownisadefaultvaluenormallyattainedbysimilar,
certifiednon‐catalyticwood
**‐Maximumburntimeareheavilydependentonthetypeofwoodburnedinthestove;assuch,thesenumbers
mayvary.
***‐Themaximumheatingcapacityofthisunitcanvarygreatlybasedonclimate,constructionstyle,insulation
andamyriadofotherfactors.UsethisinformationinconjunctionwithaBTUlosscalculationforyourhometo
determineifthisunitwillbesufficientforyourneeds.
30.1875in.
20.375in.12.5in.
31.75in.

Page | 6
INSTALLATION
InstallationOverview
Whenchoosingalocationforyournewstove,thereareamultitudeoffactorsthat
shouldbetakenintoaccountbeforebeginningtheinstallation.

1. TrafficPatterns–Tohelppreventaccidents,thestoveshouldbeplacedinalocation
whereitisoutofthewayofnormaltravelthroughthehome.

2. HeatFlow–Whendecidingonalocationforthestove,considerthewayheatmoves
throughoutyourhome.Installthestovewhereyouneedtheheat;basement
installationsoftendonotallowsufficientheattoflowtotheupperfloorsandatop
floorinstallationwillnotallowanyheattoreachthefloorsbelow.Alwaysconsider
thatheatrisesandwilltakethepathofleastresistancewhileitisstillhot.

3. ExhaustLocation–Theenginewhichdrivesawoodstoveisthechimneysystem,so
itisimportanttoconsiderpreciselyhowthechimneysystemwillbeintegratedinto
thestoveinstallation.Ideally,awoodstovechimneywillruncompletelyvertical
fromthefluecollaroftheunitallthewaytotheterminationpointabovetheroof
line.Keepingtheentirechimneysysteminsidetheheatedenvelopeofthehome
willensureastrong,easytoinitiatedraftinthechimney.Althoughexteriorchimney
systemsoftenfunctionproperly,theyaremorelikelytosufferfromcolddowndrafts
atstartuporprovideweakdrafttotheunit.Also,considerthecross‐sectionalarea
ofthechimney;althoughexistingmasonrychimneyscanoftenbeused,alarge
externalmasonrychimneywillresultinaunitthatisdifficultorimpossibleto
operateproperly.Inthatcase,aninsulatedchimneylinerwilloftenberequiredto
supplythenecessarydraft.

4. WallConstruction–Locatingthestovesothattheexhaustsystemcanpassbetween
studswillsimplifytheinstallationandeliminatetheneedtoreframeanysectionsof
thewallorceilingtoaccommodatethewallthimbleorceilingbox.
WARNING
Donotstoreorusegasolineorotherflammablevaporsandliquidsinthe
vicinityofthisoranyotherappliance.
DoNotOver‐fire–Ifanyexternalpartstartstoglow,youareover‐firing.
Reduceintakeairsupply.Over‐firingwillvoidyourwarranty.
Complywithallminimumclearancestocombustiblesasspecified.
Failuretocomplymayresultinahousefire.
Testedandapprovedforcordwoodonly.Burninganyotherfuelwill
voidyourwarranty.

Page | 7
INSTALLATION
ClearancestoCombustibles

ParallelWallInstallation









CornerInstallation





UnittoSide
Wall
Chimney
Connector
toSide
Wall
Chimney
Connector
toRear
Wall
Unitto
RearWall
Unitto
Corner
Chimney
Connector
toCorner
ABCDEF
in.(mm.)in.(mm.)in.(mm.)in.(mm.)in.(mm.)in.(mm.)
SingleWallChimney
Connector
UnprotectedSurface
12
(304.8)
19.5
(495.3)
12
(304.8)
10
(254.0)
7
(177.8)
15
(381.0)
DoubleWallChimney
Connector
UnprotectedSurface
11
(279.4)
17.5
(444.5)
10
(254.0)
8
(203.2)
6
(152.4)
14
(355.6)
A
B
CD
EF

Page | 8

INSTALLATION

VentingIntroduction
Thiswoodstoveoperatesona
naturaldraftsystem,inwhichthechimney
systempullsairthroughthestove.Thisunit
mustbeinstalledinaccordancewiththe
followingdetaileddescriptionsofventing
techniques;notinstallingthestovein
accordancewiththedetailslistedherecan
resultinpoorstoveperformance,property
damage,bodilyinjuryordeath.Avoid
make‐shiftcompromiseswheninstallingthe
ventingsystem.England’sStoveWorksis
notresponsibleforanydamageincurred
duetoapoororunsafeinstallation.
Becertainthatallaspectsofthe
ventingsystemareinstalledtotheventing
manufacturer’sinstructions,particularlythe
requiredclearancestocombustibles.Also,
becertaintouseanatticradiationshieldto
preventinsulationfromcontactinga
chimneywhichpassesthroughanattic.
Thechimneysystemisthe“engine”
whichdrivesawoodstove,soitis
imperativeforproperunitfunctionthatthe
ventingsystembeinstalledexactlyas
describedinthefollowingsection.
Ifquestionsarisepertainingtothe
safeinstallationofthestove,ourTechnical
Supportline(800‐245‐6489)isavailable.
Contactyourlocalcodeofficialtobecertain
yourinstallationmeetslocalandnational
firecodes,andifyou’reuncertainabout
howtosafelyinstallthestove,westrongly
recommendcontactingalocalNFIcertified
installertoperformtheinstallation.


VentingGuidelines
ALWAYSinstallventpipeinstrict
adherencetotheinstructionsand
clearancesincludedwithyour
ventingsystem.
DONOTconnectthiswoodstoveto
achimneyfluewhichalsoserves
anotherappliance.
DONOTinstallafluepipedamper
oranyotherrestrictivedeviceinthe
exhaustventingsystemofthisunit.
USEanapprovedwallthimblewhen
passingthroughawallandaceiling
support/firestopwhenpassing
throughaceiling.
INSTALLthreesheetmetalscrewsat
everychimneyconnectorjoint.
AVOIDexcessivehorizontalrunsand
elbows,asbothwillreducethedraft
oftheventingsystemandwillresult
inpoorstoveperformance.
INSPECTyourventingsystemoften,
tobecertainitisclearofcreosote,
fly‐ashandotherrestrictions.
CLEANtheventingsystemas
detailedinthemaintenancesection
ofthismanual.
ADHEREtothe10‐3‐2ruleregarding
chimneyterminations.
INSTALLsinglewallchimney
connectorwiththemaleenddown
topreventcreosoteleakage.Follow
doublewallchimneyconnector
manufacturer’sinstructions
regardingproperpipeinstallation.
WARNING:VentingsystemsurfacesgetHOT,andcancauseburnsif
touched.Noncombustibleshieldingorguardsmayberequired.

Page | 9
INSTALLATION
AdditionalVentingInformation
Donotmixandmatchcomponentsfromdifferentpipemanufacturerswhenassembling
yourventingsystem(i.e.DoNOTuseventingpipefromonemanufacturerandathimble
fromanother).
Werequireaminimumchimneyheightof15.0ft.Chimneysystemsshorterthanthis
maynotcreatetheamountofdraftwhichisrequiredtooperatethiswoodburningunit.
Donotusemakeshiftcompromiseswheninstallingtheventingsystem;haveexisting
chimneysystemsinspectedbeforeuseandbecertainallnewchimneysystemsare
installedtothemanufacturer’sspecificationsandwithonlyULlistedcomponents(ULCif
Canada).
PrefabricatedventingsystemsusedforthisstovemustbelistedtoULCS629(Canada)
andUL103HT(US).
Neverinstalladraftinduceroranyothersystemwhichincreasesthenaturaldraftofthe
chimney;similarly,donotinstallabarometricorstovepipedamperwiththisunit.
Neverusesinglewallordoublechimneyconnectorasachimneysystem;neverpass
eithertypeofchimneyconnectorthroughacombustiblewallwithoutcarefullyfollowing
themanufacturer’sinstructionsandthoselistedinthefollowingpageonWallPass‐
Throughs.NEVERpasschimneyconnectorthroughanattic,floor,closetorroof.
Onlyuse24gaugeMSGblacksinglewallchimneyconnectororULListed(ULCifCanada)
doublewallchimneyconnector.
SingleWallChimneyConnectorInstallation
WARNING
INSTALLVENTATCLEARANCESSPECIFIEDBYTHEVENTMANUFACTURER.
HOT!Donottouch!Severeburnsorclothingignitionmayresult.
Glassandothersurfacesarehotduringoperation.
FlueGasDirection
Crimpedormaleendof
singlewallchimney
connectormustfacedown.
Fasteneachsinglewall
chimneyconnectorjoint
withthreesheetmetal
screws.
Themaleendofsinglewall
chimneyconnectoris
installedfacingdownsothat
anyliquidcreosoteinthe
fluewillrunintotheunit
insteadofontotheoutside
ofthepipe(thenaturaldraft
inthechimneysystemwill
preventsmokeleakageat
thejoints).

Page | 10
INSTALLATION

WallPass‐Throughs
InCanada,theinstallationmustconformtoCAN/CSA‐B365whenpassingthroughcombustibleconstruction.

Page | 11
INSTALLATION
Approved Venting Method 1: Through the Wall Factory Built Chimney
Please Note:
Installation diagrams are for reference purposes only and are not drawn to scale, nor meant to be used as plans for each individual
installation. Please follow all venting system requirements, maintain the required clearances to combustibles, and follow all local
codes.
StormCollar
TerminationCap
RoofFlashing
ClassAChimneySystem
The10‐3‐2Rule:Thechimneysystem
mustterminate3.0ft.abovethepoint
whereitscenterlinepassesthroughthe
roofANDthechimneymustterminate
2.0ft.aboveanypartofthedwelling
withina10ft.radiusofthechimney.
3.0ft.
2.0ft.
10ft.
TeeandTeeSupport
WallThimble
18.0in.
PrefabricatedchimneysystemsmustconformtoUL‐103HT(2100°F)fortheU.S.andULC‐S629(650°C)for
Canada.
Thiswoodburningunitisonlylistedforinstallationwith6.0”diameterchimneyconnectorandchimneysystems.
Installingthisunitonprefabricatedchimneyslargerthan6.0”diameterwillresultindecreaseddraftandthe
potentialforpoorunitperformance.
Followallventingsystemmanufacturer’sinstallationrequirementsandrequiredclearances.
Usethreesheetmetalscrewsateachsinglewallchimneyconnectorjoint(checkmanufacturer’s
recommendationswhendoublewallchimneyconnectorisused).
Drillthreeholesinthefluecollaroftheunitandattachthechimneyconnectortotheunitusingsheetmetal
screws.
Properlyattachtheprefabricatedchimneysystemtothehomeinstrictaccordancewiththeprefabricated
chimneysystemmanufacturer’sinstructions.
Avoidnumerouselbowsandexcessivehorizontalrunsasbothwillleadtopoordraftandincreasedcreosote
accumulation.Horizontalrunsofchimneyconnectormustneverexceed4.0ft.andtheoveralllengthofthe
chimneyconnectormustnotexceed8.0ft.
Specialadaptersandslipconnectorsareavailabletoeliminatetheneedtocutsinglewallchimneyconnector.
Doublewallchimneyconnectormustbeusedwiththeseslipconnectors,asitcannotbetrimmedtolength.
ChimneyConnector
(SingleorDoubleWall)

Page | 12
INSTALLATION
Approved Venting Method 2: Through the Ceiling
Please Note:
Installation diagrams are for reference purposes only and are not drawn to scale, nor meant to be used as plans for each individual
installation. Please follow all venting system requirements, maintain the required clearances to combustibles, and follow all local
codes.
CeilingSupportBox
StormCollar
TerminationCap
RoofFlashingClassAChimneySystem
ChimneyConnector
(SingleorDoubleWall)
3.0ft.
2.0ft.
10ft.
The10‐3‐2Rule:Thechimneysystem
mustterminate3.0ft.abovethepoint
whereitscenterlinepassesthroughthe
roofANDthechimneymustterminate
2.0ft.aboveanypartofthedwelling
withina10ft.radiusofthechimney.
PrefabricatedchimneysystemsmustconformtoUL‐103HT(2100°F)fortheU.S.andULC‐S629(650°C)for
Canada.
Thiswoodburningunitisonlylistedforinstallationwith6.0”diameterchimneyconnectorandchimneysystems.
Installingthisunitonprefabricatedchimneyslargerthan6.0”diameterwillresultindecreaseddraftandthe
potentialforpoorunitperformance.
Followallventingsystemmanufacturer’sinstallationrequirementsandrequiredclearances.
Usethreesheetmetalscrewsateachsinglewallchimneyconnectorjoint(checkmanufacturer’s
recommendationswhendoublewallchimneyconnectorisused).
Drillthreeholesinthefluecollaroftheunitandattachthechimneyconnectortotheunitusingsheetmetal
screws.
Properlyattachtheprefabricatedchimneysystemtothehomeinstrictaccordancewiththeprefabricated
chimneysystemmanufacturer’sinstructions.
Theoveralllengthofthechimneyconnectormustnotexceed8.0ft.Inthecaseofcathedralceilings,the
prefabricatedchimneysystemshouldextendto8.0ft.fromthetopoftheunit.
Specialadaptersandslipconnectorsareavailabletoeliminatetheneedtocutsinglewallchimneyconnector.
Doublewallchimneyconnectormustbeusedwiththeseslipconnectors,asitcannotbetrimmedtolength.

Page | 13
INSTALLATION
Approved Venting Method 3: Internal or External Masonry Chimney System
Please Note:
Installation diagrams are for reference purposes only and are not drawn to scale, nor meant to be used as plans for each individual
installation. Please follow all venting system requirements, maintain the required clearances to combustibles, and follow all local
codes.
ChimneyConnector
(SingleorDoubleWall)
3.0ft.
2.0ft.
10ft.
The10‐3‐2Rule:Thechimneysystem
mustterminate3.0ft.abovethepoint
whereitscenterlinepassesthroughthe
roofANDthechimneymustterminate
2.0ft.aboveanypartofthedwelling
withina10ft.radiusofthechimney.
18.0in.
MasonryThimblewith
properclearanceto
combustibles
Chimneylinercross‐sectional
area(LengthxWidth)mustbe
nolargerthantwicethecross‐
sectionalareaofthefluecollar
(2x28.27in2=56.55in2).If
chimneylinerislargerthan
56.55in2,reliningwitha5.5”
or6.0”linerisrequired
AshCleanoutsmust
haveanairtightsealto
preventweakdraft.
Followtheruleslistedaboveconcerningmaximumpermissiblefluelinersize;installingthisunitonmasonry
chimneysexceeding56.55in2incross‐sectionalareawillresultindecreaseddraftandthepotentialforpoorunit
performance.
Usethreesheetmetalscrewsateachsinglewallchimneyconnectorjoint(checkmanufacturer’s
recommendationswhendoublewallchimneyconnectorisused).
Drillthreeholesinthefluecollaroftheunitandattachthechimneyconnectortotheunitusingsheetmetal
screws.
Avoidnumerouselbowsandexcessivehorizontalrunsasbothwillleadtopoordraftandincreasedcreosote
accumulation.Horizontalrunsofchimneyconnectormustneverexceed4.0ft.andtheoveralllengthofthe
chimneyconnectormustnotexceed8.0ft.
Atightsealatthethimbleiscrucialforproperunitperformanceandtocreateasafeinstallation.Usetheproper
adapterdesignedforconnectingsingleordoublewallchimneyconnectortoamasonrythimble.
Haveexistingmasonrychimneysinspectedforsafetyandproperclearancestocombustiblesbeforeputtingthem
intoservice;aqualifiedchimneysweepcanperformthisinspection.
Externalmasonrychimneysoftensuffercolddowndraftsandpoordraftperformanceevenwhentheymeetthe
cross‐sectionalarearules.Inthiscase,a6.0”insulatedlinermaybenecessary.

Page | 14
INSTALLATION
MobileHomeInstallation
ThewoodstoveMUSTbesecuredtothefloorofthemobilehomeusinglagboltsandtheholes
providedinthebottomoftheunitforthis
purpose.
Thewoodstovemustbeconnectedtothe
chimneysystemwithdoublewallchimney
connectorwhichisULlisted(ULCifCanada)
foruseinmobileandmanufacturedhomes.
Carefullyfollowallclearanceslistedinthe
appropriatesectionofthismanualANDfollow
theventingmanufacturer’sminimum
clearancerequirements.Similarly,becertain
theventingsystemusedisapprovedfor
mobilehomeuse.
Installationmustbeinaccordancewith
ManufacturersHome&SafetyStandard(HUD)
CFR3280,Part24aswellasanyapplicablelocalcodes.
OutsideCombustionAir
Theuseofoutsidecombustionairismandatorywheninstallingthiswoodstoveinamobileor
manufacturedhome.
Theoutsideairconnectionpipeprotrudesfromthebottomcenterofthestove;akitisavailable
fromEngland’sStoveWorks,Inc.designedforconnectingthisunittooutsidecombustionair.[Part
No.AC‐OAK5]
IfitisnotfeasibletousetheAC‐OAK5outsideairhookupkitinyourstoveinstallation,other
materialsmaybeused,providedthefollowingrulesarefollowed:
oThepipeusedforoutsideairhookupmustbemetal,withaminimumthicknessof.0209in.
(25gaugemildsteel)orgreaterandaninsidediameterofapproximately4.25in.
oKeeppiperunsshortanduseamechanicalfastenerateachpipejoint.
oAscreenorotherprotectiondevicemustbefittedovertheoutsideairterminationpointto
preventrain,debrisandnuisanceanimalsfromenteringthepipingsystem.Inspectthe
outsidecombustionairinletforblockanddebrismonthly.
WARNING
DONOTINSTALLINASLEEPINGROOM.
CAUTION
THESTRUCTURALINTEGRITYOFTHE
MANUFACTUREDHOMEFLOOR,WALLAND
CEILING/ROOFMUSTBEMAINTAINED.
Caution
NEVERdrawoutsidecombustionairfrom:
Wall,floororceilingcavityor
enclosedspacesuchasanattic,garageorcrawl
space.
JoistShield
/
Firesto
p
MobileHomeApprovedDouble
WallChimne
y
Connector
RoofFlashingandStormCollar
ChimneyCap/SparkArrestor
Usesiliconetocreateavapor
barrierwherethechimneypasses
throughtoexterior.
ClassAChimneySystem

Page | 15
FLOORPROTECTION
Thiswoodstoverequiresanon‐combustiblefloorprotectorifthestoveistobeinstalledona
combustiblefloor.Ifthefloorthestoveistobeinstalledonisalreadynon‐combustible(i.e.a
concretefloorinabasement),nofloorprotectionisneeded(althoughadecorativefloorprotector
canstillbeusedforaestheticreasons).
Whenusinganyfloorprotector,considerthatthisstoveisnotonlyheavybutwillinduceheating
andcoolingcyclesonthefloorprotectorwhichcandamagetileandloosenmortarandgroutjoints
locatednearthestove.
ThefloorprotectorshouldbeULapprovedorequivalent(ULCifCanada)andmustbe
noncombustiblewithanRvalueof0.5.Sincethemajorityoftheheatfromthisunitisradiant,the
floorprotectornotonlyservestokeepashesandsparksfromlandingoncombustibleflooringnear
theunitbutalsoprotectsthecombustiblefloorfromtheheatoftheunit.AhearthrugisNOTan
approvedsubstituteforaproperhearthpad.
FortheUS:Thefloorprotectormustextendatleast16in.fromthefrontofthefuelopening,8in.
fromthesidesofthedooropeningand8in.fromtherearoftheunit.
ForCanada:Thefloorprotectormustextendatleast450.0mmfromthefrontofthefuelopening,
200.0mmfromthesidesofthedooropeningand200.0mmfromtherearoftheunit.










Thenon‐combustiblefloorprotectormustextend2in.(50.8mm.)oneithersideofanyhorizontal
ventingrunsandextenddirectlyunderneathanyverticalventingpipe.
PleaseseethefollowingpageforinstructionsoncalculatingRvalues,tobecertainthatthe
plannedfloorprotectionisadequateforthisstove.
US:8.0in.
CANADA:200.0mm.
US:8.0in.
CANADA:200.0mm.
US:8.0in.
CANADA:200.0mm.
US:16.0in.
CANADA:450.0mm.
CAUTION
NEVERUSEGASOLINE,GASOLINE‐TYPELANTERNFUEL,KEROSENE,CHARCOALLIGHTERFLUID,
ORSIMILARLIQUIDSTOSTARTOR“FRESHENUP”AFIREINTHISHEATER.KEEPALLSUCH
LIQUIDSWELLAWAYFROMTHEHEATERWHILEINUSE.ADDITIONALLY,NEVERAPPLYFIRE‐
STARTERTOANYHOTSURFACEOREMBERSINTHESTOVE.

Page | 16
FLOORPROTECTION
RValueCalculation
Aneasymeansofdeterminingifaproposedalternatefloorprotectormeetsrequirementsis
tofollowthisprocedure:
1) ConvertspecificationtoR‐value:
iR‐valueisgiven–noconversionisneeded
ii k‐factorisgivenwitharequiredthickness(T)ininches:R=1/kxT
iii C‐factorisgiven:R=1/C
2) DeterminetheR‐valueoftheproposedalternatefloorprotector:
iUsethecorrectformulagiveninstep1(above)toconvertvaluesnotexpressedas
“R.”
ii Formultiplelayers,addR‐valuesofeachlayertodetermineoverallR‐value.
3) IftheoverallR‐valueofthesystemisgreaterthantheR‐valueofthespecifiedfloor
protector,thealternateisacceptable.
EXAMPLE:
Thespecifiedfloorprotectorshouldbe¾”thickmaterialwithak‐factorof0.84.The
proposedalternateis4”brickwithaC‐factorof1.25over1/8”mineralboardwithak‐
factorof0.29.
Step(a):UseformulaabovetoconvertspecificationtoR‐value.
R=1/kxT=1/0.84x.75=0.893
Step(b):CalculateRofproposedsystem.
4”brickofC=1.25,thereforeRbrick=1/C=1/1.25=0.80
1/8”mineralboardofk=0.29,thereforeRmin.bd.=1/0.29x0.125=0.431
TotalR=Rbrick+Rmineralboard=0.8+0.431=1.231
Step(c):CompareproposedsystemofRof1.231tospecifiedRof0.893.Sinceproposed
systemRisgreaterthanrequired,thesystemisacceptable.
Definitions:
Thermalconductance=C =_____Btu____=____W____
  (hr)(ft2)(degF) (m2)(degK)

Thermalconductivity=k=__(Btu)(inch)__=___W____ =____Btu____
   (hr)(ft2)(degF) (m)(degK)(hr)(ft)(degF)

Thermalresistance=R=(ft2)(hr)(degF)=(m2)(degK)
Btu  W

Page | 17
OPERATION
Break‐InFires
Thiswoodburningunitisconstructedofheavygaugesteelandcastironandisbuilttolasta
longtime.However,inordertoensurenoexcessivethermalstressesareinducedonthemetal
duringthefirstfire,threebreak‐infiresshouldbeburned,eachoneslightlyhotterthanthelast.
Thesebreak‐infireswillnotonlyhelpthestovebodyacclimatetothehightemperaturesofthe
fire,butwillalsoslowlycurethehightemperaturestovepaint,whichwillensurethehigh
qualityfinishlastsforyears.
Thisstovehasasingleaircontrolrodwhichregulatesthewoodburnrate;whentheprimaryair
controlslideispulledallthewayoutoftheunit,thestovewillburnmoreslowlyandputout
heatoveralongertimeperiod.Conversely,whentheaircontrolslideispushedallthewayin,
theunitwillburnmorequicklyandputoutalargeramountofheatoverarelativelyshorter
timeperiod.Donotattempttomodifytherangeofaircontroladjustmentforanyreason.
Thefirstbreak‐infireshouldbejustalargekindlingfire,gettingthestovetoabout300°Fas
measuredbyamagneticthermometerontherightorleftsideofthestove,abovethedoor.
Oncethistemperaturehasbeenreached,allowthefiretodieoutwiththeaircontrolopen.The
secondandthirdbreak‐infiresshouldbeabitlarger,withsomesmalldrysplitsaddedtothe
kindlingload.Thetemperaturegoalduringthesefiresisabout350°F–450°F;don’tletthefire
gethotterthanthat.
ContinuousOperation
Afterthebreak‐infiresarecomplete,thisunitisreadyforcontinuousoperation.Whenburning
thestovecontinuously,donotallowashandcoalstoaccumulatehigherthan1.0”belowthe
dooropening.Excessivecoalingisoftenaresultofburningwoodattoohighaburnrate,and
thecoalbedshouldbeallowedtoburndownbeforereloadingthestovewithfreshwood.
Combustionairisdeliveredtothestoveattwolocations:Themajorityoftheprimary
combustionairentersthefireboxviatheair‐washsystemwhichkeepstheglasscleanandfeeds
theprimarycombustionflamesonthetopsurfacesofthewood;someprimarycombustionairis
bledoffintothecoalbedviableedholesinthebottomrailoftheair‐washsystem.Everyeffort
mustbetakentomaintaintheareainfrontoftheseholesfreeofash.
Whenloadingthestoveforalongtermburn,itismostusefultorakea“v”inthecenterofthe
coalbed,toallowtheprimaryairbleedholestopushairallthewaytotherearoftheunit.
Afterloadingthestovewithafullfireboxoffreshwood,itisimportanttooperatetheunitwith
theaircontrolinthefullopenpositiontoproperlycharthewoodloadanddriveofftheinitial
moistureinthefreshwood.Oncethewoodhasbeenproperlycharredandiscompletely
ignited,theaircontrolcanthenbesettothedesiredheatoutputlevel.
Intheeventofacreosoteorsootfire(chimneyfire),closetheaircontrolonthe
stove,contactthelocalfiredepartmentandgetout!Donotthrowwateronthefire!
Contactyourlocalfireauthorityformoreinformationonhowtohandleachimney
fireanddevelopasafeevacuationplanforyouandyourfamilyintheeventofa
chimneyfire.

Page | 18

OPERATION
England’sStoveWorks,Inc.alwaysrecommendstheuseofamagneticstovethermometer,so
thatthetemperatureoftheunitcanbemonitored.Whenusingamagneticstovethermometer,
locatethethermometerabovethedooroneithertheleftorrightsideofthestoveandusethe
followingtemperaturesasroughguidelinestodeterminetheburnrateandheatoutputlevelof
thestove:
oNormalwoodstoveoperationshouldoccurbetween350°F(177°C)and550°F(288°C),
with350°F(177°C)to450°F(232°C)beingalowtomediumheatoutputleveland450°F
(232°C)to550°F(288°C)beingamediumtohighheatoutputlevel.Operatingthestove
at600°F(316°C)wouldbeconsideredthemaximumcontinuousoperatingtemperature
permissibleandunitdamagemayresultfromoperatingatthathighofaburnratefor
extendedtimeperiods.Allowingtheunittoreach650°F(343°C)orhigherisdefinedas
over‐firingandwillresultinunitdamage.
Theoptionalroomairconvectionblowerwasdesignedtoextractthemaximumamountofheat
fromthestove,forthehighestpossibleheattransferintotheroom.Sincetheblowerisso
efficientatremovingheatfromtheunit,itisveryimportanttoonlyoperatetheroomairblower
afterafreshwoodloadhasbeenallowedtoburnforatleastthirty(30)minutes.Allowinga
freshloadofwoodtoburnwithoutthebloweronensuresthattheentireunitreachesproper
operationtemperaturesandthatthesecondarycombustionsystemisfunctioningproperly.
Additionally,followtheguidelinesbelowforacceptableblowerspeeds.
Whenusingtheoptionalroomairconvectionblower(PartNo.AC‐16),theblowershouldbe
operatedasfollowsdependingonheatoutputlevel:

BurnrateHighMediumHighMediumMediumLowLow
BlowerSpeedHighLowLowLowOff


DONOTUSEGRATEORELEVATEFIRE–BUILDWOODFIREDIRECTLYONHEARTH
DONOTOPERATEWITHTHEMAINDOOROPEN–OPERATINGTHESTOVEWITHTHEMAIN
DOOROPENWILLCREATEANOVER‐FIRE
Creosote
–
FormationandNeedforRemoval
Whenwoodisburnedslowly,itproducestarandotherorganicvapors,which
combinewithexpelledmoisturetoformcreosote.Thecreosotevapors
condenseintherelativelycoolchimneyflueofaslow‐burningfire.Asaresult,
creosoteresidueaccumulatesonthefluelining.Whenignited,thiscreosote
makesanextremelyhotfire.Thechimneyandchimneyconnectorshouldbe
inspectedatleastonceeverytwomonthsduringtheheatingseasonto
determineifacreosotebuilduphasoccurred.Ifcreosotehasaccumulated,it
shouldberemovedtoreducetheriskofchimneyfire.

Page | 19
OPERATION
AdditionalSafetyGuidelines
Theinstallationofsmokedetectorsishighlyrecommendedwheninstallingthisoranyother
solidfuelburningappliance.Smokedetectorsshouldbelocatednearorineveryroomofthe
home,particularlysleepingrooms.
Asmokedetectorcanbeinstalledinthesameroomasthiscordwoodburningunit;installingthe
smokedetectortooclosetotheunitcanleadtonuisancealarmsduetoslightwispsofsmoke
emittedduringthefirestartingorreloadingprocess.Duetothis,thesmokedetectorinthe
sameroomastheunitwillbemostusefulifitislocatedasfarfromtheunitastheroomwill
permit.
Thisstoveismeantforburningcordwoodonly;neverburnpressuretreatedwood,kilndried
wood,creosotetreatedwood(railroadties),icecoveredorwetwood,greenwood,driftwood,
charcoal,coal,cokeorANYotherfuel.
Burningfuelsotherthancordwood,particularlycoalandcharcoal,canresultinhazardous
concentrationsofcarbonmonoxidebeingemittedintothedwelling.Installingacarbon
monoxidedetectorandbeingawareofthesymptomsofcarbonmonoxidepoisoningcanhelp
reducetheriskofcarbonmonoxiderelatedissues.Forthesereasons,NEVERburncoalor
charcoalinthiscordwoodstove.
Thisunitwasdesignedforoperationonlywiththeloadingdoorclosedandtightlylatched.
Operatingthisunitwiththeloadingdoorlatchedlooselyoropenwillallowexcessive
combustionairtoreachthefireandwillresultindangerouslyhighunittemperatures.Highunit
temperaturescandamagetheunit,voidthewarrantyorignitecreosotedepositedinthe
chimneysystembyprevious,slowburningfires.
Thenaturaldraftthatpullsairthroughthisunitandallowsthefiretoburnusestheindoorairof
thedwellingforcombustion,unlesstheunitisconnectedtoanoutsidecombustionairsource.
Kitchenrangeventhoods,furnacesandotherairmovementappliancesinthehomeareoften
alsoremovingairfromthedwelling;iftheamountofairfiltrationorleakagebackintothehome
isexceededbytheairbeingremoved,negativepressuremaybecreatedinthehome.
Sincethisisanaturaldraftappliance,itwilloftenbethefirstappliancetohaveproblemsrelated
tonegativepressure.Ifsmokeisforcedoutthechimneyconnectorjointsoroutoftheair
inductionsystemoftheunit,theunitislikelyfightingnegativepressureinthedwelling.
Crackingawindowordoorneartheappliancecanhelpequalizethenegativepressure;
ultimately,anunrestrictedsourceofoutsidecombustionmaybenecessaryforproperunit
function.
Iftheunitisconnectedtooutsideair,becertaintomonitortheexteriorinlettothecombustion
systemforicingorsnowaccumulation.Allowingtheoutsideairconnectiontobecome
restrictedwillresultinairstarvationtotheunit.

DONOTSTOREFUELCLOSERTHANSPECIFIEDCLEARANCESTOCOMBUSTIBLESOR
WITHINTHESPACENEEDEDFORLOADINGTHESTOVEANDFORASHREMOVAL.

Page | 20

MAINTENANCE
DailyMaintenance
Inspectthefireboxforashaccumulation;removeexcessashandfollowinstructions
belowregardingdisposal.Ashshouldnotbeallowedtoaccumulateinthestovetothe
pointthatitcoversthecoalbedairinlets.
MonthlyMaintenance
Checktheblowerfordustaccumulation(ifinstalled);checkthedoorhandleforproper
operationandtobecertainanairtightsealisstillbeingmadebythedoor.
Inspectthechimneysystemandchimneyconnectorandsweepifnecessary.Although
cleaningmayberequiredlessthanmonthly,ALWAYSinspecttheventingsystem
monthlytodecreasethechanceofachimneyfire.
Visuallyinspectthevermiculiteinsulatingboardsinthefireboxforcracksand/or
breakage.Slightsurfacecrackswillnotaffecttheperformanceoftheboards,but
crackedorcrumblingboardsshouldbereplacedimmediately.
Visuallyinspectthesecondarycombustiontubesforcracks,warpingandcorrosion.
Althoughthesetubesareconstructedfromstainlesssteel,theyoperateatveryhigh
temperaturesandcaneventuallywearoutfromnormaluse.
YearlyMaintenance
Checkallgaskets(windowanddoor)forwearandtobecertaintheystillmaintainan
airtightseal.Seethefollowingpageforinstructions.
Thoroughlycleanthechimneysystemandthechimneyconnectorsystem.Sincethe
chimneyconnectorisgenerallyexposedtohighexhausttemperatures,inspectit
carefullyforleaksandweakspots;replaceanyquestionablepieces.[Inthecaseof
straightthroughtheroofchimneysystem,becertaintoremovethevermiculitebaffle
beforepushingthechimneysweepingbrushdownintothefirebox.Forcefullyhitting
thetopofthebafflewithacleaningbrushorrodcandamageordestroythebaffle.]
Removeallashfromthestove,includingtheashwhichaccumulatesonthetopofthe
fireboxbaffles.Leavetheaircontrolopenduringthenon‐heatingmonthstoallow
someairtoflowthroughthestovetohelppreventcorrosion.Asmallopencontainerof
catlitterinthestovecanhelppreventcorrosionduringthehumidsummermonths;be
certaintoremoveitbeforebuildingafireinthefall.
DisposalofAshes–Ashesshouldbeplacedinametalcontainerwithatightfittinglid.The
closedcontainerofashesshouldbeplacedonanoncombustiblefloororontheground,well
awayfromallcombustiblematerials,pendingfinaldisposal.Iftheashesaredisposedofby
burialinsoilorotherwiselocallydispersed,theyshouldberetainedintheclosedcontainer
untilallcindershavebeenthoroughlycooled.
IMPROPERGASKETMAINTENANCE,INCLUDINGFAILURETOREPLACEGASKETS,CAN
CAUSEAIRLEAKSRESULTINGINANUNCONTROLLABLEUNIT.