ESCALADE T8210 User manual

1
FOLD AND ROLL PLAYBACK
TABLE TENNIS TABLE
OWNER'S MANUAL
MODEL NOs.
T8210
T8287
WARRANTY
Actual product may
differ slightly from
that shown in
illustrations.
READ ASSEMBLY &
OPERATING INSTRUCTIONS
AND ALL SAFETY
INFORMATIONCAREFULLY!
CARE AND MAINTENANCE
You have purchased a quality product that will give you years of enjoyment. By following these simple
maintenance steps you will add to the life of your new table. The top (playing surface) of your table is of aluminum
construction. It can be affected by atmospheric conditions, meaning both temperature and humidity. This may
cause a slight sag or distortion as top expands or contracts. This is normal and should not cause concern as
it does not detract from the play or utility value of the table.
STORAGE OF YOUR TABLE
Wind gusts can blow over or unexpectedly open the table; Store in protected area. When your table is not in
use, it should be folded up in a dry area.
CLEANING YOUR TABLE
To clean your table use a soft damp NOT WET cloth only. To prevent damage to your table's playing surface
DO NOT use any chemicals, abrasive, or cleaning products on your table's playing surface.
IMPORTANT: Periodically, lubricate all moving parts, including pivot points, to assure smooth opening and
closing. A light lubricant such as WD-40 is recommended.
LIMITED 1 YEAR WARRANTY
Manufacturer warrants to the original retail purchaser, this product to be free from defects in material and
workmanship for a period of one (1) year from the date of purchase.
Should this product become defective due to material or workmanship within the warranty period, contact
our Customer Service Department for repair or replacement at our option.
This warranty is not transferable and does not cover normal wear and tear, bowing of the table or damage
caused by improper handling, installation or use of this product. This warranty is also void if product is in
any way abused, damaged, or modified from its original state, or if used for other than residential use.
This warranty gives you specific legal rights, and you may have other rights which vary from state to state.
CAUTION
THIS IS A GAME TABLE. DO NOT SIT, STAND, LEAN, WALK OR JUMP ON TABLE! FAILURE TO
COMPLY WITH THIS CAUTION COULD RESULT IN PERSONAL INJURY AND/OR PROPERTY
DAMAGE!
UNLEVELFLOORS
If table does not seem level, it is probably because floor is not level. Move table several inches (set
table in playing position) in different directions to find the best location for the table. If the floor is
extremely unlevel, table may not play or operate properly. If table is high in the center, shim up under
the outer legs.
© 2002 Escalade Sports TABLE TENNIS WARRANTY CENTER, P.O. BOX 889, EVANSVILLE, IN 47706-889 2L-4102-01
Thank you for buying our product. We try hard to ensure that our products are of high quality and
free of problems, such as manufacturing defects or missing parts. However, if you have any
problems with your new product, please DO NOT RETURN IT TO THE STORE!.
DO NOT RETURN THIS PRODUCT TO THE STORE!
Call us at:
TOLL FREE 1-866-873-3528
(THISISACONSUMERONLYNUMBER)
Please have this Owner’s Manual with you when you call.
Or write us at: CUSTOMER SERVICE DEPT., P.O. Box 889, Evansville, IN 47706
Fax Number: [phone].
Or E-mail us at: [email protected]
Please provide model number and/or part number (not just the key number) of the product and/or part when
you call or write. These numbers can be found on the product, packaging, and/or in this Owner’s Manual.
Manufactured under one or more of the following patents:
6,179,733 6,120,397 5,921,227 5,919,102 5,901,692 5,899,824 5,816,957 5,769,744 5,749,351 5,718,212 5,498,004 5,392,757 5,271,625
5,119,741 5,071,120 5,067,728 4,911,085 4,798,381 4,717,157 4,546,754 4,515,142 4,424,968 D425,943 D425,572 D420,563

2
AT LEAST TWO (2) ADULTS ARE NEEDED TO
COMPLETE THE REST OF THIS ASSEMBLY!
2. Attach table top (#5) to table base that you
just assembled, as shown in Figure 2. With
at least one adult on each side of table top
(#5), lift top and align ends of "U"-support
tube with top of pivot tubes on caster rails
(#1). Slide tubes together.
DO NOT OPEN THE TABLE TO PLAYING
POSITION UNTIL BOTH TOPS ARE
INSTALLED! DO NOT LEAVE TABLE
STANDING UNATTENDED. IT COULD BE
KNOCKED OVER CAUSING SERIOUS
BODILY INJURY OR PROPERTY
DAMAGE.
3. With two adults, put other table top onto
other pivot tubes following instructions in
step 2.
READ AND FOLLOW ALL ASSEMBLY, OPERATING, AND
SAFETY INSTRUCTIONS CAREFULLY. AT LEAST TWO
(2) ADULTS ARE NEEDED TO PUT THIS TABLE
TOGETHER!
1. Attach cross tube (#2) to caster rails (#1)
as shown in Figure 1. Turn caster rail as
shown with pivot tubes toward inside, and
attach tube (#2) with four carriage bolts (#3)
and four wing nuts (#4). Tighten wing nuts
securely.
Figure 2
Figure 1
4. Attach corner protectors (#32) to rails using
tree plugs (#13). Simply push the plugs
through the protector and into the rail until
snug.

3
OPENING AND CLOSING INSTRUCTIONS
Figure 6
WIND GUSTS CAN BLOW OVER OR UNEXPECTEDLY OPEN THE TABLE; STORE IN
PROTECTED AREA. EXERCISE CAUTION IN OPENING/CLOSING TABLE. SMALL
CHILDREN, OR CHILDREN NOT PROPERLY INSTRUCTED IN ITS USE, MUST NOT BE
ALLOWED TO OPEN/CLOSE TABLE. IMPROPER HANDLING AND MISUSE CAN RESULT
IN SERIOUS INJURY OR DAMAGE. DO NOT CLIMB, STAND, OR JUMP ON TABLE.
CAUTION:
Figure 5
Figure 4
Figure 3
TO OPEN:
1. Hold center of top edge of table top with both
hands. Gently pull outward to midway position.
Continue to pull until disengaged from safety clips
and legs rest on the floor. Do not leave table
partially opened at midway position. See Figure 3.
2. Open other table half as in step 1 and 2.
3. Lock all four center hinges. See Figure 4.
TO CLOSE:
1. Remove net and net posts from
table.
2. Unlock all four hinges.
3. Lift table half to midpoint until
the safety clips are engaged.
Then continue lifting until
closed.
4. Raise other table half in the
same manner.
4. Secure net posts to center of table and slide net
down over posts. See Figure 5.
CAUTION! Do NOT touch any parts on
bottom of table while opening and closing.
PLAYBACK POSITION

4
1 4A-5399-00 4A-5399-00 Caster RailAssembly 2
8S-6417-03 8S-6417-03 CasterRailonly 2
2 1A-6221-02 1A-6221-02 CrossTube 1
3 1B-6061-02 1B-6061-02 1/4-20 x 2.5" Carr Bolt 4
4 2B-6082-00 2B-6082-00 1/4-20WingNut 4
5 2Q-6066-00 2Q-6066-00 4" Caster 2
2Q-6067-00 2Q-6067-00 4" Caster With lock 2
6 WN-1025-00 WN-1025-00 3/8 Jam Nut 4
7 2S-6278-01 2S-6278-01 RH PivotBracket 2
8 8S-6451-02 8S-6451-02 PivotTube 4
9 2S-6279-01 2S-6279-01 LH Pivot Bracket 2
10 1B-4090-00 1B-4090-00 #8 x 5/16 SMS 132
11 3M-6273-00 3M-6273-00 Plastic Clip 4
12 4A-6336-00 4A-6336-00 Hinge / BrktAssembly 4
13 3M-4118-00 3M-4118-00 TreePlug 8
14 2B-6088-00 2B-6088-00 NylonWasher 12
16 710-54 710-54 U Clip 4
Replacement Parts List for Model Numbers T8210 and T8287 2L-4102-01
Key# T8210M T8287M Description Qty.
17 704-138 704-138 1.25" Tube end cap 4
18 8S-4120-01 8S-4120-01 U Support 2
19 4A-5319-00 4A-5319-01 HalfTop 2
20 8S-4078-00 8S-4078-00 End Rail 2
21 8S-4077-00 8S-4077-00 Side Rail (right) 2
8S-4090-00 8S-4090-00 SideRail(Left) 2
22 4A-6452-00 4A-6452-00 Net Bracket Kit 1
24 1A-4070-01 1A-4070-01 LegAssembly 2
25 8S-4074-02 8S-4074-02 LinkageTube 4
26 701-26 701-26 1/4 -20 Lock nut 12
28 3M-4111-00 3M-4111-00 NylonSpacer 4
29 3M-6274-00 3M-6274-00 TubePlug 4
30 3F-4018-00 3F-4018-00 Net 1
31 2S-6139-01 2S-6139-01 Mounting Bracket 4
32 3M-6389-00 3M-6389-00 MoldedCorner 4
33 WB-1110-00 WB-1110-00 1/4-20 x 2" Screw 12
34 8S-4091-00 8S-4091-00 InnerRail 2
Key# T8210M T8287M Description Qty.