Gold's Gym GGMC0921.0 User manual

USER'S MANUAL
Æ
®
QUESTIONS?
As a manufacturer, we are com-
mitted to providing complete
customer satisfaction. If you
have questions, or if a part is
damaged or missing, PLEASE
CONTACT OUR CUSTOMER
SERVICE DEPARTMENT
DIRECTLY.
CALL TOLL-FREE:
1-877-776-4777
Mon.–Fri., 6 a.m.–6 p.m. MST
ON THE WEB:
www.goldsgympowerflex.com
Model No. GGMC0921.0
Serial No.
(Write the serial number in the
space above for reference.)
CAUTION
Read all precautions and instruc-
tions in this manual before using
this equipment. Save this manual
for future reference.
TABLE OF CONTENTS
IMPORTANT PRECAUTIONS . . . . . . . . . . . . . . . . . . . . . . . . . . . .2
BEFORE YOU BEGIN . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2
ASSEMBLY . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3
PART LIST/EXPLODED DRAWING . . . . . . . . . . . . . . . . . . . . . . . .3
ORDERING REPLACEMENT PARTS . . . . . . . . . . . . . .Back Cover
LIMITED WARRANTY . . . . . . . . . . . . . . . . . . . . . . . . . .Back Cover

WARNING:To reduce the risk of serious injury, read the following important precautions
before using the resistance system.
2
IMPORTANT PRECAUTIONS
1. Read all instructions in this manual and in the
literature accompanying the resistance sys-
tem before using the resistance system. Use
the resistance system only as described in
the literature.
2. It is the responsibility of the owner to ensure
that all users of the resistance system are
adequately informed of all precautions.
3. Keep hands and feet away from moving parts.
4. Make sure all parts are properly tightened
each time you use the resistance system.
Replace any worn parts immediately.
5. Always wear athletic shoes for foot protection.
6. Use only the bands included with a GOLD’S
GYM MAX PACK.
7. If you feel pain or dizziness at any time while
exercising, stop immediately and begin cool-
ing down.
WARNING: Before beginning this or any exercise program, consult your physician. This
is especially important for persons over the age of 35 or persons with pre-existing health problems.
Read all instructions before using. ICON assumes no responsibility for personal injury or property
damage sustained by or through the use of this product.
BEFORE YOU BEGIN
Thank you for selecting the GOLD’S GYM®MAX PACK
accessory. The GOLD’S GYM POWER FLEX resis-
tance system uses progressive resistance. As the
bands begin to stretch, the amount of resistance will
increase gradually.As the bands stretch further, the
resistance will increase rapidly. The MAX PACK is
designed to increase the amount of resistance available
on GOLD’S GYM POWER FLEX resistance systems.
For your benefit, read this manual carefully before
using the MAX PACK and the resistance system. If
you have additional questions, see the front cover of
this manual. To help us assist you, please note the
product model number and serial number before call-
ing. The model number is GGMC0921.0. The serial
number can be found on the product packaging.
Record the serial number on the front cover of this
manual.
To avoid a registration fee for any service needed
under warranty,you must register the accessory at
www.goldsgympowerflex.com/registration.
GOLD'S GYM is a registered trademark of Gold's Gym International, Inc. This product is manufactured and dis-
tributed under license from Gold's Gym International, Inc.

3
2
1
3
1
2
1
1
4
4
PART LIST/EXPLODED DRAWING— R1005A
Model No.GGMC0921.0
3
1 4 17.5mm Spacer
24Resistance Rod
3 4 Exterior Band
4 2 Clip
# 1 Resistance Decal
# 1 User’s Manual
Note: “#” indicates a non-illustrated part.
Specifications are subject to change without notice.
Key No. Qty. Description
ASSEMBLY
E
Bands on
this end
1
1. Attach the resistance decal along the top of the
Right Cover (E). Make sure that the resistance
decal is oriented with the pictures of the bands
onthe end shown.
2. Remove the 1/2” x 1” Button Screw (A) with the 1/2”
Small Washer (B) from each side of the resistance
system. Remove the Side Covers (C) from the Left
and Right Covers (D, E). Remove the 1/2” x 1”
Button Screw (A) with the 1/2” Washer (F) from
each side of the resistance system.
Slide the four 17.5mm Spacers (1) onto the four
Resistance Rods (2). (See the inset drawing for
correct orientation.) Slide the two removed 1/2”
Washers (F) onto two of the Rods.
Attach a Resistance Rod (2) and a Resistance Rod
with a 1/2” Washer (F) to the indicated locations on
the resistance system. Attach the other two
Resistance Rods to the other side of the system.
Slide an Exterior Band (3) onto each set of
Resistance Rods (2). For more resistance, add a
second Exterior Band to each set of Resistance
Rods. Note: It may be necessary to stretch the
Exterior Bands to slide them onto the Rods.
Secure the Exterior Bands to the Resistance Rods
with the two Clips (4).
WARNING:Always place the same
number of Exterior Bands (3) on each side of
the system. Use only the Exterior Bands includ-
ed with a GOLD’S GYM MAX PACK. Always
secure the Bands with the two Clips (4).
2
3
4
2
1
C
D
F
B
A
A
E
Small
Hole Large
Hole
1
1
2
2
1

ORDERING REPLACEMENT PARTS
To order replacement parts, see the front cover of this manual. To help us assist you, please be prepared to give
the following information:
1. the MODEL NUMBER of the product (GGMC0921.0)
2. the NAME of the product (GOLD’S GYM MAX PACK)
3. the SERIAL NUMBER of the product (see the front cover of this manual)
4. the KEY NUMBER and DESCRIPTION of the part(s) (see the PART LIST/EXPLODED DRAWING on page 3
of this manual)
Part No. 181811 R1005A Printed in China © 2002 ICON IP, Inc.
LIMITED WARRANTY
ICON Health & Fitness, Inc. (ICON), warrants this product to be free from defects in workmanship and
material, under normal use and service conditions, for a period of ninety (90) days from the date of pur-
chase. This warranty extends only to the original purchaser. ICON's obligation under this warranty is lim-
ited to replacing or repairing, at ICON's option, the product through one of its authorized service centers.
All repairs for which warranty claims are made must be pre-authorized by ICON. If the product is shipped
to a service center,freight charges to and from the service center will be the customer’sresponsibility.For
in-home service, the customer will be responsible for a minimal trip charge. This warranty does not extend
to any product or damage to a product caused by or attributable to freight damage, abuse, misuse,
improper or abnormal usage or repairs not provided by an ICON authorized service center; products used
for commercial or rental purposes; or products used as store display models. No other warranty beyond
that specifically set forth above is authorized by ICON.
ICON is not responsible or liable for indirect, special or consequential damages arising out of or in con-
nection with the use or performance of the product or damages with respect to any economic loss, loss
of property, loss of revenues or profits, loss of enjoyment or use, costs of removal or installation or other
consequential damages of whatsoever nature. Some states do not allow the exclusion or limitation of inci-
dental or consequential damages. Accordingly, the above limitation may not apply to you.
The warranty extended hereunder is in lieu of any and all other warranties and any implied warranties of
merchantability or fitness for a particular purpose is limited in its scope and duration to the terms set forth
herein. Some states do not allow limitations on how long an implied warranty lasts. Accordingly, the above
limitation may not apply to you.
This warranty gives you specific legal rights. You may also have other rights which vary from state to state.
ICON HEALTH & FITNESS, INC., 1500 S. 1000 W., LOGAN, UT 84321-9813